Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
360–25K
2025–50K
2050–75K
1075–100K
11100–150K
10150K+
107 reports with mileage · 90 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Electrical System. Review the 69 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 31 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Steering. Review the 21 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
20 crash reports25 fire reports16 injury reports
What owners actually said
197 reports
170,000 miles · Jan 17, 2021
Power Train
GREETINGS AND SALUTATIONS. THIS COMMUNICATION IS ABOUT THE DEFECTIVE TORQUE CONVERTER IN THE TRANSMISSION THAT TOYOTA IS AWARE OF. I ACQUIRED THE VEHICLE AT ABOUT 33,000 MILES AND I NOTICED THAT IT HAD THIS PROBLEM OF A SLIGHT INTERMITTENT SHUDDER, WHAT SOME WOULD CALL A SHAKE OR VIBRATION, DURING ACCELERATION COMING FROM THE T…
Read full complaint
GREETINGS AND SALUTATIONS. THIS COMMUNICATION IS ABOUT THE DEFECTIVE TORQUE CONVERTER IN THE TRANSMISSION THAT TOYOTA IS AWARE OF. I ACQUIRED THE VEHICLE AT ABOUT 33,000 MILES AND I NOTICED THAT IT HAD THIS PROBLEM OF A SLIGHT INTERMITTENT SHUDDER, WHAT SOME WOULD CALL A SHAKE OR VIBRATION, DURING ACCELERATION COMING FROM THE TRANSMISSION. IT DID NOT AFFECT THE PERFORMANCE OF THE VEHICLE SO I IGNORED IT MAINLY BECAUSE I DID NOT HAVE THE TIME TO ADDRESS IT. AS TIME WENT ON THE CONDITION BECAME MUCH MORE NOTICEABLE AND TOYOTA SENT ME A LETTER EXPLAINING THAT THEY WERE AWARE OF THE PROBLEM AFFECTING SOME OF THEIR VEHICLES AND THAT THEY WERE EXTENDING THE WARRANTY. I HAVE ATTACHED PHOTOS OF THIS LETTER WITH THIS COMMUNICATION. I FOUND OUT THAT THIS EXTENDED WARRANTY IS CONSIDERED A COURTESY AND CERTAINLY IT COVERED UP TO A CONSIDERABLE MILEAGE HOWEVER MY POSITION IS THAT BECAUSE THIS CONDITION EXISTED AT EARLY MILEAGE AND GREW CONSIDERABLY WORSE WITH EXTENDED MILEAGE AND TIME, THAT PERHAPS YOU MAY CONSIDER THAT TOYOTA SHOULD CORRECT THIS PROBLEM REGARDLESS OF MILEAGE OR TIME. MY VEHICLE IS PAST THE ALLOWABLE MILEAGE IN THE EXTENDED WARRANTY. I KNOW TOYOTA DOESN'T WANT TO HEAR THAT BUT PERHAPS THIS PROBLEM THAT THEY ARE AWARE OF IS FOUND IN A RELATIVELY SMALL NUMBER OF VEHICLES THAT IT MAY NOT CAUSE THEM MUCH GRIEF AT ALL. THANK YOU.
NHTSA ODI #11388530
188,000 miles · Jan 13, 2021
Engine
THE MILEAGE ON THE VEHICLE IS HIGH, OVER 188,000 MILES BUT I THINK THIS ISSUE IS IMPORTANT ENOUGH TO MAKE NOTE OF IT. THE PLASTIC COUPLER AT THE UPPER END OF THE RADIATOR HOSE STARTED LEAKING COOLING FLUID AND I FOUND THAT IT HAD DETERIORATED TO THE POINT THAT THE END OF THE PLASTIC COUPLER INSIDE OF THE RUBBER HOSE WAS BROKEN A…
Read full complaint
THE MILEAGE ON THE VEHICLE IS HIGH, OVER 188,000 MILES BUT I THINK THIS ISSUE IS IMPORTANT ENOUGH TO MAKE NOTE OF IT. THE PLASTIC COUPLER AT THE UPPER END OF THE RADIATOR HOSE STARTED LEAKING COOLING FLUID AND I FOUND THAT IT HAD DETERIORATED TO THE POINT THAT THE END OF THE PLASTIC COUPLER INSIDE OF THE RUBBER HOSE WAS BROKEN AND WHEN REMOVED I FOUND THAT IT WAS BRITTLE TO THE TOUCH. I HAVE ATTACHED PHOTOS OF THE PART IN QUESTION. I THINK IF TOYOTA COULD MAKE THIS PARTICULAR PART OUT OF METAL IT WOULD NOT COST MUCH AND COULD SAVE THE CONSUMER FROM A SERIOUS ISSUE.
