NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
197 reportsMileage unknown · Nov 5, 2023
EngineUnknown Or Other
At least three time this happened while driving upon stopping at a stop sign or traffic light I was proceeding while making a turn after getting the clearance to do so. However the engine shut down and I was perplexed as to what was happening. I discovered the car had shut down and I had to restart the car. Additionally thi…
Read full complaint
At least three time this happened while driving upon stopping at a stop sign or traffic light I was proceeding while making a turn after getting the clearance to do so. However the engine shut down and I was perplexed as to what was happening. I discovered the car had shut down and I had to restart the car. Additionally this occurred at a stop sign, while trying to make a sharp turn the car once again shut off and I was in the middle of intresection and other cars were behind me, and other coming towards me and I realized this SUV had stopped running again, putting me in direct harms way.
NHTSA ODI #11553645
Mileage unknown · Sep 20, 2023
Electrical SystemSteeringFire
My daughter was exiting the the freeway on off ramp and turning right. The car lost electrical power without any warnings on dash or notification. When she tried to turn the steering wheel she was unable to due to loss of power steering. She ended up crossing a median and was able to turn the wheel enough to pull into the suici…
Read full complaint
My daughter was exiting the the freeway on off ramp and turning right. The car lost electrical power without any warnings on dash or notification. When she tried to turn the steering wheel she was unable to due to loss of power steering. She ended up crossing a median and was able to turn the wheel enough to pull into the suicide lane. She noticed the hood was smoking so she shut off the car and exited the vehicle. Soon the car engine area was in flames. Fire department put out the fire and police made and incident report. The car is unusable.
NHTSA ODI #11545735
120,000 miles · Sep 7, 2023
Power TrainFire
The contact owned a 2014 Toyota Rav4. The contact stated while driving 25 MPH, it was noticed that there was smoke coming from under the hood of the vehicle, and the vehicle lost motive power. The contact arrived at the residence and the vehicle burst into flames causing the rear of another vehicle to melt. The fire department w…
Read full complaint
The contact owned a 2014 Toyota Rav4. The contact stated while driving 25 MPH, it was noticed that there was smoke coming from under the hood of the vehicle, and the vehicle lost motive power. The contact arrived at the residence and the vehicle burst into flames causing the rear of another vehicle to melt. The fire department was able to extinguish the fire. A police report was filed. No one was injured. The vehicle was not towed or diagnosed. The dealer was not contacted. The manufacturer was not contacted. The failure mileage was 120,000.
NHTSA ODI #11543080
Mileage unknown · Aug 31, 2023
Power Train
WHEN I FIRST BOUGHT THIS USED CAR WITH AROUND 90000 MILES IT STARTED VIBRATING WHICH LED TO DISCOVERING DRIVE SHAFT REPLACEMENT. ONE YEAR LATER IT NEEDS ANOTHER DRIVE SHAFT AT 118000. DOESNT GET DRIVEN MUCH IN WINTER. NOTICED CAR SHIFTED INTO A LOWER GEAR WHILE DESCENDING DOWN A STEEP HILL WHILE I WAS TRAVELING AT A HIGHER RATE …
Read full complaint
WHEN I FIRST BOUGHT THIS USED CAR WITH AROUND 90000 MILES IT STARTED VIBRATING WHICH LED TO DISCOVERING DRIVE SHAFT REPLACEMENT. ONE YEAR LATER IT NEEDS ANOTHER DRIVE SHAFT AT 118000. DOESNT GET DRIVEN MUCH IN WINTER. NOTICED CAR SHIFTED INTO A LOWER GEAR WHILE DESCENDING DOWN A STEEP HILL WHILE I WAS TRAVELING AT A HIGHER RATE AND HAD TO APPLY BRAKES QUICKLY TO MATCH THE LOWER GEAR. I FELT THIS COULD HAVE CAUSED A PROBLEM IN CAR HANDLING OR DRIVE TRAIN REPAIR. THE REPAIR IS EXPECTED TO COST $550 TO REPLACE THIS SECOND DRIVE SHAFT. PARTS DEALER SAID HE SOLD LOTS OF THESE. I THINK SOMETHING IS WRONG
NHTSA ODI #11541821
Mileage unknown · Aug 4, 2023
Electrical SystemEngineFire
Parked my vehicle 2014 Rav4 at work, went to my office and security called that my Toyota rav4 burst into flames. All caught on video. Sprinklers went off and fire department called. Fire started under the hood. Entire Engine compartment burned. Vehicle totaled.
NHTSA ODI #11536539
Mileage unknown · Jun 6, 2023
Steering
I purchased a 2014 RAV4 this past April from a private owner in Daytona Beach, Fla. Everything seemed to be fine and checked out on the test drive both me and my husband took for a spin. I noticed once I got it on the road and onto the highway the sterling wheel seemed very stiff, and I could hear a slight clicking noise. My …
Read full complaint
I purchased a 2014 RAV4 this past April from a private owner in Daytona Beach, Fla. Everything seemed to be fine and checked out on the test drive both me and my husband took for a spin. I noticed once I got it on the road and onto the highway the sterling wheel seemed very stiff, and I could hear a slight clicking noise. My husband thought it needed new tires since the ones on vehicle were pretty worn. Well, we replaced four tires, and the problem is still there. As I drove the car, I realized it was difficult to drive and keep in a lane. I feel the car as it is is dangerous to drive and it is NOT a comfortable car to drive. I have owned three other Toyota's two Camry's and a Rav 4. I would still be driving my Rav 4 if it weren't for an elderly man hitting my car and it was totaled by the insurance. I looked at several vehicles before I came across this Rav 4. I wish I never did, big mistake.. I always praised Toyota because of the dependability of the vehicles' I don't feel that way anymore. I have been in touch with Toyota Motor Corp., and they offered me NOTHING. I don't qualify for a Recall or extended warranty even though it is a safety issue. What the Toyota dealer here in Florida offered me was a repair bill for $3.000.00 which I cannot afford to have fixed right now. So now I'm stuck with a car that I'm afraid to drive because it has a mind of its own and I am afraid I could end up in a ditch. Thank You Toyota I will never buy again. I am very disappointed in Toyota and the lack of support from Toyota Corp. This has definitely changed my mind about Toyota. I should have bought American, and it would have cost less. Very unhappy Customer not that Toyota cares.
NHTSA ODI #11525658
Mileage unknown · May 24, 2023
Electrical System
The multimedia screen has been stuck in a powering up/loading cycle but would not able to complete the loading cycle, so none of the multimedia functions (radio, DVD Player, Bluetooth, GPS, etc.) would be able to function. This happened to me in early 2023. Over the past months, I have searched similar issues and possible fixe…
Read full complaint
The multimedia screen has been stuck in a powering up/loading cycle but would not able to complete the loading cycle, so none of the multimedia functions (radio, DVD Player, Bluetooth, GPS, etc.) would be able to function. This happened to me in early 2023. Over the past months, I have searched similar issues and possible fixes on the internet, but seems no easy fixes, while reported dealer repair estimates for $800+. A Google search shows many similar problems with RAV4 from their 2013 model year on. One Youtube viedeo "Rav4 radio stuck in boot loop" has had 10,000 views as of today, May 23, 2023.
NHTSA ODI #11523582
Mileage unknown · Feb 24, 2023
Unknown Or OtherFire
i have just driven the car for about 15 minutes and pulled in a driveway to wait for someone. My car was in park but running, and white smoke started to come out from under the hood. I turned the car off and got out. I walked around to the front of the car and it immediately went up in flames. I called 911 and a police car jus…
Read full complaint
i have just driven the car for about 15 minutes and pulled in a driveway to wait for someone. My car was in park but running, and white smoke started to come out from under the hood. I turned the car off and got out. I walked around to the front of the car and it immediately went up in flames. I called 911 and a police car just happened to be going by and called the fire department. They block off the street and put out the fire but the car was completely trashed.
NHTSA ODI #11508849
Mileage unknown · Feb 16, 2023
Unknown Or Other
My car was glitching and stuttering, then one day the transmission did not engage and the car would not move forward or in reverse. This only happened one time, we were told it is not the transmission, it is the torque converter. I checked on this NTHSA site and found that many Rav4s throughout the years have had torque convert…
Read full complaint
My car was glitching and stuttering, then one day the transmission did not engage and the car would not move forward or in reverse. This only happened one time, we were told it is not the transmission, it is the torque converter. I checked on this NTHSA site and found that many Rav4s throughout the years have had torque converter problems and that the warranty has been extended.
NHTSA ODI #11507612
70,000 miles · Feb 9, 2023
Equipment
The contact owns a 2014 Toyota Rav4. The contact stated while driving 10 MPH, the infotainment system started to reset independently. The contact pulled over, turned off, and restarted the vehicle and the vehicle operated normally. The dealer was contacted and stated that there was no recall on the VIN for the failure. The manuf…
Read full complaint
The contact owns a 2014 Toyota Rav4. The contact stated while driving 10 MPH, the infotainment system started to reset independently. The contact pulled over, turned off, and restarted the vehicle and the vehicle operated normally. The dealer was contacted and stated that there was no recall on the VIN for the failure. The manufacturer was contacted and also stated that there was no recall on the VIN for the failure. The failure mileage was 70,000.
NHTSA ODI #11506385
Official recalls
4Nov 1, 2023
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2013-2018 RAV4 vehicles. Certain replacement 12-volt batteries may not fit properly in the battery tray, allowing the battery to move and contact the hold-down bracket, possibly causing a short circuit.
Consequence & remedy
Consequence: A battery short circuit increases the risk of a fire.
Remedy: Dealers will replace the battery clamp sub-assembly, battery tray, and positive terminal cover, free of charge. Owner letters were mailed December 27, 2024, to 2013-2014 RAV4 owners. Additional owner notification letters will be mailed in phases, phase 2 will begin on May 14, 2025, and phase 3 in late July 2025. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 23TB13 and 23TA13.
Mar 13, 2015
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2015 Camry, Camry Hybrid, Highlander, and Highlander Hybrid, and 2014-2015 Rav4 vehicles. A component of the electric power steering (EPS) electronic control unit (ECU) may have been damaged during the manufacturing process. Over time, this damage may result in failure of the electric power steering system.
Consequence & remedy
Consequence: An unexpected loss of power steering increases the risk of a crash.
Remedy: Toyota will notify owners, and dealers will inspect the serial number of the EPS ECU or steering column assembly. If the number is within the affected range, the EPS ECU will be replaced, free of charge. The recall began on May 7, 2015. Owners may contact Toyota customer service at 1-800-331-4331.
Jan 16, 2015
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2013-2015 Toyota Rav4 vehicles manufactured June 1, 2013, to December 29, 2014, and equipped with an accessory trailer light module. The software within the module may incorrectly detect an electrical short and preventively turn off the electrical current and the trailer lights.
Consequence & remedy
Consequence: If the system incorrectly detects an electrical short and turns off the trailer lights while the trailer is being towed at night, there is an increased risk of a crash.
Remedy: SET will notify owners, and dealers will replace the trailer light module with a new unit with corrected software, free of charge. The recall began on March 17, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET-15A.
Additional source detail variants (2)
Trailer Hitches
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2013-2015 Toyota Rav4 vehicles manufactured June 1, 2013, to December 29, 2014, and equipped with an accessory trailer light module. The software within the module may incorrectly detect an electrical short and preventively turn off the electrical current and the trailer lights.
Consequence: If the system incorrectly detects an electrical short and turns off the trailer lights while the trailer is being towed at night, there is an increased risk of a crash.
Remedy: SET will notify owners, and dealers will replace the trailer light module with a new unit with corrected software, free of charge. The recall began on March 17, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET-15A.
Exterior Lighting
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2013-2015 Toyota Rav4 vehicles manufactured June 1, 2013, to December 29, 2014, and equipped with an accessory trailer light module. The software within the module may incorrectly detect an electrical short and preventively turn off the electrical current and the trailer lights.
Consequence: If the system incorrectly detects an electrical short and turns off the trailer lights while the trailer is being towed at night, there is an increased risk of a crash.
Remedy: SET will notify owners, and dealers will replace the trailer light module with a new unit with corrected software, free of charge. The recall began on March 17, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET-15A.
Dec 30, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2014-2015 Toyota 4Runner, Tacoma, FJ Cruiser, Land Cruiser, RAV4, Scion FRS, and XB vehicles. The affected vehicles may have accessories installed by SET, such as running boards or other items, that were incorrectly installed. The accessory attaching fasteners were not tightened with the proper torque, possibly causing the accessory to detach from the vehicle.
Consequence & remedy
Consequence: Accessories that detach from a vehicle may result in a vehicle crash and/or personal injury.
Remedy: SET will notify owners, and dealers will inspect and tighten the affected bolts, free of charge. The recall began February 23, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET-14B.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE21005 · Battery Hold Down Bracket Thermal Events
Opened Feb 25, 2021 · Closed Aug 12, 2024
Status: closed (inferred from source dates) · Electrical SYSTEM:12V/24V/48V Battery
The Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) to understand the contributing factors and frequency of vehicle fires originating from the battery region of the engine compartment in Model Year (MY) 2013-2018 Toyota RAV4 vehicles on 25 February 2021. At the time of opening, ODI attributed eleven allegations and additional EWR events to this PE. PE21005 focused on replacement batteries installed in the subject vehicles. No reported fire event identified in PE21005 involved the originally supplied 12V battery. The reported fires took place in vehicles known to contain aftermarket batteries or whose age exceeded the expected life of the original equipment battery. ODI identified battery dimensioning as it relates to the battery retention system (hold down bracket, radiator support bolt, J-hook, and battery tray) as the main factor set in the contact between the battery hold down bracket contacting the positive terminal of the 12V battery. The subject vehicles carried over the same battery tray and retention system from the prior generation (MY2006 – MY2012) of RAV4 vehicles. However, the subject vehicles were equipped with a dimensionally smaller battery (Group 35) than the prior generation (Group 24F). The smaller- length measurement in the Group 35 battery size in a battery tray originally designed to fit a Group 24F battery contributed to increased potential for battery movement which was exacerbated by the diversity in aftermarket battery configuration and irregularities intrinsic to battery replacement procedures. Battery movement coupled with the proximity of the B+ terminal on the battery and the grounded electrically conductive hold down bracket set the stage for a short to ground leading to an engine stall (if in operation) followed by a vehicle fire. This investigation was not able to classify the installation status, battery size, or cause of every allegation due to the fire event causing damage to the area, inaccessible vehicle, modification to the battery retention system after the event, and/or inconclusive photographic evidence. Toyota's investigation of the issue identified aftermarket battery catalogs that listed an improper battery replacement size (Group 26R) that would nevertheless fit into the subject vehicles whose battery retention system is incapable of reliably restraining a Group 26R battery. On 18 November 2021, Toyota initiated a consumer advisory campaign (21TG01) to the subject vehicle owners, notifying them of the correct size battery and offering a free inspection of the battery and retention hardware, a caution label to affix to the hold down bracket, and a discounted replacement 12V battery. This investigation with Toyota established three broad categories to characterize the battery retention system state of a given vehicle: "correct", "minor mis-installation", and "major mis-installation". - The "correct" terminology references the front bolt, bracket, and J-hook installed in a position not in contact with the positive battery terminal and the front bolt torqued to 17 Nm and the J-hook engaged with the tray hole and torqued to 4.9 Nm. - A "minor mis-installation" would describe the three retention components installed in the prescribed location, however not to the correct torque values. - The "major mis-installation" condition would constitute a retention component missing or disconnected from the system. Toyota's own testing used five exemplar batteries installed on a subject vehicle in each battery categorization resulted in: - Contact between the B+ terminal and hold down bracket in "major mis-installations" - Movement of the battery in "minor mis-installations" - No observable motion in "correct" installations. ODI conducted its own evaluation of the Toyota- specified replacement battery and 5 aftermarket Group 35 batteries. The six batteries tested conformed to the Group 35 Battery Council International (BCI) standard on overall dimensional tolerance and terminal location. That standard does not define the edge shape or material of battery casing. Physical interaction between the hold down bracket and the battery case and the friction between the casing material and the battery tray resulted in a large variability in movement forces required to incite movement when the battery was installed in the "correct" condition. Resulting in movement at an induced lateral load between 0.6 G and 1.91 G equivalent force across each battery. This force is higher than a typical vehicle could exert in a steady state turn and would only experience loads through brief shock or impulses. Multiple shock or impulse loads across time would contribute to a delay between the replacement battery installation and the fire event. Likelihood of a fire event increases as the installation method degraded from the "correct", to "minor mis-installation", and then to "major mis-installation". Protruding vent caps atop some of the batteries tested aided in restricting battery movement relative to the hold down. An absence of vent caps permitted additional movement. Following several discussions and vehicle inspections with ODI during this investigation, on 01 November 2023, Toyota filed a safety recall (NHTSA 23V-734) of 1,853,568 MY 2013 through MY 2018 Toyota RAV4 vehicles to reduce the risk of a vehicle fire with redesigned battery retention components. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration