NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes complaints
76 reportsClear category filter11,700 miles · Nov 9, 2020
Forward Collision AvoidanceService Brakes
CAR HAS STOPPED ABRUPTLY IN TRAFFIC ON TWO OCCASION IN WHAT SHOULD HAVE BEEN INNOCUOUS CIRCUMSTANCES. FIRST WAS TRAVELING IN A STRAIGHT LINE ON A SLIGHT DECLINE AND NO HAZARDS, SLOW MOVING MODERATE TRAFFIC (ABOUT 25 - 30 MPH), WHERE THE CAR WAS COASTING (DRIVE NEITHER ACCELERATING OR BRAKING) IN PERFECT WEATHER. SECOND WAS MAK…
Read full complaint
CAR HAS STOPPED ABRUPTLY IN TRAFFIC ON TWO OCCASION IN WHAT SHOULD HAVE BEEN INNOCUOUS CIRCUMSTANCES. FIRST WAS TRAVELING IN A STRAIGHT LINE ON A SLIGHT DECLINE AND NO HAZARDS, SLOW MOVING MODERATE TRAFFIC (ABOUT 25 - 30 MPH), WHERE THE CAR WAS COASTING (DRIVE NEITHER ACCELERATING OR BRAKING) IN PERFECT WEATHER. SECOND WAS MAKING A TURN AT A GREEN LEFT TURN SIGNAL, PROBABLY AT SPEED OF 15 MPH; AGAIN PERFECT WEATHER. DEALER RESPONSE WAS TO INDICATE THE SYSTEM WAS SENSITIVE AND OFFERED TO DEACTIVATE IT. SECOND RESPONSE WAS TO "RECALIBRATE" IT FOR $400. THIS VEHICLE HAS LESS THAN 12,000 VERY LIGHT MILES ON IT.
NHTSA ODI #11373804
25,000 miles · Sep 25, 2020
Service Brakes
MULTIPLE TIMES THE SUV WILL AUTOMATICALLY BREAK WITH THE PARKING BREAK. IT HAS HAPPENED WILL TRYING TO TAKE OFF FROM A LIGHT. AND WHILE DRIVING. CITY STREET
NHTSA ODI #11361207
12,000 miles · Sep 16, 2020
Service Brakes
AUTONOMOUS BREAKING OCCURS WITHOUT WARNING WITH NOTHING ON THE ROAD. THIS HAS HAPPENED ON SEVERAL OCCASION, BUT TODAY (09/16/2020) THIS OCCURRED WHILE DRIVING APPROXIMATELY 55 MPH ON APD 40 IN CLEVELAND, TENNESSEE WITH NO OBSTRUCTION IN FRONT OF VEHICLE. DASHCAM FOOTAGE MAY BE AVAILABLE, I'LL CHECK LATER TODAY TO SEE IF IT WAS…
Read full complaint
AUTONOMOUS BREAKING OCCURS WITHOUT WARNING WITH NOTHING ON THE ROAD. THIS HAS HAPPENED ON SEVERAL OCCASION, BUT TODAY (09/16/2020) THIS OCCURRED WHILE DRIVING APPROXIMATELY 55 MPH ON APD 40 IN CLEVELAND, TENNESSEE WITH NO OBSTRUCTION IN FRONT OF VEHICLE. DASHCAM FOOTAGE MAY BE AVAILABLE, I'LL CHECK LATER TODAY TO SEE IF IT WAS CAPTURED.
NHTSA ODI #11355313
5,800 miles · Sep 5, 2020
Electronic Stability Control (esc)Service BrakesVehicle Speed Control
CAR DISENGAGED ADAPTIVE CRUISE CONTROL AND EMERGENCY BRAKED SUDDENLY ("SLAMMED ON THE BRAKES"), WHILE DASHBOARD LIGHTS FLASHED WARNINGS OF FRONT END IMPACT AND DISENGAGEMENT OF ACC AND ALL ASSISTANCE SYSTEMS. THE CAR WAS TRAVELING 68MPH ON A STRAIGHT LINE, FLAT BRIDGE OVER WATER. OTHER CARS WERE TO THE SIDE AND REAR OF THE VEHIC…
Read full complaint
CAR DISENGAGED ADAPTIVE CRUISE CONTROL AND EMERGENCY BRAKED SUDDENLY ("SLAMMED ON THE BRAKES"), WHILE DASHBOARD LIGHTS FLASHED WARNINGS OF FRONT END IMPACT AND DISENGAGEMENT OF ACC AND ALL ASSISTANCE SYSTEMS. THE CAR WAS TRAVELING 68MPH ON A STRAIGHT LINE, FLAT BRIDGE OVER WATER. OTHER CARS WERE TO THE SIDE AND REAR OF THE VEHICLE, BUT NO FRONT END COLLISION WAS POSSIBLE AT THE TIME. DEALERSHIP CLAIMS THIS IS A RADAR ISSUE THAT "EVERY CAR HAS." EXTREMELY DANGEROUS!
