2021 Toyota RAV4

The driver side door actuator will not work, car is only five years old. Door will not unlock from fob, door unlock button or app. Began with a few random instances of not unlocking then turned into never unlocking again. Would have to climb through the passenger side to manually unlock by pushing switch. Got the actuator replaced but now car will not allow opening from inside, have to climb out of passenger door. This is a major safety concern as being unable to open a door in an emergency can be life threatening. The problem was reproduced and repair quoted by dealership. Problem was also reproduced by local mechanic and part replaced by them. Component inspected by manufacturer. The only warning was it sometimes not working, this began a few months back around February 2026.

The front driver-side door lock and opener (actuator) stopped working using the key fob and needs to be manually locked from the inside. When I try to access the door after manually locking driver side and using my key fob for the remaining 3 locks, the unit won't automatically open. This causes a safety risk considering I need to access the driver's side back or front passenger side to open the door. According to what I've read this is a known issue.

Passenger front door actuator\lock mechanism does not lock/unlock the door. There have been numerous lawsuits and yet NO RECALL for this very dangerous known problem. Please advise if there is any assistance from Toyota available to cure this defect that is well known to exist. I can be reached @ [XXX]. Thank you in advance for your assistance, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Gear shift makes noise when moving it, as in you can actually hear the gears/electrical equipment moving and making noise when going from park to drive. The keyless entry when the fob is near, just doesn't work well from the drivers side... I can stand there trying to allow it to unlock and it just locks again or wont unlock the passenger door even if allowing it extra time to.

The contact owns a 2021 Toyota Rav4. The contact stated that the front driver’s side door failed to lock securely. The contact stated that the door could not be locked while using the key fob, the keypad, or locked manually. The cause of the failure was not yet determined. The local dealer and manufacturer were not notified of the failure. The failure mileage was 108,000.

The front passenger door started to "not unlock" when using the keys or door buttons to unlock it, you would have to manually unlock the passenger door by reaching across from the driver's side of the car. For about a week, that was happening, then that same door started to "not lock" using the key fob, handle or door buttons, so both locking and unlocking could only be done manually. Then the most concerning incident, while driving and while a passenger was seated in the front seat, upon rounding a corner (moving less than 20 mph) in a very busy town full of parked cars and pedestrians, the closed front passenger door flung open while the vehicle was turning and moving, almost striking a pedestrian and parked car. The passenger was able to safely close the door, but this would have been impossible had there only been a driver in the car at the time. The door had been shut properly, and there were no indicator lights that the door was not fully closed. The door also "auto-locks" when moving, so there were multiple failures of the lock/door system when this occurred. The car was on the road more than 5 minutes when this happened with absolutely no warnings until the door flung open and the car made lots of warning noise at this point. We called the dealer and made an appointment and on the day of the appointment the locks magically started working again. The dealer just charged us $90 to perform a "lock diagnostic" to which they said there are no issues found. Well, let me just say, I feel a door randomly opening in a moving vehicle is a major safety problem and it is a grave concern for me to drive or ride in this car when I am not sure when or if this is going to reoccur at any given moment.

The contact owns a 2021 Toyota Rav4. The contact stated that after parking the vehicle overnight, the following morning it was discovered that the rear hatchback door had erroneously opened. The contact stated that a severe thunderstorm had occurred over night however, the keys had not been used nor were any buttons depressed to cause the hatchback door to become unlocked. The cause of the failure was not determined. The local dealer and manufacturer were not notified of the failure. The failure mileage was 4,055.