I WAS STOPPED AT A RED LIGHT IN A LEFT HAND TURN LANE. A VEHICLE MAKING A LEFT HAND TURN ACCIDENTALLY DROVE HEAD FIRST INTO MY CAR. MY PASSENGER AND I HAD SEAT BELTS ON. THE APPROXIMATE SPEED OF THE OTHER CAR WAS GREATER THAN 10 MILES PER HOUR. THE AIR BAGS DID NOT DEPLOY DESPITE CONSIDERABLE FRONT END DAMAGE. A MESSAGE ON …
Read full complaint
I WAS STOPPED AT A RED LIGHT IN A LEFT HAND TURN LANE. A VEHICLE MAKING A LEFT HAND TURN ACCIDENTALLY DROVE HEAD FIRST INTO MY CAR. MY PASSENGER AND I HAD SEAT BELTS ON. THE APPROXIMATE SPEED OF THE OTHER CAR WAS GREATER THAN 10 MILES PER HOUR. THE AIR BAGS DID NOT DEPLOY DESPITE CONSIDERABLE FRONT END DAMAGE. A MESSAGE ON THE DASHBOARD SAYS "SRS AIRBAG SYSTEM MALFUNCTION. VISIT YOUR DEALER". I WANT TO MAKE SURE THAT THE AIRBAGS WERE NOT DEFECTIVE. I HAVE READ THAT IF A VEHICLE IS STATIONARY AND THE SEAT BELTS ARE ON IT MAY NOT ACTIVATE. THAT IS OK - JUST WANT TO MAKE SURE THAT IS THE INTENT.
NHTSA ODI #11309946
Mileage unknown · Dec 22, 2019
Air BagsService BrakesWheels
THE AIRBAGS ARE OFF AND I CANT TURN IT ON, EVERY WEEK TURN IT ON THE LIGTH FLAT TIRE AND THE TIRE ARE GOOD INCLUIDING EXTRA TIRE, AND MY BRAKES ARE DOING A EXTRANGE NOISE I CHECKED THE BRAKES AND ARE GOOD.
NHTSA ODI #11290777
23,000 miles · Apr 3, 2019
Air BagsSeat BeltsCrashInjury
TL* THE CONTACT OWNED A 2017 TOYOTA RAV4. WHILE DRIVING 45 MPH, THE CONTACT SWERVED TO AVOID A DEER AND HIS FOOT SLIPPED OFF THE BRAKE PEDAL. THE CONTACT CRASHED THE VEHICLE INTO A GUARDRAIL. THE AIR BAGS DID NOT DEPLOY. THE CONTACT'S ARMS AND RIBS WERE BRUISED AND HIS NECK SNAPPED BACK AND WAS SWOLLEN. MEDICAL ATTENTION WAS NOT…
Read full complaint
TL* THE CONTACT OWNED A 2017 TOYOTA RAV4. WHILE DRIVING 45 MPH, THE CONTACT SWERVED TO AVOID A DEER AND HIS FOOT SLIPPED OFF THE BRAKE PEDAL. THE CONTACT CRASHED THE VEHICLE INTO A GUARDRAIL. THE AIR BAGS DID NOT DEPLOY. THE CONTACT'S ARMS AND RIBS WERE BRUISED AND HIS NECK SNAPPED BACK AND WAS SWOLLEN. MEDICAL ATTENTION WAS NOT RECEIVED; HOWEVER, X-RAYS WERE PERFORMED. THE CONTACT PLANNED TO SCHEDULE AN APPOINTMENT WITH A DOCTOR. A POLICE REPORT WAS NOT FILED. THE CONTACT TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC WHO DEEMED THE VEHICLE DESTROYED. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED. THE FAILURE MILEAGE WAS 23,000. *BF*JB 'PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).'*JB
NHTSA ODI #11193611
23,000 miles · Sep 29, 2018
Air BagsStructureUnknown Or OtherCrashInjury
I WAS IN A CRASH, SIDE IMPACT, PRETTY BAD. INJURED. AIRBAGS DID NOT DEPLOY. I HIT MY HEAD AND SHOULDER AGAINST THE SIDE ON THE INTERIOR OF MY VEHICLE. TRAVELING ON FREEWAY 50-60MPH, HEARD SCREECHING BEHIND DRIVERS SIDE OF ME... HEARD CRASH THEN I WAS IMPACTED ON DRIVERSIDE AND EVENTUALLY REAR PASSENGER SIDE CAUSING MY VEHICLE…
Read full complaint
I WAS IN A CRASH, SIDE IMPACT, PRETTY BAD. INJURED. AIRBAGS DID NOT DEPLOY. I HIT MY HEAD AND SHOULDER AGAINST THE SIDE ON THE INTERIOR OF MY VEHICLE. TRAVELING ON FREEWAY 50-60MPH, HEARD SCREECHING BEHIND DRIVERS SIDE OF ME... HEARD CRASH THEN I WAS IMPACTED ON DRIVERSIDE AND EVENTUALLY REAR PASSENGER SIDE CAUSING MY VEHICLE TO BE AIRBORNE AND LAND UPRIGHT. NO AIRBAGS DEPLOYED!
