NHTSA owner reports · September 18, 2026 snapshot.
Forward Collision Avoidance complaints
72 reportsClear category filterMileage unknown · Oct 7, 2021
Forward Collision Avoidance
Hello, I am the current owner of a 2019 VW Atlas with less than 13500 miles. In September 25, the Front-Assist Technology alert icon turned on the dashboard all of a sudden without any cause to my knowledge. After attempting to uncheck and deactivate the option from the settings, it still does not save this option and the icon…
Read full complaint
Hello, I am the current owner of a 2019 VW Atlas with less than 13500 miles. In September 25, the Front-Assist Technology alert icon turned on the dashboard all of a sudden without any cause to my knowledge. After attempting to uncheck and deactivate the option from the settings, it still does not save this option and the icon remains on as well as checked in the option selection. I am concerned this sensor malfunction will cause a sudden unnecessary brake while driving and put me and my family at risk for an accident. The alert was reported to the VW dealership on October 7, 2021 where I purchased the vehicle. Their assessment, findings and recommendations are to perform a wheel alignment and ACC recalibration since this sensor failure is not under “warranty “ and is at cost to the owner which is over $350. Copy of service department description available to share. Cost not included in the description since I declined the services at this time to allow for additional research on this issue. The cost is not an issue and willing to pay if necessary but truly believe this issue should be escalated due to the high number of reported cases related to the Front-Assist sensor malfunction and the manufacturer not acknowledging this is a system failure rather than weather or road conditions induced. I appreciate any additional assistance in this matter.
NHTSA ODI #11435974
13,000 miles · Aug 2, 2021
Forward Collision Avoidance
The contact owns a 2019 Volkswagen Atlas. The contact stated while driving approximately 30-35 mph, the vehicle inadvertently stalled but remained in motion. The warning message "There Is Someone in Front of You" appeared on the instrument panel. The contact stated that the vehicle restarted on its own and she was able to drive …
Read full complaint
The contact owns a 2019 Volkswagen Atlas. The contact stated while driving approximately 30-35 mph, the vehicle inadvertently stalled but remained in motion. The warning message "There Is Someone in Front of You" appeared on the instrument panel. The contact stated that the vehicle restarted on its own and she was able to drive to her destination. The vehicle was taken to the dealer who informed the contact that they could not duplicate the failure. On another occasion while driving at an undisclosed speed, the vehicle decelerated independently and the message "There Is Someone in Front of You" appeared on the instrument panel. The contact also stated that the air bag warning light illuminated once, and the rear-view camera screen would inadvertently go black. The vehicle was taken to a second the dealer The Autobarn Volkswagen of Countryside Auto Service (6161 Joliet Rd, Countryside, IL 60525) who informed the contact that they could not duplicate the failure. The manufacturer was made aware of the failure and referred the contact to the dealer for a diagnostic test. A case was opened. The vehicle was not repaired. The approximate failure mileage was 13,000.
NHTSA ODI #11427499
Mileage unknown · Jul 27, 2021
Forward Collision Avoidance
The front assist system keeps stopping my car at random times. I had told Volkswagen where I bought the car about it and they did nothing. I assuming because they have seen it for themselves. It happened on the highway, on a bridge and going up a hill. No cars were in front of and thankfully no cars were behind as I was going 50…
Read full complaint
The front assist system keeps stopping my car at random times. I had told Volkswagen where I bought the car about it and they did nothing. I assuming because they have seen it for themselves. It happened on the highway, on a bridge and going up a hill. No cars were in front of and thankfully no cars were behind as I was going 50-55 mph on the highway. The warning light came on that I was getting too close to a car but there were no cars near me then all of of a sudden the car suddenly stops. It’s very dangerous. I am going to take the vehicle back to the dealer ship again and see what they say. The car also stalls when I back up.
NHTSA ODI #11426737
Mileage unknown · May 27, 2021
Forward Collision Avoidance
The vehicle will sound the collision warning sound for no reason when no other vehicles are around. When slowly coming up to a red light with one car in front, after coming to a complete stop the vehicle beeped once and engaged the brakes. The second time this happened the vehicle was driving slowly in a school parking lot. The…
Read full complaint
The vehicle will sound the collision warning sound for no reason when no other vehicles are around. When slowly coming up to a red light with one car in front, after coming to a complete stop the vehicle beeped once and engaged the brakes. The second time this happened the vehicle was driving slowly in a school parking lot. There were cars all around but the sensors were beeping the whole time. When trying to drive forward the vehicle slammed the brakes on. Today the vehicle was stopped at an intersection, the rear camera came on, the beeping came on. The vehicle had to be shifted into park to stop the beeping and then put back into drive. This is a serious safety issue and should be a recall!
NHTSA ODI #11418830
6,000 miles · Jan 2, 2021
Electrical SystemForward Collision Avoidance
VW PERFORMED AN EMISSIONS RECALL SOFTWARE UPDATE ON THIS VEHICLE APPROXIMATELY 6 MONTHS AGO. SINCE THIS SOFTWARE UPDATE WAS PERFORMED THE ADAPTIVE CRUISE CONTROL DOES NOT WORK AFTER USING THE VEHICLES OEM REMOTE START. THE ADAPTIVE CRUISE CONTROL WORKS WHEN NOT USING REMOTE START HOWEVER. THEY HAVE SO FAR REFUSED TO OFFER A FIX.
NHTSA ODI #11386080
Mileage unknown · Dec 26, 2020
Forward Collision Avoidance
IF THE VEHICLE IS STARTED VIA REMOTE START, AND THEN DRIVEN, RADAR RELATED AND OTHER SAFETY SYSTEM ARE NOT ONLINE. THERE IS NO WARNING THAT THESE SYSTEMS ARE OFFLINE. THE ONLY INDICATOR IS CRUISE ERRORS IF YOU ATTEMPT TO ENGAGE. THE DEALER HAS VALIDATED THIS BEHAVIOR BUT HAD NO PLAN OF ACTION. THE WORK AROUND IS TO RESTART …
Read full complaint
IF THE VEHICLE IS STARTED VIA REMOTE START, AND THEN DRIVEN, RADAR RELATED AND OTHER SAFETY SYSTEM ARE NOT ONLINE. THERE IS NO WARNING THAT THESE SYSTEMS ARE OFFLINE. THE ONLY INDICATOR IS CRUISE ERRORS IF YOU ATTEMPT TO ENGAGE. THE DEALER HAS VALIDATED THIS BEHAVIOR BUT HAD NO PLAN OF ACTION. THE WORK AROUND IS TO RESTART THE CAR BEFORE DRIVING. IT'S SUSPECTED AND DISCUSSED IN MANY FORUMS. IT PRESENTS A LOSS OF SAFETY SYSTEM WITH NO ANNUNCIATION.
NHTSA ODI #11384954
12,000 miles · Dec 7, 2020
Forward Collision Avoidance
TL* THE CONTACT OWNS A 2019 VOLKSWAGEN ATLAS. THE CONTACT STATED THAT WHILE DRIVING DOWN A DRIVEWAY UNTO A STREET, THE AUTOMATIC POST COLLISION BRAKING SYSTEM ACTIVATED INDEPENDENTLY AND THE VEHICLE STALLED WITH SEVERAL UNKNOWN WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS RESTARTED AND DROVE AS DESIGNED. THE CONTACT STATED THAT I…
Read full complaint
TL* THE CONTACT OWNS A 2019 VOLKSWAGEN ATLAS. THE CONTACT STATED THAT WHILE DRIVING DOWN A DRIVEWAY UNTO A STREET, THE AUTOMATIC POST COLLISION BRAKING SYSTEM ACTIVATED INDEPENDENTLY AND THE VEHICLE STALLED WITH SEVERAL UNKNOWN WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS RESTARTED AND DROVE AS DESIGNED. THE CONTACT STATED THAT IT WAS DIFFICULT TO RESTART THE VEHICLE. THE VEHICLE WAS TAKEN TO NORM REEVES VOLKSWAGEN SUPERSTORE (20 AUTO CENTER DR, IRVINE, CA 92618) AND THE CONTACT WAS INFORMED THAT THIS WAS A KNOWN ISSUE. THE VEHICLE WAS NOT REPAIRED. THE CONTACT STATED THAT THERE WAS NO MECHANICAL FIX FOR THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT IN ORDER FOR THE FIX ISSUE, THE EMERGENCY BRAKING SYSTEM NEEDED TO BE DEACTIVATED. A CASE NUMBER WAS PROVIDED. THE CONTACT STATED THAT THE FAILURE RECURRED THREE TIMES. THE FAILURE MILEAGE WAS APPROXIMATELY 12,000.*DT*JB
NHTSA ODI #11378327
20,000 miles · Dec 6, 2020
Forward Collision Avoidance
DRIVER EXPERIENCED TWO MALFUNCTIONS OF ADAS AUTOMATIC BRAKING SYSTEM DURING A SINGLE HIGHWAY TRIP. WITH NO CARS AHEAD, THE VEHICLE FLASHED THE BRAKING WARNING. A FEW MINUTES LATER IN THE TRIP, THE VEHICLE ENGAGED THE ADAS AUTOMATIC BRAKING, WITH NO VEHICLES AHEAD, AND INITIATED A HARD STOP WHILE AT HIGHWAY SPEEDS. ROAD CONDITION…
Read full complaint
DRIVER EXPERIENCED TWO MALFUNCTIONS OF ADAS AUTOMATIC BRAKING SYSTEM DURING A SINGLE HIGHWAY TRIP. WITH NO CARS AHEAD, THE VEHICLE FLASHED THE BRAKING WARNING. A FEW MINUTES LATER IN THE TRIP, THE VEHICLE ENGAGED THE ADAS AUTOMATIC BRAKING, WITH NO VEHICLES AHEAD, AND INITIATED A HARD STOP WHILE AT HIGHWAY SPEEDS. ROAD CONDITIONS WERE CLEAR AND TEMPERATURES WERE ~50 .