NHTSA ODI #11353353
15,000 miles · Sep 3, 2020
Electrical SystemService BrakesInjury
THE AUTO BRAKING SYSTEM ACTIVATS ON ITS OWN WHILE IN MOTION. ON MULTIPLE OCCASSIONS THE CAR HAS SUDDENLY BRAKED AND IVE COME TO A COMPLETE STOP IN THE MIDDLE OF THE ROAD. NO CARS, DEBRIS, HAZARDS, OR ANYTHING WERE IN FRONT OF ME THAT SHOULD HAVE ACTIVATED THE AUTOMATIC COLLISION PREVENTION SYSTEM. IT IS SO SUDDEN THAT IT LEFT MY…
Read full complaint
THE AUTO BRAKING SYSTEM ACTIVATS ON ITS OWN WHILE IN MOTION. ON MULTIPLE OCCASSIONS THE CAR HAS SUDDENLY BRAKED AND IVE COME TO A COMPLETE STOP IN THE MIDDLE OF THE ROAD. NO CARS, DEBRIS, HAZARDS, OR ANYTHING WERE IN FRONT OF ME THAT SHOULD HAVE ACTIVATED THE AUTOMATIC COLLISION PREVENTION SYSTEM. IT IS SO SUDDEN THAT IT LEFT MY NECK AND SHOULDERS (SEAT BELT AREA) VERY SORE. THE AUTOMATIC COLLISION PREVENTION SYSTEM IS SUPPOSED TO BE A SAFETY FEATURE BUT NEARLY CAUSED A COLLISION. I HAVE TAKEN IT TO THE DEALER MULTIPLE TIMES FOR THE PROBLEM BUT EVERYTIME THEY SAY THERE ARE NO ERRRORS REPORTED ON THEIR COMPUTER AND THERE IS NOTHING THEY CAN DO. THIS IS A KNOWN PROBLEM AMONG MANY VW OWNERS AND VW KNOWS TOO BUT DOESN'T ADDRESS IT.
NHTSA ODI #11353009
10,000 miles · Sep 3, 2020
Electrical SystemService Brakes
WHEN GOING UP OR DOWN A STEEP HILL, AND ALSO 1 TIME PULLING OUT OF A PARKING LOT MY EMERGENCY BRAKES HAVE ENGAGED 5 TIMES. NO CARS HAVE BEEN AROUND (LUCKILY) AND I WAS NOT ABOUT TO HIT ANYTHING. MY COLLISION SENSORS ALSO GO OFF DAILY-THE ENTIRE TIME I'M DRIVING EVEN WHILE NOTHING IS AROUND. I CAN PULL UP TO AN EMPTY INTERSECTION…
Read full complaint
WHEN GOING UP OR DOWN A STEEP HILL, AND ALSO 1 TIME PULLING OUT OF A PARKING LOT MY EMERGENCY BRAKES HAVE ENGAGED 5 TIMES. NO CARS HAVE BEEN AROUND (LUCKILY) AND I WAS NOT ABOUT TO HIT ANYTHING. MY COLLISION SENSORS ALSO GO OFF DAILY-THE ENTIRE TIME I'M DRIVING EVEN WHILE NOTHING IS AROUND. I CAN PULL UP TO AN EMPTY INTERSECTION AND THEY WILL DO OFF. I HAVE TRIED TO CHANGE THE SENSITIVITY AND THIS STILL HAPPENS. THEY ARE NOT CONSISTENT EITHER- THE SAME ROAD CAN MAKE IT GO OFF ONE DAY AND NOT THE NEXT. BUT THEY ARE ALWAYS GOING OFF WHILE DRIVING AND I HAVE TO EXIT OUT OF THE SCREEN
NHTSA ODI #11352920
5,000 miles · Sep 2, 2020
Service BrakesUnknown Or Other
WHEN DRIVING THE VEHICLE THE BRAKES WILL AUTOMATICALLY ENGAGE SLAMMING THE CAR INTO A STAND STILL AND POTENTIALLY BEING HIT. THERE ARE SENSORS THAT ACTIVATE THE BRAKES AND THEY GO OFF WHEN THERE IS NOTHING AROUND TO SET THEM OFF. TOOK THE CAR IN. THEY COULD NOT DUPLICATE THE PROBLEM. THEY CALLED THE TECH ASSIST LINE AND THEY…
Read full complaint
WHEN DRIVING THE VEHICLE THE BRAKES WILL AUTOMATICALLY ENGAGE SLAMMING THE CAR INTO A STAND STILL AND POTENTIALLY BEING HIT. THERE ARE SENSORS THAT ACTIVATE THE BRAKES AND THEY GO OFF WHEN THERE IS NOTHING AROUND TO SET THEM OFF. TOOK THE CAR IN. THEY COULD NOT DUPLICATE THE PROBLEM. THEY CALLED THE TECH ASSIST LINE AND THEY ACKNOWLEDGE THIS IS AN ISSUE THAT THEY HAVE HEARD OF BUT WILL DO NOTHING ABOUT IT. THEY SAY IF THE BRAKES SLAM ON THEN THE SENSORS ARE WORKING. THIS WAS HAPPENING TO MY CAR DAILY AND I HONESTLY WAS AFRAID TO DRIVE THE CAR. THIS IS A TOTAL SAFETY ISSUE FOR YOUR CAR TO SLAM ON THE BRAKES FOR NO REASON IN AN UNSAFE LOCATION. I HAVE TURNED THE MANEUVER BRAKING OFF BUT I PAID A LOT OF MONEY FOR THAT FEATURE THAT DOES NOT WORK SAFELY. I ALSO GET OTHER RANDOM WARNING LIGHTS THAT GO OFF FOR NO REASON. THEY PLUG IT IN TO LOOK FOR CODES AND NOTHING SHOWS UP SO THEY DO NOT FEEL THERE IS A PROBLEM TO ADDRESS.
