Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
870–25K
2325–50K
2150–75K
1275–100K
12100–150K
6150K+
161 reports with mileage · 96 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Electrical System. Review the 75 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 29 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 29 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
22 crash reports29 fire reports11 injury reports
What owners actually said
257 reports
Mileage unknown · Jul 3, 2025
Structure
The paint on the roof of my 2013 Toyota Rav4 has begun to peel (delaminate). I first noticed it in May 2025. More recently, in June, while driving I saw in my rearview mirror what was clearly a chunk of white paint fall off the blowing from the top of my vehicle behind me - which is poses a safety hazard on the road. There are…
Read full complaint
The paint on the roof of my 2013 Toyota Rav4 has begun to peel (delaminate). I first noticed it in May 2025. More recently, in June, while driving I saw in my rearview mirror what was clearly a chunk of white paint fall off the blowing from the top of my vehicle behind me - which is poses a safety hazard on the road. There are two areas on the roof now peeling. One is about 8inches in diameter (which has grown since May) and the newest area peeling and flaking/flying off is 1 foot long and 4 to 5 inches wide. Areas of the roof where the paint has peeled are beginning to rust and compromise the integrity of the body. I contacted Toyota twice recently regarding my case (#250701000710) which is considered closed. Two representatives said they were sorry I was having this issue but advised that I would have to go to a dealer and take care of it myself. Please be aware that there was a prior/known paint peeling issue that affected cars in blizzard/pearl white (which my car is). They offered what was called a "goodwill service" at the time under which they only paid to repaint any areas of the car that were already peeling at the time. The body of my car had many large areas of peeled paint that were repainted. However, the "goodwill service" program has since expired but now the roof is peeling. So, even though aware that the painting was flawed and prone to significant peeling they did not repaint affected vehicles as a whole and so it appears this issue has resurfaced.
NHTSA ODI #11670993
Mileage unknown · Jun 18, 2025
Electrical System
The dealer, Toyota of Chula Vista insists that i pay for the recall of the battery they had my car all day yesterday first they lied battery not available then they quoted me $337
NHTSA ODI #11667758
Mileage unknown · Apr 15, 2025
Electrical System
The contact owns a 2013 Toyota RAV4. The contact received notification of NHTSA Campaign Number: 23V734000 (ELECTRICAL SYSTEM); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the…
Read full complaint
The contact owns a 2013 Toyota RAV4. The contact received notification of NHTSA Campaign Number: 23V734000 (ELECTRICAL SYSTEM); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
NHTSA ODI #11654712
Mileage unknown · Mar 11, 2025
Structure
I am reporting a paint peeling issue on my 2013 Toyota RAV4 Limited that has the potential to be a safety hazard. Large sections of paint have peeled off, exposing bare metal on the hood, roof, and/or doors, and I am concerned about its impact on visibility, corrosion, and potential flying debris while driving. 1.Visibility Obst…
Read full complaint
I am reporting a paint peeling issue on my 2013 Toyota RAV4 Limited that has the potential to be a safety hazard. Large sections of paint have peeled off, exposing bare metal on the hood, roof, and/or doors, and I am concerned about its impact on visibility, corrosion, and potential flying debris while driving. 1.Visibility Obstruction & Glare Risk: The paint on my hood is peeling off in patches, causing sun glare and reflection issues that impair my ability to see the road under certain lighting conditions. This is particularly dangerous during sunrise, sunset, or nighttime driving under streetlights. 2.Risk of Corrosion Leading to Structural Integrity Issues: With the bare metal exposed, the affected areas are at risk of rusting and corrosion, which could weaken the vehicle’s structure. If left untreated, corrosion could affect critical safety components such as the hood latch or airbag crash sensors located behind painted surfaces. 3.Potential for Peeling Paint to Become Road Debris: While driving at highway speeds, I have noticed paint flaking off and flying away. This could become a hazard to other vehicles, especially for motorcyclists or drivers behind me who could be hit by the debris. 4.Compromised Vehicle Visibility to Other Drivers: The exposed, uneven patches of primer and metal create an irregular surface, which could affect how my vehicle is seen by others, especially in low-light conditions. This may increase the risk of rear-end collisions due to diminished contrast. Toyota Response: Toyota previously acknowledged this issue with a Warranty Enhancement Program (WEP ZKG) for peeling paint, but I was informed that my vehicle is one year past the extended coverage period. Despite the defect being well-documented, Toyota has refused to assist. This is not just a cosmetic issue—it has clear safety implications. I urge NHTSA to investigate this problem further to determine if additional action is needed.
