2025 Toyota Tacoma

The driver side inner door handle does not work. This is a huge safety issue because you can only open the door by rolling down the window and pulling the outer driver side door handle. I took the truck to the dealer and the part to fix it is on back order with no known date when they will get it. I am now forced to drive an un safe vehicle for who knows how long. This is a common issue with the 2024-2025 Tacomas and needs addressed.

The interior driver-side door handle/release mechanism on my 2025 SR5 Toyota Tacoma failed without warning. The vehicle has low mileage and was being used normally. When attempting to open the driver door from the inside using ordinary force, an internal component appears to have detached or broken, leaving the interior handle completely inoperative. The handle simply hangs loose. Vehicle and failed component are available for inspection. This defect creates a significant safety risk because I cannot exit the vehicle through the driver door from inside the cabin. The only way to exit is to roll down the window, reach backward, and pull the exterior door handle. This requires an awkward twisting motion and causes shoulder pain. In an emergency such as a crash, fire, or water intrusion event, my ability to quickly exit the vehicle could be compromised. The defect also affects my ability to care for my young son, who has a medical condition and may require immediate assistance or rescue medication. If an emergency occurred while driving, I could be delayed in reaching him because I cannot promptly exit through the driver door as designed. A Toyota dealership inspected the vehicle and confirmed the failed interior door handle mechanism. However, the replacement part is on national backorder and unavailable. I was informed repairs will likely take more than a month and that the waiting list reportedly exceeds 2,000 vehicles. Numerous Tacoma owners have reported the same failure, suggesting a widespread defect. Despite reports of widespread failures and lengthy repair delays, there has been no recall, service campaign, or proactive communication from Toyota warning owners of the defect or providing guidance while awaiting repairs. There were no warning lights, messages, or advance symptoms before the failure. The handle functioned normally until it suddenly stopped working during routine use. The defect occurred without misuse, excessive force, collision, or damage.

Both the front passenger and front driver's side doors will not open from the inside. First, the passenger side door handle became defective (I took it to the Toyota dealer and they said the interior handle assembly broke where the cable connects to the handle). The part is back ordered in the thousands. Then about a month later, the same thing happened to the driver's side door. That part is also back ordered in the thousands. Now, I am unable to open either front door from the inside - an obvious safety concern - being trapped in the car in the event of an accident. And this truck is a 2025 year with 8,800 miles on it. Toyota has provided no ETA for the new parts. A basic search online for the same issue has returned hundreds of similar stories for the same model truck. I have spoken to Toyota Corporate and they have not provided me with any sort of fix or ETA, other than to get in line and wait for the back ordered parts

My father and I both purchased a 2025 Toyota Tacoma SR5 2WD double cab last year brand new from different dealerships, both were in FL. My father was driving his new Tacoma with adaptive cruise control engaged, this was on an interstate, and the vehicle in front of him moved to the left lane next to him and started braking and this caused his vehicle to start braking extremely hard with no vehicles in front of him (he was driving about 55mph when this happened). He said this has happened to him before. I was in the vehicle with him when this happened. When I was driving from his home in GA a few days later, back to my home in FL, I was on the interstate ([XXX]) with the adaptive cruise control engaged and the exact same thing happened with my truck. A semi truck in front of me moved into the lane to the right and started braking. This caused my vehicle to start braking extremely hard with no vehicles in front of me. Had a vehicle been behind me, this could have caused me to be rear-ended going about 70mph. The sudden automatic braking with NO vehicles in front of you is aggressive enough to cause a rear-end collision and possibly cause the driver to make a startled, impulsive, corrective mistake to the sudden aggressive braking. Problem has not been confirmed or reproduced. Neither my father's or my vehicle has been inspected for this issue. Im betting its a software issue. No warning lights or messages before the aggressive braking in either mine or my fathers vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I went to open my drivers side door to get out, and the handle just flopped around and didnt open the door. Driver side door opener handle doesn't work. Have to roll down driver side window with truck engine on and lift outside door handle to open driver door. In case of emergency, and no power in truck, I would not be able to get out of my drivers side door.

The contact owns a 2025 Toyota Tacoma. The contact stated that while driving at approximately 10 MPH, the rear driver's and passenger’s side rotors and brake pads suddenly detached. No warning lights were illuminated. Upon further inspection, the contact became aware of metal debris on the ground by the rear wheels. The vehicle was scheduled to be towed to a local dealer for further investigation. The vehicle was not diagnosed or repaired. In addition, the contact related the failure to NHTSA Campaign: 25V058000 (Service Brakes, Hydraulic); however, the VIN was not included. The manufacturer was not made aware of the failure. The failure mileage was approximately 18,000.

Front passenger door handle broke under normal use exiting truck resulting in inability to open door from inside, entrapping occupant. Warranty claim filed with Toyota dealership. Dealer service advisor stated this is a common failure on Gen 4.Tacomas, and Tundras. Part is on backorder. Service advisor stated backlog is large and no time estimate can be given when the repair can be made. This can result in entrapment in an accident if side windows lose power to roll down if capable of opening door from, or crawl in rear and exit through rear doors if child locks are not engaged. Recall is warranted.

The contact stated that while driving in the rain, when passing another vehicle, the vehicle began shuddering and experienced a loss of power. The check engine light illuminated and multiple other warning indicators. The vehicle pulled over to the vehicle was stopped and eventually restarted. The vehicle was taken to a dealer were it was diagnosed with an air intake failure. Shortly after, the vehicle experienced the same issue. Again and was returned to a dealer. The dealer diagnosed with a turbo mud and water found inside the air intake, water is covering the filter and there was no additional repairs that could be completed so the vehicle. The manufacturer was not notified of the issue. The approximate failure mileage was 19,600.