Mechanic stated that the secondary air injection system is a common problem in this generation of Tundra.. I have had my check engine light come on 3 different times and addressed each by replacing all the sensors to the secondary air injection system. My mechanic is a Toyota dealer mechanic. My issue is that my car has lost pow…
Read full complaint
Mechanic stated that the secondary air injection system is a common problem in this generation of Tundra.. I have had my check engine light come on 3 different times and addressed each by replacing all the sensors to the secondary air injection system. My mechanic is a Toyota dealer mechanic. My issue is that my car has lost power to accelerate at highway speeds and came close to causing and accident. I am now at my third attempt at replacing now the actual pump. I understand that Toyota has replaced the gooseneck part where the hose is attaches to the pump. This tells me that there was a problem or else why would they change a good thing? Is there a warranty for this part?
NHTSA ODI #11580149
Mileage unknown · Nov 12, 2022
Engine
Cam tower leaks oil on the heat shield below it. Cam tower uses rtv rubber seal instead of a gasket. The rubber deteriorates and the cam tower leaks engine oil on the heat shield. Not clear why Toyota used form in place rubber material instead of real gasket. Repair however is major. Need to take apart engine to repair. …
Read full complaint
Cam tower leaks oil on the heat shield below it. Cam tower uses rtv rubber seal instead of a gasket. The rubber deteriorates and the cam tower leaks engine oil on the heat shield. Not clear why Toyota used form in place rubber material instead of real gasket. Repair however is major. Need to take apart engine to repair. Major repair. The fix is to replace it with the same material again. Which is subject to deteriorate again. This is a know issue on the 5.7 L engine. Toyota seems to have its head in the sand hoping they shouldn’t be forced to recall. However this is a know design flaw resulting in leaking oil on the heat shield. With no Toyota recommended new design or parts repair except to do it all over again and hope it doesn’t leak again it’s ridiculous. . Terrible design that leaks oil on the heat shield.
NHTSA ODI #11493283
122,000 miles · Jul 21, 2022
Engine
The contact owns a 2013 Toyota Tundra. The contact stated while driving approximately 70 MPH, the vehicle and steering wheel started shaking. The contact pulled over safely and inspected the vehicle and noticed there was power steering fluid leaking from the vehicle. The vehicle was taken to an independent mechanic who diagnosed…
Read full complaint
The contact owns a 2013 Toyota Tundra. The contact stated while driving approximately 70 MPH, the vehicle and steering wheel started shaking. The contact pulled over safely and inspected the vehicle and noticed there was power steering fluid leaking from the vehicle. The vehicle was taken to an independent mechanic who diagnosed the failure as an engine leak. There was initially no warning light illuminated; however, after arriving home, the check engine warning light illuminated. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 122,000.
NHTSA ODI #11475070
58,000 miles · Sep 30, 2020
Electrical SystemEngineFuel/propulsion System
ON TWO DIFFERENT OCCASIONS I WAS DRIVING MY TUNDRA ON THE FREEWAY AT APPROX. 70 MPH. MY TRUCK LOST POWER AND I ALMOST CAUSED ACCIDENTS ON BOTH INSTANCES SINCE I COULD NOT ACCELERATE PAST 40 MPH. I HAD TO MANAGE MY WAY OUT OF THE FREEWAY TO A SAFE PLACE. 2TWO DIAGNOSTICS WERE PERFORMED AND I RECEIVED CODES P0418, P1604, C1241, P2…
Read full complaint
ON TWO DIFFERENT OCCASIONS I WAS DRIVING MY TUNDRA ON THE FREEWAY AT APPROX. 70 MPH. MY TRUCK LOST POWER AND I ALMOST CAUSED ACCIDENTS ON BOTH INSTANCES SINCE I COULD NOT ACCELERATE PAST 40 MPH. I HAD TO MANAGE MY WAY OUT OF THE FREEWAY TO A SAFE PLACE. 2TWO DIAGNOSTICS WERE PERFORMED AND I RECEIVED CODES P0418, P1604, C1241, P2445, P2441. I WAS TOLD BY THE TOYOTA DEALERSHIP THAT THERE WAS A PROBLEM WITH A FAULTY SECONDARY AIR INJECTION SYSTEM PUMP AND OTHER COMPONENTS RELATED TO THE SYSTEM AND I WAS PROVIDED A REPAIR COST OF OVER $3,000 DOLLARS. I WAS LATER INFORMED, AND I DISCOVERED THROUGH RESEARCH, THAT TOYOTA HAD INSTALLED FAULTY/DEFECTIVE AIR PUMPS IN THOUSANDS OF TUNDRAS 2013'S LIKE THE ONE THAT I OWN. I REACHED OUT TO CORPORATE OFFICE BUT THEY STATED THAT MY VIN NUMBER SOMEHOW DID NOT "QUALIFY" AS ONE OF THE AFFECTED PICKUPS. MY TUNDRA ONLY HAS 60K MILES AND I USE IT TO COMMUTE FROM AND TO WORK BASICALLY. I PERFORM ROUTINE MAINTENANCE. THERE IS OBVIOUSLY A PROBLEM WITH A DEFECTIVE SECONDARY AIR PUMP SYSTEM THAT TOYOTA REFUSES TO FIX. MY TRUCK IS A LIABILITY ON THE ROAD AND THIS IS MY ONLY MEANS OF TRANSPORTATION. IT LOOSES POWER AND THE CHECK ENGINE LIGHT ACTIVATES. TOYOTA RECALLED THOUSANDS OF VEHICLES LIKE MINE AND FIXED THEM AFTER THEY ACKNOWLEDGED THAT THEY HAD PLACED FAULTY AIR PUMP SYSTEMS. MY TRUCK IS A POTENTIAL POSSIBLE CAUSE FOR AN ACCIDENT SINCE IT UNPREDICTABLY LOOSES POWER ON THE FREEWAY. I HAVE NOT RECEIVED A SOLUTION FROM HEADQUARTERS/CORPORATE OFFICE TO REPAIR MY TRUCK AT NO PRICE SINCE IT IS AFFECTED BY THEIR FAULTY PUMPS. THEY DID OFFER $750 DOLLARS TOWARDS THE COST OF PARTS, MEANING THAT I HAVE TO COME OUT WITH OVER $2000K OUT OF POCKET. I NEED TOYOTA TO TAKE RESPONSIBILITY AND FIX MY TRUCK.
NHTSA ODI #11362059
116,000 miles · Sep 25, 2020
Engine
#4 INTAKE VALVE SPRING BROKE AND CAUSE ENGINE FAILURE
NHTSA ODI #11361152
74,734 miles · Jun 18, 2020
EngineFuel/propulsion SystemUnknown Or Other
MY 2013 TOYOTA TUNDRA TRUCK ( 74,734 MILES) SUDDENLY HAD ENGINE FAILURE WHILE DRIVING DOWN AN INCLINE AT 48 MPH. I LOST POWER STEERING AND POWER BRAKES. AFTER EVENTUALLY PULLING THE WHEEL WITH MUCH EFFORT AND USING THE EMERGENCY BRAKE I WAS ABLE TO GET THE TRUCK OFF TO THE SIDE OF THE ROAD. I TURNED THE KEY AND THE ENGINE START…
Read full complaint
MY 2013 TOYOTA TUNDRA TRUCK ( 74,734 MILES) SUDDENLY HAD ENGINE FAILURE WHILE DRIVING DOWN AN INCLINE AT 48 MPH. I LOST POWER STEERING AND POWER BRAKES. AFTER EVENTUALLY PULLING THE WHEEL WITH MUCH EFFORT AND USING THE EMERGENCY BRAKE I WAS ABLE TO GET THE TRUCK OFF TO THE SIDE OF THE ROAD. I TURNED THE KEY AND THE ENGINE STARTED RIGHT AWAY AND I WAS ABLE TO DRIVE AGAIN BUT ONLY AT A REDUCED SPEED OF 40 MPH OR LESS ( IT'S CALLED "LIMP" MODE) MY MECHANIC DIAGNOSED IT AS A SECONDARY AIR INJECTION PUMP FAILURE. UPON INVESTIGATING THIS ON SEVERAL TUNDRA OWNER MESSAGE BOARDS, I FIND THAT THIS IS A COMMON FAILURE TUNDRA TRUCKS AT AROUND 75000 MILES. THE TOYOTA DEALER CONFIRMED THAT THIS HAS BEEN A COMMON PROBLEM AND LOOKED UP MY VIN NUMBER TO SEE IF IT QUALIFIED FOR A WARRANTY EXTENSION PROGRAM THAT TOYOTA HAS OFFERED FOR SOME 2012 AND 2013 TUNDRA TRUCKS. UNFORTUNATELY MY VIN NUMBER WAS A FEW NUMBERS BEYOND THE EXTENSION PROGRAM. HAD MY WIFE BEEN DRIVING THE TRUCK WHEN THIS HAPPENED, I AM NOT SO SURE SHE WOULD HAVE HAD THE STRENGTH TO SAFELY BRING THE TRUCK UNDER CONTROL AND GET IT OFF THE ROAD WITH NO POWER STEERING OR POWER BRAKES. I WANT TOYOTA TO EXTEND THE WARRANTY ON THIS FAULTY PART BEFORE SOMEONE GETS INTO A SERIOUS ACCIDENT. THEY HAVE OBVIOUSLY ADMITTED THERE IS A PROBLEM WITH THIS PART AND SHOULD EXTEND IT TO ALL TOYOTA TRUCK OWNERS WITH THIS PARTICULAR PROBLEM. NOT JUST A SELECT FEW. *TR
NHTSA ODI #11329510
60,000 miles · Feb 24, 2020
Engine
THE TRUCK AT ONLY 60,000 MILES HAS A FAULTY CAM TOWER SEAL LEAK THAT CAUSES OIL TO DRIP ONTO THE EXHAUST WITH POTENTIAL TO CAUSE AN ENGINE FIRE.
NHTSA ODI #11311120
120,000 miles · May 8, 2019
Engine
DRIVING ON INTERSTATE THE TRUCK ALL OF SUDDEN LOOSES POWER AND. DASH WARNING LIGHTS COME ON AND I HAVE EXTREMELY HARD TIME GETTING TRUCK TO SIDE OF ROAD SAFETY WITHOUT POWER. TOOK TO SHOP SAID I HAD AIR INJECTION PUMP WATER INTRUSION AND IT WAS COMMON ISSUES WITH MOST OF TUNDRA THEY HAVE RECALLED EARLY YEARS BEFORE MINE AND IT'…
Read full complaint
DRIVING ON INTERSTATE THE TRUCK ALL OF SUDDEN LOOSES POWER AND. DASH WARNING LIGHTS COME ON AND I HAVE EXTREMELY HARD TIME GETTING TRUCK TO SIDE OF ROAD SAFETY WITHOUT POWER. TOOK TO SHOP SAID I HAD AIR INJECTION PUMP WATER INTRUSION AND IT WAS COMMON ISSUES WITH MOST OF TUNDRA THEY HAVE RECALLED EARLY YEARS BEFORE MINE AND IT'S A $4000 BILL MY TRUCK HAS 120000 MILES ON IT. PLEASE HELP
NHTSA ODI #11206369
64,000 miles · Apr 27, 2019
Engine
AT ONLY 64000 MILES MY 2013 PLATINUM TUNDRA HAS A CAM TOWER LEAK. THIS IS A FIRE HAZARD AND NEEDS TO BE ADDRESSED ASAP.
NHTSA ODI #11204080
Mileage unknown · Apr 12, 2019
Engine
CAM TOWER OIL LEAKS ON BOTH DRIVER AND PASSENGER SIDE - OIL LEAKING ONTO TO MANIFOLD CAUSING SMOKE - POSSIBLE FIRE RISK - NUMEROUS COMPLAINTS WENT UNANSWERED, FINALLY DIAGNOSED BY THE DEALER, HOWEVER TOYOTA NOT WILLING TO FIX AS VEHICLE IS OUTSIDE OF MANUFACTURER'S WARRANTY - THIS IS A KNOWN ISSUE!!
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2008-2022 Sequoia and 2007-2021 Tundra vehicles. The power steering gear assembly may have been manufactured incorrectly, which can result in an oil leak.
Consequence & remedy
Consequence: An oil leak may cause a sudden loss of power steering assist, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the power steering gear assembly as necessary, free of charge. Owner notification letters were mailed on January 21, 2022. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are 21TB10 and 21TA10.
Additional source detail variants (2)
Steering:hydraulic Power Assist System
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2008-2022 Sequoia and 2007-2021 Tundra vehicles. The power steering gear assembly may have been manufactured incorrectly, which can result in an oil leak.
Consequence: An oil leak may cause a sudden loss of power steering assist, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the power steering gear assembly as necessary, free of charge. Owner notification letters were mailed on January 21, 2022. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are 21TB10 and 21TA10.
Steering:rack And Pinion
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2008-2022 Sequoia and 2007-2021 Tundra vehicles. The power steering gear assembly may have been manufactured incorrectly, which can result in an oil leak.
Consequence: An oil leak may cause a sudden loss of power steering assist, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the power steering gear assembly as necessary, free of charge. Owner notification letters were mailed on January 21, 2022. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are 21TB10 and 21TA10.
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2013-2017 Toyota Tundra and Sequoia vehicles accessorized with Southeast Toyota accessory 20-inch Rockstar wheels installed by Southeast Toyota or a Southeast Toyota dealer. The Rockstar wheels were installed with lugnuts that may crack and detach.
Consequence & remedy
Consequence: Lugnuts that crack and detach may cause the wheels to separate from the vehicle, increasing the risk of a crash.
Remedy: SET will notify owners, and dealers will install new replacement lugnuts, free of charge. The recall began June 23, 2017. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET17A.
Gulf States Toyota, Inc. (GST) is recalling certain model year 2013-2014 Toyota Tundra vehicles modified by GST as part of certain vehicle packages to be equipped with a combination of non-Toyota-brand 20-inch alloy wheels and chrome plated lug nuts. The coating on the lug nuts may give, causing the lug nuts to loosen or the wheel studs to fracture.
Consequence & remedy
Consequence: If the lug nuts loosen, or the wheel studs fracture, the wheel may separate from the vehicle, increasing the risk of a crash.
Remedy: GST will notify owners, and dealers will replace 20 lug nuts and torque them to specification, free of charge. The recall began in August 2014. Owners may contact GST customer service at 1-800-444-1074.
Southeast Toyota is recalling certain model year 2008 and 2010-2013 Toyota Tundra, 2010-2012 Rav4, 2012 Toyota Sequoia, 2010-2011 Toyota Corolla, 2010-2011 Toyota Camry and Camry Hybrid, 2010-2013 Toyota Highlander and Highlander Hybrid, 2010-2013 Toyota FJ Cruiser, 2011 Toyota Land Cruiser, 2010-2013 Toyota Venza, 2010-2011 Toyota 4Runner, 2010-2013 Toyota Tacoma, 2011-2012 Toyota Sienna, 2012 Toyota Prius, 2013 Scion FR-S, 2011 Scion XD, 2011 Scion XB, and 2012 Scion TC vehicles. These vehicles were sold with labels that were outside the allowable one percent of accuracy of actual weight added. Thus, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) Number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: An inaccurate label could lead to owners overloading their vehicles and tires. An overloaded vehicle can result in a tire failure which may result in a vehicle crash, personal injury, or property damage.
Remedy: Southeast Toyota will notify owners and provide a corrected label with instructions concerning its installation. A small group of the affected vehicles will need additonal remedies which are still being developed. The recall began on May 28, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence & remedy
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Additional source detail variants (2)
Seats
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
EA19001 · Electrical Overstress
Opened Apr 19, 2019 · Closed Sep 19, 2024
Status: closed (inferred from source dates) · Air Bags: Air Bag/restraint Control Module
The Office of Defects Investigation (ODI) opened this investigation to determine if the failure of airbags to deploy during severe crashes, in certain vehicles, was the result of a safety related defect. During the investigation a complex failure was studied that can result in non-deployment of subject vehicle air bags and other restraint system devices in severe crash events. The subject vehicles may be equipped with an airbag control unit (ACU) for the supplemental restraint system (SRS) Electronic Control Unit (ECU) manufactured by ZF-TRW. The ECU receives signals from crash sensors mounted in the vehicle and deploys the vehicle air bags and seat belt pretensioners in accordance with manufacturer design specifications. The ECU in the subject vehicles contains a model DS84 application-specific integrated circuit (ASIC) which controls the communication of the crash sensor signal, firing commands (i.e., when to deploy the airbag(s) and/or pretensioners), and fault information (e.g., diagnostic trouble codes). In September 2016, FCA announced recall 16V-668 for certain model year (MY) 2010 to 2014 Chrysler, Dodge and Jeep products manufactured with the subject ZF-TRW ACU. In this recall, FCA discussed an EOS condition that resulted in a failure of the subject DS84 ASIC, which caused air bag non-deployment. FCA noted that the defect condition had only been observed in vehicles equipped with sensor harnessing routed across the front of the vehicle. Other FCA vehicles that also used the subject ACU, but were not equipped with cross-car harnessing, had not experienced EOS failures, despite similar time in service. During the course of this investigation, ODI sent two separate Information Request (IR) letters to six vehicle manufactures (including FCA, Hyundai, Honda, Kia, Mitsubishi, and Toyota) and one IR letter to ZF-TRW. These IR letters resulted in ODI receiving comprehensive data from these manufacturers and suppliers. Studies of this data found that the DS84 ASIC does not have sufficient protection against negative electrical transients or electrical overstress (“EOS”) that can be generated in certain severe crashes. An electrical transient occurs when the electrical power supplied to a circuit changes momentarily over a short duration of time. In these severe crash cases, the crash sensors and other powered wiring can be damaged and short circuited so as to create a negative electrical transient of sufficient intensity and duration (that are outside the vehicle manufacturer's specification) to damage the ASIC before the restraint device deployment signal is received by the SRS ECU. This damaged signal can lead to incomplete or nondeployment of the air bags and/or pretensioners. Airbag non-deployment and/or lack of pretensioner operation can increase the risk or severity of injury in a crash.A total of 8 fatalities and 14 injuries were associated with known EOS events. The common element in all investigated manufacturers vehicles is the SRS ECU containing a DS84 ASIC manufactured by ZF-TRW. The risk associated with the ASIC is equally shared among all OEMS involved in the investigation. The actual real-world risk can be mitigated by other factors which were assessed by ODI during this investigation. The first mitigating factor involves protections built into the ACU design which protect the DS84 ASIC from damage. There are multiple strategies and levels of protection employed by different OEMs that provide effective EOS mitigation. The two most common strategies at the ACU level are circuit protection diodes on the remote senor signal lines, and current limiting resistors that protect critical components. The second mitigating factor is found at the vehicle level and involves the location and routing of the wires leading from the crash sensors to the SRS ECU. If the wires are well protected in a crash and are not routed with other power wires carrying large currents, the risk for an EOS event is significantly reduced or eliminated. These design specific factors combine to produce a spectrum of risk for the vehicles equipped with ACUs using the DS84 ASIC. Given the many of years of field exposure, it is possible to divide the subject population into two groups; vehicles which have experienced EOS events, and vehicles which have not experienced EOS field events. Four of the six OEMs involved in this investigation have experienced EOS field events on at least one of their models equipped with a DS84 ASIC. All vehicle models (including the Toyota models identified in the Failure Report Summary of the opening resume for this investigation) with field events have been recalled. In an abundance of caution, ODI kept this investigation open five years to monitor field performance and did not identify any field events on vehicles not included in existing safety recalls. Given the spectrum of risk identified in this investigation and that all vehicles with a demonstrated unreasonable risk have been recalled, ODI is closing this investigation. ODI is closing this investigation with the following manufacturer safety recalls: 16V-668, 18E-043, 18V-137, 18V-363, and 20V-024. With the recall actions taken by the subject vehicle and equipment manufacturers, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exists on other model or model year vehicles outside of the recall scopes. The agency reserves the right to take further action if warranted by the circumstances.
2013 Toyota Tundra Problems, Complaints & Recalls | Skip That Year
Illustration