NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
73 reportsClear category filterMileage unknown · Jul 26, 2026
Electrical SystemVisibility/wiper
The infotainment display in this vehicle intermittently fails to power on, most often at startup. When this occurs, the screen remains dark while audio and physical controls continue to function. The vehicle sometimes must be restarted, and the display does not always return. When the display is dark, the rearview camera image i…
Read full complaint
The infotainment display in this vehicle intermittently fails to power on, most often at startup. When this occurs, the screen remains dark while audio and physical controls continue to function. The vehicle sometimes must be restarted, and the display does not always return. When the display is dark, the rearview camera image is unavailable. This defect first occurred approximately three weeks after the vehicle was purchased as a manufacturer Certified Pre-Owned vehicle, and it remains unresolved. The most recent occurrence was yesterday, Jul 25 2026. At least 15 video recordings document the failure between October 2024 and the present, along with complete service records. On multiple occasions the display and rearview camera were already non-functional from vehicle startup, and the vehicle was subsequently reversed without a rear camera image because no camera-equipped alternative was available. On more than one of these occasions, this resulted in a near-miss with another vehicle or object. The dealer has confirmed and reproduced the underlying fault on more than one occasion. In October 2024, a stored fault code was found in the infotainment control module and the module was replaced under manufacturer warranty; the display failure continued unchanged afterward. In May 2026, the wiring harness between the control module and the display was replaced under manufacturer warranty after the manufacturer diagnosed an internal failure in the harness; the manufacturer's own repair record states the repair was tested and verified over a 3-mile road test, and the failure recurred within weeks. The vehicle and its service history are available for inspection upon request. The manufacturer has been notified in writing that this defect presents a safety issue due to loss of rearview camera function, and has not directly addressed that concern in its written responses.
NHTSA ODI #11752918
Mileage unknown · Jul 22, 2026
Electrical System
I was stopped at a drive thru window and as I reached out to get my food, the window rose up by itself. As I drove home over the next ten minutes, the locks locked and unlocked by themselves and the windows rolled down and up by themselves. Warning lights came on and then went off, including "Fault: Electronic parking brake," an…
Read full complaint
I was stopped at a drive thru window and as I reached out to get my food, the window rose up by itself. As I drove home over the next ten minutes, the locks locked and unlocked by themselves and the windows rolled down and up by themselves. Warning lights came on and then went off, including "Fault: Electronic parking brake," and "Error:Airbag." The dash screen went off for a few seconds and then came back on.
NHTSA ODI #11752193
Mileage unknown · Jun 12, 2026
Air BagsElectrical SystemUnknown Or Other
The air conditioning drain tube clogged and leaked into the air bag control module and caused an entire electrical failure in my car with air bag sensors, braking, windows rolling down, doors locking and unlocking automatically while driving, etc as well as the carpet getting mold.
NHTSA ODI #11743656
Mileage unknown · Mar 10, 2026
Electrical SystemService BrakesUnknown Or Other
Component Failed: ABS Braking System / Wiring Harness. Safety Risk: While driving at highway speeds with my service animal, the vehicle suffered a catastrophic ABS failure. The brakes became unresponsive, and the dashboard displayed multiple critical safety warnings, nearly resulting in a collision. Confirmation: The failure was…
Read full complaint
Component Failed: ABS Braking System / Wiring Harness. Safety Risk: While driving at highway speeds with my service animal, the vehicle suffered a catastrophic ABS failure. The brakes became unresponsive, and the dashboard displayed multiple critical safety warnings, nearly resulting in a collision. Confirmation: The failure was confirmed by Schumacher VW (West Palm Beach) during a forensic inspection. They identified the cause as a corroded/damaged wiring harness—the exact defect visible in a diagnostic video from Jim Ellis VW one week prior. Warning Symptoms: "Front Assist" and sensor warning lamps appeared on [XXX]. I paid Jim Ellis VW for a diagnostic; however, they failed to repair the visible defect and later falsely denied to the BBB that the diagnostic ever occurred. Summary: This vehicle (VIN: [XXX] ) has a documented safety defect that was identified by a technician but concealed by dealership management. This concealment led to a total loss of braking assist while the vehicle was in motion. The vehicle is currently available for inspection at Schumacher VW. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11723430
Mileage unknown · Mar 2, 2026
Electrical SystemEngineFuel/propulsion System
The vehicle warning lights come on and off to make it seem like I am about to hit or to close to something when I am not moving at all. The vehicle putts and stalls while driving like it wants to cut off. It also does this when I am at a complete stop as well as if I am backing up Warning lights on the dash appear than disappe…
Read full complaint
The vehicle warning lights come on and off to make it seem like I am about to hit or to close to something when I am not moving at all. The vehicle putts and stalls while driving like it wants to cut off. It also does this when I am at a complete stop as well as if I am backing up Warning lights on the dash appear than disappear sometimes as well.
NHTSA ODI #11721334
Mileage unknown · Mar 2, 2026
Electrical SystemEnginePower Train
1. What component or system failed or malfunctioned, and is it available for inspection upon request? The engine and the HVAC systems. Specifically, a persistent "ghost misfire"—where the engine vibrates and shudders without triggering a dashboard warning light—and a total heater failure. The vehicle is currently held at the dea…
Read full complaint
1. What component or system failed or malfunctioned, and is it available for inspection upon request? The engine and the HVAC systems. Specifically, a persistent "ghost misfire"—where the engine vibrates and shudders without triggering a dashboard warning light—and a total heater failure. The vehicle is currently held at the dealership; all service records (RO# 367641, 367891, 367980, 368179) are available. 2. How was your safety or the safety of others put at risk? The "ghost misfire" causes shaking and hesitation during acceleration, creating a risk of losing power or stalling in high-speed traffic. Because the vehicle's diagnostics do not trigger a warning light for this condition, the driver has no advance notice of a potential engine failure. 3. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. Dealership technicians confirmed the misfire on Feb 9 (RO# 367891) and found a defective spark plug gap (.024” vs. .036”). On Feb 25, the service consultant confirmed the "ghost misfire" remained active. The heater failure was confirmed via a 'Heater Support Pump Dry Run' fault code (RO# 367641). 4. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? The vehicle has been inspected by dealership technicians. Formal complaints have also been filed with the California Bureau of Automotive Repair and the California Attorney General. 5. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Symptoms began following a service on Jan 30. Feb 8: Exhaust malfunction light (MIL) appeared briefly with severe shaking. Feb 9–present: Exhaust malfunction warning lights appeared briefly and then disappeared, but the engine vibration and "ghost misfire" symptoms remain active and undetected by the vehicle's onboard diagnostics. Feb 17: Total loss of heat occurred during a highway drive without a dashboard warning lamp
NHTSA ODI #11721328
Mileage unknown · Feb 27, 2026
Electrical SystemService BrakesUnknown Or Other
I am reporting a critical safety failure of the ABS wiring harness following service at Jim Ellis Volkswagen. I originally brought the vehicle in for a "Front Assist" safety light diagnostic. Immediately following the service, the ABS wiring harness failed, disabling my braking safety systems. The dealership is currently withhol…
Read full complaint
I am reporting a critical safety failure of the ABS wiring harness following service at Jim Ellis Volkswagen. I originally brought the vehicle in for a "Front Assist" safety light diagnostic. Immediately following the service, the ABS wiring harness failed, disabling my braking safety systems. The dealership is currently withholding the diagnostic report and technician notes that would confirm the state of the wiring harness during their inspection. This failure has rendered the vehicle undriveable and creates a severe safety risk to the driver and public.
NHTSA ODI #11721018
Mileage unknown · Jan 1, 2026
Electrical SystemForward Collision AvoidanceUnknown Or Other
There is a yellow triangle on my dash and when the dealer did the troubleshooting they indicated that there is a fault in the system with the transmission shifter and a part is needed to correct the issue. The vehicle is just beyond the warrantee period with 39,000 miles.
NHTSA ODI #11708170
Mileage unknown · Dec 18, 2025
Electrical System
The radio keeps turning off and on and random stuff keeps popping up on the dash I have read that atlas models from 2019 to 2023 have wiring harness issues why Is there no recall for this and all research I have done with what is going on is leading up to a wiring harness issue
NHTSA ODI #11705935
Mileage unknown · Aug 30, 2025
Electrical SystemEngineFuel/propulsion System
With auto stop/start disengaged, vehicles stalls at slow speed (approaching a stop sign) or while idling at a stop light. displays "start car manually" when this happens. Now error code displays "Error Stop-start" The stalling has happened 5 times this week.
NHTSA ODI #11684060
Official recalls
12Sep 11, 2026
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Tiguan, 2018-2019 Atlas, and 2019-2021 Audi Q3 vehicles. One of the bolts that attaches the steering rack to the subframe may corrode and break. If this happens, the steering rack housing can break.
Consequence & remedy
Consequence: A broken steering rack housing can result in a loss of steering control, increasing the risk of a crash.
Remedy: Dealers will replace the right-side steering rack mounting bolt, free of charge. Owner notification letters are expected to be mailed November 10, 2026. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's numbers for this recall are 48LG and 48VT. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on September 16, 2026.
Oct 4, 2023
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2019 Atlas vehicles. The driver's side impact air bag may be missing a weld at the side air bag housing.
Consequence & remedy
Consequence: The driver's side impact air bag could deploy improperly or detach in a crash, increasing the risk of injury.
Remedy: Dealers will replace the driver's side impact air bag, free of charge. Owner notification letters were mailed October 19, 2023. Owners may contact Volkswagen's customer service at 1-800-893-5298. Volkswagen's number for this recall is 69FK.
Mar 29, 2023
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018-2021 Atlas and 2020 Atlas Cross Sport vehicles. The passenger occupant detection system (PODS) may experience a fault in the wiring and deactivate the front passenger air bag when the seat is occupied.
Consequence & remedy
Consequence: A deactivated passenger air bag increases the risk of injury during a crash.
Remedy: Dealers will replace the PODS sensor mat and wiring harness, free of charge. Owner notification letters were mailed on March 22, 2024. Owners may contact Volkswagen's customer service at 1-800-893-5298. Volkswagen's number for this recall is 69FB.
Oct 31, 2022
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2019 Volkswagen Tiguan LWB, Golf Sportswagen A7, Golf Alltrack, Golf R GP, Audi Q3, Audi A3 Cabriolet, 2019-2020 Jetta NF, Jetta GLI, Golf GTI, Atlas, Golf A7, Audi A3, 2020-2021 Atlas Cross Sport, and 2021 Atlas FL vehicles. The tire pressure monitoring system may not detect an air pressure loss in adequate time when deflating occurs among all four tires simultaneously. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 138, "Tire Pressure Monitoring Systems."
Consequence & remedy
Consequence: An undetected sudden loss of pressure in all four tires increases the risk of a crash.
Remedy: Dealers will update the TPMS software, free of charge. Owner notification letters were mailed November 18, 2022. Owners may contact Volkswagen's customer service at 1-800-893-5298 or Audis customer service at 1-800-253-2834. Volkswagen's numbers for this recall are (Audi) 45J7, and (VW) 45J6 and 45J8.
Mar 28, 2022
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2019-2020 Atlas, 2020-2023 Atlas Cross Sport, and 2021-2023 Atlas FL vehicles. The door wiring harness electrical contacts may corrode, disrupting the electrical connection and delaying the deployment of the driver or passenger front side air bag during a side impact crash.
Consequence & remedy
Consequence: A delayed air bag deployment can increase the risk of injury.
Remedy: Dealers will secure and, as necessary, replace any the front door wiring harnesses showing a fault code, free of charge. Owner notification letters were mailed June 20, 2022. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 97GF.
Feb 16, 2022
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018-2021 Atlas and 2020-2021 Atlas Cross Sport vehicles equipped with accessory side steps. The reduced Gross Vehicle Weight Rating (GVWR) label, reflecting the additional weight of the side steps, was not installed. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: Without the reduced GVWR label, the vehicle could be overloaded, leading to a loss of control and increasing the risk of a crash.
Remedy: Dealers will install the reduced GVWR label, free of charge. Owner notification letters were mailed March 31, 2022. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 09D9.
Mar 5, 2021
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018-2019 Atlas vehicles equipped with Continental tires. On the affected vehicles, it is possible that one or more tires were cured for too long during tire production.
Consequence & remedy
Consequence: Over cured tires may develop a break in the sidewall, resulting in sudden air loss or belt edge separation which could lead to tread/belt loss. Either condition can cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will inspect the tires, and replace them as necessary, free of charge. The recall began on March 24, 2021. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 44R1.
Aug 21, 2019
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2019 Atlas vehicles. The suction jet in the fuel tank may have been welded in the incorrect position allowing fuel to leak. Additionally, the vehicle may stall due to uneven fuel distribution.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire. An engine stall can increase the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will replace the fuel tank, free of charge. The recall began August 30, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 20BU.
May 22, 2019
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2012-2020 Volkswagen Passat and 2018-2019 Atlas vehicles. The blocking cap disabling the adjustment of the headlight's horizontal aim may not have been installed. As such, these vehicles fail to conform to Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: Without the blocking cap, the headlight aim can be adjusted out of specification, reducing visibility and increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will inspect and, as necessary, block the headlight horizontal adjustment, free of charge. The recall began July 16, 2019. Owners may contact Volkswagen customer service at 1-800-253-2834. Volkswagen's number for this recall is 94L9.
Mar 20, 2019
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2019 Atlas and 2020 Passat vehicles. An incorrect driver and/or front passenger side impact air bag may have been installed.
Consequence & remedy
Consequence: In an event of a side impact crash, an incorrect side airbag may not deploy as intended, increasing the risk of injury.
Remedy: Volkswagen has inspected and replaced the side air bags, free of charge. The recall was completed in April 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 69Y8.
Dec 19, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018-2019 Volkswagen Atlas, 2015 Volkswagen Golf SportWagen, and 2019 Volkswagen Jetta vehicles. The rear coil springs may prematurely fracture.
Consequence & remedy
Consequence: If a coil spring fractures while driving, it may damage a rear tire causing a loss of vehicle control, increasing the risk of a crash.
Remedy: Volkswagen has notified owners, and dealers will replace the rear axle coil springs, free of charge. The recall began January 31, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 42J2/42J3.
Nov 26, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018-2019 Volkswagen Atlas and Tiguan and 2019 Volkswagen Jetta vehicles that do not have keyless entry. The instrument cluster may not provide an audible warning to let the driver know that the key is still in the ignition when the door is open. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection."
Consequence & remedy
Consequence: If the driver is not notified by an audible noise that the key is left in the ignition, it can increase the risk of vehicle theft or crash.
Remedy: Volkswagen will notify owners, and dealers will reprogram the instrument cluster, free of charge. The recall began December 13, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's numbers for this recall are 90L3 and 90L4.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA24004 · Inadvertent Automatic Emergency Braking
Opened Dec 18, 2024 · No close date supplied
Status: open (inferred from source dates) · Forward Collision Avoidance; Forward Collision Avoidance: Automatic Emergency Braking
On September 28, 2023, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE23017) to assess reports of inadvertent activation of the Front Assist automatic emergency braking (AEB) system in model year (MY) 2018-2019 Volkswagen Atlas vehicles. The reports alleged that activation of the AEB system occurred while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Volkswagen indicated that it is aware of a total of 226 reports that may relate to the alleged defect in MY 2019 Volkswagen Atlas vehicles.Volkswagen stated that some customers possibly had an inadequate understanding of Front Assist and its limitations. However, many consumer complaints alleged that Volkswagen dealerships were unable to reproduce the condition or stated that Volkswagen dealerships informed the consumers that this braking is considered normal Front Assist operation. ODI's analysis shows that MY 2019 Volkswagen Atlas vehicles have the highest rate of unique incident reports alleging AEB inadvertent activation when compared to their Volkswagen peers. To date, ODI has received a total of 44 consumer complaints of inadvertent activation of Front Assist in MY 2019 Volkswagen Atlas vehicles.In total, ODI reviewed 187 unique (i.e., non-duplicative Vehicle Identification Numbers) reports that may relate to the alleged defect, which include four reports on injury incidents and one report involving a crash. PE23017 has been upgraded to an Engineering Analysis to further assess the scope, frequency, and potential safety-related consequences of inadvertent AEB activations in MY 2019 Volkswagen Atlas vehicles. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Forward Collision Avoidance: Automatic Emergency Braking
On September 28, 2023, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE23017) to assess reports of inadvertent activation of the Front Assist automatic emergency braking (AEB) system in model year (MY) 2018-2019 Volkswagen Atlas vehicles. The reports alleged that activation of the AEB system occurred while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Volkswagen indicated that it is aware of a total of 226 reports that may relate to the alleged defect in MY 2019 Volkswagen Atlas vehicles.Volkswagen stated that some customers possibly had an inadequate understanding of Front Assist and its limitations. However, many consumer complaints alleged that Volkswagen dealerships were unable to reproduce the condition or stated that Volkswagen dealerships informed the consumers that this braking is considered normal Front Assist operation. ODI's analysis shows that MY 2019 Volkswagen Atlas vehicles have the highest rate of unique incident reports alleging AEB inadvertent activation when compared to their Volkswagen peers. To date, ODI has received a total of 44 consumer complaints of inadvertent activation of Front Assist in MY 2019 Volkswagen Atlas vehicles.In total, ODI reviewed 187 unique (i.e., non-duplicative Vehicle Identification Numbers) reports that may relate to the alleged defect, which include four reports on injury incidents and one report involving a crash. PE23017 has been upgraded to an Engineering Analysis to further assess the scope, frequency, and potential safety-related consequences of inadvertent AEB activations in MY 2019 Volkswagen Atlas vehicles. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Forward Collision Avoidance
On September 28, 2023, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE23017) to assess reports of inadvertent activation of the Front Assist automatic emergency braking (AEB) system in model year (MY) 2018-2019 Volkswagen Atlas vehicles. The reports alleged that activation of the AEB system occurred while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Volkswagen indicated that it is aware of a total of 226 reports that may relate to the alleged defect in MY 2019 Volkswagen Atlas vehicles.Volkswagen stated that some customers possibly had an inadequate understanding of Front Assist and its limitations. However, many consumer complaints alleged that Volkswagen dealerships were unable to reproduce the condition or stated that Volkswagen dealerships informed the consumers that this braking is considered normal Front Assist operation. ODI's analysis shows that MY 2019 Volkswagen Atlas vehicles have the highest rate of unique incident reports alleging AEB inadvertent activation when compared to their Volkswagen peers. To date, ODI has received a total of 44 consumer complaints of inadvertent activation of Front Assist in MY 2019 Volkswagen Atlas vehicles.In total, ODI reviewed 187 unique (i.e., non-duplicative Vehicle Identification Numbers) reports that may relate to the alleged defect, which include four reports on injury incidents and one report involving a crash. PE23017 has been upgraded to an Engineering Analysis to further assess the scope, frequency, and potential safety-related consequences of inadvertent AEB activations in MY 2019 Volkswagen Atlas vehicles. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE23017 · Inadvertent Automatic Emergency Braking
Opened Sep 28, 2023 · Closed Dec 18, 2024
Status: closed (inferred from source dates) · Forward Collision Avoidance; Forward Collision Avoidance: Automatic Emergency Braking
On September 28, 2023, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE23017) to assess reports of inadvertent activation of the Front Assist automatic emergency braking (AEB) system in model year (MY) 2018-2019 Volkswagen Atlas vehicles.The reports alleged that activation of the AEB system occurred while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Volkswagen indicated that it is aware of a total of 292 reports that may relate to the alleged defect in MY 2018-2019 Volkswagen Atlas vehicles.Volkswagen stated that some customers possibly had an inadequate understanding of Front Assist and its limitations. However, many consumer complaints alleged that Volkswagen dealerships were unable to reproduce the condition or Volkswagen dealerships informed the consumers that this braking is considered normal Front Assist operation. ODI's analysis shows that MY 2019 Volkswagen Atlas vehicles have the highest rate of unique incident reports alleging AEB inadvertent activation when compared to their Volkswagen peers.The rate of unique incident reports alleging AEB inadvertent activation in MY 2018 Volkswagen Atlas vehicles was comparable to their Volkswagen peers. To date, ODI has received a total of 69 consumer complaints of inadvertent activation of Front Assist in MY 2018-2019 Volkswagen Atlas vehicles. In total, ODI reviewed 264 unique (i.e., non-duplicative Vehicle Identification Numbers) reports that may relate to the alleged defect, which include eight reports of incidents involving an alleged injury and two reports involving a crash. PE23017 has been upgraded to an Engineering Analysis (EA24004) to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations in MY 2019 Volkswagen Atlas vehicles. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Forward Collision Avoidance: Automatic Emergency Braking
On September 28, 2023, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE23017) to assess reports of inadvertent activation of the Front Assist automatic emergency braking (AEB) system in model year (MY) 2018-2019 Volkswagen Atlas vehicles.The reports alleged that activation of the AEB system occurred while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Volkswagen indicated that it is aware of a total of 292 reports that may relate to the alleged defect in MY 2018-2019 Volkswagen Atlas vehicles.Volkswagen stated that some customers possibly had an inadequate understanding of Front Assist and its limitations. However, many consumer complaints alleged that Volkswagen dealerships were unable to reproduce the condition or Volkswagen dealerships informed the consumers that this braking is considered normal Front Assist operation. ODI's analysis shows that MY 2019 Volkswagen Atlas vehicles have the highest rate of unique incident reports alleging AEB inadvertent activation when compared to their Volkswagen peers.The rate of unique incident reports alleging AEB inadvertent activation in MY 2018 Volkswagen Atlas vehicles was comparable to their Volkswagen peers. To date, ODI has received a total of 69 consumer complaints of inadvertent activation of Front Assist in MY 2018-2019 Volkswagen Atlas vehicles. In total, ODI reviewed 264 unique (i.e., non-duplicative Vehicle Identification Numbers) reports that may relate to the alleged defect, which include eight reports of incidents involving an alleged injury and two reports involving a crash. PE23017 has been upgraded to an Engineering Analysis (EA24004) to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations in MY 2019 Volkswagen Atlas vehicles. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Forward Collision Avoidance
On September 28, 2023, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE23017) to assess reports of inadvertent activation of the Front Assist automatic emergency braking (AEB) system in model year (MY) 2018-2019 Volkswagen Atlas vehicles.The reports alleged that activation of the AEB system occurred while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Volkswagen indicated that it is aware of a total of 292 reports that may relate to the alleged defect in MY 2018-2019 Volkswagen Atlas vehicles.Volkswagen stated that some customers possibly had an inadequate understanding of Front Assist and its limitations. However, many consumer complaints alleged that Volkswagen dealerships were unable to reproduce the condition or Volkswagen dealerships informed the consumers that this braking is considered normal Front Assist operation. ODI's analysis shows that MY 2019 Volkswagen Atlas vehicles have the highest rate of unique incident reports alleging AEB inadvertent activation when compared to their Volkswagen peers.The rate of unique incident reports alleging AEB inadvertent activation in MY 2018 Volkswagen Atlas vehicles was comparable to their Volkswagen peers. To date, ODI has received a total of 69 consumer complaints of inadvertent activation of Front Assist in MY 2018-2019 Volkswagen Atlas vehicles. In total, ODI reviewed 264 unique (i.e., non-duplicative Vehicle Identification Numbers) reports that may relate to the alleged defect, which include eight reports of incidents involving an alleged injury and two reports involving a crash. PE23017 has been upgraded to an Engineering Analysis (EA24004) to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations in MY 2019 Volkswagen Atlas vehicles. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
PE21008 · Fuel Injector Leak
Opened Mar 29, 2021 · Closed Oct 3, 2022
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:fuel Injection System:injectors
On March 29, 2021, the Office of Defects Investigations (ODI) opened PE21-008 to investigate instances of fuel injectors leaking in the engine compartment in model year (MY) 2018 through 2020 Volkswagen Atlas and Atlas Cross Sport SUVs. These vehicles are equipped with either a 3.6 or 2.0 liter engine. The subject investigation concerns vehicles equipped with 3.6L engines. Prior to opening the investigation, ODI also observed that warranty data for the fuel system from TREAD reporting was an outlier for the MY 2018 Atlas.The allegation involved fuel injectors leaking fuel near engine compartment components that operate at high temperatures. Consumers allege a fuel leak, fuel odor, and/or an illuminated check engine malfunction indicator light (MIL) on that alerts them to the condition. Fuel leaking in the engine compartment has a higher potential risk of fire as nearby components are operating at higher temperatures compared to other areas of the vehicle. No fires have been connected to this issue to date.The 3.6L engine is a VR6 type engine. Due to its specific design, the VR6 has two types of injectors with different designs installed. Cylinders 1, 3, and 5 use long injectors and cylinders 2, 4, and 6 use short injectors. Unlike the short injectors, the long injectors require an extension pipe necessary to reach cylinders 1, 3, and 5. Volkswagen stated that the potential root cause for a leaking injector is typically either a damaged, misaligned, or missing supporting ring or a damaged O-ring. These rings assist in connecting the injector to the extension pipe. If one of these conditions is present in a vehicle, the O-ring has difficulty withstanding fuel pressure over time.Volkswagen stated that an analysis of warranty data related to leaking injectors in vehicles equipped with 3.6L engines showed that the vast majority of leaking allegations were related to internal leaks. Fuel can leak into the cylinder causing misfiring in the affected cylinders. This condition would not cause fuel to enter into the engine compartment. Volkswagen states that these internal leaks pose no unreasonable risk to motor vehicle safety.Analysis of all relevant data indicates that the subject condition is an early-life failure with a relatively low failure rate. The average failure mileage calculated from all data sources was determined to be approximately 14,000 miles. Only two failures were reported outside of the vehicles' warranty coverage period. The average time to failure for the subject vehicle population is approximately 12 months in service (MIS). The majority of failures were below the average of 14,000 miles or 12 MIS. Analysis of reported failures showed that the failure rate is approximately 0.08% or 0.8 incidents per thousand vehicles (IPTV).To date, there have been no reported fires, crashes, injuries, or fatalities related to this issue. In view of the low rate of failure, the nature of early-life failure, and low potential hazard to drivers, this Preliminary Evaluation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers:11446833, 11438403, 11382958, 11298402, 11291955, 11218819, 11218780
Additional source detail variants (2)
Fuel System, Gasoline:fuel Injection System:injectors
On March 29, 2021, the Office of Defects Investigations (ODI) opened PE21-008 to investigate instances of fuel injectors leaking in the engine compartment in model year (MY) 2018 through 2020 Volkswagen Atlas and Atlas Cross Sport SUVs. These vehicles are equipped with either a 3.6 or 2.0 liter engine. The subject investigation concerns vehicles equipped with 3.6L engines. Prior to opening the investigation, ODI also observed that warranty data for the fuel system from TREAD reporting was an outlier for the MY 2018 Atlas.The allegation involved fuel injectors leaking fuel near engine compartment components that operate at high temperatures. Consumers allege a fuel leak, fuel odor, and/or an illuminated check engine malfunction indicator light (MIL) on that alerts them to the condition. Fuel leaking in the engine compartment has a higher potential risk of fire as nearby components are operating at higher temperatures compared to other areas of the vehicle. No fires have been connected to this issue to date.The 3.6L engine is a VR6 type engine. Due to its specific design, the VR6 has two types of injectors with different designs installed. Cylinders 1, 3, and 5 use long injectors and cylinders 2, 4, and 6 use short injectors. Unlike the short injectors, the long injectors require an extension pipe necessary to reach cylinders 1, 3, and 5. Volkswagen stated that the potential root cause for a leaking injector is typically either a damaged, misaligned, or missing supporting ring or a damaged O-ring. These rings assist in connecting the injector to the extension pipe. If one of these conditions is present in a vehicle, the O-ring has difficulty withstanding fuel pressure over time.Volkswagen stated that an analysis of warranty data related to leaking injectors in vehicles equipped with 3.6L engines showed that the vast majority of leaking allegations were related to internal leaks. Fuel can leak into the cylinder causing misfiring in the affected cylinders. This condition would not cause fuel to enter into the engine compartment. Volkswagen states that these internal leaks pose no unreasonable risk to motor vehicle safety.Analysis of all relevant data indicates that the subject condition is an early-life failure with a relatively low failure rate. The average failure mileage calculated from all data sources was determined to be approximately 14,000 miles. Only two failures were reported outside of the vehicles' warranty coverage period. The average time to failure for the subject vehicle population is approximately 12 months in service (MIS). The majority of failures were below the average of 14,000 miles or 12 MIS. Analysis of reported failures showed that the failure rate is approximately 0.08% or 0.8 incidents per thousand vehicles (IPTV).To date, there have been no reported fires, crashes, injuries, or fatalities related to this issue. In view of the low rate of failure, the nature of early-life failure, and low potential hazard to drivers, this Preliminary Evaluation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers:11446833, 11438403, 11382958, 11298402, 11291955, 11218819, 11218780
Fuel System, Gasoline
On March 29, 2021, the Office of Defects Investigations (ODI) opened PE21-008 to investigate instances of fuel injectors leaking in the engine compartment in model year (MY) 2018 through 2020 Volkswagen Atlas and Atlas Cross Sport SUVs. These vehicles are equipped with either a 3.6 or 2.0 liter engine. The subject investigation concerns vehicles equipped with 3.6L engines. Prior to opening the investigation, ODI also observed that warranty data for the fuel system from TREAD reporting was an outlier for the MY 2018 Atlas.The allegation involved fuel injectors leaking fuel near engine compartment components that operate at high temperatures. Consumers allege a fuel leak, fuel odor, and/or an illuminated check engine malfunction indicator light (MIL) on that alerts them to the condition. Fuel leaking in the engine compartment has a higher potential risk of fire as nearby components are operating at higher temperatures compared to other areas of the vehicle. No fires have been connected to this issue to date.The 3.6L engine is a VR6 type engine. Due to its specific design, the VR6 has two types of injectors with different designs installed. Cylinders 1, 3, and 5 use long injectors and cylinders 2, 4, and 6 use short injectors. Unlike the short injectors, the long injectors require an extension pipe necessary to reach cylinders 1, 3, and 5. Volkswagen stated that the potential root cause for a leaking injector is typically either a damaged, misaligned, or missing supporting ring or a damaged O-ring. These rings assist in connecting the injector to the extension pipe. If one of these conditions is present in a vehicle, the O-ring has difficulty withstanding fuel pressure over time.Volkswagen stated that an analysis of warranty data related to leaking injectors in vehicles equipped with 3.6L engines showed that the vast majority of leaking allegations were related to internal leaks. Fuel can leak into the cylinder causing misfiring in the affected cylinders. This condition would not cause fuel to enter into the engine compartment. Volkswagen states that these internal leaks pose no unreasonable risk to motor vehicle safety.Analysis of all relevant data indicates that the subject condition is an early-life failure with a relatively low failure rate. The average failure mileage calculated from all data sources was determined to be approximately 14,000 miles. Only two failures were reported outside of the vehicles' warranty coverage period. The average time to failure for the subject vehicle population is approximately 12 months in service (MIS). The majority of failures were below the average of 14,000 miles or 12 MIS. Analysis of reported failures showed that the failure rate is approximately 0.08% or 0.8 incidents per thousand vehicles (IPTV).To date, there have been no reported fires, crashes, injuries, or fatalities related to this issue. In view of the low rate of failure, the nature of early-life failure, and low potential hazard to drivers, this Preliminary Evaluation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers:11446833, 11438403, 11382958, 11298402, 11291955, 11218819, 11218780
Illustration