NHTSA ODI #11378151
5,000 miles · Dec 1, 2020
Back Over PreventionForward Collision Avoidance
ON NUMEROUS OCCASIONS OUR 2019 VW ATLAS SEL PREMIUM HAS ENGAGED THE BRAKES EVEN WHEN THERE ARE NO OBSTACLES TO AVOID CREATING A DANGEROUS, SCARY AND UNPREDICTABLE SENECIO FOR OUR FAMILY AND OTHER DRIVERS AROUND US. THE PROBLEMS WITH THE AUTOMATED BRAKING HAVE BEEN ATTRIBUTED BY SERVICE ADVISORS AS SOFTWARE ISSUES WITH 'FRONT AS…
Read full complaint
ON NUMEROUS OCCASIONS OUR 2019 VW ATLAS SEL PREMIUM HAS ENGAGED THE BRAKES EVEN WHEN THERE ARE NO OBSTACLES TO AVOID CREATING A DANGEROUS, SCARY AND UNPREDICTABLE SENECIO FOR OUR FAMILY AND OTHER DRIVERS AROUND US. THE PROBLEMS WITH THE AUTOMATED BRAKING HAVE BEEN ATTRIBUTED BY SERVICE ADVISORS AS SOFTWARE ISSUES WITH 'FRONT ASSIST, MANEUVER BRAKING, AND/OR REMOTE START".
NHTSA ODI #11377290
6,090 miles · Nov 18, 2020
EngineForward Collision AvoidanceSuspension
THE CAR RANDOMLY DOES NOT ACCELERATE AT LOW SPEEDS WHEN CHANGING LANES IN TRAFFIC, HAS A SCREECHING NOISE UPON ACCELERATION THAT VW SAYS IS A NORMAL LOUD NOISE BECAUSE ITS TOO EXPENSIVE TO REPAIR ALL THE VEHICLES (THAT'S THE EXACT WORDS FROM THE VW MECHANIC). I HAVE A VIDEO THAT SHOWS THE PROBLEM WITH EXCELEAREATION YET VW TELL…
Read full complaint
THE CAR RANDOMLY DOES NOT ACCELERATE AT LOW SPEEDS WHEN CHANGING LANES IN TRAFFIC, HAS A SCREECHING NOISE UPON ACCELERATION THAT VW SAYS IS A NORMAL LOUD NOISE BECAUSE ITS TOO EXPENSIVE TO REPAIR ALL THE VEHICLES (THAT'S THE EXACT WORDS FROM THE VW MECHANIC). I HAVE A VIDEO THAT SHOWS THE PROBLEM WITH EXCELEAREATION YET VW TELLS ME THEY'RE NOTHING WRONG WITH THE CAR. THE SWAY BARS HAVE BEEN REPLACED TWO TIMES IN 6 MONTHS AND THE PROBLEM STILL ISN'T REPAIRED. THE AUTO COLLISION RANDOMLY WORKS.
NHTSA ODI #11375246
Official recalls
12Sep 11, 2026
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Tiguan, 2018-2019 Atlas, and 2019-2021 Audi Q3 vehicles. One of the bolts that attaches the steering rack to the subframe may corrode and break. If this happens, the steering rack housing can break.
Consequence & remedy
Consequence: A broken steering rack housing can result in a loss of steering control, increasing the risk of a crash.
Remedy: Dealers will replace the right-side steering rack mounting bolt, free of charge. Owner notification letters are expected to be mailed November 10, 2026. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's numbers for this recall are 48LG and 48VT. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on September 16, 2026.
Oct 4, 2023
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2019 Atlas vehicles. The driver's side impact air bag may be missing a weld at the side air bag housing.
Consequence & remedy
Consequence: The driver's side impact air bag could deploy improperly or detach in a crash, increasing the risk of injury.