NHTSA ODI #11352800
10,000 miles · Aug 24, 2020
Service Brakes
MY BRAKES HAVE LOCKED UP 4 OR 5 TIMES (SINCE PURCHASING THE CAR IN APRIL 2019) WHEN EXITING A PARKING LOT WITH MINIMAL SLOPE TO TURN ONTO THE STREET. THE CAR MAKES A GRINDING NOISE AND ALERTS BEEP. THE CAR MUST BE PLACED IN PARK, THEN REVERSE TO MAKE THE DRIVE FEATURE FUNCTION AGAIN TO GET OUT OF THE MIDDLE OF THE STREET. THE FO…
Read full complaint
MY BRAKES HAVE LOCKED UP 4 OR 5 TIMES (SINCE PURCHASING THE CAR IN APRIL 2019) WHEN EXITING A PARKING LOT WITH MINIMAL SLOPE TO TURN ONTO THE STREET. THE CAR MAKES A GRINDING NOISE AND ALERTS BEEP. THE CAR MUST BE PLACED IN PARK, THEN REVERSE TO MAKE THE DRIVE FEATURE FUNCTION AGAIN TO GET OUT OF THE MIDDLE OF THE STREET. THE FORCE OF THE BRAKING, LOCKS UP THE SEAT BELTS AS WELL. THANKFULLY NO ONE HAS BEEN BEHIND ME TO AVOID REAR END COLLISION NOR ONCOMING. I AM NERVOUS TO PULL OUT OF A DRIVEWAY NOW
NHTSA ODI #11350934
11,000 miles · Aug 20, 2020
Service Brakes
THE BRAKES ACTIVATED ON THEIR OWN WHILE IN MOTION, AND THE CAR CAME TO A COMPLETE STOP IN THE MIDDLE OF THE ROAD. NO CARS WERE IN FRONT OF ME OR ANYTHING ELSE THAT SHOULD HAVE ACTIVATED THE AUTOMATIC COLLISION PREVENTION SYSTEM. THE CAR BEHIND ALSO HAD TO STOP TO AVOID CRASHING INTO MY REAR. THE AUTOMATIC COLLISION PREVENTION…
Read full complaint
THE BRAKES ACTIVATED ON THEIR OWN WHILE IN MOTION, AND THE CAR CAME TO A COMPLETE STOP IN THE MIDDLE OF THE ROAD. NO CARS WERE IN FRONT OF ME OR ANYTHING ELSE THAT SHOULD HAVE ACTIVATED THE AUTOMATIC COLLISION PREVENTION SYSTEM. THE CAR BEHIND ALSO HAD TO STOP TO AVOID CRASHING INTO MY REAR. THE AUTOMATIC COLLISION PREVENTION SYSTEM IS SUPPOSED TO BE A SAFETY FEATURE BUT NEARLY CAUSED A COLLISION.
NHTSA ODI #11350423
500 miles · Aug 10, 2020
Power TrainService BrakesUnknown Or Other
CAR JUST STOPS WHEN LEAVING A PARKING LOT AND MY DRIVEWAY , NO OTHER CARS ARE IN THE AREA. BRAKING IS JERKY ALERT SYSTEM GOES CRAZY WITH NO ONE AROUND THE CAR JUST STOPS. THIS HAPPEN TO US A TOTAL OF 7 TIMES SO FAR. I THE FIRST TIME I REPORTED TO THE DEALER WAS ON JUNE 8 THE CAR HAD 500 MILES. WENT BACK TO THE DEALER LATE JUNE A…
Read full complaint
CAR JUST STOPS WHEN LEAVING A PARKING LOT AND MY DRIVEWAY , NO OTHER CARS ARE IN THE AREA. BRAKING IS JERKY ALERT SYSTEM GOES CRAZY WITH NO ONE AROUND THE CAR JUST STOPS. THIS HAPPEN TO US A TOTAL OF 7 TIMES SO FAR. I THE FIRST TIME I REPORTED TO THE DEALER WAS ON JUNE 8 THE CAR HAD 500 MILES. WENT BACK TO THE DEALER LATE JUNE AND THEY TEST DROVE THE CAR WITH US. IT DIDNT STOP BUT THE SERVICE MANGER DID WITNESS THE SENSITIVE ALERTS AND STATED THAT HE WOULD CONTACT THE FIELD MANAGER. NO FOLLOW UP FROM THE DEALER WAS RECEIVED FOR THREE WEEKS . THIS DEALER IS NOT ACTING IN GOOD FAITH. THEN HE SAYS THAT THERE IS NO UPDATES TO THE COLLISION WARNING SYSTEM AND TOLD US TO CALL CUSTOMER CARE. I HAVE A 43,000 CAR THAT I AM AFRAID TO DRIVE.
