2020 Toyota RAV4

The rear liftgate is no longer aligned and does not sit evenly when closed. After noticing the uneven fit, I inspected the liftgate hinges and found that both metal hinge brackets appear to be cracking and splitting at their mounting points. There were no warning lights or messages before the problem appeared. I am concerned that the hinges could fail completely, causing the liftgate to fall unexpectedly, detach from the vehicle, or create a road hazard while driving.

The contact owns a 2020 Toyota RAV4. The contact stated that while driving at an undisclosed speed, the contact noticed that there was an unusual sound coming from the rear of the vehicle. The contact parked and inspected the vehicle. The contact stated that upon opening the rear passenger's side door, the contact noticed water leaking from the bottom of the door panel onto the ground. The contact stated about a gallon of water leaked from the rear passenger's side door panel. The vehicle was taken to the dealer, where the contact was informed that the repair was not covered under a recall. The vehicle was not repaired. The contact referenced an unknown recall; however, the VIN was not associated with the recall. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure, and a case was filed. The contact was advised to take the vehicle to the dealer for inspection. The failure mileage was approximately 60,000.

The contact owns a 2020 Toyota RAV4. The contact stated that while driving, the contact observed a swishing noise coming from the rear passenger door. Upon inspecting the vehicle, the contact noticed the swishing noise when moving the door. The vehicle was taken to a dealer, where it was diagnosed that water had collected in the rear passenger door and all door seals needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 87,000.

I am having a failure of my liftgate. My liftgate hinges are cracked and pulling away. The welds are cracked and weak. The liftgate does not close properly. I fear my liftgate will fall off and this could cause safety concerns for other vehicles behind me as well as potential harm to passengers in the back seat. I have a call into the dealer where my 2020 RAV4 Adventure was purchased but have not heard back from them yet.

The powered liftgate hinge is cracking and coming off the body of the car. Now the trunk/liftgate will not close. This is now a safety concern as I’m afraid the other hinge is becoming overloaded and the entire thing could separate off from the car. This seems to be a common issue with my model and year. No warning of this. All of a sudden I could not close my trunk.

2020 Hybrid RAV4 rear liftgate failure. The vehicle has been in no accidents and has never been damaged. Initially, it was a slight misalignment in 2022 and would still latch once opened and closed, but over time, the liftgate itself became separated from the vehicle body and the hinges are visibly bent. Initially presumed the sensor was being blocked somehow as it wouldn’t close as it lowered, but over time you could visibly see the alignment was off from the vehicle body. Now the tail lights no longer line up and there is large gapping along the top of the liftgate where it should meet the body of the car. Bent hinges were confirmed at a Toyota dealership and then confirmed at a body shop as well. The body shop informed me that they have seen and repaired this exact issue multiple times and recommended checking with the service center in case of any recalls or TBs. As of 2026 before repairs, the trunk is completely unusable as it has to be forced closed after use which threatens to compromise the structure of the vehicle. If the trunk cannot be latched or opened, it poses a safety hazard as a blocked means of emergency egress as well as a safety hazard of opening on the road if no longer able to latch.

I am writing to formally report a significant structural failure regarding the power liftgate system on my 2020 Toyota RAV4 Hybrid XLE. Recently, the trunk began failing to close properly. Upon a detailed inspection, I discovered that the sheet metal surrounding the hinges has suffered catastrophic failure. The left-side hinge mounting point is severely fractured, and the right side is exhibiting clear stress cracks. This is not a case of "wear and tear." This is a structural failure where the force exerted by the factory power struts appears to have overpowered the vehicle's body structure, leading to metal fatigue and tearing. I would like to emphasize the following points regarding this case: Maintenance & Care: This vehicle has been maintained strictly according to Toyota’s recommended intervals and has been handled with the utmost care. There has been no external impact or misuse of the liftgate. Safety Risk: The inability to securely latch the trunk poses a severe safety hazard. I am concerned about the liftgate's stability at highway speeds and the potential for exhaust fumes to enter the cabin. Consequently, I no longer feel safe using this vehicle for my daily commute. Request for Action: Given that this appears to be a known issue within the 2019–2021 RAV4 production years, I am requesting that Toyota stand behind its reputation for quality and safety. I ask that Toyota cover the full cost of the structural repairs and the replacement of the affected hinges and struts. I trust that Toyota will treat this as a priority safety matter. I look forward to your prompt response regarding a diagnostic appointment and a resolution for these repairs. Sincerely, [XXX] VIN [XXX] Phone Number [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)