NHTSA ODI #11647732
Mileage unknown · Mar 11, 2025
Electrical SystemFire
Car started cutting on and off then battery caught fire while driving. The battery is still in the vehicle. Car was inspected by Victory Toyota of Brook Park. There were no warning lamps or messages before the incident occurred.
NHTSA ODI #11647656
Mileage unknown · Feb 25, 2025
Electrical System
See attached document for complaint.
NHTSA ODI #11644710
Mileage unknown · Feb 24, 2025
Electrical System
The contact owns a 2013 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (ELECTRICAL SYSTEM); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. …
Read full complaint
The contact owns a 2013 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (ELECTRICAL SYSTEM); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. The contact was not pleased with paying for the repair of the vehicle and then being reimbursed for the recall repair. Parts distribution disconnect.
NHTSA ODI #11644531
Mileage unknown · Feb 5, 2025
Electrical System
This recall has been an open, unresolved issue for more than 1 year. Finally Toyota has offered me a repair for this issue, but they are charging me an extra $250 to replace the car battery, which is perfectly functional. Without replacing the battery they would not complete the recall. So unfair as this was their issue to begin…
Read full complaint
This recall has been an open, unresolved issue for more than 1 year. Finally Toyota has offered me a repair for this issue, but they are charging me an extra $250 to replace the car battery, which is perfectly functional. Without replacing the battery they would not complete the recall. So unfair as this was their issue to begin with!
NHTSA ODI #11640862
Mileage unknown · Jan 23, 2025
Power Train
The vehicle shudders significantly when accelerating/cruising between 35-45 mph. The shudder started slight and did not pose an issue for a while, but now its significant enough that is causes erratic steering. The vehicle waved back and forth from the vibration yesterday and went across the median line into oncoming traffic. …
Read full complaint
The vehicle shudders significantly when accelerating/cruising between 35-45 mph. The shudder started slight and did not pose an issue for a while, but now its significant enough that is causes erratic steering. The vehicle waved back and forth from the vibration yesterday and went across the median line into oncoming traffic. I was able to regain control and accelerated through past 45 mph when the vibration receded. After calling Toyota I learned that Toyota knew about this issue and the a faulty torque converter was to blame. There was no recall or notification just (as the dealer explained, an extended warranty). Since I was not "notified" I did not know of this dangerous exposure and missed the time period to get the convertor replaced by Toyota.
NHTSA ODI #11638027
Mileage unknown · Jan 17, 2025
Unknown Or Other
There is a large amount of peeling paint on the roof and front side panels of the car that started on 1/9/25. Toyota says they had a recall but that it expired. I brought the car to the dealer where it was original purchased (by the previous owner) and they completed a paint inspection and found "excessive paint peeling" but the…
Read full complaint
There is a large amount of peeling paint on the roof and front side panels of the car that started on 1/9/25. Toyota says they had a recall but that it expired. I brought the car to the dealer where it was original purchased (by the previous owner) and they completed a paint inspection and found "excessive paint peeling" but they are not willing to do anything. I called Toyota customer care but they have denied and closed my case (case #250109001939). There is at least a 2 foot section on the roof where the paint just peeled off and blew away. Without the paint the car will rust and become unsafe.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2013-2018 RAV4 vehicles. Certain replacement 12-volt batteries may not fit properly in the battery tray, allowing the battery to move and contact the hold-down bracket, possibly causing a short circuit.
Consequence & remedy
Consequence: A battery short circuit increases the risk of a fire.
Remedy: Dealers will replace the battery clamp sub-assembly, battery tray, and positive terminal cover, free of charge. Owner letters were mailed December 27, 2024, to 2013-2014 RAV4 owners. Additional owner notification letters will be mailed in phases, phase 2 will begin on May 14, 2025, and phase 3 in late July 2025. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 23TB13 and 23TA13.