NHTSA ODI #11132299
17,000 miles · Jun 25, 2018
Air BagsCrash
MY WIFE DROVE HER CAR (2017 TOYOTA RAV4 , PURCHASED ON NOV 17TH,2016) INTO MY NEIGHBOR 'S MAILBOX AND A SMALL TREE NEXT TO THE MAILBOX IN THE RESIDENTIAL AREA ON THE MORNING OF JUN 22TH,2018.PLEASE FIND ATTACHED PICTURE AND YOU WILL FIND THE AIR BAG DIDN'T DEPLOY UNDER THE SITUATION LIKE PICTURE SHOWS. I AM VERY CONCERNED THAT T…
Read full complaint
MY WIFE DROVE HER CAR (2017 TOYOTA RAV4 , PURCHASED ON NOV 17TH,2016) INTO MY NEIGHBOR 'S MAILBOX AND A SMALL TREE NEXT TO THE MAILBOX IN THE RESIDENTIAL AREA ON THE MORNING OF JUN 22TH,2018.PLEASE FIND ATTACHED PICTURE AND YOU WILL FIND THE AIR BAG DIDN'T DEPLOY UNDER THE SITUATION LIKE PICTURE SHOWS. I AM VERY CONCERNED THAT THE AIR BAG DIDN'T DEPLOY . ALSO, I WANT TO CONFIRM IS ANY RECALLS FOR THIS MODEL? THIS ACCIDENT HAPPENED AT 33971 SUMMERSET DRIVE,SOLON,OH.NOBODY HURT BUT THE CAR LOOKS REALLY TERRIBLE.
NHTSA ODI #11103823
12,000 miles · May 16, 2018
Air BagsCrashInjury
VEHICLE WAS INVOLVED IN A 50 MPH CRASH ON THE FREEWAY WHERE ANOTHER VEHICLE HIT THE PASSENGER SIDE AND THE SIDE AIRBAGS DID NOT DEPLOY. THE CAR SPUN AND THE FRONT END WAS HIT AGAIN CAUSING DAMAGE TO THE FRONT END AND THE FRONT AIRBAGS DID NOT DEPLOY
NHTSA ODI #11094062
6,259 miles · Jan 6, 2018
Air Bags
SRS AIRBAG MALFUNCTION
NHTSA ODI #11060875
3,615 miles · Oct 7, 2017
Air BagsSeat Belts
THE CAR SUDDENLY SHOWED A YELLOW WARNING ALERT THAT THE VEHICLE AIRBAG IS NOT FUNCTIONING AND LOOK FOR THE NEAREST DEALER. WE WENT TO THE DEALER AND ON THE CUTOMER STATEMENT OF PROBLEM TOYOTA PUT MALFUNCTION ILLUMINATED PASSENGER SEATBUCKLE SWITH CORRECTION TAKEN WAS ORDER SEAT BELT BUCKLE FRONT SEAT
NHTSA ODI #11032207
3,700 miles · Jul 14, 2017
Air BagsStructureUnknown Or OtherCrash
WHILE PULLING INTO TO A PARKING SPACE,MY CAR SUDDENLY ACCELERATED AND JUMPED THE CURB CAUSING THE CAR TO HIT A TREE,CAUSING ALL AIR BAGS TO GO OFF. I WAS ASKED IF I HIT THE GAS INSTEAD OF THE BRAKE. THIS HAPPENED SO FAST THAT I SUPPOSE ANYTHING IS POSSIBLE BUT I REALLY DON'T THINK THAT IS WHAT HAPPENED. IS THERE A WAY THAT THEY…
Read full complaint
WHILE PULLING INTO TO A PARKING SPACE,MY CAR SUDDENLY ACCELERATED AND JUMPED THE CURB CAUSING THE CAR TO HIT A TREE,CAUSING ALL AIR BAGS TO GO OFF. I WAS ASKED IF I HIT THE GAS INSTEAD OF THE BRAKE. THIS HAPPENED SO FAST THAT I SUPPOSE ANYTHING IS POSSIBLE BUT I REALLY DON'T THINK THAT IS WHAT HAPPENED. IS THERE A WAY THAT THEY CAN TELL WHAT HAPPENEED?
NHTSA ODI #11005357
950 miles · Mar 18, 2017
Air Bags
THE LIGHT FOR "SRS AIRBAG SYSTEM MALFUNCTION" WILL INTERMITTENTLY GO ON WHILE DRIVING ON HIGHWAY OR COUNTRY ROADS. THE LIGHT WILL GO OFF ONLY ONCE THE VEHICLE IS TURNED OFF.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2013-2018 RAV4 vehicles. Certain replacement 12-volt batteries may not fit properly in the battery tray, allowing the battery to move and contact the hold-down bracket, possibly causing a short circuit.
Consequence & remedy
Consequence: A battery short circuit increases the risk of a fire.
Remedy: Dealers will replace the battery clamp sub-assembly, battery tray, and positive terminal cover, free of charge. Owner letters were mailed December 27, 2024, to 2013-2014 RAV4 owners. Additional owner notification letters will be mailed in phases, phase 2 will begin on May 14, 2025, and phase 3 in late July 2025. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 23TB13 and 23TA13.
Southeast Toyota Distributors, LLC (SET) is recalling certain 2017-2019 Toyota Camry, Corolla, Rav4, Sienna, and Yaris iA vehicles equipped with factory-installed floor mats. The load carrying capacity modification label may be incorrect. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: An incorrect label may lead to unintentionally overloading the vehicle, increasing the risk of a crash.
Remedy: SET will notify owners and provide a corrected label for placement over the inaccurate label, free of charge. The recall began August 23, 2019. Owners may contact Toyota customer service at 1-888-270-9371. SET's number for this recall is SET19A.
Gulf States Toyota, Inc. (Gulf States) is recalling certain 2017 4Runner , 86, Avalon, Camry, Camry Hybrid, Corolla, Corolla iM, Highlander, Highlander Hybrid, Prius, Prius C, RAV4, RAV4 Hybrid, Sienna and Yaris vehicles. The spare tire air pressure was not adjusted to the proper pressure as stated on the Tire Pressure Label.
Consequence & remedy
Consequence: A spare tire that is not inflated to the proper value may not perform as intended, increasing the risk of a crash.
Remedy: Gulf States will notify owners, and dealers will inspect the spare tires, adjusting their pressure as necessary, free of charge. The recall began June 15, 2017. Owners may contact Gulf States customer service at 1-800-444-1074. Toyota's number for this recall is 17R2.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE21005 · Battery Hold Down Bracket Thermal Events
Opened Feb 25, 2021 · Closed Aug 12, 2024
Status: closed (inferred from source dates) · Electrical SYSTEM:12V/24V/48V Battery
The Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) to understand the contributing factors and frequency of vehicle fires originating from the battery region of the engine compartment in Model Year (MY) 2013-2018 Toyota RAV4 vehicles on 25 February 2021. At the time of opening, ODI attributed eleven allegations and additional EWR events to this PE. PE21005 focused on replacement batteries installed in the subject vehicles. No reported fire event identified in PE21005 involved the originally supplied 12V battery. The reported fires took place in vehicles known to contain aftermarket batteries or whose age exceeded the expected life of the original equipment battery. ODI identified battery dimensioning as it relates to the battery retention system (hold down bracket, radiator support bolt, J-hook, and battery tray) as the main factor set in the contact between the battery hold down bracket contacting the positive terminal of the 12V battery. The subject vehicles carried over the same battery tray and retention system from the prior generation (MY2006 – MY2012) of RAV4 vehicles. However, the subject vehicles were equipped with a dimensionally smaller battery (Group 35) than the prior generation (Group 24F). The smaller- length measurement in the Group 35 battery size in a battery tray originally designed to fit a Group 24F battery contributed to increased potential for battery movement which was exacerbated by the diversity in aftermarket battery configuration and irregularities intrinsic to battery replacement procedures. Battery movement coupled with the proximity of the B+ terminal on the battery and the grounded electrically conductive hold down bracket set the stage for a short to ground leading to an engine stall (if in operation) followed by a vehicle fire. This investigation was not able to classify the installation status, battery size, or cause of every allegation due to the fire event causing damage to the area, inaccessible vehicle, modification to the battery retention system after the event, and/or inconclusive photographic evidence. Toyota's investigation of the issue identified aftermarket battery catalogs that listed an improper battery replacement size (Group 26R) that would nevertheless fit into the subject vehicles whose battery retention system is incapable of reliably restraining a Group 26R battery. On 18 November 2021, Toyota initiated a consumer advisory campaign (21TG01) to the subject vehicle owners, notifying them of the correct size battery and offering a free inspection of the battery and retention hardware, a caution label to affix to the hold down bracket, and a discounted replacement 12V battery. This investigation with Toyota established three broad categories to characterize the battery retention system state of a given vehicle: "correct", "minor mis-installation", and "major mis-installation". - The "correct" terminology references the front bolt, bracket, and J-hook installed in a position not in contact with the positive battery terminal and the front bolt torqued to 17 Nm and the J-hook engaged with the tray hole and torqued to 4.9 Nm. - A "minor mis-installation" would describe the three retention components installed in the prescribed location, however not to the correct torque values. - The "major mis-installation" condition would constitute a retention component missing or disconnected from the system. Toyota's own testing used five exemplar batteries installed on a subject vehicle in each battery categorization resulted in: - Contact between the B+ terminal and hold down bracket in "major mis-installations" - Movement of the battery in "minor mis-installations" - No observable motion in "correct" installations. ODI conducted its own evaluation of the Toyota- specified replacement battery and 5 aftermarket Group 35 batteries. The six batteries tested conformed to the Group 35 Battery Council International (BCI) standard on overall dimensional tolerance and terminal location. That standard does not define the edge shape or material of battery casing. Physical interaction between the hold down bracket and the battery case and the friction between the casing material and the battery tray resulted in a large variability in movement forces required to incite movement when the battery was installed in the "correct" condition. Resulting in movement at an induced lateral load between 0.6 G and 1.91 G equivalent force across each battery. This force is higher than a typical vehicle could exert in a steady state turn and would only experience loads through brief shock or impulses. Multiple shock or impulse loads across time would contribute to a delay between the replacement battery installation and the fire event. Likelihood of a fire event increases as the installation method degraded from the "correct", to "minor mis-installation", and then to "major mis-installation". Protruding vent caps atop some of the batteries tested aided in restricting battery movement relative to the hold down. An absence of vent caps permitted additional movement. Following several discussions and vehicle inspections with ODI during this investigation, on 01 November 2023, Toyota filed a safety recall (NHTSA 23V-734) of 1,853,568 MY 2013 through MY 2018 Toyota RAV4 vehicles to reduce the risk of a vehicle fire with redesigned battery retention components. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration