IllustrationStruts but were told it's either stabilizer or steering rod
2019 Volkswagen Atlas
Owner reports · Recalls · Investigations
More warning signs than most Atlas years
Owner complaints for the 2019 Volkswagen Atlas are substantially higher than the model-year median of 169.
About this comparison →How this year compares
Owner complaints by model year
Compare all Atlas years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
960–25K
2125–50K
1250–75K
675–100K
3100–150K
1150K+
139 reports with mileage · 335 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 141 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes. Review the 76 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 73 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
7 crash reports0 fire reports9 injury reports
Wheels complaints
10 reportsVehicle experiences intermittent front end vibration and shaking at highway speeds, sometimes during light braking. The vibration feels similar to driving over rumble strips and can become strong enough to affect steering feel and driver confidence. The issue occurs intermittently and is more noticeable at higher speeds. Volksw…
Read full complaint
Vehicle experiences intermittent front end vibration and shaking at highway speeds, sometimes during light braking. The vibration feels similar to driving over rumble strips and can become strong enough to affect steering feel and driver confidence. The issue occurs intermittently and is more noticeable at higher speeds. Volkswagen dealership inspected the vehicle and recommended replacement of the steering rack and tie rod components. During the inspection, I was informed the steering rack/tie rod related component was currently on backorder, raising concern that this may not be an isolated issue affecting only this vehicle. Front brake pads and rotors were replaced afterward through an independent repair facility in an attempt to correct the issue, however the vibration and shaking still continue while driving. Vehicle currently has approximately 87,000 miles. No warning lights were present at the time of the issue.
The rear driver side seat belt does not stay in place when the seat is lowered, therefore, leaving this seat without a seatbelt. The adaptive cruise control sometimes works and sometimes does not work. There is no specific reason for this. It works during the snow and does not work during the sunshine. When making a hard right …
Read full complaint
The rear driver side seat belt does not stay in place when the seat is lowered, therefore, leaving this seat without a seatbelt. The adaptive cruise control sometimes works and sometimes does not work. There is no specific reason for this. It works during the snow and does not work during the sunshine. When making a hard right or left turn, there is a grinding noise underneath, I am guessing it has something to do withthe wheels or what the wheels are attached to... I have brought each of these items up to the dealership service department and they look at me like I am crazy stating this is the way volkswagon works. I do not believe this is so.
My car just hit 30,000 miles. The light for loss of tire pressure on my left rear tire goes on. I go to the gas station to put air in the tire, and touch the tread with my fingers. THE INSIDE INCH OF TREAD/RUBBER ON BOTH REAR TIRES IS COMPLETELY WORN DOWN --- down to the metal. Seems like a serious alignment issue to me on this …
Read full complaint
My car just hit 30,000 miles. The light for loss of tire pressure on my left rear tire goes on. I go to the gas station to put air in the tire, and touch the tread with my fingers. THE INSIDE INCH OF TREAD/RUBBER ON BOTH REAR TIRES IS COMPLETELY WORN DOWN --- down to the metal. Seems like a serious alignment issue to me on this vehicle. Service and tire rotations regularly performed at the VW dealership in accordance with manufacturer recommendations.
WAS TRAVELING ON EXPRESSWAY WHEN MY PASSENGER SIDE REAR TIRE BLEW. UPON PULLING OFF THE ROAD I SAW THAT THE WHOLE TIRE HAD SEPARATED FROM THE SIDEWALL AND WOULD NEED TO BE TOWED TO THE DEALERSHIP. ONCE AT THE DEALERSHIP IT WAS DETERMINED THE BLOW OUT CAUSED DAMAGE TO THE STRUT, EMISSIONS, AND WHEEL LINING. WHEN I GOT HOME I RESE…
Read full complaint
WAS TRAVELING ON EXPRESSWAY WHEN MY PASSENGER SIDE REAR TIRE BLEW. UPON PULLING OFF THE ROAD I SAW THAT THE WHOLE TIRE HAD SEPARATED FROM THE SIDEWALL AND WOULD NEED TO BE TOWED TO THE DEALERSHIP. ONCE AT THE DEALERSHIP IT WAS DETERMINED THE BLOW OUT CAUSED DAMAGE TO THE STRUT, EMISSIONS, AND WHEEL LINING. WHEN I GOT HOME I RESEARCHED MY TIRES WHICH ARE CONTINENTAL CROSS CONTACT SPORT LX IN SIZE 225/50/20 AND FOUND THAT THEY HAVE A LONG LIST OF RECALLS ON THIS MODEL OF TIRE. I CALLED CONTINENTAL AND PROVIDED THE DOT NUMBER AND MOLD NUMBER BUT WAS TOLD IT WAS NOT PART OF THE RECALL EVEN THOUGH WHAT HAPPENED TO MY TIRE IS WHAT THE RECALL STATES CAN HAPPEN. I INFORMED THE REPRESENTATIVE THAT I BELIEVE MY TIRE(S) IS ONE OF THE AFFECTED TIRES AS THIS LIST IS ON GOING. I ENDED UP FILING A PROPERTY DAMAGE CLAIM WITH CONTINENTAL AS I FEEL THEY ARE LIABLE FOR THE DAMAGE.