Remedy: Dealers will replace the driver's side impact air bag, free of charge. Owner notification letters were mailed October 19, 2023. Owners may contact Volkswagen's customer service at 1-800-893-5298. Volkswagen's number for this recall is 69FK.
Mar 29, 2023
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018-2021 Atlas and 2020 Atlas Cross Sport vehicles. The passenger occupant detection system (PODS) may experience a fault in the wiring and deactivate the front passenger air bag when the seat is occupied.
Consequence & remedy
Consequence: A deactivated passenger air bag increases the risk of injury during a crash.
Remedy: Dealers will replace the PODS sensor mat and wiring harness, free of charge. Owner notification letters were mailed on March 22, 2024. Owners may contact Volkswagen's customer service at 1-800-893-5298. Volkswagen's number for this recall is 69FB.
Oct 31, 2022
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2019 Volkswagen Tiguan LWB, Golf Sportswagen A7, Golf Alltrack, Golf R GP, Audi Q3, Audi A3 Cabriolet, 2019-2020 Jetta NF, Jetta GLI, Golf GTI, Atlas, Golf A7, Audi A3, 2020-2021 Atlas Cross Sport, and 2021 Atlas FL vehicles. The tire pressure monitoring system may not detect an air pressure loss in adequate time when deflating occurs among all four tires simultaneously. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 138, "Tire Pressure Monitoring Systems."
Consequence & remedy
Consequence: An undetected sudden loss of pressure in all four tires increases the risk of a crash.
Remedy: Dealers will update the TPMS software, free of charge. Owner notification letters were mailed November 18, 2022. Owners may contact Volkswagen's customer service at 1-800-893-5298 or Audis customer service at 1-800-253-2834. Volkswagen's numbers for this recall are (Audi) 45J7, and (VW) 45J6 and 45J8.
Mar 28, 2022
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2019-2020 Atlas, 2020-2023 Atlas Cross Sport, and 2021-2023 Atlas FL vehicles. The door wiring harness electrical contacts may corrode, disrupting the electrical connection and delaying the deployment of the driver or passenger front side air bag during a side impact crash.
Consequence & remedy
Consequence: A delayed air bag deployment can increase the risk of injury.
Remedy: Dealers will secure and, as necessary, replace any the front door wiring harnesses showing a fault code, free of charge. Owner notification letters were mailed June 20, 2022. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 97GF.
Feb 16, 2022
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018-2021 Atlas and 2020-2021 Atlas Cross Sport vehicles equipped with accessory side steps. The reduced Gross Vehicle Weight Rating (GVWR) label, reflecting the additional weight of the side steps, was not installed. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: Without the reduced GVWR label, the vehicle could be overloaded, leading to a loss of control and increasing the risk of a crash.
Remedy: Dealers will install the reduced GVWR label, free of charge. Owner notification letters were mailed March 31, 2022. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 09D9.
Mar 5, 2021
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018-2019 Atlas vehicles equipped with Continental tires. On the affected vehicles, it is possible that one or more tires were cured for too long during tire production.
Consequence & remedy
Consequence: Over cured tires may develop a break in the sidewall, resulting in sudden air loss or belt edge separation which could lead to tread/belt loss. Either condition can cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will inspect the tires, and replace them as necessary, free of charge. The recall began on March 24, 2021. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 44R1.
Aug 21, 2019
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2019 Atlas vehicles. The suction jet in the fuel tank may have been welded in the incorrect position allowing fuel to leak. Additionally, the vehicle may stall due to uneven fuel distribution.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire. An engine stall can increase the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will replace the fuel tank, free of charge. The recall began August 30, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 20BU.
May 22, 2019
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2012-2020 Volkswagen Passat and 2018-2019 Atlas vehicles. The blocking cap disabling the adjustment of the headlight's horizontal aim may not have been installed. As such, these vehicles fail to conform to Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: Without the blocking cap, the headlight aim can be adjusted out of specification, reducing visibility and increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will inspect and, as necessary, block the headlight horizontal adjustment, free of charge. The recall began July 16, 2019. Owners may contact Volkswagen customer service at 1-800-253-2834. Volkswagen's number for this recall is 94L9.
Mar 20, 2019
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2019 Atlas and 2020 Passat vehicles. An incorrect driver and/or front passenger side impact air bag may have been installed.
Consequence & remedy
Consequence: In an event of a side impact crash, an incorrect side airbag may not deploy as intended, increasing the risk of injury.
Remedy: Volkswagen has inspected and replaced the side air bags, free of charge. The recall was completed in April 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 69Y8.
