Fuel/propulsion SystemPower TrainVehicle Speed Control
DRIVING MY 2004 VOLKSWAGEN BEETLE IS DANGEROUS. THE TIPTRONIC TRANSMISSION IN THE 2004 VW BEETLE IS KNOWN BY VOLKSWAGEN TO BE DEFECTIVE. AT ANY POINT THE VALVE BODY CAN FAIL, WHICH CAUSES DELAYED SHIFTING, AND HARD JERKING BETWEEN GEARS. MY 2004 BEETLE FAILS TO SHIFT WHEN ACCELERATING BETWEEN 2ND AND 3RD GEAR. THIS CAUSES THE VE…
Read full complaint
DRIVING MY 2004 VOLKSWAGEN BEETLE IS DANGEROUS. THE TIPTRONIC TRANSMISSION IN THE 2004 VW BEETLE IS KNOWN BY VOLKSWAGEN TO BE DEFECTIVE. AT ANY POINT THE VALVE BODY CAN FAIL, WHICH CAUSES DELAYED SHIFTING, AND HARD JERKING BETWEEN GEARS. MY 2004 BEETLE FAILS TO SHIFT WHEN ACCELERATING BETWEEN 2ND AND 3RD GEAR. THIS CAUSES THE VEHICLE TO COAST FOR SEVERAL SECONDS, SOMETIMES REQUIRING PULLING OFF THE ROAD BECAUSE OF TRAFFIC. WHEN DOWNSHIFTING IT JERKS EXTREMELY HARD. YOU GET IN, START THE ENGINE, AND RECEIVE NO WARNINGS THAT ANYTHING IS WRONG WITH THE VEHICLE. NO CHECK-ENGINE LIGHT PROVIDES ANY INDICATION THAT THE VEHICLE IS DANGEROUS. YOU DRIVE DOWN SOME CITY STREETS AND HOP ONTO THE FREEWAY TO GO TO YOUR FAVORITE GROCERY STORE. AFTER GETTING OFF THE FREEWAY THE CAR IS FULLY WARMED UP, AND AS IT DOWNSHIFTS FROM 4TH TO 3RD GEAR IT LURCHES. IT FEELS LIKE THE ENGINE IS TRYING TO JUMP OUT OF THE CAR! NO ENGINE LIGHT COMES ON. THEN YOU STOP AT THE END OF THE OFF-RAMP, AND WAIT FOR A TRAFFIC LIGHT TO TURN. AFTER TURNING THE CAR SHIFTS FROM 1ST TO 2ND GEAR. THEN IT FAILS TO SHIFT FROM 2ND TO 3RD GEAR. THE GEAR DOESN'T ENGAGE, AND THE CAR COASTS DOWN THE ROAD WITHOUT ANY POWER. DRIVERS PASSING BY ARE STARING. THE SUV BEHIND YOU IS RIGHT ON YOUR BUTT; THEY BEGIN HONKING. THERE'S NOTHING YOU CAN DO. FINALLY, AFTER 20 SECONDS OF COASTING THE CAR ENTERS 3RD GEAR WITH A GIANT LURCH. IT FEELS LIKE IT'S GOING TO EXPLODE! YOU PULL INTO THE GROCERY STORE PARKING LOT, HEART RACING, KNOWING THAT THE CAR YOU'RE DRIVING ALMOST CAUSED AN ACCIDENT THAT COULD KILL A HALF A DOZEN PEOPLE. AND YOU KNOW TO GET HOME IT'S GOING TO HAPPEN ALL OVER AGAIN. THIS PROBLEM IS REPORTED BY HUNDREDS OF OWNERS. THIS IS AN EXTREME SAFETY HAZARD. VOLKSWAGEN NEEDS TO RECALL THE AFFECTED VEHICLES AND PAY DAMAGES FOR THOSE WHOSE TRANSMISSIONS WERE DESTROYED BY THIS DEFECTIVE VALVE BODY AND TRANSMISSION.
NHTSA ODI #11415125
79,000 miles · Apr 9, 2018
Fuel/propulsion System
FEUL LEAK, REAR PASSANGER SIDE RIGHT. SAME SIDE THAT THE FUEL FILL IS ON.