VEHICLE HAS 11K MILES. TOOK THE VEHICLE IN TO REPAIR A TIRE WITH A NAIL. MY ALIGNMENT WAS OFF (I THOUGHT I WAS FEELING A SHAKE ANYWAY). HAD THE ALIGNMENT FIXED BUT A WEEK LATER (FIRST TIME ON THE HIGHWAY) MY VEHICLE IS SHAKING FAR TOO MUCH TO BE THE ROAD. ALL TIRES ARE IN GOOD SHAPE AS THEY WERE CHECKED DURING THE ALIGNMENT. SHA…
Read full complaint
VEHICLE HAS 11K MILES. TOOK THE VEHICLE IN TO REPAIR A TIRE WITH A NAIL. MY ALIGNMENT WAS OFF (I THOUGHT I WAS FEELING A SHAKE ANYWAY). HAD THE ALIGNMENT FIXED BUT A WEEK LATER (FIRST TIME ON THE HIGHWAY) MY VEHICLE IS SHAKING FAR TOO MUCH TO BE THE ROAD. ALL TIRES ARE IN GOOD SHAPE AS THEY WERE CHECKED DURING THE ALIGNMENT. SHAKING DOES NOT OCCUR WHILE DRIVING UNDER 45 MPH.
I BOUGHT MY NEW VW ATLAS IN DECEMBER OF 2019. WHEN I BOUGHT IT, I NOTICED A RUBBING/SQUEAKING NOISE WHEN I TURNED THE STEERING WHEEL BUT WAS TOLD THAT WAS NORMAL FOR A NEW VEHICLES. SO, I LET IT GO, THEN CAME TO REALIZE IT CONTINUED TO GET WORSE AND LOUDER OVER TIME. SO AT MY 10,000 MILE CHECK, THEY TOLD ME IT WAS THE STEERING R…
Read full complaint
I BOUGHT MY NEW VW ATLAS IN DECEMBER OF 2019. WHEN I BOUGHT IT, I NOTICED A RUBBING/SQUEAKING NOISE WHEN I TURNED THE STEERING WHEEL BUT WAS TOLD THAT WAS NORMAL FOR A NEW VEHICLES. SO, I LET IT GO, THEN CAME TO REALIZE IT CONTINUED TO GET WORSE AND LOUDER OVER TIME. SO AT MY 10,000 MILE CHECK, THEY TOLD ME IT WAS THE STEERING RACK THAT NEEDED TO BE REPLACED ASAP BUT THAT IT WAS ON BACK ORDER AND COULD TAKE A COUPLE OF WEEKS FOR THE PART TO COME IN. I WAS TOLD THIS WAS NOT A COMMON ISSUE. SO I WAITED 3-4 WEEKS, AND THE PART FINALLY CAME IN. IT WAS REPLACED AND I THOUGHT I WAS DONE WITH REPAIRS EARLY ON. THEN, A COUPLE OF DAYS PASS AND I FIND THAT THERE IS STILL SOMEWHAT OF A NOISE WHEN I TURN MY WHEEL AND ESPECIALLY WHEN I'M ON THE BACKROADS GOING OVER BUMPS. I TAKE IT BACK THE DEALERSHIP AND OF COURSE, THEY CAN'T REPLICATE THE PROBLEM. A COUPLE MORE WEEKS PASS, I'M STILL HEARING A CREAKY NOISE AND THEN ONE NIGHT ON MY WAY HOME, ALL OF THE SENSOR AND WARNING LIGHTS LIGHT UP IN MY DIGITAL COCKPIT. I HAVE IT TOWED, VW DETERMINES IT'S A TIRE SENSOR OF WHICH THEY REPAIR. THREE WEEKS LATER, HERE I AM AGAIN AND ALL OF MY TIRE PRESSURE SENSORS ARE ON AGAIN ON MY WAY HOME FROM WORK. I HAVE A NEW TIRE FROM WHERE I GOT A FLAT TWO WEEKS AGO, AND THAT TIRE PRESSURE SENSOR LIGHT IS ALSO ON. SO, NOW NOT ONLY AM I HAVING AN ISSUE WITH MY TIRES BUT THE FIRST STEERING WHEEL NOISE ISSUE STILL ISN'T REPAIRED ON AN ATLAS THAT I BOUGHT WITH 12 MILES ON IT IN DECEMBER OF 2019. VW CORPORATE HAS BEEN CALLED, THE DEALERS CORPORATE HAS BEEN CALLED AND STILL I HAVEN'T GOTTEN NOWHERE.
