Coolant bypass valve failure
2020 Toyota RAV4
Owner reports · Recalls · Investigations
More warning signs than most RAV4 years
Owner complaints for the 2020 Toyota RAV4 are substantially higher than the model-year median of 258.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all RAV4 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
195 reports with mileage · 439 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine. Review the 180 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 119 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 90 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
180 reportsThe wiring harness to the lithium battery is corroded, and it is unregulated. My repair shop said the car is unsafe to drive because of the amount of unregulated electricity in the battery. Also, the cruise control doesn't work. My repair shop says this is happening to other vehicles. Parts and labor total almost $7,000. …
Read full complaint
The wiring harness to the lithium battery is corroded, and it is unregulated. My repair shop said the car is unsafe to drive because of the amount of unregulated electricity in the battery. Also, the cruise control doesn't work. My repair shop says this is happening to other vehicles. Parts and labor total almost $7,000.
Warning light: Engine Maintenance Required Coolant Bypass Valve
Continuous Warning light display : Engine Maintenance Required Visit Your Dealer. The OBD diagnostic scanner lists the faulty system as follows: Code P268115. Engine coolant bypass valve circuit short to battery or open circuit. This appears to be a common fault on certain Toyota RAV4 years.
at only 55k miles my 2020 toyota rav4 has shown an “engine maintenance required” sign. not to be mistaken with general maintenance. apparently this is a widely common issue where brand new toyotas are having cooling bypass valve issue. however concerningly so, because there are no recalls for this problem yet seemingly every rav…
Read full complaint
at only 55k miles my 2020 toyota rav4 has shown an “engine maintenance required” sign. not to be mistaken with general maintenance. apparently this is a widely common issue where brand new toyotas are having cooling bypass valve issue. however concerningly so, because there are no recalls for this problem yet seemingly every rav4 has this problem? how is there no recall, everyone is paying out of pocket for essentially poor manufacturing, its outrageous, also considering the part itself is under $100 but some dealers are charging anywhere to $600-$1300. it’s predatory and outright wrong.
The coolant bypass valve has been failed prematurely therefor engine heat up and there is a warning on my dashboard that say "engine maintenance required"
Check engine light came on and noted a malfunction in the electronic control of the engine, throttle or transmission. When taken to the dealer they found code P012807 related to engine cooling and suggested a replacement of the thermostat. This part should have a life of 100k or 8-10 years and car currently has less than 60k mil…
Read full complaint
Check engine light came on and noted a malfunction in the electronic control of the engine, throttle or transmission. When taken to the dealer they found code P012807 related to engine cooling and suggested a replacement of the thermostat. This part should have a life of 100k or 8-10 years and car currently has less than 60k miles and 4 years old. Asked the dealership about known recall 20TA04 - for engine cooling recall but they insisted my car was not impacted. This is a safety issue as it could result in overheating of the engine leading to fire hazards.
What component or system failed or malfunctioned, and is it available for inspection upon request? The Engine Coolant Bypass Valve B failed. The check engine light comes on and disables All-Wheel-Drive, Radar Cruise Control, Lane Keep Assist and interrupts functionality of the infortainment system. I am also worried that it cou…
Read full complaint
What component or system failed or malfunctioned, and is it available for inspection upon request? The Engine Coolant Bypass Valve B failed. The check engine light comes on and disables All-Wheel-Drive, Radar Cruise Control, Lane Keep Assist and interrupts functionality of the infortainment system. I am also worried that it could have a negative effect on the operation of the engine. How was your safety or the safety of others put at risk? My safety or the safety of others was not put at risk. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. The problem has been confirmed by an independent service center. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No
•August 19, 2022: All emergency/error code lights came on the dash while driving on highway. The vehicle was taken to Don McGill Toyota for service. In that time, all error codes came back and went away a few times on their own. Vehicle was taken on 08/20/2022 (please refer to service records) in which it was originally deemed t…
Read full complaint
