Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
170–25K
2325–50K
3850–75K
1675–100K
15100–150K
5150K+
114 reports with mileage · 51 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Air Bags. Review the 43 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 36 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 23 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
13 crash reports4 fire reports11 injury reports
What owners actually said
165 reports
73,000 miles · Nov 22, 2004
Seat Belts
I OWN A 2002 VW BEETLE. THE SEAT BELT LATCH BECAME DEFECTIVE, THUS TURNING THE AIRBAG SYSTEM IN MY CAR OFF. I HAVE 80K MILES ON MY CAR AND THE REPAIR COST ME OVER $350. VW IS REFUSING TO PAY FOR THIS VITAL SAFETY ISSUE STATING THEY ARE NOT REQUIRED TO REPAIR OUT OF WARRANTY ITEMS. ISN'T THERE A LAW THAT REQUIRES AUTO MANUFACT…
Read full complaint
I OWN A 2002 VW BEETLE. THE SEAT BELT LATCH BECAME DEFECTIVE, THUS TURNING THE AIRBAG SYSTEM IN MY CAR OFF. I HAVE 80K MILES ON MY CAR AND THE REPAIR COST ME OVER $350. VW IS REFUSING TO PAY FOR THIS VITAL SAFETY ISSUE STATING THEY ARE NOT REQUIRED TO REPAIR OUT OF WARRANTY ITEMS. ISN'T THERE A LAW THAT REQUIRES AUTO MANUFACTURERS TO REPAIR DEFECTIVE SEAT BELTS? DO I HAVE ANY RECOURSE FOR GETTING THIS PAID FOR? THANKS. *JB
NHTSA ODI #10100345
Mileage unknown · Nov 15, 2004
Electrical System
MY CAR CONTINUES TO GET STUCK IN PARK. IT'S LEFT ME STRANDED NEEDING ASSISTANCE FROM STRANGERS. ITS FRUSTRATING AND SCARY TO HAVE THIS HAPPEN.*AK
NHTSA ODI #10098883
19,900 miles · Sep 3, 2004
Power Train
WHILE AT A STOP/DRIVING VEHICLE JERKED FORWARD. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK
NHTSA ODI #10090385
14,900 miles · Jul 26, 2004
Fuel System, GasolineInjury
I HAVE A 2002 VOLKSWAGEN BEETLE AND WAS FILLING THE GAS TANK WITH FUEL AT A TEXACO IN BEAUFORT, SOUTH CAROLINA. THE GAS PUMP SHUT OFF WHEN THE TANK FILLED UP, AND I PULLED THE PUMP FROM MY TANK. WHEN I REMOVED THE PUMP GASOLINE BURST OUT OF THE TANK AND COVERED ME IN GASOLINE. THE GASOLINE WENT INTO MY EYES AND ALL OVER MY BO…
Read full complaint
I HAVE A 2002 VOLKSWAGEN BEETLE AND WAS FILLING THE GAS TANK WITH FUEL AT A TEXACO IN BEAUFORT, SOUTH CAROLINA. THE GAS PUMP SHUT OFF WHEN THE TANK FILLED UP, AND I PULLED THE PUMP FROM MY TANK. WHEN I REMOVED THE PUMP GASOLINE BURST OUT OF THE TANK AND COVERED ME IN GASOLINE. THE GASOLINE WENT INTO MY EYES AND ALL OVER MY BODY AND CLOTHES, AND I BECAME CHEMICALLY BLIND FOR NEARLY TWO HOURS. I WAS RUSHED TO THE HOSPITAL AND HAD TO HAVE MY EYES FLUSHED OUT WITH TWO BOTTLES OF SOLUTION PER EYE. THE GAS STATION REPLACED THE NOZZLE OF THE PUMP, BUT STILL COULD NOT VERIFY THAT THE PUMP WAS TO BLAME. THE EXPERIENCE WAS EXTREMELY TRAUMATIC.*AK
NHTSA ODI #10082716
Mileage unknown · Jul 6, 2004
Electrical System
THE VEHICLE WARNING PANEL LIGHT ILLUMINATE FOR NO APPARENT REASON. THE BATTERY DIED. THE VEHICLE INDICATED IT WAS OVERHEATING WHEN IT WASN'T. THE VEHICLE INDICATED IT WAS OUT OF GAS WHEN IT WASN'T. THE VEHICLE HAS HAD CONSTANT ELECTRICAL PROBLEMS THAT AFFECT THE LIGHTS, DOOR LOCKS, SEATS, ENGINE AND WARNING LIGHTS. THE CONS…
Read full complaint
THE VEHICLE WARNING PANEL LIGHT ILLUMINATE FOR NO APPARENT REASON. THE BATTERY DIED. THE VEHICLE INDICATED IT WAS OVERHEATING WHEN IT WASN'T. THE VEHICLE INDICATED IT WAS OUT OF GAS WHEN IT WASN'T. THE VEHICLE HAS HAD CONSTANT ELECTRICAL PROBLEMS THAT AFFECT THE LIGHTS, DOOR LOCKS, SEATS, ENGINE AND WARNING LIGHTS. THE CONSUMER HAS STOPPED DRIVING THE VEHICLE. *AK
NHTSA ODI #10072216
9,000 miles · Apr 26, 2004
Engine And Engine CoolingFire
I WAS DRIVING AT 65 MPH ATTEMPTED TO ACCELERATE WHEN THE VEHICLE "COUGHED OR SPUTTERED" AND THE ENGINE QUIT. I TURNED THE KEY TO OFF POSITION AND BACK ON AND THE ENGINE RESTARTED. I PROCEEDED TO DRIVE ON DOWN THE HIGHWAY APPROXIMATELY ONE TO TWO MILES WHEN I HEARD A LOUD EXPLOSION, LIKE A BACKFIRE, COME FROM UNDER THE CAR. TH…
Read full complaint
I WAS DRIVING AT 65 MPH ATTEMPTED TO ACCELERATE WHEN THE VEHICLE "COUGHED OR SPUTTERED" AND THE ENGINE QUIT. I TURNED THE KEY TO OFF POSITION AND BACK ON AND THE ENGINE RESTARTED. I PROCEEDED TO DRIVE ON DOWN THE HIGHWAY APPROXIMATELY ONE TO TWO MILES WHEN I HEARD A LOUD EXPLOSION, LIKE A BACKFIRE, COME FROM UNDER THE CAR. THE CAR BEGAN SMOKING IMMEDIATELY A BLUISH SMOKE. I KNEW SOMETHING WAS NOT RIGHT SO I SLOWED DOWN, TURNED AROUND AND BEGAN HEADING BACK TOWARD THE CITY. THE CAR DID NOT HAVE FULL POWER AND SO I WAS ONLY GOING TWENTY TO THIRTY MILES PER HOUR AND HAD TRAVELED ABOUT ONE HALF MILE WHEN ANOTHER CAR BEGAN PASSING ME AND FLAGGED ME DOWN TELLING ME THAT MY CAR WAS ON FIRE. BY THE TIME I GOT STOPPED THE SMOKE WAS COMING OUT THE HOOD AND OUT FROM THE DASH. I IMMDEDIATELY GRABBED MISCELLANEOUS PERSONAL ITEMS AND CARRIED THEM ABOUT 5O FEET BEHIND THE VEHICLE AND WAS ABLE TO RUN BACK FOR ONE MORE TRIP BEFORE IT LOOKED ENTIRELY UNSAFE TO ATTEMPT ANOTHER TRIP. THE WITNESS CALLED 911 BUT THE CAR WAS COMPLETELY BURNT UP BEFORE THE FIRE DEPARTMENT GOT THERE. *AK
NHTSA ODI #10067847
512 miles · Dec 16, 2003
Wheels
THE LEFT FRONT WHEEL SPLIT IN HALF WHILE DRIVING AT NORMAL SPEED. THE CONSUMER HIT A CURB AS A RESULT. THE FRONT AND SIDE AIRBAG DEPLOYED. PLEASE DESCRIBE FURTHER. (VOLKSWAGEN BEETLE 2003 NOT IN SYSTEM.) *JB *MR
NHTSA ODI #10051624
13,000 miles · Dec 10, 2003
Power Train
CONSUMER STATED WHEN SHIFTING THE VEHICLE INTO REVERSE IT MOVED FORWARD. *AK THIS HAPPENED THREE DIFFERENT TIMES TO THREE DIFFERENT DRIVERS. ONCE WHILE SITTING AT A LIGHT, WHEN CONSUMER TOOK FOOT OFF THE BRAKE, IT WENT REVERSE. *PH
NHTSA ODI #10046443
Mileage unknown · Nov 20, 2003
Tires
WHILE DRIVING AT 65 MPH, THE LEFT REAR TIRE EXPLODED. THE DRIVER WAS ABLE TO PULL OVER TO THE SHOULDER. THE DRIVER HAD THE VEHICLE TOWED TO A GAS STATION TO REPLACE THE TIRE. *PH
NHTSA ODI #10048434
Mileage unknown · Aug 25, 2003
Exterior LightingVehicle Speed Control
THE EPC LIGHT COMES ON THE DASH. I WAS TOLD THIS IS DUE TO A BRAKE LIGHT SWITCH THAT WILL GO OUT. THIS CAUSES CRUISE CONTROL TO GO OUT, BRAKE LIGHTS TO NOT WORK, AND DIFFICULTY GETTING YOUR GEARSHIFT OUT OF PARK OR NEUTRAL.*AK
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC OR MANUAL TRANSMISSIONS AND CRUISE CONTROLS, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING SAFETY RECALLS 03V-265 OR 04V-096.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 27, 2006. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:brake Lights:switch
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:brake Lights
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
THE BRAKE LIGHT SWITCH USED IN CRUISE CONTROL EQUIPPED MY 1998-1999 AND ALL MY 2000 AND LATER MODELS HAS UNDERGONE MULTIPLE REVISIONS.ANALYSIS OF WARRANTY AND COMPLAINT DATA INDICATES HIGH REPLACEMENT RATES OCCURRED IN VEHICLES BUILT WITH BRAKE SWITCH PART NUMBERS 1J0 945 511A AND 1J0 945 511B, THE ORIGINAL AND FIRST REVISION LEVELS, RESPECTIVELY.THE FAILURE OF THE SWITCH COULD RESULT IN FAILURE OF THE BRAKE LIGHTS TO ILLUMINATE WHEN THE BRAKES ARE APPLIED, OR COULD CAUSE THE BRAKE LAMPS TO STAY CONTINUALLY ILLUMINATED.EITHER CONDITION RESULTS IN THE INABILITY OF THE BRAKE LIGHTS TO NOTIFY OTHER MOTORISTS OF VEHICLE BRAKING.UNDER SAFETY RECALL 03V-265, VOLKSWAGEN WILL INSPECT THE BRAKE LIGHT SWITCH ON ALL VEHICLES BUILT THROUGH NOVEMBER 2001.ANY AFFECTED SWITCH WILL BE REPLACED FREE OF CHARGE WITH THE MOST CURRENT VERSION, PART NUMBER 1J0 945 511D.
Additional source detail variants (2)
Exterior Lighting:brake Lights:switch
THE BRAKE LIGHT SWITCH USED IN CRUISE CONTROL EQUIPPED MY 1998-1999 AND ALL MY 2000 AND LATER MODELS HAS UNDERGONE MULTIPLE REVISIONS.ANALYSIS OF WARRANTY AND COMPLAINT DATA INDICATES HIGH REPLACEMENT RATES OCCURRED IN VEHICLES BUILT WITH BRAKE SWITCH PART NUMBERS 1J0 945 511A AND 1J0 945 511B, THE ORIGINAL AND FIRST REVISION LEVELS, RESPECTIVELY.THE FAILURE OF THE SWITCH COULD RESULT IN FAILURE OF THE BRAKE LIGHTS TO ILLUMINATE WHEN THE BRAKES ARE APPLIED, OR COULD CAUSE THE BRAKE LAMPS TO STAY CONTINUALLY ILLUMINATED.EITHER CONDITION RESULTS IN THE INABILITY OF THE BRAKE LIGHTS TO NOTIFY OTHER MOTORISTS OF VEHICLE BRAKING.UNDER SAFETY RECALL 03V-265, VOLKSWAGEN WILL INSPECT THE BRAKE LIGHT SWITCH ON ALL VEHICLES BUILT THROUGH NOVEMBER 2001.ANY AFFECTED SWITCH WILL BE REPLACED FREE OF CHARGE WITH THE MOST CURRENT VERSION, PART NUMBER 1J0 945 511D.
Exterior Lighting:brake Lights
THE BRAKE LIGHT SWITCH USED IN CRUISE CONTROL EQUIPPED MY 1998-1999 AND ALL MY 2000 AND LATER MODELS HAS UNDERGONE MULTIPLE REVISIONS.ANALYSIS OF WARRANTY AND COMPLAINT DATA INDICATES HIGH REPLACEMENT RATES OCCURRED IN VEHICLES BUILT WITH BRAKE SWITCH PART NUMBERS 1J0 945 511A AND 1J0 945 511B, THE ORIGINAL AND FIRST REVISION LEVELS, RESPECTIVELY.THE FAILURE OF THE SWITCH COULD RESULT IN FAILURE OF THE BRAKE LIGHTS TO ILLUMINATE WHEN THE BRAKES ARE APPLIED, OR COULD CAUSE THE BRAKE LAMPS TO STAY CONTINUALLY ILLUMINATED.EITHER CONDITION RESULTS IN THE INABILITY OF THE BRAKE LIGHTS TO NOTIFY OTHER MOTORISTS OF VEHICLE BRAKING.UNDER SAFETY RECALL 03V-265, VOLKSWAGEN WILL INSPECT THE BRAKE LIGHT SWITCH ON ALL VEHICLES BUILT THROUGH NOVEMBER 2001.ANY AFFECTED SWITCH WILL BE REPLACED FREE OF CHARGE WITH THE MOST CURRENT VERSION, PART NUMBER 1J0 945 511D.
2002 Volkswagen Beetle Problems, Complaints & Recalls | Skip That Year
Illustration