NHTSA ODI #11348391
Official recalls
12Sep 11, 2026
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Tiguan, 2018-2019 Atlas, and 2019-2021 Audi Q3 vehicles. One of the bolts that attaches the steering rack to the subframe may corrode and break. If this happens, the steering rack housing can break.
Consequence & remedy
Consequence: A broken steering rack housing can result in a loss of steering control, increasing the risk of a crash.
Remedy: Dealers will replace the right-side steering rack mounting bolt, free of charge. Owner notification letters are expected to be mailed November 10, 2026. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's numbers for this recall are 48LG and 48VT. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on September 16, 2026.
Oct 4, 2023
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2019 Atlas vehicles. The driver's side impact air bag may be missing a weld at the side air bag housing.
Consequence & remedy
Consequence: The driver's side impact air bag could deploy improperly or detach in a crash, increasing the risk of injury.
Remedy: Dealers will replace the driver's side impact air bag, free of charge. Owner notification letters were mailed October 19, 2023. Owners may contact Volkswagen's customer service at 1-800-893-5298. Volkswagen's number for this recall is 69FK.
Mar 29, 2023
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018-2021 Atlas and 2020 Atlas Cross Sport vehicles. The passenger occupant detection system (PODS) may experience a fault in the wiring and deactivate the front passenger air bag when the seat is occupied.
Consequence & remedy
Consequence: A deactivated passenger air bag increases the risk of injury during a crash.
Remedy: Dealers will replace the PODS sensor mat and wiring harness, free of charge. Owner notification letters were mailed on March 22, 2024. Owners may contact Volkswagen's customer service at 1-800-893-5298. Volkswagen's number for this recall is 69FB.
Oct 31, 2022
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2019 Volkswagen Tiguan LWB, Golf Sportswagen A7, Golf Alltrack, Golf R GP, Audi Q3, Audi A3 Cabriolet, 2019-2020 Jetta NF, Jetta GLI, Golf GTI, Atlas, Golf A7, Audi A3, 2020-2021 Atlas Cross Sport, and 2021 Atlas FL vehicles. The tire pressure monitoring system may not detect an air pressure loss in adequate time when deflating occurs among all four tires simultaneously. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 138, "Tire Pressure Monitoring Systems."
Consequence & remedy
Consequence: An undetected sudden loss of pressure in all four tires increases the risk of a crash.
Remedy: Dealers will update the TPMS software, free of charge. Owner notification letters were mailed November 18, 2022. Owners may contact Volkswagen's customer service at 1-800-893-5298 or Audis customer service at 1-800-253-2834. Volkswagen's numbers for this recall are (Audi) 45J7, and (VW) 45J6 and 45J8.
Mar 28, 2022
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2019-2020 Atlas, 2020-2023 Atlas Cross Sport, and 2021-2023 Atlas FL vehicles. The door wiring harness electrical contacts may corrode, disrupting the electrical connection and delaying the deployment of the driver or passenger front side air bag during a side impact crash.
Consequence & remedy
Consequence: A delayed air bag deployment can increase the risk of injury.
Remedy: Dealers will secure and, as necessary, replace any the front door wiring harnesses showing a fault code, free of charge. Owner notification letters were mailed June 20, 2022. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 97GF.
Feb 16, 2022
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018-2021 Atlas and 2020-2021 Atlas Cross Sport vehicles equipped with accessory side steps. The reduced Gross Vehicle Weight Rating (GVWR) label, reflecting the additional weight of the side steps, was not installed. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: Without the reduced GVWR label, the vehicle could be overloaded, leading to a loss of control and increasing the risk of a crash.
Remedy: Dealers will install the reduced GVWR label, free of charge. Owner notification letters were mailed March 31, 2022. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 09D9.
Mar 5, 2021
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018-2019 Atlas vehicles equipped with Continental tires. On the affected vehicles, it is possible that one or more tires were cured for too long during tire production.
Consequence & remedy
Consequence: Over cured tires may develop a break in the sidewall, resulting in sudden air loss or belt edge separation which could lead to tread/belt loss. Either condition can cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will inspect the tires, and replace them as necessary, free of charge. The recall began on March 24, 2021. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 44R1.
Aug 21, 2019
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2019 Atlas vehicles. The suction jet in the fuel tank may have been welded in the incorrect position allowing fuel to leak. Additionally, the vehicle may stall due to uneven fuel distribution.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire. An engine stall can increase the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will replace the fuel tank, free of charge. The recall began August 30, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 20BU.
May 22, 2019
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2012-2020 Volkswagen Passat and 2018-2019 Atlas vehicles. The blocking cap disabling the adjustment of the headlight's horizontal aim may not have been installed. As such, these vehicles fail to conform to Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: Without the blocking cap, the headlight aim can be adjusted out of specification, reducing visibility and increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will inspect and, as necessary, block the headlight horizontal adjustment, free of charge. The recall began July 16, 2019. Owners may contact Volkswagen customer service at 1-800-253-2834. Volkswagen's number for this recall is 94L9.
Mar 20, 2019
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2019 Atlas and 2020 Passat vehicles. An incorrect driver and/or front passenger side impact air bag may have been installed.
Consequence & remedy
Consequence: In an event of a side impact crash, an incorrect side airbag may not deploy as intended, increasing the risk of injury.
Remedy: Volkswagen has inspected and replaced the side air bags, free of charge. The recall was completed in April 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 69Y8.
Dec 19, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018-2019 Volkswagen Atlas, 2015 Volkswagen Golf SportWagen, and 2019 Volkswagen Jetta vehicles. The rear coil springs may prematurely fracture.
Consequence & remedy
Consequence: If a coil spring fractures while driving, it may damage a rear tire causing a loss of vehicle control, increasing the risk of a crash.
Remedy: Volkswagen has notified owners, and dealers will replace the rear axle coil springs, free of charge. The recall began January 31, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 42J2/42J3.
Nov 26, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018-2019 Volkswagen Atlas and Tiguan and 2019 Volkswagen Jetta vehicles that do not have keyless entry. The instrument cluster may not provide an audible warning to let the driver know that the key is still in the ignition when the door is open. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection."
Consequence & remedy
Consequence: If the driver is not notified by an audible noise that the key is left in the ignition, it can increase the risk of vehicle theft or crash.
Remedy: Volkswagen will notify owners, and dealers will reprogram the instrument cluster, free of charge. The recall began December 13, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's numbers for this recall are 90L3 and 90L4.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA24004 · Inadvertent Automatic Emergency Braking
Opened Dec 18, 2024 · No close date supplied
Status: open (inferred from source dates) · Forward Collision Avoidance; Forward Collision Avoidance: Automatic Emergency Braking
On September 28, 2023, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE23017) to assess reports of inadvertent activation of the Front Assist automatic emergency braking (AEB) system in model year (MY) 2018-2019 Volkswagen Atlas vehicles. The reports alleged that activation of the AEB system occurred while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Volkswagen indicated that it is aware of a total of 226 reports that may relate to the alleged defect in MY 2019 Volkswagen Atlas vehicles.Volkswagen stated that some customers possibly had an inadequate understanding of Front Assist and its limitations. However, many consumer complaints alleged that Volkswagen dealerships were unable to reproduce the condition or stated that Volkswagen dealerships informed the consumers that this braking is considered normal Front Assist operation. ODI's analysis shows that MY 2019 Volkswagen Atlas vehicles have the highest rate of unique incident reports alleging AEB inadvertent activation when compared to their Volkswagen peers. To date, ODI has received a total of 44 consumer complaints of inadvertent activation of Front Assist in MY 2019 Volkswagen Atlas vehicles.In total, ODI reviewed 187 unique (i.e., non-duplicative Vehicle Identification Numbers) reports that may relate to the alleged defect, which include four reports on injury incidents and one report involving a crash. PE23017 has been upgraded to an Engineering Analysis to further assess the scope, frequency, and potential safety-related consequences of inadvertent AEB activations in MY 2019 Volkswagen Atlas vehicles. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Forward Collision Avoidance: Automatic Emergency Braking
On September 28, 2023, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE23017) to assess reports of inadvertent activation of the Front Assist automatic emergency braking (AEB) system in model year (MY) 2018-2019 Volkswagen Atlas vehicles. The reports alleged that activation of the AEB system occurred while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Volkswagen indicated that it is aware of a total of 226 reports that may relate to the alleged defect in MY 2019 Volkswagen Atlas vehicles.Volkswagen stated that some customers possibly had an inadequate understanding of Front Assist and its limitations. However, many consumer complaints alleged that Volkswagen dealerships were unable to reproduce the condition or stated that Volkswagen dealerships informed the consumers that this braking is considered normal Front Assist operation. ODI's analysis shows that MY 2019 Volkswagen Atlas vehicles have the highest rate of unique incident reports alleging AEB inadvertent activation when compared to their Volkswagen peers. To date, ODI has received a total of 44 consumer complaints of inadvertent activation of Front Assist in MY 2019 Volkswagen Atlas vehicles.In total, ODI reviewed 187 unique (i.e., non-duplicative Vehicle Identification Numbers) reports that may relate to the alleged defect, which include four reports on injury incidents and one report involving a crash. PE23017 has been upgraded to an Engineering Analysis to further assess the scope, frequency, and potential safety-related consequences of inadvertent AEB activations in MY 2019 Volkswagen Atlas vehicles. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Forward Collision Avoidance
On September 28, 2023, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE23017) to assess reports of inadvertent activation of the Front Assist automatic emergency braking (AEB) system in model year (MY) 2018-2019 Volkswagen Atlas vehicles. The reports alleged that activation of the AEB system occurred while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Volkswagen indicated that it is aware of a total of 226 reports that may relate to the alleged defect in MY 2019 Volkswagen Atlas vehicles.Volkswagen stated that some customers possibly had an inadequate understanding of Front Assist and its limitations. However, many consumer complaints alleged that Volkswagen dealerships were unable to reproduce the condition or stated that Volkswagen dealerships informed the consumers that this braking is considered normal Front Assist operation. ODI's analysis shows that MY 2019 Volkswagen Atlas vehicles have the highest rate of unique incident reports alleging AEB inadvertent activation when compared to their Volkswagen peers. To date, ODI has received a total of 44 consumer complaints of inadvertent activation of Front Assist in MY 2019 Volkswagen Atlas vehicles.In total, ODI reviewed 187 unique (i.e., non-duplicative Vehicle Identification Numbers) reports that may relate to the alleged defect, which include four reports on injury incidents and one report involving a crash. PE23017 has been upgraded to an Engineering Analysis to further assess the scope, frequency, and potential safety-related consequences of inadvertent AEB activations in MY 2019 Volkswagen Atlas vehicles. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE23017 · Inadvertent Automatic Emergency Braking
Opened Sep 28, 2023 · Closed Dec 18, 2024
Status: closed (inferred from source dates) · Forward Collision Avoidance; Forward Collision Avoidance: Automatic Emergency Braking
On September 28, 2023, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE23017) to assess reports of inadvertent activation of the Front Assist automatic emergency braking (AEB) system in model year (MY) 2018-2019 Volkswagen Atlas vehicles.The reports alleged that activation of the AEB system occurred while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Volkswagen indicated that it is aware of a total of 292 reports that may relate to the alleged defect in MY 2018-2019 Volkswagen Atlas vehicles.Volkswagen stated that some customers possibly had an inadequate understanding of Front Assist and its limitations. However, many consumer complaints alleged that Volkswagen dealerships were unable to reproduce the condition or Volkswagen dealerships informed the consumers that this braking is considered normal Front Assist operation. ODI's analysis shows that MY 2019 Volkswagen Atlas vehicles have the highest rate of unique incident reports alleging AEB inadvertent activation when compared to their Volkswagen peers.The rate of unique incident reports alleging AEB inadvertent activation in MY 2018 Volkswagen Atlas vehicles was comparable to their Volkswagen peers. To date, ODI has received a total of 69 consumer complaints of inadvertent activation of Front Assist in MY 2018-2019 Volkswagen Atlas vehicles. In total, ODI reviewed 264 unique (i.e., non-duplicative Vehicle Identification Numbers) reports that may relate to the alleged defect, which include eight reports of incidents involving an alleged injury and two reports involving a crash. PE23017 has been upgraded to an Engineering Analysis (EA24004) to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations in MY 2019 Volkswagen Atlas vehicles. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Forward Collision Avoidance: Automatic Emergency Braking
On September 28, 2023, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE23017) to assess reports of inadvertent activation of the Front Assist automatic emergency braking (AEB) system in model year (MY) 2018-2019 Volkswagen Atlas vehicles.The reports alleged that activation of the AEB system occurred while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Volkswagen indicated that it is aware of a total of 292 reports that may relate to the alleged defect in MY 2018-2019 Volkswagen Atlas vehicles.Volkswagen stated that some customers possibly had an inadequate understanding of Front Assist and its limitations. However, many consumer complaints alleged that Volkswagen dealerships were unable to reproduce the condition or Volkswagen dealerships informed the consumers that this braking is considered normal Front Assist operation. ODI's analysis shows that MY 2019 Volkswagen Atlas vehicles have the highest rate of unique incident reports alleging AEB inadvertent activation when compared to their Volkswagen peers.The rate of unique incident reports alleging AEB inadvertent activation in MY 2018 Volkswagen Atlas vehicles was comparable to their Volkswagen peers. To date, ODI has received a total of 69 consumer complaints of inadvertent activation of Front Assist in MY 2018-2019 Volkswagen Atlas vehicles. In total, ODI reviewed 264 unique (i.e., non-duplicative Vehicle Identification Numbers) reports that may relate to the alleged defect, which include eight reports of incidents involving an alleged injury and two reports involving a crash. PE23017 has been upgraded to an Engineering Analysis (EA24004) to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations in MY 2019 Volkswagen Atlas vehicles. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Forward Collision Avoidance
On September 28, 2023, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE23017) to assess reports of inadvertent activation of the Front Assist automatic emergency braking (AEB) system in model year (MY) 2018-2019 Volkswagen Atlas vehicles.The reports alleged that activation of the AEB system occurred while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Volkswagen indicated that it is aware of a total of 292 reports that may relate to the alleged defect in MY 2018-2019 Volkswagen Atlas vehicles.Volkswagen stated that some customers possibly had an inadequate understanding of Front Assist and its limitations. However, many consumer complaints alleged that Volkswagen dealerships were unable to reproduce the condition or Volkswagen dealerships informed the consumers that this braking is considered normal Front Assist operation. ODI's analysis shows that MY 2019 Volkswagen Atlas vehicles have the highest rate of unique incident reports alleging AEB inadvertent activation when compared to their Volkswagen peers.The rate of unique incident reports alleging AEB inadvertent activation in MY 2018 Volkswagen Atlas vehicles was comparable to their Volkswagen peers. To date, ODI has received a total of 69 consumer complaints of inadvertent activation of Front Assist in MY 2018-2019 Volkswagen Atlas vehicles. In total, ODI reviewed 264 unique (i.e., non-duplicative Vehicle Identification Numbers) reports that may relate to the alleged defect, which include eight reports of incidents involving an alleged injury and two reports involving a crash. PE23017 has been upgraded to an Engineering Analysis (EA24004) to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations in MY 2019 Volkswagen Atlas vehicles. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
PE21008 · Fuel Injector Leak
Opened Mar 29, 2021 · Closed Oct 3, 2022
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:fuel Injection System:injectors
On March 29, 2021, the Office of Defects Investigations (ODI) opened PE21-008 to investigate instances of fuel injectors leaking in the engine compartment in model year (MY) 2018 through 2020 Volkswagen Atlas and Atlas Cross Sport SUVs. These vehicles are equipped with either a 3.6 or 2.0 liter engine. The subject investigation concerns vehicles equipped with 3.6L engines. Prior to opening the investigation, ODI also observed that warranty data for the fuel system from TREAD reporting was an outlier for the MY 2018 Atlas.The allegation involved fuel injectors leaking fuel near engine compartment components that operate at high temperatures. Consumers allege a fuel leak, fuel odor, and/or an illuminated check engine malfunction indicator light (MIL) on that alerts them to the condition. Fuel leaking in the engine compartment has a higher potential risk of fire as nearby components are operating at higher temperatures compared to other areas of the vehicle. No fires have been connected to this issue to date.The 3.6L engine is a VR6 type engine. Due to its specific design, the VR6 has two types of injectors with different designs installed. Cylinders 1, 3, and 5 use long injectors and cylinders 2, 4, and 6 use short injectors. Unlike the short injectors, the long injectors require an extension pipe necessary to reach cylinders 1, 3, and 5. Volkswagen stated that the potential root cause for a leaking injector is typically either a damaged, misaligned, or missing supporting ring or a damaged O-ring. These rings assist in connecting the injector to the extension pipe. If one of these conditions is present in a vehicle, the O-ring has difficulty withstanding fuel pressure over time.Volkswagen stated that an analysis of warranty data related to leaking injectors in vehicles equipped with 3.6L engines showed that the vast majority of leaking allegations were related to internal leaks. Fuel can leak into the cylinder causing misfiring in the affected cylinders. This condition would not cause fuel to enter into the engine compartment. Volkswagen states that these internal leaks pose no unreasonable risk to motor vehicle safety.Analysis of all relevant data indicates that the subject condition is an early-life failure with a relatively low failure rate. The average failure mileage calculated from all data sources was determined to be approximately 14,000 miles. Only two failures were reported outside of the vehicles' warranty coverage period. The average time to failure for the subject vehicle population is approximately 12 months in service (MIS). The majority of failures were below the average of 14,000 miles or 12 MIS. Analysis of reported failures showed that the failure rate is approximately 0.08% or 0.8 incidents per thousand vehicles (IPTV).To date, there have been no reported fires, crashes, injuries, or fatalities related to this issue. In view of the low rate of failure, the nature of early-life failure, and low potential hazard to drivers, this Preliminary Evaluation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers:11446833, 11438403, 11382958, 11298402, 11291955, 11218819, 11218780
Additional source detail variants (2)
Fuel System, Gasoline:fuel Injection System:injectors
On March 29, 2021, the Office of Defects Investigations (ODI) opened PE21-008 to investigate instances of fuel injectors leaking in the engine compartment in model year (MY) 2018 through 2020 Volkswagen Atlas and Atlas Cross Sport SUVs. These vehicles are equipped with either a 3.6 or 2.0 liter engine. The subject investigation concerns vehicles equipped with 3.6L engines. Prior to opening the investigation, ODI also observed that warranty data for the fuel system from TREAD reporting was an outlier for the MY 2018 Atlas.The allegation involved fuel injectors leaking fuel near engine compartment components that operate at high temperatures. Consumers allege a fuel leak, fuel odor, and/or an illuminated check engine malfunction indicator light (MIL) on that alerts them to the condition. Fuel leaking in the engine compartment has a higher potential risk of fire as nearby components are operating at higher temperatures compared to other areas of the vehicle. No fires have been connected to this issue to date.The 3.6L engine is a VR6 type engine. Due to its specific design, the VR6 has two types of injectors with different designs installed. Cylinders 1, 3, and 5 use long injectors and cylinders 2, 4, and 6 use short injectors. Unlike the short injectors, the long injectors require an extension pipe necessary to reach cylinders 1, 3, and 5. Volkswagen stated that the potential root cause for a leaking injector is typically either a damaged, misaligned, or missing supporting ring or a damaged O-ring. These rings assist in connecting the injector to the extension pipe. If one of these conditions is present in a vehicle, the O-ring has difficulty withstanding fuel pressure over time.Volkswagen stated that an analysis of warranty data related to leaking injectors in vehicles equipped with 3.6L engines showed that the vast majority of leaking allegations were related to internal leaks. Fuel can leak into the cylinder causing misfiring in the affected cylinders. This condition would not cause fuel to enter into the engine compartment. Volkswagen states that these internal leaks pose no unreasonable risk to motor vehicle safety.Analysis of all relevant data indicates that the subject condition is an early-life failure with a relatively low failure rate. The average failure mileage calculated from all data sources was determined to be approximately 14,000 miles. Only two failures were reported outside of the vehicles' warranty coverage period. The average time to failure for the subject vehicle population is approximately 12 months in service (MIS). The majority of failures were below the average of 14,000 miles or 12 MIS. Analysis of reported failures showed that the failure rate is approximately 0.08% or 0.8 incidents per thousand vehicles (IPTV).To date, there have been no reported fires, crashes, injuries, or fatalities related to this issue. In view of the low rate of failure, the nature of early-life failure, and low potential hazard to drivers, this Preliminary Evaluation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers:11446833, 11438403, 11382958, 11298402, 11291955, 11218819, 11218780
Fuel System, Gasoline
On March 29, 2021, the Office of Defects Investigations (ODI) opened PE21-008 to investigate instances of fuel injectors leaking in the engine compartment in model year (MY) 2018 through 2020 Volkswagen Atlas and Atlas Cross Sport SUVs. These vehicles are equipped with either a 3.6 or 2.0 liter engine. The subject investigation concerns vehicles equipped with 3.6L engines. Prior to opening the investigation, ODI also observed that warranty data for the fuel system from TREAD reporting was an outlier for the MY 2018 Atlas.The allegation involved fuel injectors leaking fuel near engine compartment components that operate at high temperatures. Consumers allege a fuel leak, fuel odor, and/or an illuminated check engine malfunction indicator light (MIL) on that alerts them to the condition. Fuel leaking in the engine compartment has a higher potential risk of fire as nearby components are operating at higher temperatures compared to other areas of the vehicle. No fires have been connected to this issue to date.The 3.6L engine is a VR6 type engine. Due to its specific design, the VR6 has two types of injectors with different designs installed. Cylinders 1, 3, and 5 use long injectors and cylinders 2, 4, and 6 use short injectors. Unlike the short injectors, the long injectors require an extension pipe necessary to reach cylinders 1, 3, and 5. Volkswagen stated that the potential root cause for a leaking injector is typically either a damaged, misaligned, or missing supporting ring or a damaged O-ring. These rings assist in connecting the injector to the extension pipe. If one of these conditions is present in a vehicle, the O-ring has difficulty withstanding fuel pressure over time.Volkswagen stated that an analysis of warranty data related to leaking injectors in vehicles equipped with 3.6L engines showed that the vast majority of leaking allegations were related to internal leaks. Fuel can leak into the cylinder causing misfiring in the affected cylinders. This condition would not cause fuel to enter into the engine compartment. Volkswagen states that these internal leaks pose no unreasonable risk to motor vehicle safety.Analysis of all relevant data indicates that the subject condition is an early-life failure with a relatively low failure rate. The average failure mileage calculated from all data sources was determined to be approximately 14,000 miles. Only two failures were reported outside of the vehicles' warranty coverage period. The average time to failure for the subject vehicle population is approximately 12 months in service (MIS). The majority of failures were below the average of 14,000 miles or 12 MIS. Analysis of reported failures showed that the failure rate is approximately 0.08% or 0.8 incidents per thousand vehicles (IPTV).To date, there have been no reported fires, crashes, injuries, or fatalities related to this issue. In view of the low rate of failure, the nature of early-life failure, and low potential hazard to drivers, this Preliminary Evaluation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers:11446833, 11438403, 11382958, 11298402, 11291955, 11218819, 11218780
Illustration