THE CAR VIBRATES WHEN DRIVING 65 MPH OR HIGHER. THE DEALERSHIP ACKNOWLEDGED THE VIBRATION AND REPLACED THE TIRES 3 TIMES BUT THE CAR IS STILL VIBRATING. THE CORPORATE OFFICES OF VW HAVE BEEN CONTACTED BUT THEY WERE NO HELP. *TR
PURCHASED VEHICLE 4/18/2020. SUV WAS SHAKING AND TOLD THE SELLER. THEY STATED THEY WOULD FIX WHEN THEY DID THE STICKER AND REGISTRATION. ATTEMPTED TO FIX THE SHAKING BY ROAD FORCE BALANCE. WAS TOLD WAS A FLAT SPOT SO THEY REPLACED RIMS AND TIRES WITH A SET OFF ANOTHER TRUCK. STILL SHOOK AND WAS PULLING TO RIGHT. THEY ATTEMPTED F…
Read full complaint
PURCHASED VEHICLE 4/18/2020. SUV WAS SHAKING AND TOLD THE SELLER. THEY STATED THEY WOULD FIX WHEN THEY DID THE STICKER AND REGISTRATION. ATTEMPTED TO FIX THE SHAKING BY ROAD FORCE BALANCE. WAS TOLD WAS A FLAT SPOT SO THEY REPLACED RIMS AND TIRES WITH A SET OFF ANOTHER TRUCK. STILL SHOOK AND WAS PULLING TO RIGHT. THEY ATTEMPTED FIXING THE TIRES AND DID ROAD TEST BALANCING ON 4 SEPARATE OCCASIONS. THE TRUCK STILL SHAKES EXCESSIVELY AND PULLS TO THE RIGHT. I CONTACTED CORPORATE AND THE DEALER. THEY STATED THAT THEY DID WHAT THEY COULD AND NO LONGER WISH TO DO ANYTHING ELSE. IT IS A SAFETY CONCERN AS MY WIFE AND TWIN 16 MONTH OLD GIRLS WILL BE IN THE SUV. WE PURCHASED IT BRAND NEW AND HAS BEEN SHAKING SINCE THEN. IT SHAKES AT 40-60 MILES AN HOUR. SO HIGHWAY SPEEDS. IT IS NOT SUITABLE TO BE DRIVEN ON HIGHWAYS AT THOSE SPEEDS. *TR
STRUCK A LARGE POTHOLE WITH DRIVER'S SIDE FRONT WHEEL WHILE TRAVELING 15MPH ON A ROUNDABOUT WHICH APPARENTLY CAUSED THE SIDE AIRBAGS TO DEPLOY. NO BODY DAMAGE AND NO APPEARANCE OF SUSPENSION DAMAGE. TIRE AND WHEEL REMAINED INTACT, DROVE STRAIGHT TO DEALERSHIP FOR CLOSER LOOK/EXPLANATION AS TO WHY ALL SIDE AIRBAGS DEPLOYED.
Official recalls
1226V590000 · Steering
Sep 11, 2026
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Tiguan, 2018-2019 Atlas, and 2019-2021 Audi Q3 vehicles. One of the bolts that attaches the steering rack to the subframe may corrode and break. If this happens, the steering rack housing can break.
Consequence & remedy
Consequence: A broken steering rack housing can result in a loss of steering control, increasing the risk of a crash.
Remedy: Dealers will replace the right-side steering rack mounting bolt, free of charge. Owner notification letters are expected to be mailed November 10, 2026. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's numbers for this recall are 48LG and 48VT. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on September 16, 2026.
23V671000 · Air Bags:side/window:curtain
Oct 4, 2023
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2019 Atlas vehicles. The driver's side impact air bag may be missing a weld at the side air bag housing.
Consequence & remedy
Consequence: The driver's side impact air bag could deploy improperly or detach in a crash, increasing the risk of injury.
Remedy: Dealers will replace the driver's side impact air bag, free of charge. Owner notification letters were mailed October 19, 2023. Owners may contact Volkswagen's customer service at 1-800-893-5298. Volkswagen's number for this recall is 69FK.
23V215000 · Air Bags:sensor:occupant Classification:front Passenger
Mar 29, 2023
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018-2021 Atlas and 2020 Atlas Cross Sport vehicles. The passenger occupant detection system (PODS) may experience a fault in the wiring and deactivate the front passenger air bag when the seat is occupied.
Consequence & remedy
Consequence: A deactivated passenger air bag increases the risk of injury during a crash.
Remedy: Dealers will replace the PODS sensor mat and wiring harness, free of charge. Owner notification letters were mailed on March 22, 2024. Owners may contact Volkswagen's customer service at 1-800-893-5298. Volkswagen's number for this recall is 69FB.
22V815000 · Tires:pressure Monitoring And Regulating Systems
Oct 31, 2022
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2019 Volkswagen Tiguan LWB, Golf Sportswagen A7, Golf Alltrack, Golf R GP, Audi Q3, Audi A3 Cabriolet, 2019-2020 Jetta NF, Jetta GLI, Golf GTI, Atlas, Golf A7, Audi A3, 2020-2021 Atlas Cross Sport, and 2021 Atlas FL vehicles. The tire pressure monitoring system may not detect an air pressure loss in adequate time when deflating occurs among all four tires simultaneously. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 138, "Tire Pressure Monitoring Systems."
Consequence & remedy
Consequence: An undetected sudden loss of pressure in all four tires increases the risk of a crash.
Remedy: Dealers will update the TPMS software, free of charge. Owner notification letters were mailed November 18, 2022. Owners may contact Volkswagen's customer service at 1-800-893-5298 or Audis customer service at 1-800-253-2834. Volkswagen's numbers for this recall are (Audi) 45J7, and (VW) 45J6 and 45J8.
22V152000 · Air Bags:side/window
Mar 28, 2022
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2019-2020 Atlas, 2020-2023 Atlas Cross Sport, and 2021-2023 Atlas FL vehicles. The door wiring harness electrical contacts may corrode, disrupting the electrical connection and delaying the deployment of the driver or passenger front side air bag during a side impact crash.
Consequence & remedy
Consequence: A delayed air bag deployment can increase the risk of injury.
Remedy: Dealers will secure and, as necessary, replace any the front door wiring harnesses showing a fault code, free of charge. Owner notification letters were mailed June 20, 2022. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 97GF.
22V086000 · Equipment:other:labels
Feb 16, 2022
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018-2021 Atlas and 2020-2021 Atlas Cross Sport vehicles equipped with accessory side steps. The reduced Gross Vehicle Weight Rating (GVWR) label, reflecting the additional weight of the side steps, was not installed. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: Without the reduced GVWR label, the vehicle could be overloaded, leading to a loss of control and increasing the risk of a crash.
Remedy: Dealers will install the reduced GVWR label, free of charge. Owner notification letters were mailed March 31, 2022. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 09D9.
21V142000 · Tires:sidewall
Mar 5, 2021
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018-2019 Atlas vehicles equipped with Continental tires. On the affected vehicles, it is possible that one or more tires were cured for too long during tire production.
Consequence & remedy
Consequence: Over cured tires may develop a break in the sidewall, resulting in sudden air loss or belt edge separation which could lead to tread/belt loss. Either condition can cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will inspect the tires, and replace them as necessary, free of charge. The recall began on March 24, 2021. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 44R1.
19V614000 · Fuel System, Gasoline:storage:tank Assembly
Aug 21, 2019
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2019 Atlas vehicles. The suction jet in the fuel tank may have been welded in the incorrect position allowing fuel to leak. Additionally, the vehicle may stall due to uneven fuel distribution.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire. An engine stall can increase the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will replace the fuel tank, free of charge. The recall began August 30, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 20BU.
19V389000 · Exterior Lighting:headlights
May 22, 2019
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2012-2020 Volkswagen Passat and 2018-2019 Atlas vehicles. The blocking cap disabling the adjustment of the headlight's horizontal aim may not have been installed. As such, these vehicles fail to conform to Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: Without the blocking cap, the headlight aim can be adjusted out of specification, reducing visibility and increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will inspect and, as necessary, block the headlight horizontal adjustment, free of charge. The recall began July 16, 2019. Owners may contact Volkswagen customer service at 1-800-253-2834. Volkswagen's number for this recall is 94L9.
19V218000 · Air Bags:side/window
Mar 20, 2019
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2019 Atlas and 2020 Passat vehicles. An incorrect driver and/or front passenger side impact air bag may have been installed.
Consequence & remedy
Consequence: In an event of a side impact crash, an incorrect side airbag may not deploy as intended, increasing the risk of injury.
Remedy: Volkswagen has inspected and replaced the side air bags, free of charge. The recall was completed in April 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 69Y8.
18V904000 · Suspension:rear:springs:coil Springs
Dec 19, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018-2019 Volkswagen Atlas, 2015 Volkswagen Golf SportWagen, and 2019 Volkswagen Jetta vehicles. The rear coil springs may prematurely fracture.
Consequence & remedy
Consequence: If a coil spring fractures while driving, it may damage a rear tire causing a loss of vehicle control, increasing the risk of a crash.
Remedy: Volkswagen has notified owners, and dealers will replace the rear axle coil springs, free of charge. The recall began January 31, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 42J2/42J3.
18V824000 · Electrical System: Instrument Cluster/panel
Nov 26, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018-2019 Volkswagen Atlas and Tiguan and 2019 Volkswagen Jetta vehicles that do not have keyless entry. The instrument cluster may not provide an audible warning to let the driver know that the key is still in the ignition when the door is open. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection."
Consequence & remedy
Consequence: If the driver is not notified by an audible noise that the key is left in the ignition, it can increase the risk of vehicle theft or crash.
Remedy: Volkswagen will notify owners, and dealers will reprogram the instrument cluster, free of charge. The recall began December 13, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's numbers for this recall are 90L3 and 90L4.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA24004 · Inadvertent Automatic Emergency Braking
Opened Dec 18, 2024 · No close date supplied
Status: open (inferred from source dates) · Forward Collision Avoidance; Forward Collision Avoidance: Automatic Emergency Braking
On September 28, 2023, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE23017) to assess reports of inadvertent activation of the Front Assist automatic emergency braking (AEB) system in model year (MY) 2018-2019 Volkswagen Atlas vehicles. The reports alleged that activation of the AEB system occurred while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Volkswagen indicated that it is aware of a total of 226 reports that may relate to the alleged defect in MY 2019 Volkswagen Atlas vehicles.Volkswagen stated that some customers possibly had an inadequate understanding of Front Assist and its limitations. However, many consumer complaints alleged that Volkswagen dealerships were unable to reproduce the condition or stated that Volkswagen dealerships informed the consumers that this braking is considered normal Front Assist operation. ODI's analysis shows that MY 2019 Volkswagen Atlas vehicles have the highest rate of unique incident reports alleging AEB inadvertent activation when compared to their Volkswagen peers. To date, ODI has received a total of 44 consumer complaints of inadvertent activation of Front Assist in MY 2019 Volkswagen Atlas vehicles.In total, ODI reviewed 187 unique (i.e., non-duplicative Vehicle Identification Numbers) reports that may relate to the alleged defect, which include four reports on injury incidents and one report involving a crash. PE23017 has been upgraded to an Engineering Analysis to further assess the scope, frequency, and potential safety-related consequences of inadvertent AEB activations in MY 2019 Volkswagen Atlas vehicles. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Forward Collision Avoidance: Automatic Emergency Braking
On September 28, 2023, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE23017) to assess reports of inadvertent activation of the Front Assist automatic emergency braking (AEB) system in model year (MY) 2018-2019 Volkswagen Atlas vehicles. The reports alleged that activation of the AEB system occurred while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Volkswagen indicated that it is aware of a total of 226 reports that may relate to the alleged defect in MY 2019 Volkswagen Atlas vehicles.Volkswagen stated that some customers possibly had an inadequate understanding of Front Assist and its limitations. However, many consumer complaints alleged that Volkswagen dealerships were unable to reproduce the condition or stated that Volkswagen dealerships informed the consumers that this braking is considered normal Front Assist operation. ODI's analysis shows that MY 2019 Volkswagen Atlas vehicles have the highest rate of unique incident reports alleging AEB inadvertent activation when compared to their Volkswagen peers. To date, ODI has received a total of 44 consumer complaints of inadvertent activation of Front Assist in MY 2019 Volkswagen Atlas vehicles.In total, ODI reviewed 187 unique (i.e., non-duplicative Vehicle Identification Numbers) reports that may relate to the alleged defect, which include four reports on injury incidents and one report involving a crash. PE23017 has been upgraded to an Engineering Analysis to further assess the scope, frequency, and potential safety-related consequences of inadvertent AEB activations in MY 2019 Volkswagen Atlas vehicles. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Forward Collision Avoidance
On September 28, 2023, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE23017) to assess reports of inadvertent activation of the Front Assist automatic emergency braking (AEB) system in model year (MY) 2018-2019 Volkswagen Atlas vehicles. The reports alleged that activation of the AEB system occurred while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Volkswagen indicated that it is aware of a total of 226 reports that may relate to the alleged defect in MY 2019 Volkswagen Atlas vehicles.Volkswagen stated that some customers possibly had an inadequate understanding of Front Assist and its limitations. However, many consumer complaints alleged that Volkswagen dealerships were unable to reproduce the condition or stated that Volkswagen dealerships informed the consumers that this braking is considered normal Front Assist operation. ODI's analysis shows that MY 2019 Volkswagen Atlas vehicles have the highest rate of unique incident reports alleging AEB inadvertent activation when compared to their Volkswagen peers. To date, ODI has received a total of 44 consumer complaints of inadvertent activation of Front Assist in MY 2019 Volkswagen Atlas vehicles.In total, ODI reviewed 187 unique (i.e., non-duplicative Vehicle Identification Numbers) reports that may relate to the alleged defect, which include four reports on injury incidents and one report involving a crash. PE23017 has been upgraded to an Engineering Analysis to further assess the scope, frequency, and potential safety-related consequences of inadvertent AEB activations in MY 2019 Volkswagen Atlas vehicles. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE23017 · Inadvertent Automatic Emergency Braking
Opened Sep 28, 2023 · Closed Dec 18, 2024
Status: closed (inferred from source dates) · Forward Collision Avoidance; Forward Collision Avoidance: Automatic Emergency Braking
On September 28, 2023, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE23017) to assess reports of inadvertent activation of the Front Assist automatic emergency braking (AEB) system in model year (MY) 2018-2019 Volkswagen Atlas vehicles.The reports alleged that activation of the AEB system occurred while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Volkswagen indicated that it is aware of a total of 292 reports that may relate to the alleged defect in MY 2018-2019 Volkswagen Atlas vehicles.Volkswagen stated that some customers possibly had an inadequate understanding of Front Assist and its limitations. However, many consumer complaints alleged that Volkswagen dealerships were unable to reproduce the condition or Volkswagen dealerships informed the consumers that this braking is considered normal Front Assist operation. ODI's analysis shows that MY 2019 Volkswagen Atlas vehicles have the highest rate of unique incident reports alleging AEB inadvertent activation when compared to their Volkswagen peers.The rate of unique incident reports alleging AEB inadvertent activation in MY 2018 Volkswagen Atlas vehicles was comparable to their Volkswagen peers. To date, ODI has received a total of 69 consumer complaints of inadvertent activation of Front Assist in MY 2018-2019 Volkswagen Atlas vehicles. In total, ODI reviewed 264 unique (i.e., non-duplicative Vehicle Identification Numbers) reports that may relate to the alleged defect, which include eight reports of incidents involving an alleged injury and two reports involving a crash. PE23017 has been upgraded to an Engineering Analysis (EA24004) to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations in MY 2019 Volkswagen Atlas vehicles. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Forward Collision Avoidance: Automatic Emergency Braking
On September 28, 2023, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE23017) to assess reports of inadvertent activation of the Front Assist automatic emergency braking (AEB) system in model year (MY) 2018-2019 Volkswagen Atlas vehicles.The reports alleged that activation of the AEB system occurred while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Volkswagen indicated that it is aware of a total of 292 reports that may relate to the alleged defect in MY 2018-2019 Volkswagen Atlas vehicles.Volkswagen stated that some customers possibly had an inadequate understanding of Front Assist and its limitations. However, many consumer complaints alleged that Volkswagen dealerships were unable to reproduce the condition or Volkswagen dealerships informed the consumers that this braking is considered normal Front Assist operation. ODI's analysis shows that MY 2019 Volkswagen Atlas vehicles have the highest rate of unique incident reports alleging AEB inadvertent activation when compared to their Volkswagen peers.The rate of unique incident reports alleging AEB inadvertent activation in MY 2018 Volkswagen Atlas vehicles was comparable to their Volkswagen peers. To date, ODI has received a total of 69 consumer complaints of inadvertent activation of Front Assist in MY 2018-2019 Volkswagen Atlas vehicles. In total, ODI reviewed 264 unique (i.e., non-duplicative Vehicle Identification Numbers) reports that may relate to the alleged defect, which include eight reports of incidents involving an alleged injury and two reports involving a crash. PE23017 has been upgraded to an Engineering Analysis (EA24004) to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations in MY 2019 Volkswagen Atlas vehicles. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Forward Collision Avoidance
On September 28, 2023, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE23017) to assess reports of inadvertent activation of the Front Assist automatic emergency braking (AEB) system in model year (MY) 2018-2019 Volkswagen Atlas vehicles.The reports alleged that activation of the AEB system occurred while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Volkswagen indicated that it is aware of a total of 292 reports that may relate to the alleged defect in MY 2018-2019 Volkswagen Atlas vehicles.Volkswagen stated that some customers possibly had an inadequate understanding of Front Assist and its limitations. However, many consumer complaints alleged that Volkswagen dealerships were unable to reproduce the condition or Volkswagen dealerships informed the consumers that this braking is considered normal Front Assist operation. ODI's analysis shows that MY 2019 Volkswagen Atlas vehicles have the highest rate of unique incident reports alleging AEB inadvertent activation when compared to their Volkswagen peers.The rate of unique incident reports alleging AEB inadvertent activation in MY 2018 Volkswagen Atlas vehicles was comparable to their Volkswagen peers. To date, ODI has received a total of 69 consumer complaints of inadvertent activation of Front Assist in MY 2018-2019 Volkswagen Atlas vehicles. In total, ODI reviewed 264 unique (i.e., non-duplicative Vehicle Identification Numbers) reports that may relate to the alleged defect, which include eight reports of incidents involving an alleged injury and two reports involving a crash. PE23017 has been upgraded to an Engineering Analysis (EA24004) to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations in MY 2019 Volkswagen Atlas vehicles. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
PE21008 · Fuel Injector Leak
Opened Mar 29, 2021 · Closed Oct 3, 2022
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:fuel Injection System:injectors
On March 29, 2021, the Office of Defects Investigations (ODI) opened PE21-008 to investigate instances of fuel injectors leaking in the engine compartment in model year (MY) 2018 through 2020 Volkswagen Atlas and Atlas Cross Sport SUVs. These vehicles are equipped with either a 3.6 or 2.0 liter engine. The subject investigation concerns vehicles equipped with 3.6L engines. Prior to opening the investigation, ODI also observed that warranty data for the fuel system from TREAD reporting was an outlier for the MY 2018 Atlas.The allegation involved fuel injectors leaking fuel near engine compartment components that operate at high temperatures. Consumers allege a fuel leak, fuel odor, and/or an illuminated check engine malfunction indicator light (MIL) on that alerts them to the condition. Fuel leaking in the engine compartment has a higher potential risk of fire as nearby components are operating at higher temperatures compared to other areas of the vehicle. No fires have been connected to this issue to date.The 3.6L engine is a VR6 type engine. Due to its specific design, the VR6 has two types of injectors with different designs installed. Cylinders 1, 3, and 5 use long injectors and cylinders 2, 4, and 6 use short injectors. Unlike the short injectors, the long injectors require an extension pipe necessary to reach cylinders 1, 3, and 5. Volkswagen stated that the potential root cause for a leaking injector is typically either a damaged, misaligned, or missing supporting ring or a damaged O-ring. These rings assist in connecting the injector to the extension pipe. If one of these conditions is present in a vehicle, the O-ring has difficulty withstanding fuel pressure over time.Volkswagen stated that an analysis of warranty data related to leaking injectors in vehicles equipped with 3.6L engines showed that the vast majority of leaking allegations were related to internal leaks. Fuel can leak into the cylinder causing misfiring in the affected cylinders. This condition would not cause fuel to enter into the engine compartment. Volkswagen states that these internal leaks pose no unreasonable risk to motor vehicle safety.Analysis of all relevant data indicates that the subject condition is an early-life failure with a relatively low failure rate. The average failure mileage calculated from all data sources was determined to be approximately 14,000 miles. Only two failures were reported outside of the vehicles' warranty coverage period. The average time to failure for the subject vehicle population is approximately 12 months in service (MIS). The majority of failures were below the average of 14,000 miles or 12 MIS. Analysis of reported failures showed that the failure rate is approximately 0.08% or 0.8 incidents per thousand vehicles (IPTV).To date, there have been no reported fires, crashes, injuries, or fatalities related to this issue. In view of the low rate of failure, the nature of early-life failure, and low potential hazard to drivers, this Preliminary Evaluation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers:11446833, 11438403, 11382958, 11298402, 11291955, 11218819, 11218780
Additional source detail variants (2)
Fuel System, Gasoline:fuel Injection System:injectors
On March 29, 2021, the Office of Defects Investigations (ODI) opened PE21-008 to investigate instances of fuel injectors leaking in the engine compartment in model year (MY) 2018 through 2020 Volkswagen Atlas and Atlas Cross Sport SUVs. These vehicles are equipped with either a 3.6 or 2.0 liter engine. The subject investigation concerns vehicles equipped with 3.6L engines. Prior to opening the investigation, ODI also observed that warranty data for the fuel system from TREAD reporting was an outlier for the MY 2018 Atlas.The allegation involved fuel injectors leaking fuel near engine compartment components that operate at high temperatures. Consumers allege a fuel leak, fuel odor, and/or an illuminated check engine malfunction indicator light (MIL) on that alerts them to the condition. Fuel leaking in the engine compartment has a higher potential risk of fire as nearby components are operating at higher temperatures compared to other areas of the vehicle. No fires have been connected to this issue to date.The 3.6L engine is a VR6 type engine. Due to its specific design, the VR6 has two types of injectors with different designs installed. Cylinders 1, 3, and 5 use long injectors and cylinders 2, 4, and 6 use short injectors. Unlike the short injectors, the long injectors require an extension pipe necessary to reach cylinders 1, 3, and 5. Volkswagen stated that the potential root cause for a leaking injector is typically either a damaged, misaligned, or missing supporting ring or a damaged O-ring. These rings assist in connecting the injector to the extension pipe. If one of these conditions is present in a vehicle, the O-ring has difficulty withstanding fuel pressure over time.Volkswagen stated that an analysis of warranty data related to leaking injectors in vehicles equipped with 3.6L engines showed that the vast majority of leaking allegations were related to internal leaks. Fuel can leak into the cylinder causing misfiring in the affected cylinders. This condition would not cause fuel to enter into the engine compartment. Volkswagen states that these internal leaks pose no unreasonable risk to motor vehicle safety.Analysis of all relevant data indicates that the subject condition is an early-life failure with a relatively low failure rate. The average failure mileage calculated from all data sources was determined to be approximately 14,000 miles. Only two failures were reported outside of the vehicles' warranty coverage period. The average time to failure for the subject vehicle population is approximately 12 months in service (MIS). The majority of failures were below the average of 14,000 miles or 12 MIS. Analysis of reported failures showed that the failure rate is approximately 0.08% or 0.8 incidents per thousand vehicles (IPTV).To date, there have been no reported fires, crashes, injuries, or fatalities related to this issue. In view of the low rate of failure, the nature of early-life failure, and low potential hazard to drivers, this Preliminary Evaluation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers:11446833, 11438403, 11382958, 11298402, 11291955, 11218819, 11218780
Fuel System, Gasoline
On March 29, 2021, the Office of Defects Investigations (ODI) opened PE21-008 to investigate instances of fuel injectors leaking in the engine compartment in model year (MY) 2018 through 2020 Volkswagen Atlas and Atlas Cross Sport SUVs. These vehicles are equipped with either a 3.6 or 2.0 liter engine. The subject investigation concerns vehicles equipped with 3.6L engines. Prior to opening the investigation, ODI also observed that warranty data for the fuel system from TREAD reporting was an outlier for the MY 2018 Atlas.The allegation involved fuel injectors leaking fuel near engine compartment components that operate at high temperatures. Consumers allege a fuel leak, fuel odor, and/or an illuminated check engine malfunction indicator light (MIL) on that alerts them to the condition. Fuel leaking in the engine compartment has a higher potential risk of fire as nearby components are operating at higher temperatures compared to other areas of the vehicle. No fires have been connected to this issue to date.The 3.6L engine is a VR6 type engine. Due to its specific design, the VR6 has two types of injectors with different designs installed. Cylinders 1, 3, and 5 use long injectors and cylinders 2, 4, and 6 use short injectors. Unlike the short injectors, the long injectors require an extension pipe necessary to reach cylinders 1, 3, and 5. Volkswagen stated that the potential root cause for a leaking injector is typically either a damaged, misaligned, or missing supporting ring or a damaged O-ring. These rings assist in connecting the injector to the extension pipe. If one of these conditions is present in a vehicle, the O-ring has difficulty withstanding fuel pressure over time.Volkswagen stated that an analysis of warranty data related to leaking injectors in vehicles equipped with 3.6L engines showed that the vast majority of leaking allegations were related to internal leaks. Fuel can leak into the cylinder causing misfiring in the affected cylinders. This condition would not cause fuel to enter into the engine compartment. Volkswagen states that these internal leaks pose no unreasonable risk to motor vehicle safety.Analysis of all relevant data indicates that the subject condition is an early-life failure with a relatively low failure rate. The average failure mileage calculated from all data sources was determined to be approximately 14,000 miles. Only two failures were reported outside of the vehicles' warranty coverage period. The average time to failure for the subject vehicle population is approximately 12 months in service (MIS). The majority of failures were below the average of 14,000 miles or 12 MIS. Analysis of reported failures showed that the failure rate is approximately 0.08% or 0.8 incidents per thousand vehicles (IPTV).To date, there have been no reported fires, crashes, injuries, or fatalities related to this issue. In view of the low rate of failure, the nature of early-life failure, and low potential hazard to drivers, this Preliminary Evaluation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers:11446833, 11438403, 11382958, 11298402, 11291955, 11218819, 11218780