NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
197 reports102,000 miles · Jul 12, 2021
EngineSteeringFire
The contact owned a 2014 Toyota Rav4. The contact stated while making a right turn at an undisclosed speed, the steering wheel was difficult to turn. During the failure, the instrument panel flashed approximately 4-5 times before going black. The contact stepped out to look under the hood and noticed a small fire. The police dep…
Read full complaint
The contact owned a 2014 Toyota Rav4. The contact stated while making a right turn at an undisclosed speed, the steering wheel was difficult to turn. During the failure, the instrument panel flashed approximately 4-5 times before going black. The contact stepped out to look under the hood and noticed a small fire. The police department was contacted and arrived and put out the fire. A police report was filed. The vehicle was towed away and deemed a total loss. The contact was not injured. Medical attention was not needed. The dealer was not contacted. The manufacturer was made aware of the failure and opened a case. The approximate failure mileage was 102,000.
NHTSA ODI #11424423
Mileage unknown · Jun 6, 2021
Electrical SystemEngineCrashFire
After a minor front end collision, the RAV4 immediately began smoking and caught fire. With a minor accident where the other car only had their front bumper minorly damaged, the RAV4 should not have caught fire. Their must be a defect in either the battery or oil line for the car to have caught fire. The car is a total loss a…
Read full complaint
After a minor front end collision, the RAV4 immediately began smoking and caught fire. With a minor accident where the other car only had their front bumper minorly damaged, the RAV4 should not have caught fire. Their must be a defect in either the battery or oil line for the car to have caught fire. The car is a total loss and I am asking for a full investigation as my 2 children were in the car when the fire started.
NHTSA ODI #11419845
Mileage unknown · Jun 1, 2021
Electrical SystemEngineFuel/propulsion SystemFire
Making a turn onto a local toll road and entire car went dead without warning of any kind. I had to struggle with loss of power steering to complete turn without going off road. Car came to a stop. I tried to call my wife to advise her I was having car problems which is surprising as I haven't had issues previously and had an …
Read full complaint
Making a turn onto a local toll road and entire car went dead without warning of any kind. I had to struggle with loss of power steering to complete turn without going off road. Car came to a stop. I tried to call my wife to advise her I was having car problems which is surprising as I haven't had issues previously and had an earlier version of the RAV4 that I drove for 210,000 miles. Anyway, another vehicle stopped alongside and inquired if I needed assistance. As I talked, I noticed a smokey smell from what I had initially assumed was steam. I stepped outside the vehicle and observed through the drivers side front wheel well to see fire at the bottom of the engine compartment. Since I was driving to trails to ride my mountain bike, I had a water bottle and squeezed it onto the flames which partially extinguished and then relit. I hit the hood release but decided it was better to leave the hood down. I went to the rear lift gate to open it to retrieve my expensive carbon fiber mountain bike but it was locked. I tried to open the back driver side door also without success and tried hitting the unlock button on the drivers door but there was no power. About this time the smoke coming from the hood increased and I decided to heed the advise being given to step away from the car. Had I remembered sooner, I probably could have reached around the driver's seat to recover my wallet from the back pocket of the seat. As the fire increased, I stepped increasingly further back from the vehicle. About 5 minutes into the fire a state trooper arrived and expended his only extinguisher in an unsuccessful attempt to put out the fire. It was probably another 12-15 minutes before the fire department arrived to extinguish the fire but by that time, the car and its contents were a total loss.
NHTSA ODI #11419257
Mileage unknown · May 22, 2021
EngineFuel/propulsion System
I was driving down the road. I slowed up for a light and it turned green and started to go and my car turned off. Electrical still worked but engine was off.
NHTSA ODI #11418136
Mileage unknown · May 20, 2021
Electrical SystemUnknown Or Other
All but one lock has now failed. The truck is not able to be opened. There were no warnings/indications, and now the company is telling me that it is no longer under warranty and it cannot be repaired unless paid for. I do find similar stories online and that the locks fail a second time in some cases.
NHTSA ODI #11417929
110,000 miles · Apr 7, 2021
Electrical SystemEngineFire
ON MARCH 20, MY 2014 TOYOTA RAV4 CAUGHT FIRE. IT WAS PARKED IN MY GARAGE AND HAD NOT BEEN MOVED FOR AT LEAST 24 HOURS. THE CAR FIRE CAUGHT THE RAFTERS IN MY ATTACHED GARAGE AND THEN CAUGHT THE REST OF MY HOME ON FIRE.
NHTSA ODI #11406924
88,000 miles · Mar 24, 2021
EngineFire
WHILE I WAS DRIVING IN CAPITOL REEF NATIONAL PARK ON A WELL GRADED AND FULLY MAINTAINED DIRT ROAD, ALL THE LIGHTS IN MY DASH STARTED FLICKERING, AND THEN MY CARS ENGINE SHUT DOWN. IT FELT LIKE I WAS DRIVING / COASTING IN NEUTRAL. I PULLED OVER AND PUT THE CAR IN PARK, THEN SMOKE STARTED COMING FROM BENEATH THE HOOD. I GOT OUT OF…
Read full complaint
WHILE I WAS DRIVING IN CAPITOL REEF NATIONAL PARK ON A WELL GRADED AND FULLY MAINTAINED DIRT ROAD, ALL THE LIGHTS IN MY DASH STARTED FLICKERING, AND THEN MY CARS ENGINE SHUT DOWN. IT FELT LIKE I WAS DRIVING / COASTING IN NEUTRAL. I PULLED OVER AND PUT THE CAR IN PARK, THEN SMOKE STARTED COMING FROM BENEATH THE HOOD. I GOT OUT OF THE CAR. IT WAS A LITTLE SMOKE, THEN MORE, AND THEN SUBSIDED TO BEING BARLEY NOTICEABLE AFTER A COUPLE OF MINUTES. AFTER IT SUBSIDED, I GOT BACK IN THE CAR TO TRY TO START IT, HOPING IT WAS AN OVERHEATED ENGINE AND I MIGHT GET THE CAR TO TURN OVER. IT WOULD NOT START. I CALLED A TOW TRUCK. SHORTLY AFTER THAT, I NOTICED A HISSING NOISE COMING FROM BENEATH THE HOOD, SAW A LIQUID DRIPPING BENEATH THE THE FRONT LEFT (DRIVERS SIDE) PART OF THE CAR. I ALSO SAW A SMALL FLAME. I CALLED 911 TO REPORT THAT MY CAR WAS ON FIRE. WITHIN 10-15 MINUTES, THE CAR WAS COMPLETELY ENGULFED IN FLAMES. THE PARK RANGER, SHERIFF, AND FIRE DEPARTMENT SHOWED UP SHORTLY AFTER THAT. A CHARRED CAR FRAME IS ESSENTIALLY WHAT'S LEFT.
NHTSA ODI #11404722
90,000 miles · Mar 2, 2021
Electrical System
OVER THE PAST THREE MONTHS, THE ELECTRICAL SYSTEM WILL RESTART WHILE I'M DRIVING, USUALLY WHEN FLICKING ON MY BRIGHTS. I GOT THE CAR CHECKED AND THE MECHANICS STATED IT PROBABLY WAS FROM THE BUILD UP ON THE BATTERY. THERE WERE A COUPLE DAYS WHEN THE BATTERY WAS COMPLETELY DEAD. THANKS FOR ANY ADVICE.