VOLKSWAGEN IS RECALLING 76,900 MY 2004-2005 NEW BEETLE AND MY 2003-2005 NEW BEETLE CONVERTIBLES EQUIPPED WITH AN ADVANCED (DUAL-STAGE) AIR BAG SYSTEM. THIS SYSTEM MAY HAVE AIR BAG FRONTAL CRASH SENSORS THAT CONTAIN A SOLDER JOINT ON THE CIRCUIT BOARD THAT MAY CRACK UNDER CERTAIN HIGH TEMPERATURE CONDITIONS. IF THIS OCCURS, THE AIR BAG INDICATOR LIGHT WILL ILLUMINATE AND THE FALLBACK ALGORITHM WILL ENSURE THAT THE FRONT AIR BAGS ALWAYS DEPLOY IN A FRONTAL CRASH IN WHICH THE VEHICLE'S DECELERATION IS HIGH ENOUGH TO ACTIVATE THE FRONTAL AIR BAGS.
Consequence & remedy
Consequence: IN LOW-SEVERITY FRONTAL IMPACTS, THE FRONT AIR BAGS MAY DEPLOY MORE FORCEFULLY THAN DESIGNED, INCREASING THE POSSIBILITY OF INJURY TO OUT-OF-POSITION FRONT SEAT OCCUPANTS.
Remedy: DEALERS WILL INSPECT EACH VEHICLE TO DETERMINE THAT THE SPECIFIC DEFECT CRASH SENSOR IS PRESENT ON ONE OR BOTH SIDES OF THE VEHICLE. ALL OF THE DEFECT CRASH SENSORS WILL BE REPLACED FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR BEFORE JULY 31, 2008. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
ON CERTAIN PASSENGER VEHICLES, THE HIGH PRESSURE DIESEL PUMPS WERE PRODUCED WITH AN IMPROPER FASTENER, WHICH COULD ALLOW DIESEL FUEL TO ESCAPE FROM THE PUMP.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY LEAD TO A FIRE.
Remedy: DEALERS WILL REPLACE THE DIESEL PUMP. THE RECALL BEGAN ON FEBRUARY 8, 2005. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE08012 · Front Air Bag Crash Sensor Failure
Opened Feb 15, 2008 · Closed Apr 24, 2008
Status: closed (inferred from source dates) · Air Bags:frontal:sensor/control MODULE-INACTIVE
CERTAIN SUBJECT VEHICLES, MODEL YEAR (MY) 2003 CONVERTIBLE AND MY 2004 SEDAN AND CONVERTIBLE VEHICLES ARE EQUIPPED WITH AN ADVANCED DUAL-STAGE AIR BAG SYSTEM.THE AIR BAG CRASH SENSORS (#1F0 909 606) CONTAIN A SOLDER JOINT ON THE CIRCUIT BOARD THAT MAY CRACK UNDER CERTAIN HIGH TEMPERATURE CONDITIONS.IF THIS OCCURS, THE AIR BAG INDICATOR LIGHT WILL ILLUMINATE AND THE CONTROL MODULE WILL ENABLE A FALLBACK ALGORITHM THAT WILL ENSURE THAT THE FRONT AIR BAG ALWAYS DEPLOYS IN A FRONTAL CRASH IN WHICH THE VEHICLE'S DECELERATION IS HIGH ENOUGH TO ACTIVATE THE FRONTAL AIR BAGS.HOWEVER, IN LOW-SEVERITY FRONTAL IMPACTS, THE FRONT AIR BAGS MAY DEPLOY MORE FORCEFULLY THAN DESIGNED, INCREASING THE POSSIBILITY OF INJURY TO OUT-OF-POSITION FRONT SEAT OCCUPANTS.VOLKSWAGEN WILL INSPECT FOR THE DEFECTIVE CRASH SENSOR AND REPLACE WITH AN UPDATED DESIGN.IN ADDITION, 16,177 EARLY-MY 2005 NEW BEETLE SEDAN AND CONVERTIBLE VEHICLES (BUILT THROUGH OCT 31, 2004) ARE ALSO INCLUDED IN THE RECALL CAMPAIGN.THIS PRELIMINARY EVALUATION IS CLOSED (SEE RECALL 08V-178)
2004 Volkswagen Beetle Problems, Complaints & Recalls | Skip That Year
Illustration