Dec 19, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018-2019 Volkswagen Atlas, 2015 Volkswagen Golf SportWagen, and 2019 Volkswagen Jetta vehicles. The rear coil springs may prematurely fracture.
Consequence & remedy
Consequence: If a coil spring fractures while driving, it may damage a rear tire causing a loss of vehicle control, increasing the risk of a crash.
Remedy: Volkswagen has notified owners, and dealers will replace the rear axle coil springs, free of charge. The recall began January 31, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 42J2/42J3.
Nov 26, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018-2019 Volkswagen Atlas and Tiguan and 2019 Volkswagen Jetta vehicles that do not have keyless entry. The instrument cluster may not provide an audible warning to let the driver know that the key is still in the ignition when the door is open. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection."
Consequence & remedy
Consequence: If the driver is not notified by an audible noise that the key is left in the ignition, it can increase the risk of vehicle theft or crash.
Remedy: Volkswagen will notify owners, and dealers will reprogram the instrument cluster, free of charge. The recall began December 13, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's numbers for this recall are 90L3 and 90L4.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA24004 · Inadvertent Automatic Emergency Braking
Opened Dec 18, 2024 · No close date supplied
Status: open (inferred from source dates) · Forward Collision Avoidance; Forward Collision Avoidance: Automatic Emergency Braking
On September 28, 2023, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE23017) to assess reports of inadvertent activation of the Front Assist automatic emergency braking (AEB) system in model year (MY) 2018-2019 Volkswagen Atlas vehicles. The reports alleged that activation of the AEB system occurred while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Volkswagen indicated that it is aware of a total of 226 reports that may relate to the alleged defect in MY 2019 Volkswagen Atlas vehicles.Volkswagen stated that some customers possibly had an inadequate understanding of Front Assist and its limitations. However, many consumer complaints alleged that Volkswagen dealerships were unable to reproduce the condition or stated that Volkswagen dealerships informed the consumers that this braking is considered normal Front Assist operation. ODI's analysis shows that MY 2019 Volkswagen Atlas vehicles have the highest rate of unique incident reports alleging AEB inadvertent activation when compared to their Volkswagen peers. To date, ODI has received a total of 44 consumer complaints of inadvertent activation of Front Assist in MY 2019 Volkswagen Atlas vehicles.In total, ODI reviewed 187 unique (i.e., non-duplicative Vehicle Identification Numbers) reports that may relate to the alleged defect, which include four reports on injury incidents and one report involving a crash. PE23017 has been upgraded to an Engineering Analysis to further assess the scope, frequency, and potential safety-related consequences of inadvertent AEB activations in MY 2019 Volkswagen Atlas vehicles. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Forward Collision Avoidance: Automatic Emergency Braking
On September 28, 2023, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE23017) to assess reports of inadvertent activation of the Front Assist automatic emergency braking (AEB) system in model year (MY) 2018-2019 Volkswagen Atlas vehicles. The reports alleged that activation of the AEB system occurred while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Volkswagen indicated that it is aware of a total of 226 reports that may relate to the alleged defect in MY 2019 Volkswagen Atlas vehicles.Volkswagen stated that some customers possibly had an inadequate understanding of Front Assist and its limitations. However, many consumer complaints alleged that Volkswagen dealerships were unable to reproduce the condition or stated that Volkswagen dealerships informed the consumers that this braking is considered normal Front Assist operation. ODI's analysis shows that MY 2019 Volkswagen Atlas vehicles have the highest rate of unique incident reports alleging AEB inadvertent activation when compared to their Volkswagen peers. To date, ODI has received a total of 44 consumer complaints of inadvertent activation of Front Assist in MY 2019 Volkswagen Atlas vehicles.In total, ODI reviewed 187 unique (i.e., non-duplicative Vehicle Identification Numbers) reports that may relate to the alleged defect, which include four reports on injury incidents and one report involving a crash. PE23017 has been upgraded to an Engineering Analysis to further assess the scope, frequency, and potential safety-related consequences of inadvertent AEB activations in MY 2019 Volkswagen Atlas vehicles. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Forward Collision Avoidance
On September 28, 2023, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE23017) to assess reports of inadvertent activation of the Front Assist automatic emergency braking (AEB) system in model year (MY) 2018-2019 Volkswagen Atlas vehicles. The reports alleged that activation of the AEB system occurred while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Volkswagen indicated that it is aware of a total of 226 reports that may relate to the alleged defect in MY 2019 Volkswagen Atlas vehicles.Volkswagen stated that some customers possibly had an inadequate understanding of Front Assist and its limitations. However, many consumer complaints alleged that Volkswagen dealerships were unable to reproduce the condition or stated that Volkswagen dealerships informed the consumers that this braking is considered normal Front Assist operation. ODI's analysis shows that MY 2019 Volkswagen Atlas vehicles have the highest rate of unique incident reports alleging AEB inadvertent activation when compared to their Volkswagen peers. To date, ODI has received a total of 44 consumer complaints of inadvertent activation of Front Assist in MY 2019 Volkswagen Atlas vehicles.In total, ODI reviewed 187 unique (i.e., non-duplicative Vehicle Identification Numbers) reports that may relate to the alleged defect, which include four reports on injury incidents and one report involving a crash. PE23017 has been upgraded to an Engineering Analysis to further assess the scope, frequency, and potential safety-related consequences of inadvertent AEB activations in MY 2019 Volkswagen Atlas vehicles. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE23017 · Inadvertent Automatic Emergency Braking
Opened Sep 28, 2023 · Closed Dec 18, 2024
Status: closed (inferred from source dates) · Forward Collision Avoidance; Forward Collision Avoidance: Automatic Emergency Braking
On September 28, 2023, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE23017) to assess reports of inadvertent activation of the Front Assist automatic emergency braking (AEB) system in model year (MY) 2018-2019 Volkswagen Atlas vehicles.The reports alleged that activation of the AEB system occurred while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Volkswagen indicated that it is aware of a total of 292 reports that may relate to the alleged defect in MY 2018-2019 Volkswagen Atlas vehicles.Volkswagen stated that some customers possibly had an inadequate understanding of Front Assist and its limitations. However, many consumer complaints alleged that Volkswagen dealerships were unable to reproduce the condition or Volkswagen dealerships informed the consumers that this braking is considered normal Front Assist operation. ODI's analysis shows that MY 2019 Volkswagen Atlas vehicles have the highest rate of unique incident reports alleging AEB inadvertent activation when compared to their Volkswagen peers.The rate of unique incident reports alleging AEB inadvertent activation in MY 2018 Volkswagen Atlas vehicles was comparable to their Volkswagen peers. To date, ODI has received a total of 69 consumer complaints of inadvertent activation of Front Assist in MY 2018-2019 Volkswagen Atlas vehicles. In total, ODI reviewed 264 unique (i.e., non-duplicative Vehicle Identification Numbers) reports that may relate to the alleged defect, which include eight reports of incidents involving an alleged injury and two reports involving a crash. PE23017 has been upgraded to an Engineering Analysis (EA24004) to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations in MY 2019 Volkswagen Atlas vehicles. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Forward Collision Avoidance: Automatic Emergency Braking
On September 28, 2023, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE23017) to assess reports of inadvertent activation of the Front Assist automatic emergency braking (AEB) system in model year (MY) 2018-2019 Volkswagen Atlas vehicles.The reports alleged that activation of the AEB system occurred while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Volkswagen indicated that it is aware of a total of 292 reports that may relate to the alleged defect in MY 2018-2019 Volkswagen Atlas vehicles.Volkswagen stated that some customers possibly had an inadequate understanding of Front Assist and its limitations. However, many consumer complaints alleged that Volkswagen dealerships were unable to reproduce the condition or Volkswagen dealerships informed the consumers that this braking is considered normal Front Assist operation. ODI's analysis shows that MY 2019 Volkswagen Atlas vehicles have the highest rate of unique incident reports alleging AEB inadvertent activation when compared to their Volkswagen peers.The rate of unique incident reports alleging AEB inadvertent activation in MY 2018 Volkswagen Atlas vehicles was comparable to their Volkswagen peers. To date, ODI has received a total of 69 consumer complaints of inadvertent activation of Front Assist in MY 2018-2019 Volkswagen Atlas vehicles. In total, ODI reviewed 264 unique (i.e., non-duplicative Vehicle Identification Numbers) reports that may relate to the alleged defect, which include eight reports of incidents involving an alleged injury and two reports involving a crash. PE23017 has been upgraded to an Engineering Analysis (EA24004) to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations in MY 2019 Volkswagen Atlas vehicles. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Forward Collision Avoidance
On September 28, 2023, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE23017) to assess reports of inadvertent activation of the Front Assist automatic emergency braking (AEB) system in model year (MY) 2018-2019 Volkswagen Atlas vehicles.The reports alleged that activation of the AEB system occurred while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Volkswagen indicated that it is aware of a total of 292 reports that may relate to the alleged defect in MY 2018-2019 Volkswagen Atlas vehicles.Volkswagen stated that some customers possibly had an inadequate understanding of Front Assist and its limitations. However, many consumer complaints alleged that Volkswagen dealerships were unable to reproduce the condition or Volkswagen dealerships informed the consumers that this braking is considered normal Front Assist operation. ODI's analysis shows that MY 2019 Volkswagen Atlas vehicles have the highest rate of unique incident reports alleging AEB inadvertent activation when compared to their Volkswagen peers.The rate of unique incident reports alleging AEB inadvertent activation in MY 2018 Volkswagen Atlas vehicles was comparable to their Volkswagen peers. To date, ODI has received a total of 69 consumer complaints of inadvertent activation of Front Assist in MY 2018-2019 Volkswagen Atlas vehicles. In total, ODI reviewed 264 unique (i.e., non-duplicative Vehicle Identification Numbers) reports that may relate to the alleged defect, which include eight reports of incidents involving an alleged injury and two reports involving a crash. PE23017 has been upgraded to an Engineering Analysis (EA24004) to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations in MY 2019 Volkswagen Atlas vehicles. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
PE21008 · Fuel Injector Leak
Opened Mar 29, 2021 · Closed Oct 3, 2022
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:fuel Injection System:injectors
On March 29, 2021, the Office of Defects Investigations (ODI) opened PE21-008 to investigate instances of fuel injectors leaking in the engine compartment in model year (MY) 2018 through 2020 Volkswagen Atlas and Atlas Cross Sport SUVs. These vehicles are equipped with either a 3.6 or 2.0 liter engine. The subject investigation concerns vehicles equipped with 3.6L engines. Prior to opening the investigation, ODI also observed that warranty data for the fuel system from TREAD reporting was an outlier for the MY 2018 Atlas.The allegation involved fuel injectors leaking fuel near engine compartment components that operate at high temperatures. Consumers allege a fuel leak, fuel odor, and/or an illuminated check engine malfunction indicator light (MIL) on that alerts them to the condition. Fuel leaking in the engine compartment has a higher potential risk of fire as nearby components are operating at higher temperatures compared to other areas of the vehicle. No fires have been connected to this issue to date.The 3.6L engine is a VR6 type engine. Due to its specific design, the VR6 has two types of injectors with different designs installed. Cylinders 1, 3, and 5 use long injectors and cylinders 2, 4, and 6 use short injectors. Unlike the short injectors, the long injectors require an extension pipe necessary to reach cylinders 1, 3, and 5. Volkswagen stated that the potential root cause for a leaking injector is typically either a damaged, misaligned, or missing supporting ring or a damaged O-ring. These rings assist in connecting the injector to the extension pipe. If one of these conditions is present in a vehicle, the O-ring has difficulty withstanding fuel pressure over time.Volkswagen stated that an analysis of warranty data related to leaking injectors in vehicles equipped with 3.6L engines showed that the vast majority of leaking allegations were related to internal leaks. Fuel can leak into the cylinder causing misfiring in the affected cylinders. This condition would not cause fuel to enter into the engine compartment. Volkswagen states that these internal leaks pose no unreasonable risk to motor vehicle safety.Analysis of all relevant data indicates that the subject condition is an early-life failure with a relatively low failure rate. The average failure mileage calculated from all data sources was determined to be approximately 14,000 miles. Only two failures were reported outside of the vehicles' warranty coverage period. The average time to failure for the subject vehicle population is approximately 12 months in service (MIS). The majority of failures were below the average of 14,000 miles or 12 MIS. Analysis of reported failures showed that the failure rate is approximately 0.08% or 0.8 incidents per thousand vehicles (IPTV).To date, there have been no reported fires, crashes, injuries, or fatalities related to this issue. In view of the low rate of failure, the nature of early-life failure, and low potential hazard to drivers, this Preliminary Evaluation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers:11446833, 11438403, 11382958, 11298402, 11291955, 11218819, 11218780
Additional source detail variants (2)
Fuel System, Gasoline:fuel Injection System:injectors
On March 29, 2021, the Office of Defects Investigations (ODI) opened PE21-008 to investigate instances of fuel injectors leaking in the engine compartment in model year (MY) 2018 through 2020 Volkswagen Atlas and Atlas Cross Sport SUVs. These vehicles are equipped with either a 3.6 or 2.0 liter engine. The subject investigation concerns vehicles equipped with 3.6L engines. Prior to opening the investigation, ODI also observed that warranty data for the fuel system from TREAD reporting was an outlier for the MY 2018 Atlas.The allegation involved fuel injectors leaking fuel near engine compartment components that operate at high temperatures. Consumers allege a fuel leak, fuel odor, and/or an illuminated check engine malfunction indicator light (MIL) on that alerts them to the condition. Fuel leaking in the engine compartment has a higher potential risk of fire as nearby components are operating at higher temperatures compared to other areas of the vehicle. No fires have been connected to this issue to date.The 3.6L engine is a VR6 type engine. Due to its specific design, the VR6 has two types of injectors with different designs installed. Cylinders 1, 3, and 5 use long injectors and cylinders 2, 4, and 6 use short injectors. Unlike the short injectors, the long injectors require an extension pipe necessary to reach cylinders 1, 3, and 5. Volkswagen stated that the potential root cause for a leaking injector is typically either a damaged, misaligned, or missing supporting ring or a damaged O-ring. These rings assist in connecting the injector to the extension pipe. If one of these conditions is present in a vehicle, the O-ring has difficulty withstanding fuel pressure over time.Volkswagen stated that an analysis of warranty data related to leaking injectors in vehicles equipped with 3.6L engines showed that the vast majority of leaking allegations were related to internal leaks. Fuel can leak into the cylinder causing misfiring in the affected cylinders. This condition would not cause fuel to enter into the engine compartment. Volkswagen states that these internal leaks pose no unreasonable risk to motor vehicle safety.Analysis of all relevant data indicates that the subject condition is an early-life failure with a relatively low failure rate. The average failure mileage calculated from all data sources was determined to be approximately 14,000 miles. Only two failures were reported outside of the vehicles' warranty coverage period. The average time to failure for the subject vehicle population is approximately 12 months in service (MIS). The majority of failures were below the average of 14,000 miles or 12 MIS. Analysis of reported failures showed that the failure rate is approximately 0.08% or 0.8 incidents per thousand vehicles (IPTV).To date, there have been no reported fires, crashes, injuries, or fatalities related to this issue. In view of the low rate of failure, the nature of early-life failure, and low potential hazard to drivers, this Preliminary Evaluation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers:11446833, 11438403, 11382958, 11298402, 11291955, 11218819, 11218780
Fuel System, Gasoline
On March 29, 2021, the Office of Defects Investigations (ODI) opened PE21-008 to investigate instances of fuel injectors leaking in the engine compartment in model year (MY) 2018 through 2020 Volkswagen Atlas and Atlas Cross Sport SUVs. These vehicles are equipped with either a 3.6 or 2.0 liter engine. The subject investigation concerns vehicles equipped with 3.6L engines. Prior to opening the investigation, ODI also observed that warranty data for the fuel system from TREAD reporting was an outlier for the MY 2018 Atlas.The allegation involved fuel injectors leaking fuel near engine compartment components that operate at high temperatures. Consumers allege a fuel leak, fuel odor, and/or an illuminated check engine malfunction indicator light (MIL) on that alerts them to the condition. Fuel leaking in the engine compartment has a higher potential risk of fire as nearby components are operating at higher temperatures compared to other areas of the vehicle. No fires have been connected to this issue to date.The 3.6L engine is a VR6 type engine. Due to its specific design, the VR6 has two types of injectors with different designs installed. Cylinders 1, 3, and 5 use long injectors and cylinders 2, 4, and 6 use short injectors. Unlike the short injectors, the long injectors require an extension pipe necessary to reach cylinders 1, 3, and 5. Volkswagen stated that the potential root cause for a leaking injector is typically either a damaged, misaligned, or missing supporting ring or a damaged O-ring. These rings assist in connecting the injector to the extension pipe. If one of these conditions is present in a vehicle, the O-ring has difficulty withstanding fuel pressure over time.Volkswagen stated that an analysis of warranty data related to leaking injectors in vehicles equipped with 3.6L engines showed that the vast majority of leaking allegations were related to internal leaks. Fuel can leak into the cylinder causing misfiring in the affected cylinders. This condition would not cause fuel to enter into the engine compartment. Volkswagen states that these internal leaks pose no unreasonable risk to motor vehicle safety.Analysis of all relevant data indicates that the subject condition is an early-life failure with a relatively low failure rate. The average failure mileage calculated from all data sources was determined to be approximately 14,000 miles. Only two failures were reported outside of the vehicles' warranty coverage period. The average time to failure for the subject vehicle population is approximately 12 months in service (MIS). The majority of failures were below the average of 14,000 miles or 12 MIS. Analysis of reported failures showed that the failure rate is approximately 0.08% or 0.8 incidents per thousand vehicles (IPTV).To date, there have been no reported fires, crashes, injuries, or fatalities related to this issue. In view of the low rate of failure, the nature of early-life failure, and low potential hazard to drivers, this Preliminary Evaluation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers:11446833, 11438403, 11382958, 11298402, 11291955, 11218819, 11218780
Illustration