NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
73 reportsClear category filterMileage unknown · Nov 1, 2021
Electrical System
While driving vehicle with my baby with me in heavy traffic area engine completely died when I came to a red light. Cars expected me to proceed on green light. No steering, no brakes, rear sensors went off and warning said Low 12V Battery. Tried to restart it to no avail. Engine would just click. 3 men had to put their hazards o…
Read full complaint
While driving vehicle with my baby with me in heavy traffic area engine completely died when I came to a red light. Cars expected me to proceed on green light. No steering, no brakes, rear sensors went off and warning said Low 12V Battery. Tried to restart it to no avail. Engine would just click. 3 men had to put their hazards on and started pushing the VW Atlas to the nearest parking lot a ways off endangering the lives of these 3 men their vehicles and my baby and my own life. Took vehicle to get Battery and alternator tested, but all was “Perfectly fine”. I will not wait for a fatality in my family to happen. VW should recall or do something day IMMEDIATELY.
NHTSA ODI #11438986
7,400 miles · Apr 4, 2021
Electrical SystemService Brakes
THE REAR WINDOW ROLLS DOWN BY ITSELF WITH NOBODY TOUCHING ANY OF THE BUTTONS. THE LIGHT POPS UP ON THE DASH AND SAYS FAULTY ELECTRICAL. THE VEHICLE WILL SUDDENLY STOP IN THE MIDDLE OF DRIVING. THE EMERGENCY BREAK APPLIES. THE EMERGENCY BRAKE LIGHT COMES ON. CHECK ENGINE LIGHT ILLUMINATES. UNABLE TO SAFELY DRIVE AS THE VEHIC…
Read full complaint
THE REAR WINDOW ROLLS DOWN BY ITSELF WITH NOBODY TOUCHING ANY OF THE BUTTONS. THE LIGHT POPS UP ON THE DASH AND SAYS FAULTY ELECTRICAL. THE VEHICLE WILL SUDDENLY STOP IN THE MIDDLE OF DRIVING. THE EMERGENCY BREAK APPLIES. THE EMERGENCY BRAKE LIGHT COMES ON. CHECK ENGINE LIGHT ILLUMINATES. UNABLE TO SAFELY DRIVE AS THE VEHICLE JUST STOPS WITHOUT WARNING. VEHICLE IN MOTION ON THE STREET AND ON THE HIGHWAY OCCURRED SEVERAL TIMES
NHTSA ODI #11406294
10,555 miles · Jan 7, 2021
Electrical SystemUnknown Or OtherVehicle Speed Control
THE REAR WINDOW ROLLS DOWN BY ITSELF WITH NOBODY TOUCHING ANY OF THE BUTTONS. THE LIGHT POPS UP ON THE DASH AND SAYS FAULTY ELECTRICAL. THE VEHICLE WAS IN MOTION, IN THE CITY. THE VEHICLE WILL SUDDENLY ATTEMPT TO STOP IN THE MIDDLE OF A DRIVE/MIDDLE OF THE ROAD. ALMOST AS IF THE EMERGENCY BREAK HAS BEEN PULLED, ONLY NOBODY HAS …
Read full complaint
THE REAR WINDOW ROLLS DOWN BY ITSELF WITH NOBODY TOUCHING ANY OF THE BUTTONS. THE LIGHT POPS UP ON THE DASH AND SAYS FAULTY ELECTRICAL. THE VEHICLE WAS IN MOTION, IN THE CITY. THE VEHICLE WILL SUDDENLY ATTEMPT TO STOP IN THE MIDDLE OF A DRIVE/MIDDLE OF THE ROAD. ALMOST AS IF THE EMERGENCY BREAK HAS BEEN PULLED, ONLY NOBODY HAS TOUCHED IT. THE EMERGENCY BRAKE LIGHT DOES COME ON. AGAIN, IN MOTION, ON THE HIGHWAY (HAS HAPPENED A FEW TIMES). NOW, THE REMOTE START DOES NOT WORK.
NHTSA ODI #11386994
6,000 miles · Jan 2, 2021
Electrical SystemForward Collision Avoidance
VW PERFORMED AN EMISSIONS RECALL SOFTWARE UPDATE ON THIS VEHICLE APPROXIMATELY 6 MONTHS AGO. SINCE THIS SOFTWARE UPDATE WAS PERFORMED THE ADAPTIVE CRUISE CONTROL DOES NOT WORK AFTER USING THE VEHICLES OEM REMOTE START. THE ADAPTIVE CRUISE CONTROL WORKS WHEN NOT USING REMOTE START HOWEVER. THEY HAVE SO FAR REFUSED TO OFFER A FIX.
