Illustration99 TOYOTA FRAME IS RUSTED THROUGH WHEN CARFAX REPORT SPECIFICALLY LISTED A TOYOTA DEALER CHECKED SAME VEHICLE FOR FRAME RUST IN 2014 WITH 207000 MILES ON IT. IT PASSED IF THAT'S WHAT U WANT TO CALL IT. NOW IN 2018 WITH AN ADDITIONAL 15,000 MILES ON IT, IT HAS RUSTED THROUGH.
1999 Toyota Tacoma
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1999 Toyota Tacoma do not stand out strongly from the model-year median of 228.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Tacoma years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
40–25K
525–50K
950–75K
1975–100K
49100–150K
41150K+
127 reports with mileage · 122 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Structure. Review the 102 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 38 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 35 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
40 crash reports1 fire reports21 injury reports
Structure complaints
102 reportsFRAME RUSTED OUT, CAUSING THE BODY TO DROP AND A BOLT TO SETTLE ON MY GAS TANK, RESULTING IN A FUEL LEAK. NEEDS A NEW FRAME TO FIX.
TL* THE CONTACT OWNS A 1999 TOYOTA TACOMA. THE CONTACT STATED DURING STATE INSPECTION THEY WERE MADE AWARE OF THE VEHICLE'S FRAME HAVING SEVERE CORROSION. THE SULLIVAN BROTHERS TOYOTA LOCATED IN KINGSTON, MA WAS CONTACTED WHERE IT WAS CONFIRMED THE FRAME NEEDED TO BE REPLACED. THE CONTACT DECLINED REPLACEMENT DUE TO THE COST OF …
Read full complaint
TL* THE CONTACT OWNS A 1999 TOYOTA TACOMA. THE CONTACT STATED DURING STATE INSPECTION THEY WERE MADE AWARE OF THE VEHICLE'S FRAME HAVING SEVERE CORROSION. THE SULLIVAN BROTHERS TOYOTA LOCATED IN KINGSTON, MA WAS CONTACTED WHERE IT WAS CONFIRMED THE FRAME NEEDED TO BE REPLACED. THE CONTACT DECLINED REPLACEMENT DUE TO THE COST OF THE REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 86,600. UPDATED 10/12/17*LJ *TR
WHEN I CHANGED THE OIL IN MARCH, I NOTICED A HUGE HOLE ON THE INSIDE OF THE LEFT FRAME MEMBER, NEXT TO THE GAS TANK. I THEN CHECKED THE RIGHT SIDE, AND FOUND A LONG LINE OF RUSTED THROUGH HOLES ALONG THE BOTTOM OF THAT FRAME MEMBER. I FEEL THIS IS A MAJOR SAFETY DEFECT BY THE OEM'S SELECTION OF STEEL GRADES.
THE FRAME HAS BEEN DIAGNOSED BY 2 SEPARATE REPAIR SHOPS AS BEING NOT DRIVABLE DUE TO HOLES. THIS MAKE AND MODEL WAS RECALLED FOR THIS REASON AND WAS BROUGHT INTO A TOYOTA SERVICE CENTER IN 2009. THE FRAME WAS INSPECTED "OK" AND NO WORK WAS DONE. THE FRAME IS NOW ROTTED AND I AM NOW BEING TOLD IT IS INELIGIBLE FOR REPAIR BECAUSE …
Read full complaint
THE FRAME HAS BEEN DIAGNOSED BY 2 SEPARATE REPAIR SHOPS AS BEING NOT DRIVABLE DUE TO HOLES. THIS MAKE AND MODEL WAS RECALLED FOR THIS REASON AND WAS BROUGHT INTO A TOYOTA SERVICE CENTER IN 2009. THE FRAME WAS INSPECTED "OK" AND NO WORK WAS DONE. THE FRAME IS NOW ROTTED AND I AM NOW BEING TOLD IT IS INELIGIBLE FOR REPAIR BECAUSE IT IS NOW OUTSIDE OF THE 15-YEAR WARRANTY WINDOW. THIS VEHICLE WAS, IN FACT, BROUGHT TO TOYOTA WITHIN THE WINDOW AND NOTHING WAS DONE ABOUT IT.
TOYOTA SENT A RECALL CARD IN 2011 TO RUST PROOF THE FRAME. THEY COVERED UP THE RUST AND SAID THE VEHICLE WAS GOOD TO GO. THE FRAME HAS RUSTED TO THE POINT THE VEHICLE IS NOT SAFE TO DRIVE. I HAVE A FRIEND THAT HAD THE SAME PROBLEM AND THEY PURCHASED HIS VEHICLE AND I KNOW SEVERAL PEOPLE HAVE HAD THEIR FRAME'S REPLACED AT NO CHAR…
Read full complaint
TOYOTA SENT A RECALL CARD IN 2011 TO RUST PROOF THE FRAME. THEY COVERED UP THE RUST AND SAID THE VEHICLE WAS GOOD TO GO. THE FRAME HAS RUSTED TO THE POINT THE VEHICLE IS NOT SAFE TO DRIVE. I HAVE A FRIEND THAT HAD THE SAME PROBLEM AND THEY PURCHASED HIS VEHICLE AND I KNOW SEVERAL PEOPLE HAVE HAD THEIR FRAME'S REPLACED AT NO CHARGE BY TOYOTA. THEY AVOIDED THE ISSUE AND NOW I HAVE A UNSAFE VEHICLE.
FRAME RUSTED SO BAD THERE ARE HOLES, AND A BRACKET HAS BROKEN LOSE CAUSING THE WHEEL TO MOVE. WAS TOLD TOO DANGEROUS TO DRIVE BY MECHANIC A COUPLE OF DAYS AGO.
HOLES RUSTED THROUGH ON FRAME. BELIEVE IT'S CALLED LIFT SPRING BRACKET BROKE BECAUSE OF RUST. MECHANIC INFORMED ME A COUPLE OF DAYS AGO WHEN I WANTED TO KNOW IF RUSTED OUT HOLE IN FRAME COULD BE REPAIRED
TL* THE CONTACT OWNS A 1999 TOYOTA TACOMA. THE CONTACT STATED THAT THE FRAME ON THE VEHICLE WAS CORRODED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE FRAME NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 68,000.
THE FRAME IS RUSTING OUT AND FALLING APART. THIS HAS MADE THE VEHICLE UNSAFE TO DRIVE.
Official recalls
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.