NHTSA ODI #11398781
51,000 miles · Feb 4, 2021
EngineFire
TL* THE CONTACT OWNED A 2014 TOYOTA RAV4. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 5 MPH, THE VEHICLE CAUGHT ON FIRE COMING IN THE DRIVER'S SIDE ENGINE COMPARTMENT. THE FIRE DEPARTMENT WAS CONTACTED AND ARRIVED AT THE SCENE AND EXTINGUISHED THE FIRE. THE VEHICLE WAS TOWED TO INDEPENDENT MECHANIC WHERE IT WAS DEEMED A TOTAL…
Read full complaint
TL* THE CONTACT OWNED A 2014 TOYOTA RAV4. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 5 MPH, THE VEHICLE CAUGHT ON FIRE COMING IN THE DRIVER'S SIDE ENGINE COMPARTMENT. THE FIRE DEPARTMENT WAS CONTACTED AND ARRIVED AT THE SCENE AND EXTINGUISHED THE FIRE. THE VEHICLE WAS TOWED TO INDEPENDENT MECHANIC WHERE IT WAS DEEMED A TOTAL LOSS. UPON INVESTIGATION, THE CONTACT ASSOCIATED THE FAILURE WITH NHTSA CAMPAIGN NUMBER: 15V011000 (TRAILER HITCHES, EXTERIOR LIGHTING) HOWEVER, THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS NOT INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 51,000. THE CONTACT CASE HAS BEEN CLOSED OUT WITH CASE MGMT AND WILL BE NOTIFIED BY THE TOYOTA CLAIMS DEPT IN REGARDS TO THE STATUS case and as of today my case 4/29/21.
NHTSA ODI #11394683
68,000 miles · Feb 1, 2021
Electrical System
MY HEAD UNIT WHICH PROVIDES NAVIGATION, SOUND, HANDS FREE PHONE, BLUETOOTH AND MUSIC OPTIONS CONTINUALLY ATTEMPTS TO RELOAD. SO I HAVE NONE OF THE ABOVE FEATURES TO USE. THIS PRESENTS A PROBLEM, AS IF I WANT TO MAKE OR RECEIVE A PHONE CALL, OR SPEAK HANDS FREE, THE OPTION NO LONGER EXISTS. I HAVE REVIEWED WEBSITES LIKE YOUTUB…
Read full complaint
MY HEAD UNIT WHICH PROVIDES NAVIGATION, SOUND, HANDS FREE PHONE, BLUETOOTH AND MUSIC OPTIONS CONTINUALLY ATTEMPTS TO RELOAD. SO I HAVE NONE OF THE ABOVE FEATURES TO USE. THIS PRESENTS A PROBLEM, AS IF I WANT TO MAKE OR RECEIVE A PHONE CALL, OR SPEAK HANDS FREE, THE OPTION NO LONGER EXISTS. I HAVE REVIEWED WEBSITES LIKE YOUTUBE AND CARCOMPLAINTS.COM, AND THERE ARE A LOT OF OWNERS OF NOT JUST A RAV4, BUT OTHER TOYOTA BRANDS WHO ARE HAVING OR HAVE EXPERIENCED THE SAME ISSUE. I'VE CALLED TOYOTA, AND THEY SAID THERE IS NO RECALL ON THIS SYSTEM. I DON'T SEE HOW NOT HAVING YOUR NAVIGATION, OR HANDS FREE PHONE SERVICES NOT WORKING, CANNOT BE A SAFETY CONCERN! THE WHOLE POINT OF HANDS FREE IS INDEED A SAFETY ISSUE! IT DOESN'T MATTER WHETHER YOU ARE DRIVING OR NOT, THE SYSTEM JUST WANTS TO CONTINUALLY REBOOT. FROM WHAT I'VE READ AND WATCHED, THIS IS A KNOWN MANUFACTURING FLAW WITHIN THE 'ENTUNE' SYSTEM. I'M HOPING YOUR ORGANIZATION CAN REVIEW THIS ISSUE AND SUPPORT THE MILLIONS OF TOYOTA OWNERS ACROSS THE NATION.
NHTSA ODI #11391014
Official recalls
4Nov 1, 2023
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2013-2018 RAV4 vehicles. Certain replacement 12-volt batteries may not fit properly in the battery tray, allowing the battery to move and contact the hold-down bracket, possibly causing a short circuit.
Consequence & remedy
Consequence: A battery short circuit increases the risk of a fire.
Remedy: Dealers will replace the battery clamp sub-assembly, battery tray, and positive terminal cover, free of charge. Owner letters were mailed December 27, 2024, to 2013-2014 RAV4 owners. Additional owner notification letters will be mailed in phases, phase 2 will begin on May 14, 2025, and phase 3 in late July 2025. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 23TB13 and 23TA13.
Mar 13, 2015
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2015 Camry, Camry Hybrid, Highlander, and Highlander Hybrid, and 2014-2015 Rav4 vehicles. A component of the electric power steering (EPS) electronic control unit (ECU) may have been damaged during the manufacturing process. Over time, this damage may result in failure of the electric power steering system.
Consequence & remedy
Consequence: An unexpected loss of power steering increases the risk of a crash.
Remedy: Toyota will notify owners, and dealers will inspect the serial number of the EPS ECU or steering column assembly. If the number is within the affected range, the EPS ECU will be replaced, free of charge. The recall began on May 7, 2015. Owners may contact Toyota customer service at 1-800-331-4331.
Jan 16, 2015
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2013-2015 Toyota Rav4 vehicles manufactured June 1, 2013, to December 29, 2014, and equipped with an accessory trailer light module. The software within the module may incorrectly detect an electrical short and preventively turn off the electrical current and the trailer lights.
Consequence & remedy
Consequence: If the system incorrectly detects an electrical short and turns off the trailer lights while the trailer is being towed at night, there is an increased risk of a crash.
Remedy: SET will notify owners, and dealers will replace the trailer light module with a new unit with corrected software, free of charge. The recall began on March 17, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET-15A.
Additional source detail variants (2)
Trailer Hitches
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2013-2015 Toyota Rav4 vehicles manufactured June 1, 2013, to December 29, 2014, and equipped with an accessory trailer light module. The software within the module may incorrectly detect an electrical short and preventively turn off the electrical current and the trailer lights.
Consequence: If the system incorrectly detects an electrical short and turns off the trailer lights while the trailer is being towed at night, there is an increased risk of a crash.
Remedy: SET will notify owners, and dealers will replace the trailer light module with a new unit with corrected software, free of charge. The recall began on March 17, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET-15A.
Exterior Lighting
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2013-2015 Toyota Rav4 vehicles manufactured June 1, 2013, to December 29, 2014, and equipped with an accessory trailer light module. The software within the module may incorrectly detect an electrical short and preventively turn off the electrical current and the trailer lights.
Consequence: If the system incorrectly detects an electrical short and turns off the trailer lights while the trailer is being towed at night, there is an increased risk of a crash.
Remedy: SET will notify owners, and dealers will replace the trailer light module with a new unit with corrected software, free of charge. The recall began on March 17, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET-15A.
Dec 30, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2014-2015 Toyota 4Runner, Tacoma, FJ Cruiser, Land Cruiser, RAV4, Scion FRS, and XB vehicles. The affected vehicles may have accessories installed by SET, such as running boards or other items, that were incorrectly installed. The accessory attaching fasteners were not tightened with the proper torque, possibly causing the accessory to detach from the vehicle.
Consequence & remedy
Consequence: Accessories that detach from a vehicle may result in a vehicle crash and/or personal injury.
Remedy: SET will notify owners, and dealers will inspect and tighten the affected bolts, free of charge. The recall began February 23, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET-14B.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE21005 · Battery Hold Down Bracket Thermal Events
Opened Feb 25, 2021 · Closed Aug 12, 2024
Status: closed (inferred from source dates) · Electrical SYSTEM:12V/24V/48V Battery
The Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) to understand the contributing factors and frequency of vehicle fires originating from the battery region of the engine compartment in Model Year (MY) 2013-2018 Toyota RAV4 vehicles on 25 February 2021. At the time of opening, ODI attributed eleven allegations and additional EWR events to this PE. PE21005 focused on replacement batteries installed in the subject vehicles. No reported fire event identified in PE21005 involved the originally supplied 12V battery. The reported fires took place in vehicles known to contain aftermarket batteries or whose age exceeded the expected life of the original equipment battery. ODI identified battery dimensioning as it relates to the battery retention system (hold down bracket, radiator support bolt, J-hook, and battery tray) as the main factor set in the contact between the battery hold down bracket contacting the positive terminal of the 12V battery. The subject vehicles carried over the same battery tray and retention system from the prior generation (MY2006 – MY2012) of RAV4 vehicles. However, the subject vehicles were equipped with a dimensionally smaller battery (Group 35) than the prior generation (Group 24F). The smaller- length measurement in the Group 35 battery size in a battery tray originally designed to fit a Group 24F battery contributed to increased potential for battery movement which was exacerbated by the diversity in aftermarket battery configuration and irregularities intrinsic to battery replacement procedures. Battery movement coupled with the proximity of the B+ terminal on the battery and the grounded electrically conductive hold down bracket set the stage for a short to ground leading to an engine stall (if in operation) followed by a vehicle fire. This investigation was not able to classify the installation status, battery size, or cause of every allegation due to the fire event causing damage to the area, inaccessible vehicle, modification to the battery retention system after the event, and/or inconclusive photographic evidence. Toyota's investigation of the issue identified aftermarket battery catalogs that listed an improper battery replacement size (Group 26R) that would nevertheless fit into the subject vehicles whose battery retention system is incapable of reliably restraining a Group 26R battery. On 18 November 2021, Toyota initiated a consumer advisory campaign (21TG01) to the subject vehicle owners, notifying them of the correct size battery and offering a free inspection of the battery and retention hardware, a caution label to affix to the hold down bracket, and a discounted replacement 12V battery. This investigation with Toyota established three broad categories to characterize the battery retention system state of a given vehicle: "correct", "minor mis-installation", and "major mis-installation". - The "correct" terminology references the front bolt, bracket, and J-hook installed in a position not in contact with the positive battery terminal and the front bolt torqued to 17 Nm and the J-hook engaged with the tray hole and torqued to 4.9 Nm. - A "minor mis-installation" would describe the three retention components installed in the prescribed location, however not to the correct torque values. - The "major mis-installation" condition would constitute a retention component missing or disconnected from the system. Toyota's own testing used five exemplar batteries installed on a subject vehicle in each battery categorization resulted in: - Contact between the B+ terminal and hold down bracket in "major mis-installations" - Movement of the battery in "minor mis-installations" - No observable motion in "correct" installations. ODI conducted its own evaluation of the Toyota- specified replacement battery and 5 aftermarket Group 35 batteries. The six batteries tested conformed to the Group 35 Battery Council International (BCI) standard on overall dimensional tolerance and terminal location. That standard does not define the edge shape or material of battery casing. Physical interaction between the hold down bracket and the battery case and the friction between the casing material and the battery tray resulted in a large variability in movement forces required to incite movement when the battery was installed in the "correct" condition. Resulting in movement at an induced lateral load between 0.6 G and 1.91 G equivalent force across each battery. This force is higher than a typical vehicle could exert in a steady state turn and would only experience loads through brief shock or impulses. Multiple shock or impulse loads across time would contribute to a delay between the replacement battery installation and the fire event. Likelihood of a fire event increases as the installation method degraded from the "correct", to "minor mis-installation", and then to "major mis-installation". Protruding vent caps atop some of the batteries tested aided in restricting battery movement relative to the hold down. An absence of vent caps permitted additional movement. Following several discussions and vehicle inspections with ODI during this investigation, on 01 November 2023, Toyota filed a safety recall (NHTSA 23V-734) of 1,853,568 MY 2013 through MY 2018 Toyota RAV4 vehicles to reduce the risk of a vehicle fire with redesigned battery retention components. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration