SUDDEN LOSS OF AIR PRESSURE IN TIRE(S) ON 2001 NEW BEETLE WITH 17 INCH ALUMINUM WHEELS. CAUSED BY CORROSION ON THE BEAD AREA OF THE RIM. CAUSED SEVERE DAMAGE TO TIRE, HAD TO REPLACE ONE EXPENSIVE TIRE BECAUSE OF DAMAGE TO SIDEWALL. 3 TOTAL OCCURRENCES ON 2 DIFFERENT RIMS. TIRE DEALER "CLEANED UP" THE BEAD AREA AND REMOUNTED …
Read full complaint
SUDDEN LOSS OF AIR PRESSURE IN TIRE(S) ON 2001 NEW BEETLE WITH 17 INCH ALUMINUM WHEELS. CAUSED BY CORROSION ON THE BEAD AREA OF THE RIM. CAUSED SEVERE DAMAGE TO TIRE, HAD TO REPLACE ONE EXPENSIVE TIRE BECAUSE OF DAMAGE TO SIDEWALL. 3 TOTAL OCCURRENCES ON 2 DIFFERENT RIMS. TIRE DEALER "CLEANED UP" THE BEAD AREA AND REMOUNTED THE TIRE. LUCKILY ALL FAILURES EITHER OCCURRED AT LOW SPEEDS OR NOTICED WITH CAR PARKED. COULD NOT REINFLATE TIRE AS RIM WOULD NOT RESEAL WITHOUT REMOUNTING. *TR
NHTSA ODI #10371024
7,850 miles · Feb 27, 2007
Wheels
2001 NEW BEETLE GL PROBLEM: DURING HEAVY SNOW FALLS GREATER THAN 6 INCHES, SNOW WILL ACCUMULATE ON THE INSIDE OF THE WHEELS (STEEL APPLICATION ONLY, NO COMMENT ON ALUMINUM WHEELS). WHEN THIS HAPPENS, THE TIRES BECOME UNBALANCED WHICH CAUSES THE ENTIRE VEHICLE TO SHAKE WITH TREMENDOUS FORCE. MY LATEST EXPERIENCE WAS 2/14/06…
Read full complaint
2001 NEW BEETLE GL PROBLEM: DURING HEAVY SNOW FALLS GREATER THAN 6 INCHES, SNOW WILL ACCUMULATE ON THE INSIDE OF THE WHEELS (STEEL APPLICATION ONLY, NO COMMENT ON ALUMINUM WHEELS). WHEN THIS HAPPENS, THE TIRES BECOME UNBALANCED WHICH CAUSES THE ENTIRE VEHICLE TO SHAKE WITH TREMENDOUS FORCE. MY LATEST EXPERIENCE WAS 2/14/06. THE VEHICLE SHAKE WAS SO BAD I COULD NOT DRIVE SAFELY OVER 40 MPH. THE FIRST TIME THIS HAPPENED I TOOK MY VEHICLE TO THE DEALER. ALL HE DID WAS PUT THE VEHICLE IN A HEATED GARAGE TO MELT THE ICE AND SNOW. APPARENTLY THIS WAS HAPPENING TO NUMEROUS NEW BEETLE OWNERS. THIS SITUATION WILL LEAD TO A LOSS OF CONTROL OF THE VEHICLE. THUS A SAFETY ISSUE. PLS DO SOMETHING BEFORE SOMEONE IS HURT. *JB
NHTSA ODI #10183604
98,000 miles · Sep 7, 2006
SuspensionWheelsCrashInjury
WHILE DRIVING HOME FROM WORK AT ABOUT 12 AM IN THE RIGHT HAND LANE ON HIGHWAY 217 IN TIGARD OREGON, JUST PASSED EXIT 4 MY STEERING STARTED PULLING ME TO THE RIGHT SIDE OF THE ROAD, TOWARDS THE GUARD RAIL. (WAS TRAVELING AT APPROX. 55 MPH) I TRIED TO CORRECT BY PULLING THE STEERING WHEEL LEFT, BUT THE VEHICLE WOULD NOT RESPOND.…
Read full complaint
WHILE DRIVING HOME FROM WORK AT ABOUT 12 AM IN THE RIGHT HAND LANE ON HIGHWAY 217 IN TIGARD OREGON, JUST PASSED EXIT 4 MY STEERING STARTED PULLING ME TO THE RIGHT SIDE OF THE ROAD, TOWARDS THE GUARD RAIL. (WAS TRAVELING AT APPROX. 55 MPH) I TRIED TO CORRECT BY PULLING THE STEERING WHEEL LEFT, BUT THE VEHICLE WOULD NOT RESPOND. I THEN HEAR A VERY LOUD SNAPPING/BREAKING NOISE UNDER MY LEFT FOOT AND THE NEXT THING I KNOW MY CAR SLIDES TO THE RIGHT HAND SIDE, INTO THE GUARD RAIL. I THEN BOUNCED OFF OF THE GUARD RAIL AND THE CAR CONTINUED SLIDING/SPINNING UNTIL COMING TO REST IN THE LEFT HAND LANE. TIGARD POLICE ARRIVED AT THE SCENE AND STATED THAT IT LOOKED LIKE THE "SUSPENSION BROKE AND THE WHEEL FELL OFF", CAUSING THE WRECK. THERE WAS SUBSTANTIAL DAMAGE TO THE FRONT END (LEFT SIDE) AND MARKS ON THE REAR BUMPER. WITNESS FOLLOWING BEHIND ME STATED THAT THEY SAW ME DRIVING IN FRONT OF THEM AND THEN ALL OF A SUDDEN THE CAR STARTED SPINNING, APPARENTLY FOR NO REASON SINCE THERE WAS NO IMPACT. *NM
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC OR MANUAL TRANSMISSIONS AND CRUISE CONTROLS, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING SAFETY RECALLS 03V-265 OR 04V-096.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 27, 2006. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:brake Lights:switch
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:brake Lights
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
THE BRAKE LIGHT SWITCH USED IN CRUISE CONTROL EQUIPPED MY 1998-1999 AND ALL MY 2000 AND LATER MODELS HAS UNDERGONE MULTIPLE REVISIONS.ANALYSIS OF WARRANTY AND COMPLAINT DATA INDICATES HIGH REPLACEMENT RATES OCCURRED IN VEHICLES BUILT WITH BRAKE SWITCH PART NUMBERS 1J0 945 511A AND 1J0 945 511B, THE ORIGINAL AND FIRST REVISION LEVELS, RESPECTIVELY.THE FAILURE OF THE SWITCH COULD RESULT IN FAILURE OF THE BRAKE LIGHTS TO ILLUMINATE WHEN THE BRAKES ARE APPLIED, OR COULD CAUSE THE BRAKE LAMPS TO STAY CONTINUALLY ILLUMINATED.EITHER CONDITION RESULTS IN THE INABILITY OF THE BRAKE LIGHTS TO NOTIFY OTHER MOTORISTS OF VEHICLE BRAKING.UNDER SAFETY RECALL 03V-265, VOLKSWAGEN WILL INSPECT THE BRAKE LIGHT SWITCH ON ALL VEHICLES BUILT THROUGH NOVEMBER 2001.ANY AFFECTED SWITCH WILL BE REPLACED FREE OF CHARGE WITH THE MOST CURRENT VERSION, PART NUMBER 1J0 945 511D.
Additional source detail variants (2)
Exterior Lighting:brake Lights:switch
THE BRAKE LIGHT SWITCH USED IN CRUISE CONTROL EQUIPPED MY 1998-1999 AND ALL MY 2000 AND LATER MODELS HAS UNDERGONE MULTIPLE REVISIONS.ANALYSIS OF WARRANTY AND COMPLAINT DATA INDICATES HIGH REPLACEMENT RATES OCCURRED IN VEHICLES BUILT WITH BRAKE SWITCH PART NUMBERS 1J0 945 511A AND 1J0 945 511B, THE ORIGINAL AND FIRST REVISION LEVELS, RESPECTIVELY.THE FAILURE OF THE SWITCH COULD RESULT IN FAILURE OF THE BRAKE LIGHTS TO ILLUMINATE WHEN THE BRAKES ARE APPLIED, OR COULD CAUSE THE BRAKE LAMPS TO STAY CONTINUALLY ILLUMINATED.EITHER CONDITION RESULTS IN THE INABILITY OF THE BRAKE LIGHTS TO NOTIFY OTHER MOTORISTS OF VEHICLE BRAKING.UNDER SAFETY RECALL 03V-265, VOLKSWAGEN WILL INSPECT THE BRAKE LIGHT SWITCH ON ALL VEHICLES BUILT THROUGH NOVEMBER 2001.ANY AFFECTED SWITCH WILL BE REPLACED FREE OF CHARGE WITH THE MOST CURRENT VERSION, PART NUMBER 1J0 945 511D.
Exterior Lighting:brake Lights
THE BRAKE LIGHT SWITCH USED IN CRUISE CONTROL EQUIPPED MY 1998-1999 AND ALL MY 2000 AND LATER MODELS HAS UNDERGONE MULTIPLE REVISIONS.ANALYSIS OF WARRANTY AND COMPLAINT DATA INDICATES HIGH REPLACEMENT RATES OCCURRED IN VEHICLES BUILT WITH BRAKE SWITCH PART NUMBERS 1J0 945 511A AND 1J0 945 511B, THE ORIGINAL AND FIRST REVISION LEVELS, RESPECTIVELY.THE FAILURE OF THE SWITCH COULD RESULT IN FAILURE OF THE BRAKE LIGHTS TO ILLUMINATE WHEN THE BRAKES ARE APPLIED, OR COULD CAUSE THE BRAKE LAMPS TO STAY CONTINUALLY ILLUMINATED.EITHER CONDITION RESULTS IN THE INABILITY OF THE BRAKE LIGHTS TO NOTIFY OTHER MOTORISTS OF VEHICLE BRAKING.UNDER SAFETY RECALL 03V-265, VOLKSWAGEN WILL INSPECT THE BRAKE LIGHT SWITCH ON ALL VEHICLES BUILT THROUGH NOVEMBER 2001.ANY AFFECTED SWITCH WILL BE REPLACED FREE OF CHARGE WITH THE MOST CURRENT VERSION, PART NUMBER 1J0 945 511D.
2001 Volkswagen Beetle Problems, Complaints & Recalls | Skip That Year
Illustration