NHTSA ODI #11387812
Mileage unknown · Dec 9, 2020
Power Train
WHEN CAR IS IN MOVEMENT AT SPEED OF 20 OR30 MPG CHANGING CAUSE A SHIVERS INTO A JERKING FEELING
NHTSA ODI #11382777
78,000 miles · Nov 11, 2020
Power Train
PURCHASED A USED 2014 TOYOTA RAV4 ON 01-2018 FOR THE PURCHASE PRICE OF $12,000. IT HAD 36,198 MILES AT THE TIME OF PURCHASE. APPROXIMATELY ONE YEAR AFTER PURCHASE, NOTICED A SHUTTERING WHILE AT CERTAIN SPEEDS. LOOKED INTO RECALLS AND FOUND THAT THERE WAS A SERVICE BULLETIN REGARDING THESE SYMPTOMS. CALLED TOYOTA AND THEY TOOK MY…
Read full complaint
PURCHASED A USED 2014 TOYOTA RAV4 ON 01-2018 FOR THE PURCHASE PRICE OF $12,000. IT HAD 36,198 MILES AT THE TIME OF PURCHASE. APPROXIMATELY ONE YEAR AFTER PURCHASE, NOTICED A SHUTTERING WHILE AT CERTAIN SPEEDS. LOOKED INTO RECALLS AND FOUND THAT THERE WAS A SERVICE BULLETIN REGARDING THESE SYMPTOMS. CALLED TOYOTA AND THEY TOOK MY CAR'S INFORMATION. THEY SAID THAT MY CAR WAS 'ELIGIBLE' FOR THE REPAIRS TO BE DONE. HOWEVER, TOYOTA CALLED THE NEXT DAY AND SAID MY CAR DID NOT QUALIFY BECAUSE IT WAS A 'TOTAL LOSS' VEHICLE. I WAS SHOCKED TO HEAR THIS AS I PURCHASED IT WITH A BLUE TITLE. UPON FURTHER INVESTIGATION, I FOUND THE VEHICLE HAD HAIL DAMAGE AND THE INSURANCE COMPANY OPTED TO ISSUE A TOTAL LOSS CLAIM BUT DID NOT FEEL OBLIGATED TO BADGE THE TITLE AS SALVAGE. I FILED COMPLAINT WITH TEXAS BOARD OF INSURANCE BUT THEY HAVE BEEN NO HELP. MY QUESTION TO NHTSA IS HOW CAN TOYOTA REFUSE TO PERFORM WORK ON A VEHICLE THAT HAS A BLUE TITLE? IT HAS NEVER BEEN DEEMED OR BADGED AS SALVAGE AND YET I AM LEFT TO CONTINUE DRIVING A POSSIBLY UNSAFE VEHICLE THAT I PAID FULL MARKET PRICE FOR.
NHTSA ODI #11374185
83,098 miles · Oct 24, 2020
Air BagsStructureCrashInjury
AIRBAGS WERE NOT DEPLOYED AFTER A CRASH THAT LEFT THE CAR CONSIDERED A 'TOTAL LOSS'. THE CAR HIT A POLE AND THE AIRBAGS DID NOT DEPLOY AT ALL. CAUSING DRIVER TO INJURE FINGER AND MISS TIME FROM WORK.
NHTSA ODI #11366198
126,000 miles · Oct 10, 2020
Electrical SystemUnknown Or Other
I'VE HAD MULTIPLE ISSUES WITH THIS CAR. THE LOCK ACTUATORS ON ALL THE DOORS AND REAR HATCH CONSTANTLY BREAK, THE RADIO COMPLETELY STOPPED WORKING AND A NEW AFTER MARKET RADIO HAD TO BE INSTALLED SINCE TOYOTA WON'T RECALL THE RADIOS, THE AC BLOWER MOTOR KEEPS SHORTING OUT, AND THE USB PORTS SHORT OUT AND STOP WORKING.
NHTSA ODI #11363684
150,000 miles · Oct 5, 2020
Unknown Or Other
THE RADIO SCREEN ONLY DISPLAYS THE TOYOTA SIGN. IT WILL CHANGE STATIONS WITH THE PRE SET ON THE STEERING WHEEL BUT YOU CAN NOT DO ANYTHING ELSE CUZ THE SCREEN DOES NOT DISPLAY ANYTHING OTHER THAN THE TOYOTA SIGN.
NHTSA ODI #11362799
Mileage unknown · Aug 12, 2020
Unknown Or Other
RUSTING INSIDE VEHICLE AND BOLTS FOR HATCH BACK IS RUSTING OUT
NHTSA ODI #11348761
Mileage unknown · Aug 11, 2020
Seat Belts
TL* THE CONTACT OWNS A 2014 TOYOTA RAV4. THE CONTACT STATED WHILE THE VEHICLE WAS STATIONARY, THE FRONT PASSENGER'S SIDE SEAT BELT FAILED TO RETRACT. THE CONTACT STATED THAT THE SEAT BELT WARNING INDICATOR WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO LOCAL DEALER COAD TOYOTA LOCATED AT 357 SIEMERS DR, CAPE GIRARDEAU, MO 63701, (573…
Read full complaint
TL* THE CONTACT OWNS A 2014 TOYOTA RAV4. THE CONTACT STATED WHILE THE VEHICLE WAS STATIONARY, THE FRONT PASSENGER'S SIDE SEAT BELT FAILED TO RETRACT. THE CONTACT STATED THAT THE SEAT BELT WARNING INDICATOR WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO LOCAL DEALER COAD TOYOTA LOCATED AT 357 SIEMERS DR, CAPE GIRARDEAU, MO 63701, (573) 335-2927, WHERE IT WAS DIAGNOSED WITH NEEDING SEAT BELT ASSEMBLY TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED AS OF YET. THE MANUFACTURER HAD NOT BEEN INFORMED OF FAILURE. THE FAILURE MILEAGE WAS UNKNOWN. THE VIN WAS NOT AVAILABLE.
NHTSA ODI #11348617
Mileage unknown · Jul 16, 2020
Electrical SystemExterior Lighting
FUEL GAUGE LIGHT IS ON EMPTY BUT THE CAR HAS A FULL TANK
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2013-2018 RAV4 vehicles. Certain replacement 12-volt batteries may not fit properly in the battery tray, allowing the battery to move and contact the hold-down bracket, possibly causing a short circuit.
Consequence & remedy
Consequence: A battery short circuit increases the risk of a fire.
Remedy: Dealers will replace the battery clamp sub-assembly, battery tray, and positive terminal cover, free of charge. Owner letters were mailed December 27, 2024, to 2013-2014 RAV4 owners. Additional owner notification letters will be mailed in phases, phase 2 will begin on May 14, 2025, and phase 3 in late July 2025. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 23TB13 and 23TA13.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2015 Camry, Camry Hybrid, Highlander, and Highlander Hybrid, and 2014-2015 Rav4 vehicles. A component of the electric power steering (EPS) electronic control unit (ECU) may have been damaged during the manufacturing process. Over time, this damage may result in failure of the electric power steering system.
Consequence & remedy
Consequence: An unexpected loss of power steering increases the risk of a crash.
Remedy: Toyota will notify owners, and dealers will inspect the serial number of the EPS ECU or steering column assembly. If the number is within the affected range, the EPS ECU will be replaced, free of charge. The recall began on May 7, 2015. Owners may contact Toyota customer service at 1-800-331-4331.
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2013-2015 Toyota Rav4 vehicles manufactured June 1, 2013, to December 29, 2014, and equipped with an accessory trailer light module. The software within the module may incorrectly detect an electrical short and preventively turn off the electrical current and the trailer lights.
Consequence & remedy
Consequence: If the system incorrectly detects an electrical short and turns off the trailer lights while the trailer is being towed at night, there is an increased risk of a crash.
Remedy: SET will notify owners, and dealers will replace the trailer light module with a new unit with corrected software, free of charge. The recall began on March 17, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET-15A.
Additional source detail variants (2)
Trailer Hitches
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2013-2015 Toyota Rav4 vehicles manufactured June 1, 2013, to December 29, 2014, and equipped with an accessory trailer light module. The software within the module may incorrectly detect an electrical short and preventively turn off the electrical current and the trailer lights.
Consequence: If the system incorrectly detects an electrical short and turns off the trailer lights while the trailer is being towed at night, there is an increased risk of a crash.
Remedy: SET will notify owners, and dealers will replace the trailer light module with a new unit with corrected software, free of charge. The recall began on March 17, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET-15A.
Exterior Lighting
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2013-2015 Toyota Rav4 vehicles manufactured June 1, 2013, to December 29, 2014, and equipped with an accessory trailer light module. The software within the module may incorrectly detect an electrical short and preventively turn off the electrical current and the trailer lights.
Consequence: If the system incorrectly detects an electrical short and turns off the trailer lights while the trailer is being towed at night, there is an increased risk of a crash.
Remedy: SET will notify owners, and dealers will replace the trailer light module with a new unit with corrected software, free of charge. The recall began on March 17, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET-15A.
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2014-2015 Toyota 4Runner, Tacoma, FJ Cruiser, Land Cruiser, RAV4, Scion FRS, and XB vehicles. The affected vehicles may have accessories installed by SET, such as running boards or other items, that were incorrectly installed. The accessory attaching fasteners were not tightened with the proper torque, possibly causing the accessory to detach from the vehicle.
Consequence & remedy
Consequence: Accessories that detach from a vehicle may result in a vehicle crash and/or personal injury.
Remedy: SET will notify owners, and dealers will inspect and tighten the affected bolts, free of charge. The recall began February 23, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET-14B.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE21005 · Battery Hold Down Bracket Thermal Events
Opened Feb 25, 2021 · Closed Aug 12, 2024
Status: closed (inferred from source dates) · Electrical SYSTEM:12V/24V/48V Battery
The Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) to understand the contributing factors and frequency of vehicle fires originating from the battery region of the engine compartment in Model Year (MY) 2013-2018 Toyota RAV4 vehicles on 25 February 2021. At the time of opening, ODI attributed eleven allegations and additional EWR events to this PE. PE21005 focused on replacement batteries installed in the subject vehicles. No reported fire event identified in PE21005 involved the originally supplied 12V battery. The reported fires took place in vehicles known to contain aftermarket batteries or whose age exceeded the expected life of the original equipment battery. ODI identified battery dimensioning as it relates to the battery retention system (hold down bracket, radiator support bolt, J-hook, and battery tray) as the main factor set in the contact between the battery hold down bracket contacting the positive terminal of the 12V battery. The subject vehicles carried over the same battery tray and retention system from the prior generation (MY2006 – MY2012) of RAV4 vehicles. However, the subject vehicles were equipped with a dimensionally smaller battery (Group 35) than the prior generation (Group 24F). The smaller- length measurement in the Group 35 battery size in a battery tray originally designed to fit a Group 24F battery contributed to increased potential for battery movement which was exacerbated by the diversity in aftermarket battery configuration and irregularities intrinsic to battery replacement procedures. Battery movement coupled with the proximity of the B+ terminal on the battery and the grounded electrically conductive hold down bracket set the stage for a short to ground leading to an engine stall (if in operation) followed by a vehicle fire. This investigation was not able to classify the installation status, battery size, or cause of every allegation due to the fire event causing damage to the area, inaccessible vehicle, modification to the battery retention system after the event, and/or inconclusive photographic evidence. Toyota's investigation of the issue identified aftermarket battery catalogs that listed an improper battery replacement size (Group 26R) that would nevertheless fit into the subject vehicles whose battery retention system is incapable of reliably restraining a Group 26R battery. On 18 November 2021, Toyota initiated a consumer advisory campaign (21TG01) to the subject vehicle owners, notifying them of the correct size battery and offering a free inspection of the battery and retention hardware, a caution label to affix to the hold down bracket, and a discounted replacement 12V battery. This investigation with Toyota established three broad categories to characterize the battery retention system state of a given vehicle: "correct", "minor mis-installation", and "major mis-installation". - The "correct" terminology references the front bolt, bracket, and J-hook installed in a position not in contact with the positive battery terminal and the front bolt torqued to 17 Nm and the J-hook engaged with the tray hole and torqued to 4.9 Nm. - A "minor mis-installation" would describe the three retention components installed in the prescribed location, however not to the correct torque values. - The "major mis-installation" condition would constitute a retention component missing or disconnected from the system. Toyota's own testing used five exemplar batteries installed on a subject vehicle in each battery categorization resulted in: - Contact between the B+ terminal and hold down bracket in "major mis-installations" - Movement of the battery in "minor mis-installations" - No observable motion in "correct" installations. ODI conducted its own evaluation of the Toyota- specified replacement battery and 5 aftermarket Group 35 batteries. The six batteries tested conformed to the Group 35 Battery Council International (BCI) standard on overall dimensional tolerance and terminal location. That standard does not define the edge shape or material of battery casing. Physical interaction between the hold down bracket and the battery case and the friction between the casing material and the battery tray resulted in a large variability in movement forces required to incite movement when the battery was installed in the "correct" condition. Resulting in movement at an induced lateral load between 0.6 G and 1.91 G equivalent force across each battery. This force is higher than a typical vehicle could exert in a steady state turn and would only experience loads through brief shock or impulses. Multiple shock or impulse loads across time would contribute to a delay between the replacement battery installation and the fire event. Likelihood of a fire event increases as the installation method degraded from the "correct", to "minor mis-installation", and then to "major mis-installation". Protruding vent caps atop some of the batteries tested aided in restricting battery movement relative to the hold down. An absence of vent caps permitted additional movement. Following several discussions and vehicle inspections with ODI during this investigation, on 01 November 2023, Toyota filed a safety recall (NHTSA 23V-734) of 1,853,568 MY 2013 through MY 2018 Toyota RAV4 vehicles to reduce the risk of a vehicle fire with redesigned battery retention components. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration