2025 Toyota Tacoma

We rented a vehicle consisting of the identified Toyota Tacoma with an installed cab-over camper (Travel Lite 550U-XS, VIN: [XXX]). While driving this rental vehicle on a two-lane highway with our family, including two young children (ages [XXX] and [XXX]), a fire ignited in the vehicle's built-in propane/gas stove system. We were not alerted to the fire by any onboard safety equipment, though the camper was equipped with a smoke alarm. We were alerted only by a passing motorist. The vehicle's smoke alarm did not activate until several minutes after the fire had already been extinguished by us using the vehicle's fire extinguisher, and after the smoke inside the camper had already dissipated. The smoke alarm sustained visible smoke damage and its exterior housing was melted, which we believe indicates the alarm was exposed to significant heat/smoke without triggering, or triggered only very late in that exposure. We believe this represents a serious safety equipment failure: a smoke/fire detection system that did not provide any early warning during an active fire, in a small space. This delay in detection could have resulted in serious injury or death. Additionally, we received no safety briefing regarding the hazards of the propane system at the time of vehicle handover. The vehicle overview video provided to us contained no safety information regarding the gas system, and we later discovered it depicted a different vehicle unit than the one we were actually provided, raising questions about whether this vehicle's specific gas/stove configuration and safety equipment had been properly reviewed or tested prior to rental. We made a best guess at cause in speaking with the responder fire department, but we cannot know for sure. To be clear, there was no issue with the Toyota Tacoma itself. We are submitting this complaint to ensure NHTSA is aware of this potential safety defect in the smoke alarm system and/or propane stove. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(

Front passenger interior door handle is a fragile component. Mine failed with little to no force where the cable disconnects from the handle. It has rendered the ability to exit the vehicle via the handle impossible, and Passenger must roll down window and reach for the exterior handle to exit. I’ve had my vehicle at the dealer, and being sent back with vehicle not fixed due to parts being on backorder. No ETA is able to be provided.

The drivers door handle inside the truck has failed leaving me unable to open the drivers door unless I roll the window down and open the door from the outside. I took the truck to a local dealer and they let me know this is a very common problem on the truck and the parts to fix it are on nationwide back order. Was sent home with the vehicle knowing the door is inoperable unless opened from the outside. This poses a serious safety risk in the event of an accident or emergency where one needs to exit the vehicle quickly.

I am reporting a severe safety hazard on my 2025 Toyota Tacoma caused by incorrect alignment specs and an uncorrected extreme toe setting. On a recent service visit, alignment inspection showed a Total Toe of +1.62 degrees (OEM target is approximately +0.10 degrees). The alignment machine database loaded incorrect tolerance specs (+1.37 to +1.87 degrees displayed as acceptable green range), leading technicians to leave the extreme toe-in completely unadjusted. In less than 2,000 miles of normal driving since a prior inspection, both front tires suffered extreme, rapid toe wear down to the internal cord layer. Operating a vehicle with +1.62 degrees total toe causes severe lateral tire drag and creates an imminent threat of a catastrophic tire blowout at highway speeds, presenting a significant vehicle safety defect.

The contact owns a 2025 Toyota Tacoma. The contact stated that while stationary and attempting to exit the vehicle from the driver's side, the interior driver's side door handle fractured, preventing the opening or locking of the door from the inside. The handle remained physically attached to the door panel but was inoperable. The vehicle was taken to the local dealer to be inspected. While at the dealer, it was discovered that another Tacoma at the dealer had a similar interior door handle failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 4,476.

Driver side front and passenger door handle broke internally. The door is unable to be opened from the inside. This puts occupants at risk of not being able to exit the veichle in an emergency or safely from the inside. The problem was fixed for the front after several weeks due to back order of the part. Per my service representative at Toyota, it was a safety concern so they paid for a rental while they waited for the part and repaired the veichle. The mechanism broke without warning and suddenly after normal expected use.

2025 Toyota Tacoma SR5 - 8038 Miles The passenger on the right rear side tried to exit the 2025 SR5 Toyota Tacoma, and the interior door handle would not engage. It was confirmed with the Toyota dealership: PERFORMED INSPECTION AND VERIFIED R/R INNER DOOR HANDLE IS INOPERATIVE. FOUND THE INTERNAL RETURN SPRINGS DISENGAGED FROM THEIR RETENTION POINTS AND HAVE LOST PROPER TENSION DUE TO INSUFFICIENT SPRING RETENTION/IMPROPER FACTORY FITMENT. CONDITION IS CONSISTENT WITH COMPONENT MATERIAL FATIGUE AND RETAINER DESIGN FAILURE, RESULTING IN LOSS OF HANDLE RETURN FUNCTION AND LATCH ACTUATION. RECOMMEND REPLACEMENT OF R/R INNER DOOR HANDLE ASSEMBLY TO RESTORE PROPER OPERATION. The part is on back order due to this being a constant issue. They have informed me that they are not sure when they will have the part. They told me that there are even customers who have been waiting for over a month so far. Driving around with the inability to open the doors from the inside is a trap hazard! Based on multiple complaints and reports, Toyota should issue a recall for these vehicles.