NHTSA ODI #11386080
23,000 miles · Sep 12, 2020
Electrical SystemEngineUnknown Or Other
THE VEHICLE SHUTS DOWN WHILE DRIVING. IT HAS HAPPEN 3 TIMES. AUTO START/STOP IS DISENGAGED EACH TIME. ONE INCIDENT (6/19/20) WHILE DRIVING 50MPH, HAD TO COAST INTO A PARKING LOT & RESTART THE ENGINE. ANOTHER (8/19/20) WHEN SLOWING DOWN TO GO INTO OUR DRIVEWAY. TOOK THE CAR TO THE DEALER AFTER EACH OF THESE INCIDENTS. THEY COULD…
Read full complaint
THE VEHICLE SHUTS DOWN WHILE DRIVING. IT HAS HAPPEN 3 TIMES. AUTO START/STOP IS DISENGAGED EACH TIME. ONE INCIDENT (6/19/20) WHILE DRIVING 50MPH, HAD TO COAST INTO A PARKING LOT & RESTART THE ENGINE. ANOTHER (8/19/20) WHEN SLOWING DOWN TO GO INTO OUR DRIVEWAY. TOOK THE CAR TO THE DEALER AFTER EACH OF THESE INCIDENTS. THEY COULD NOT DIAGNOSE THE ISSUE. DEALER HAS CONTACTED VW TECH & ENGINEERING. WE HAVE STARTED FILE WITH VW CUSTOMER CARE. WE WERE INSTRUCTED BY VW THAT THE NEXT TIME IT HAPPENS, LEAVE THE CAR WHERE IT STOPS & TO CALL CUSTOMER CARE FOR A TOW. WE ALSO HAVE HAD AN ISSUE WITH ONE KEY NOT BEING RECOGNIZED BY THE CAR ON SEVERAL OCCASIONS. TODAY, THE INSTRUMENT DISPLAY & THE RADIO SHUT DOWN WHILE IDLING AT CVS (AUTO START/STOP WAS OFF).
NHTSA ODI #11354563
15,000 miles · Sep 3, 2020
Electrical SystemService BrakesInjury
THE AUTO BRAKING SYSTEM ACTIVATS ON ITS OWN WHILE IN MOTION. ON MULTIPLE OCCASSIONS THE CAR HAS SUDDENLY BRAKED AND IVE COME TO A COMPLETE STOP IN THE MIDDLE OF THE ROAD. NO CARS, DEBRIS, HAZARDS, OR ANYTHING WERE IN FRONT OF ME THAT SHOULD HAVE ACTIVATED THE AUTOMATIC COLLISION PREVENTION SYSTEM. IT IS SO SUDDEN THAT IT LEFT MY…
Read full complaint
THE AUTO BRAKING SYSTEM ACTIVATS ON ITS OWN WHILE IN MOTION. ON MULTIPLE OCCASSIONS THE CAR HAS SUDDENLY BRAKED AND IVE COME TO A COMPLETE STOP IN THE MIDDLE OF THE ROAD. NO CARS, DEBRIS, HAZARDS, OR ANYTHING WERE IN FRONT OF ME THAT SHOULD HAVE ACTIVATED THE AUTOMATIC COLLISION PREVENTION SYSTEM. IT IS SO SUDDEN THAT IT LEFT MY NECK AND SHOULDERS (SEAT BELT AREA) VERY SORE. THE AUTOMATIC COLLISION PREVENTION SYSTEM IS SUPPOSED TO BE A SAFETY FEATURE BUT NEARLY CAUSED A COLLISION. I HAVE TAKEN IT TO THE DEALER MULTIPLE TIMES FOR THE PROBLEM BUT EVERYTIME THEY SAY THERE ARE NO ERRRORS REPORTED ON THEIR COMPUTER AND THERE IS NOTHING THEY CAN DO. THIS IS A KNOWN PROBLEM AMONG MANY VW OWNERS AND VW KNOWS TOO BUT DOESN'T ADDRESS IT.
NHTSA ODI #11353009
10,000 miles · Sep 3, 2020
Electrical SystemService Brakes
WHEN GOING UP OR DOWN A STEEP HILL, AND ALSO 1 TIME PULLING OUT OF A PARKING LOT MY EMERGENCY BRAKES HAVE ENGAGED 5 TIMES. NO CARS HAVE BEEN AROUND (LUCKILY) AND I WAS NOT ABOUT TO HIT ANYTHING. MY COLLISION SENSORS ALSO GO OFF DAILY-THE ENTIRE TIME I'M DRIVING EVEN WHILE NOTHING IS AROUND. I CAN PULL UP TO AN EMPTY INTERSECTION…
Read full complaint
WHEN GOING UP OR DOWN A STEEP HILL, AND ALSO 1 TIME PULLING OUT OF A PARKING LOT MY EMERGENCY BRAKES HAVE ENGAGED 5 TIMES. NO CARS HAVE BEEN AROUND (LUCKILY) AND I WAS NOT ABOUT TO HIT ANYTHING. MY COLLISION SENSORS ALSO GO OFF DAILY-THE ENTIRE TIME I'M DRIVING EVEN WHILE NOTHING IS AROUND. I CAN PULL UP TO AN EMPTY INTERSECTION AND THEY WILL DO OFF. I HAVE TRIED TO CHANGE THE SENSITIVITY AND THIS STILL HAPPENS. THEY ARE NOT CONSISTENT EITHER- THE SAME ROAD CAN MAKE IT GO OFF ONE DAY AND NOT THE NEXT. BUT THEY ARE ALWAYS GOING OFF WHILE DRIVING AND I HAVE TO EXIT OUT OF THE SCREEN
NHTSA ODI #11352920
10,500 miles · Aug 9, 2020
Electrical System
CAR WOULDN'T START AFTER BEING GARAGE FOR TWO DAYS. NOTHING WAS LEFT ON IN THE CAR. THE OTHER THING I NOTICED WAS THAT THE START STOP FUNCTION NO LONGER WORKS. WHEN I FIRST BOUGHT THE CAR IT WORKED ALL THE TIME.
NHTSA ODI #11344213
30,480 miles · Jun 30, 2020
Electrical SystemFuel/propulsion SystemVehicle Speed Control
I HAVE BEEN HAVING PROBLEMS WITH THE CAR SLAMMING ON BRAKES FOR NO REASON, NO CARS IN FRONT OF US WE WERE ON THE HIGHWAY DRIVING AT ABOUT 70 MPH. THE ACC SYSTEM WORKS SPORADICALLY. WE WERE TOLD THAT WHEN THEY DID THE RECALL REPAIR IT DEPROGRAMMED THE ACC WHICH THEY SAY THERE IS NO SOFTWARE UPDATE. MY DAUGHTER WAS PARKING THE CA…
Read full complaint
I HAVE BEEN HAVING PROBLEMS WITH THE CAR SLAMMING ON BRAKES FOR NO REASON, NO CARS IN FRONT OF US WE WERE ON THE HIGHWAY DRIVING AT ABOUT 70 MPH. THE ACC SYSTEM WORKS SPORADICALLY. WE WERE TOLD THAT WHEN THEY DID THE RECALL REPAIR IT DEPROGRAMMED THE ACC WHICH THEY SAY THERE IS NO SOFTWARE UPDATE. MY DAUGHTER WAS PARKING THE CAR AND THE CAR SHUT OFF ON THE MIDDLE OF THE ROAD AND TOLD HER TO MANUALLY RESTART THE CAR. THERE IS A GRINDING NOISE WHEN ACCELERATING THE DEALERSHIP SAID THIS WAS 'NORMAL AND RELATED TO THE TORQUE CONVERTER. THE CRUISE CONTROL ALSO WORKS SPORADICALLY SINCE THE RECALL REPAIR. THE CAR STALLING AND SLAMMING ON BRAKES ARE BOTH VERY SERIOUS SAFETY CONCERNS.
NHTSA ODI #11331640
1 miles · Jun 23, 2020
Electrical SystemService BrakesUnknown Or Other
WHILE DRIVING 35MPH,NO ONE IN EITHER DIRECTION, FLAT STREET SURFACE,BRAKING SYSTEM WENT ON WITH THE ALERT ON DASH AND NOISE.IT HAS HAPPENED 4 TIMES WHERE THE CARS BRAKING SYSTEM TURNS ON, BRAKES WHILE ACCELERATING, AND THEN IT TAKES SEVERAL SECONDS BEFORE YOU CAN MOVE FROM THE INTERSECTION, HOPING NOT TO HAVE A COLLISION FROM CA…
Read full complaint
WHILE DRIVING 35MPH,NO ONE IN EITHER DIRECTION, FLAT STREET SURFACE,BRAKING SYSTEM WENT ON WITH THE ALERT ON DASH AND NOISE.IT HAS HAPPENED 4 TIMES WHERE THE CARS BRAKING SYSTEM TURNS ON, BRAKES WHILE ACCELERATING, AND THEN IT TAKES SEVERAL SECONDS BEFORE YOU CAN MOVE FROM THE INTERSECTION, HOPING NOT TO HAVE A COLLISION FROM CAR THAT IS BEHIND.TOOK TO THE DEALERS SEVERAL TIMES AND THEY CANNOT VERIFY. THE ENGINE LIGHT WAS ON FOR SEVERAL WEEKS.ONE DEALER SAID THEY CANNOT SEE ME FOR ANOTHER 2 WEEKS. CALLED VW HEADQUARTERS TO GET ME IN SOONER. THE TRIANGLE LIGHT WITH EXCLAMATION POINT WAS ALSO ON. THE KEY LIGHT WAS ON AS WELL WHILE MY CAR WAS RUNNING, STATING THE KEYS WERE NOT IN THE CAR. WHEN I WENT TO ACCELERATE, CAR TURNED OFF. SUNROOF WAS LEAKING--HAVE A VIDEO REMOTE KEYS DO NOT WORK ALL THE TIME. START UP HAS ISSUES, DOORS LOCK WHEN I AM CLOSE TO THE CAR FOR NO REASON, DOORS DO NOT UNLOCK FROM THE INSIDE UNTIL I TURN ON THE CAR, THE REAR DOOR DOES NOT OPEN AT TIMES- HAVE A VIDEO, IF KEYS ARE IN POCKET, DOORS DO NOT UNLOCK EASILY(WAS TOLD I HAVE TO HOLD THE HANDLE CORRECTLY OR IT WILL NOT OPEN) THE SIDE ALERT SYSTEM GOES OFF ALL THE TIME WHEN NOTHING IS THERE. FRONT WINDOWS WOULD NOT GO DOWN -ON RECEIPT THEY STATED THEY FOUND WINDOWS WERE FINE. ADVISOR TOLD ME THAT THE BUTTON ON THE DOOR WAS BURNED OUT, BUT THEY DID NOT WRITE THAT IN THE REPORT. STEERING ISSUES WHERE THE CAR WAS MOVING RIGHT TO LEFT AND VERY LOOSE. *TR
NHTSA ODI #11330388
Official recalls
12Sep 11, 2026
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Tiguan, 2018-2019 Atlas, and 2019-2021 Audi Q3 vehicles. One of the bolts that attaches the steering rack to the subframe may corrode and break. If this happens, the steering rack housing can break.
Consequence & remedy
Consequence: A broken steering rack housing can result in a loss of steering control, increasing the risk of a crash.
Remedy: Dealers will replace the right-side steering rack mounting bolt, free of charge. Owner notification letters are expected to be mailed November 10, 2026. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's numbers for this recall are 48LG and 48VT. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on September 16, 2026.
Oct 4, 2023
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2019 Atlas vehicles. The driver's side impact air bag may be missing a weld at the side air bag housing.
Consequence & remedy
Consequence: The driver's side impact air bag could deploy improperly or detach in a crash, increasing the risk of injury.
Remedy: Dealers will replace the driver's side impact air bag, free of charge. Owner notification letters were mailed October 19, 2023. Owners may contact Volkswagen's customer service at 1-800-893-5298. Volkswagen's number for this recall is 69FK.
Mar 29, 2023
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018-2021 Atlas and 2020 Atlas Cross Sport vehicles. The passenger occupant detection system (PODS) may experience a fault in the wiring and deactivate the front passenger air bag when the seat is occupied.
Consequence & remedy
Consequence: A deactivated passenger air bag increases the risk of injury during a crash.
Remedy: Dealers will replace the PODS sensor mat and wiring harness, free of charge. Owner notification letters were mailed on March 22, 2024. Owners may contact Volkswagen's customer service at 1-800-893-5298. Volkswagen's number for this recall is 69FB.
Oct 31, 2022
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2019 Volkswagen Tiguan LWB, Golf Sportswagen A7, Golf Alltrack, Golf R GP, Audi Q3, Audi A3 Cabriolet, 2019-2020 Jetta NF, Jetta GLI, Golf GTI, Atlas, Golf A7, Audi A3, 2020-2021 Atlas Cross Sport, and 2021 Atlas FL vehicles. The tire pressure monitoring system may not detect an air pressure loss in adequate time when deflating occurs among all four tires simultaneously. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 138, "Tire Pressure Monitoring Systems."
Consequence & remedy
Consequence: An undetected sudden loss of pressure in all four tires increases the risk of a crash.
Remedy: Dealers will update the TPMS software, free of charge. Owner notification letters were mailed November 18, 2022. Owners may contact Volkswagen's customer service at 1-800-893-5298 or Audis customer service at 1-800-253-2834. Volkswagen's numbers for this recall are (Audi) 45J7, and (VW) 45J6 and 45J8.
Mar 28, 2022
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2019-2020 Atlas, 2020-2023 Atlas Cross Sport, and 2021-2023 Atlas FL vehicles. The door wiring harness electrical contacts may corrode, disrupting the electrical connection and delaying the deployment of the driver or passenger front side air bag during a side impact crash.
Consequence & remedy
Consequence: A delayed air bag deployment can increase the risk of injury.
Remedy: Dealers will secure and, as necessary, replace any the front door wiring harnesses showing a fault code, free of charge. Owner notification letters were mailed June 20, 2022. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 97GF.
Feb 16, 2022
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018-2021 Atlas and 2020-2021 Atlas Cross Sport vehicles equipped with accessory side steps. The reduced Gross Vehicle Weight Rating (GVWR) label, reflecting the additional weight of the side steps, was not installed. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: Without the reduced GVWR label, the vehicle could be overloaded, leading to a loss of control and increasing the risk of a crash.
Remedy: Dealers will install the reduced GVWR label, free of charge. Owner notification letters were mailed March 31, 2022. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 09D9.
Mar 5, 2021
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018-2019 Atlas vehicles equipped with Continental tires. On the affected vehicles, it is possible that one or more tires were cured for too long during tire production.
Consequence & remedy
Consequence: Over cured tires may develop a break in the sidewall, resulting in sudden air loss or belt edge separation which could lead to tread/belt loss. Either condition can cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will inspect the tires, and replace them as necessary, free of charge. The recall began on March 24, 2021. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 44R1.
Aug 21, 2019
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2019 Atlas vehicles. The suction jet in the fuel tank may have been welded in the incorrect position allowing fuel to leak. Additionally, the vehicle may stall due to uneven fuel distribution.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire. An engine stall can increase the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will replace the fuel tank, free of charge. The recall began August 30, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 20BU.
May 22, 2019
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2012-2020 Volkswagen Passat and 2018-2019 Atlas vehicles. The blocking cap disabling the adjustment of the headlight's horizontal aim may not have been installed. As such, these vehicles fail to conform to Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: Without the blocking cap, the headlight aim can be adjusted out of specification, reducing visibility and increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will inspect and, as necessary, block the headlight horizontal adjustment, free of charge. The recall began July 16, 2019. Owners may contact Volkswagen customer service at 1-800-253-2834. Volkswagen's number for this recall is 94L9.
Mar 20, 2019
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2019 Atlas and 2020 Passat vehicles. An incorrect driver and/or front passenger side impact air bag may have been installed.
Consequence & remedy
Consequence: In an event of a side impact crash, an incorrect side airbag may not deploy as intended, increasing the risk of injury.
Remedy: Volkswagen has inspected and replaced the side air bags, free of charge. The recall was completed in April 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 69Y8.
Dec 19, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018-2019 Volkswagen Atlas, 2015 Volkswagen Golf SportWagen, and 2019 Volkswagen Jetta vehicles. The rear coil springs may prematurely fracture.
Consequence & remedy
Consequence: If a coil spring fractures while driving, it may damage a rear tire causing a loss of vehicle control, increasing the risk of a crash.
Remedy: Volkswagen has notified owners, and dealers will replace the rear axle coil springs, free of charge. The recall began January 31, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 42J2/42J3.
Nov 26, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018-2019 Volkswagen Atlas and Tiguan and 2019 Volkswagen Jetta vehicles that do not have keyless entry. The instrument cluster may not provide an audible warning to let the driver know that the key is still in the ignition when the door is open. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection."
Consequence & remedy
Consequence: If the driver is not notified by an audible noise that the key is left in the ignition, it can increase the risk of vehicle theft or crash.
Remedy: Volkswagen will notify owners, and dealers will reprogram the instrument cluster, free of charge. The recall began December 13, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's numbers for this recall are 90L3 and 90L4.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA24004 · Inadvertent Automatic Emergency Braking
Opened Dec 18, 2024 · No close date supplied
Status: open (inferred from source dates) · Forward Collision Avoidance; Forward Collision Avoidance: Automatic Emergency Braking
On September 28, 2023, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE23017) to assess reports of inadvertent activation of the Front Assist automatic emergency braking (AEB) system in model year (MY) 2018-2019 Volkswagen Atlas vehicles. The reports alleged that activation of the AEB system occurred while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Volkswagen indicated that it is aware of a total of 226 reports that may relate to the alleged defect in MY 2019 Volkswagen Atlas vehicles.Volkswagen stated that some customers possibly had an inadequate understanding of Front Assist and its limitations. However, many consumer complaints alleged that Volkswagen dealerships were unable to reproduce the condition or stated that Volkswagen dealerships informed the consumers that this braking is considered normal Front Assist operation. ODI's analysis shows that MY 2019 Volkswagen Atlas vehicles have the highest rate of unique incident reports alleging AEB inadvertent activation when compared to their Volkswagen peers. To date, ODI has received a total of 44 consumer complaints of inadvertent activation of Front Assist in MY 2019 Volkswagen Atlas vehicles.In total, ODI reviewed 187 unique (i.e., non-duplicative Vehicle Identification Numbers) reports that may relate to the alleged defect, which include four reports on injury incidents and one report involving a crash. PE23017 has been upgraded to an Engineering Analysis to further assess the scope, frequency, and potential safety-related consequences of inadvertent AEB activations in MY 2019 Volkswagen Atlas vehicles. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Forward Collision Avoidance: Automatic Emergency Braking
On September 28, 2023, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE23017) to assess reports of inadvertent activation of the Front Assist automatic emergency braking (AEB) system in model year (MY) 2018-2019 Volkswagen Atlas vehicles. The reports alleged that activation of the AEB system occurred while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Volkswagen indicated that it is aware of a total of 226 reports that may relate to the alleged defect in MY 2019 Volkswagen Atlas vehicles.Volkswagen stated that some customers possibly had an inadequate understanding of Front Assist and its limitations. However, many consumer complaints alleged that Volkswagen dealerships were unable to reproduce the condition or stated that Volkswagen dealerships informed the consumers that this braking is considered normal Front Assist operation. ODI's analysis shows that MY 2019 Volkswagen Atlas vehicles have the highest rate of unique incident reports alleging AEB inadvertent activation when compared to their Volkswagen peers. To date, ODI has received a total of 44 consumer complaints of inadvertent activation of Front Assist in MY 2019 Volkswagen Atlas vehicles.In total, ODI reviewed 187 unique (i.e., non-duplicative Vehicle Identification Numbers) reports that may relate to the alleged defect, which include four reports on injury incidents and one report involving a crash. PE23017 has been upgraded to an Engineering Analysis to further assess the scope, frequency, and potential safety-related consequences of inadvertent AEB activations in MY 2019 Volkswagen Atlas vehicles. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Forward Collision Avoidance
On September 28, 2023, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE23017) to assess reports of inadvertent activation of the Front Assist automatic emergency braking (AEB) system in model year (MY) 2018-2019 Volkswagen Atlas vehicles. The reports alleged that activation of the AEB system occurred while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Volkswagen indicated that it is aware of a total of 226 reports that may relate to the alleged defect in MY 2019 Volkswagen Atlas vehicles.Volkswagen stated that some customers possibly had an inadequate understanding of Front Assist and its limitations. However, many consumer complaints alleged that Volkswagen dealerships were unable to reproduce the condition or stated that Volkswagen dealerships informed the consumers that this braking is considered normal Front Assist operation. ODI's analysis shows that MY 2019 Volkswagen Atlas vehicles have the highest rate of unique incident reports alleging AEB inadvertent activation when compared to their Volkswagen peers. To date, ODI has received a total of 44 consumer complaints of inadvertent activation of Front Assist in MY 2019 Volkswagen Atlas vehicles.In total, ODI reviewed 187 unique (i.e., non-duplicative Vehicle Identification Numbers) reports that may relate to the alleged defect, which include four reports on injury incidents and one report involving a crash. PE23017 has been upgraded to an Engineering Analysis to further assess the scope, frequency, and potential safety-related consequences of inadvertent AEB activations in MY 2019 Volkswagen Atlas vehicles. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE23017 · Inadvertent Automatic Emergency Braking
Opened Sep 28, 2023 · Closed Dec 18, 2024
Status: closed (inferred from source dates) · Forward Collision Avoidance; Forward Collision Avoidance: Automatic Emergency Braking
On September 28, 2023, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE23017) to assess reports of inadvertent activation of the Front Assist automatic emergency braking (AEB) system in model year (MY) 2018-2019 Volkswagen Atlas vehicles.The reports alleged that activation of the AEB system occurred while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Volkswagen indicated that it is aware of a total of 292 reports that may relate to the alleged defect in MY 2018-2019 Volkswagen Atlas vehicles.Volkswagen stated that some customers possibly had an inadequate understanding of Front Assist and its limitations. However, many consumer complaints alleged that Volkswagen dealerships were unable to reproduce the condition or Volkswagen dealerships informed the consumers that this braking is considered normal Front Assist operation. ODI's analysis shows that MY 2019 Volkswagen Atlas vehicles have the highest rate of unique incident reports alleging AEB inadvertent activation when compared to their Volkswagen peers.The rate of unique incident reports alleging AEB inadvertent activation in MY 2018 Volkswagen Atlas vehicles was comparable to their Volkswagen peers. To date, ODI has received a total of 69 consumer complaints of inadvertent activation of Front Assist in MY 2018-2019 Volkswagen Atlas vehicles. In total, ODI reviewed 264 unique (i.e., non-duplicative Vehicle Identification Numbers) reports that may relate to the alleged defect, which include eight reports of incidents involving an alleged injury and two reports involving a crash. PE23017 has been upgraded to an Engineering Analysis (EA24004) to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations in MY 2019 Volkswagen Atlas vehicles. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Forward Collision Avoidance: Automatic Emergency Braking
On September 28, 2023, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE23017) to assess reports of inadvertent activation of the Front Assist automatic emergency braking (AEB) system in model year (MY) 2018-2019 Volkswagen Atlas vehicles.The reports alleged that activation of the AEB system occurred while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Volkswagen indicated that it is aware of a total of 292 reports that may relate to the alleged defect in MY 2018-2019 Volkswagen Atlas vehicles.Volkswagen stated that some customers possibly had an inadequate understanding of Front Assist and its limitations. However, many consumer complaints alleged that Volkswagen dealerships were unable to reproduce the condition or Volkswagen dealerships informed the consumers that this braking is considered normal Front Assist operation. ODI's analysis shows that MY 2019 Volkswagen Atlas vehicles have the highest rate of unique incident reports alleging AEB inadvertent activation when compared to their Volkswagen peers.The rate of unique incident reports alleging AEB inadvertent activation in MY 2018 Volkswagen Atlas vehicles was comparable to their Volkswagen peers. To date, ODI has received a total of 69 consumer complaints of inadvertent activation of Front Assist in MY 2018-2019 Volkswagen Atlas vehicles. In total, ODI reviewed 264 unique (i.e., non-duplicative Vehicle Identification Numbers) reports that may relate to the alleged defect, which include eight reports of incidents involving an alleged injury and two reports involving a crash. PE23017 has been upgraded to an Engineering Analysis (EA24004) to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations in MY 2019 Volkswagen Atlas vehicles. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Forward Collision Avoidance
On September 28, 2023, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE23017) to assess reports of inadvertent activation of the Front Assist automatic emergency braking (AEB) system in model year (MY) 2018-2019 Volkswagen Atlas vehicles.The reports alleged that activation of the AEB system occurred while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Volkswagen indicated that it is aware of a total of 292 reports that may relate to the alleged defect in MY 2018-2019 Volkswagen Atlas vehicles.Volkswagen stated that some customers possibly had an inadequate understanding of Front Assist and its limitations. However, many consumer complaints alleged that Volkswagen dealerships were unable to reproduce the condition or Volkswagen dealerships informed the consumers that this braking is considered normal Front Assist operation. ODI's analysis shows that MY 2019 Volkswagen Atlas vehicles have the highest rate of unique incident reports alleging AEB inadvertent activation when compared to their Volkswagen peers.The rate of unique incident reports alleging AEB inadvertent activation in MY 2018 Volkswagen Atlas vehicles was comparable to their Volkswagen peers. To date, ODI has received a total of 69 consumer complaints of inadvertent activation of Front Assist in MY 2018-2019 Volkswagen Atlas vehicles. In total, ODI reviewed 264 unique (i.e., non-duplicative Vehicle Identification Numbers) reports that may relate to the alleged defect, which include eight reports of incidents involving an alleged injury and two reports involving a crash. PE23017 has been upgraded to an Engineering Analysis (EA24004) to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations in MY 2019 Volkswagen Atlas vehicles. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
PE21008 · Fuel Injector Leak
Opened Mar 29, 2021 · Closed Oct 3, 2022
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:fuel Injection System:injectors
On March 29, 2021, the Office of Defects Investigations (ODI) opened PE21-008 to investigate instances of fuel injectors leaking in the engine compartment in model year (MY) 2018 through 2020 Volkswagen Atlas and Atlas Cross Sport SUVs. These vehicles are equipped with either a 3.6 or 2.0 liter engine. The subject investigation concerns vehicles equipped with 3.6L engines. Prior to opening the investigation, ODI also observed that warranty data for the fuel system from TREAD reporting was an outlier for the MY 2018 Atlas.The allegation involved fuel injectors leaking fuel near engine compartment components that operate at high temperatures. Consumers allege a fuel leak, fuel odor, and/or an illuminated check engine malfunction indicator light (MIL) on that alerts them to the condition. Fuel leaking in the engine compartment has a higher potential risk of fire as nearby components are operating at higher temperatures compared to other areas of the vehicle. No fires have been connected to this issue to date.The 3.6L engine is a VR6 type engine. Due to its specific design, the VR6 has two types of injectors with different designs installed. Cylinders 1, 3, and 5 use long injectors and cylinders 2, 4, and 6 use short injectors. Unlike the short injectors, the long injectors require an extension pipe necessary to reach cylinders 1, 3, and 5. Volkswagen stated that the potential root cause for a leaking injector is typically either a damaged, misaligned, or missing supporting ring or a damaged O-ring. These rings assist in connecting the injector to the extension pipe. If one of these conditions is present in a vehicle, the O-ring has difficulty withstanding fuel pressure over time.Volkswagen stated that an analysis of warranty data related to leaking injectors in vehicles equipped with 3.6L engines showed that the vast majority of leaking allegations were related to internal leaks. Fuel can leak into the cylinder causing misfiring in the affected cylinders. This condition would not cause fuel to enter into the engine compartment. Volkswagen states that these internal leaks pose no unreasonable risk to motor vehicle safety.Analysis of all relevant data indicates that the subject condition is an early-life failure with a relatively low failure rate. The average failure mileage calculated from all data sources was determined to be approximately 14,000 miles. Only two failures were reported outside of the vehicles' warranty coverage period. The average time to failure for the subject vehicle population is approximately 12 months in service (MIS). The majority of failures were below the average of 14,000 miles or 12 MIS. Analysis of reported failures showed that the failure rate is approximately 0.08% or 0.8 incidents per thousand vehicles (IPTV).To date, there have been no reported fires, crashes, injuries, or fatalities related to this issue. In view of the low rate of failure, the nature of early-life failure, and low potential hazard to drivers, this Preliminary Evaluation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers:11446833, 11438403, 11382958, 11298402, 11291955, 11218819, 11218780
Additional source detail variants (2)
Fuel System, Gasoline:fuel Injection System:injectors
On March 29, 2021, the Office of Defects Investigations (ODI) opened PE21-008 to investigate instances of fuel injectors leaking in the engine compartment in model year (MY) 2018 through 2020 Volkswagen Atlas and Atlas Cross Sport SUVs. These vehicles are equipped with either a 3.6 or 2.0 liter engine. The subject investigation concerns vehicles equipped with 3.6L engines. Prior to opening the investigation, ODI also observed that warranty data for the fuel system from TREAD reporting was an outlier for the MY 2018 Atlas.The allegation involved fuel injectors leaking fuel near engine compartment components that operate at high temperatures. Consumers allege a fuel leak, fuel odor, and/or an illuminated check engine malfunction indicator light (MIL) on that alerts them to the condition. Fuel leaking in the engine compartment has a higher potential risk of fire as nearby components are operating at higher temperatures compared to other areas of the vehicle. No fires have been connected to this issue to date.The 3.6L engine is a VR6 type engine. Due to its specific design, the VR6 has two types of injectors with different designs installed. Cylinders 1, 3, and 5 use long injectors and cylinders 2, 4, and 6 use short injectors. Unlike the short injectors, the long injectors require an extension pipe necessary to reach cylinders 1, 3, and 5. Volkswagen stated that the potential root cause for a leaking injector is typically either a damaged, misaligned, or missing supporting ring or a damaged O-ring. These rings assist in connecting the injector to the extension pipe. If one of these conditions is present in a vehicle, the O-ring has difficulty withstanding fuel pressure over time.Volkswagen stated that an analysis of warranty data related to leaking injectors in vehicles equipped with 3.6L engines showed that the vast majority of leaking allegations were related to internal leaks. Fuel can leak into the cylinder causing misfiring in the affected cylinders. This condition would not cause fuel to enter into the engine compartment. Volkswagen states that these internal leaks pose no unreasonable risk to motor vehicle safety.Analysis of all relevant data indicates that the subject condition is an early-life failure with a relatively low failure rate. The average failure mileage calculated from all data sources was determined to be approximately 14,000 miles. Only two failures were reported outside of the vehicles' warranty coverage period. The average time to failure for the subject vehicle population is approximately 12 months in service (MIS). The majority of failures were below the average of 14,000 miles or 12 MIS. Analysis of reported failures showed that the failure rate is approximately 0.08% or 0.8 incidents per thousand vehicles (IPTV).To date, there have been no reported fires, crashes, injuries, or fatalities related to this issue. In view of the low rate of failure, the nature of early-life failure, and low potential hazard to drivers, this Preliminary Evaluation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers:11446833, 11438403, 11382958, 11298402, 11291955, 11218819, 11218780
Fuel System, Gasoline
On March 29, 2021, the Office of Defects Investigations (ODI) opened PE21-008 to investigate instances of fuel injectors leaking in the engine compartment in model year (MY) 2018 through 2020 Volkswagen Atlas and Atlas Cross Sport SUVs. These vehicles are equipped with either a 3.6 or 2.0 liter engine. The subject investigation concerns vehicles equipped with 3.6L engines. Prior to opening the investigation, ODI also observed that warranty data for the fuel system from TREAD reporting was an outlier for the MY 2018 Atlas.The allegation involved fuel injectors leaking fuel near engine compartment components that operate at high temperatures. Consumers allege a fuel leak, fuel odor, and/or an illuminated check engine malfunction indicator light (MIL) on that alerts them to the condition. Fuel leaking in the engine compartment has a higher potential risk of fire as nearby components are operating at higher temperatures compared to other areas of the vehicle. No fires have been connected to this issue to date.The 3.6L engine is a VR6 type engine. Due to its specific design, the VR6 has two types of injectors with different designs installed. Cylinders 1, 3, and 5 use long injectors and cylinders 2, 4, and 6 use short injectors. Unlike the short injectors, the long injectors require an extension pipe necessary to reach cylinders 1, 3, and 5. Volkswagen stated that the potential root cause for a leaking injector is typically either a damaged, misaligned, or missing supporting ring or a damaged O-ring. These rings assist in connecting the injector to the extension pipe. If one of these conditions is present in a vehicle, the O-ring has difficulty withstanding fuel pressure over time.Volkswagen stated that an analysis of warranty data related to leaking injectors in vehicles equipped with 3.6L engines showed that the vast majority of leaking allegations were related to internal leaks. Fuel can leak into the cylinder causing misfiring in the affected cylinders. This condition would not cause fuel to enter into the engine compartment. Volkswagen states that these internal leaks pose no unreasonable risk to motor vehicle safety.Analysis of all relevant data indicates that the subject condition is an early-life failure with a relatively low failure rate. The average failure mileage calculated from all data sources was determined to be approximately 14,000 miles. Only two failures were reported outside of the vehicles' warranty coverage period. The average time to failure for the subject vehicle population is approximately 12 months in service (MIS). The majority of failures were below the average of 14,000 miles or 12 MIS. Analysis of reported failures showed that the failure rate is approximately 0.08% or 0.8 incidents per thousand vehicles (IPTV).To date, there have been no reported fires, crashes, injuries, or fatalities related to this issue. In view of the low rate of failure, the nature of early-life failure, and low potential hazard to drivers, this Preliminary Evaluation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers:11446833, 11438403, 11382958, 11298402, 11291955, 11218819, 11218780
Illustration