•August 19, 2022: All emergency/error code lights came on the dash while driving on highway. The vehicle was taken to Don McGill Toyota for service. In that time, all error codes came back and went away a few times on their own. Vehicle was taken on 08/20/2022 (please refer to service records) in which it was originally deemed there were no issues with the vehicle. Toyota recommended that if the problem persists, bring the vehicle back in. •August 26, 2022: Vehicle emergency lights came back on while driving on the highway again. The vehicle was taken back to Don McGill Toyota for a service emergency. Was told the Vehicle needed a sensor replaced. Got the vehicle back on September 15, 2022. •September 6, 2023: Vehicle emergency lights come back on. The vehicle was taken to Don McGill Toyota. Another part was replaced (please refer to service records) and the vehicle was returned on September 9, 2023. •August 2024: Vehicle emergency lights come back on. The vehicle was taken to Don McGill Toyota for a break service as well as getting this emergency lights issue resolved. The vehicle was picked up 5 hours later, however upon driving a little in the dealership parking lot, emergency lights came back on. Immediately went back and brought it up to the service advisor, who then took the car back for another 1 hour and deemed the vehicle needed to be “recalibrated”. This recalibration was completed, then left the dealership. •September 3, 2024: Vehicle emergency lights come back on. This time the vehicle struggled to brake when the lights came on. The vehicle was taken into Don McGill Toyota for immediate service. Breaks were looked at and recalibration was completed. Vehicle returned on September 6, 2024. •September 14, 2024: Vehicle emergency lights come back on. The vehicle was taken to Don McGill Toyota for emergency service. Brakes were checked and the vehicle was driven around to bring the lights up. The vehicle was given back on October 1, 2024, after the ser
My Toyota 2020 RAV4 has a dangerous design flaw. It rolls when turned off and in drive mode. For example, my driveway is on an incline, and a couple times I have pulled into my driveway, gotten distracted, and I forgot to put the car in Park. When I hit the on/off button, the car rolls backwards, accelerating due to gravity. …
Read full complaint
My Toyota 2020 RAV4 has a dangerous design flaw. It rolls when turned off and in drive mode. For example, my driveway is on an incline, and a couple times I have pulled into my driveway, gotten distracted, and I forgot to put the car in Park. When I hit the on/off button, the car rolls backwards, accelerating due to gravity. If you're not quick, you can end up rolling out into traffic, or running someone over that is behind your car. All the other cars I've ever owned didn't roll when the car was turned off unless you were in neutral. I believe this is a design flaw because I've spoken to a few other RAV4 owners that have experienced the same thing, and on one occasion, I tested it on another RAV4 and it was the same. I can see this being very dangerous. If you are standing outside of the car and hit the on/off button while it's in drive, you would get knocked down by the door, and your car would be rolling without you in the car.
Official recalls
623V865000 · Air Bags:sensor:occupant Classification
Dec 20, 2023
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2020-2021 Avalon, Avalon Hybrid, Corolla, Highlander, Highlander Hybrid, RAV4, RAV4 Hybrid, Lexus ES350, Lexus RX350, Lexus RX450H, 2021 Sienna Hybrid, Lexus ES250, 2020-2022 Camry, Camry Hybrid, and ES300H vehicles. A short circuit may develop in the Occupant Classification System (OCS) sensor, preventing the front passenger air bag from deploying.
Consequence & remedy
Consequence: An air bag that does not deploy during a crash increases the risk of injury.
Remedy: Dealers will inspect and replace the sensor as necessary, free of charge. Interim letters notifying owners of the safety risk were mailed in February 2024. Some final remedy owner letters were mailed October 31, 2024. Letters will continue to be mailed in phases through January 2026. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is 23TB15/23TA15 Lexus 23LB03/23LA03.
20V734000 · Air Bags:frontal; Steering:column
Nov 25, 2020
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2020-2021 Toyota Avalon and 2020 Avalon Hybrid, RAV4, and RAV4 Hybrid vehicles. Breakaway pins within the steering column, designed to absorb energy and reduce injury during a crash, could have been damaged during production, possibly affecting the performance of the driver's air bag in the event of a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: In the event of a crash, an air bag that does not perform as designed can increase the risk of injury.
Remedy: Toyota will notify owners, and dealers will replace the steering column, free of charge. The recall began December 18, 2020. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is 20TB17/20TA17.
Additional source detail variants (2)
Air Bags:frontal
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2020-2021 Toyota Avalon and 2020 Avalon Hybrid, RAV4, and RAV4 Hybrid vehicles. Breakaway pins within the steering column, designed to absorb energy and reduce injury during a crash, could have been damaged during production, possibly affecting the performance of the driver's air bag in the event of a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: In the event of a crash, an air bag that does not perform as designed can increase the risk of injury.
Remedy: Toyota will notify owners, and dealers will replace the steering column, free of charge. The recall began December 18, 2020. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is 20TB17/20TA17.
Steering:column
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2020-2021 Toyota Avalon and 2020 Avalon Hybrid, RAV4, and RAV4 Hybrid vehicles. Breakaway pins within the steering column, designed to absorb energy and reduce injury during a crash, could have been damaged during production, possibly affecting the performance of the driver's air bag in the event of a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: In the event of a crash, an air bag that does not perform as designed can increase the risk of injury.
Remedy: Toyota will notify owners, and dealers will replace the steering column, free of charge. The recall began December 18, 2020. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is 20TB17/20TA17.
20V682000 · Fuel System, Gasoline:delivery:fuel Pump
Nov 4, 2020
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2018-2019 4Runner, 2019-2020 Avalon, 2019 Corolla Hatchback, 2017-2019 Highlander, 2018-2020 Camry, 2020 Corolla, 2018-2019 Land Cruiser, 2017-2020 Tacoma, 2019-2020 RAV4, 2019-2020 Sequoia, 2017-2020 Sienna, 2019-2020 Tundra, 2018-2020 Lexus ES350, 2017 Lexus GS200t, 2017-2019 Lexus GS350, 2019 Lexus GS300, 2018-2020 Lexus LC500h, 2019-2020 Lexus LS500, 2018-2019 Lexus GX460, 2017 Lexus IS200t, 2019 Lexus IS300, 2019 Lexus IS350, 2018-2020 Lexus LC500, 2018 Lexus LS500, 2019 Lexus LS500h, 2018-2019 Lexus LX570, 2017 Lexus RC200t, 2019 Lexus RC300, RC350, 2017 and 2019-2020 Lexus RX350, 2018-2020 RX350L, 2019 Lexus UX200, 2018-2019 Lexus NX300 vehicles. The low-pressure fuel pump inside the fuel tank may fail.
Consequence & remedy
Consequence: If the fuel pump fails, the engine can stall while driving, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the fuel pump assembly with an improved one, free of charge. Owners of specific models were notified that remedy parts were available starting January 21, 2021. Owners of other models will be notified as remedy parts become available. Remedy parts should be available for all affected vehicles by late March 2021. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Note: This recall is an expansion of recall 20V-012. Toyota's number for this recall is 20TA02. Lexus' number for this recall is 20LA01.
20V373000 · Steering:electric Power Assist System
Jun 24, 2020
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2019-2020 RAV4 and 2020 RAV4 Hybrid vehicles equipped with electric power steering (EPS). Water may enter through the steering gear box cover and cause a loss of electric power steering assist.
Consequence & remedy
Consequence: A loss of power steering assist could increase steering effort at low vehicle speeds, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the power steering gear box, free of charge. The recall began August 17, 2020. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is 20TB11 / 20TA11.
20V286000 · Suspension:front:control Arm:lower Arm
May 20, 2020
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2019-2020 RAV4 and RAV4 Hybrid vehicles. The front lower suspension arms may have cracks, which may result in the suspension arm separating from the front wheel assembly.
Consequence & remedy
Consequence: If a suspension control arm breaks, it can result in a loss of vehicle control, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace both front lower suspension arms, free of charge. This recall began August 10, 2020. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's interim numbers for this recall are 20TB08 / 20TA08.
20V064000 · Engine And Engine Cooling
Feb 6, 2020
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2020 Toyota Avalon Hybrid, Camry, Camry Hybrid and Lexus ES300h and 2019-2020 RAV4 and RAV4 Hybrid vehicles equipped with 2.5L 4-Cylinder engines. Porosity in the engine castings may result in cracks than can allow coolant to leak internally and/or externally.
Consequence & remedy
Consequence: A coolant leak can cause the engine to overheat and cause a vehicle stall in conventional gasoline vehicles, increasing the risk of a crash. Additionally, for all involved vehicles, the engine may get damaged mechanically, possibly resulting in an engine oil leak, increasing the risk of a fire.
Remedy: Toyota will notify owners, and dealers will inspect and replace the engine including the engine block, as necessary, free of charge. The recall began April 3, 2020. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus at 1-800-255-3987. Toyota's number for this recall is 20TA04. Lexus' number for this recall is 20LA02.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.
Illustration