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2013-2015 Toyota Rav4 vehicles manufactured June 1, 2013, to December 29, 2014, and equipped with an accessory trailer light module. The software within the module may incorrectly detect an electrical short and preventively turn off the electrical current and the trailer lights.
Consequence & remedy
Consequence: If the system incorrectly detects an electrical short and turns off the trailer lights while the trailer is being towed at night, there is an increased risk of a crash.
Remedy: SET will notify owners, and dealers will replace the trailer light module with a new unit with corrected software, free of charge. The recall began on March 17, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET-15A.
Additional source detail variants (2)
Trailer Hitches
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2013-2015 Toyota Rav4 vehicles manufactured June 1, 2013, to December 29, 2014, and equipped with an accessory trailer light module. The software within the module may incorrectly detect an electrical short and preventively turn off the electrical current and the trailer lights.
Consequence: If the system incorrectly detects an electrical short and turns off the trailer lights while the trailer is being towed at night, there is an increased risk of a crash.
Remedy: SET will notify owners, and dealers will replace the trailer light module with a new unit with corrected software, free of charge. The recall began on March 17, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET-15A.
Exterior Lighting
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2013-2015 Toyota Rav4 vehicles manufactured June 1, 2013, to December 29, 2014, and equipped with an accessory trailer light module. The software within the module may incorrectly detect an electrical short and preventively turn off the electrical current and the trailer lights.
Consequence: If the system incorrectly detects an electrical short and turns off the trailer lights while the trailer is being towed at night, there is an increased risk of a crash.
Remedy: SET will notify owners, and dealers will replace the trailer light module with a new unit with corrected software, free of charge. The recall began on March 17, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET-15A.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE21005 · Battery Hold Down Bracket Thermal Events
Opened Feb 25, 2021 · Closed Aug 12, 2024
Status: closed (inferred from source dates) · Electrical SYSTEM:12V/24V/48V Battery
The Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) to understand the contributing factors and frequency of vehicle fires originating from the battery region of the engine compartment in Model Year (MY) 2013-2018 Toyota RAV4 vehicles on 25 February 2021. At the time of opening, ODI attributed eleven allegations and additional EWR events to this PE. PE21005 focused on replacement batteries installed in the subject vehicles. No reported fire event identified in PE21005 involved the originally supplied 12V battery. The reported fires took place in vehicles known to contain aftermarket batteries or whose age exceeded the expected life of the original equipment battery. ODI identified battery dimensioning as it relates to the battery retention system (hold down bracket, radiator support bolt, J-hook, and battery tray) as the main factor set in the contact between the battery hold down bracket contacting the positive terminal of the 12V battery. The subject vehicles carried over the same battery tray and retention system from the prior generation (MY2006 – MY2012) of RAV4 vehicles. However, the subject vehicles were equipped with a dimensionally smaller battery (Group 35) than the prior generation (Group 24F). The smaller- length measurement in the Group 35 battery size in a battery tray originally designed to fit a Group 24F battery contributed to increased potential for battery movement which was exacerbated by the diversity in aftermarket battery configuration and irregularities intrinsic to battery replacement procedures. Battery movement coupled with the proximity of the B+ terminal on the battery and the grounded electrically conductive hold down bracket set the stage for a short to ground leading to an engine stall (if in operation) followed by a vehicle fire. This investigation was not able to classify the installation status, battery size, or cause of every allegation due to the fire event causing damage to the area, inaccessible vehicle, modification to the battery retention system after the event, and/or inconclusive photographic evidence. Toyota's investigation of the issue identified aftermarket battery catalogs that listed an improper battery replacement size (Group 26R) that would nevertheless fit into the subject vehicles whose battery retention system is incapable of reliably restraining a Group 26R battery. On 18 November 2021, Toyota initiated a consumer advisory campaign (21TG01) to the subject vehicle owners, notifying them of the correct size battery and offering a free inspection of the battery and retention hardware, a caution label to affix to the hold down bracket, and a discounted replacement 12V battery. This investigation with Toyota established three broad categories to characterize the battery retention system state of a given vehicle: "correct", "minor mis-installation", and "major mis-installation". - The "correct" terminology references the front bolt, bracket, and J-hook installed in a position not in contact with the positive battery terminal and the front bolt torqued to 17 Nm and the J-hook engaged with the tray hole and torqued to 4.9 Nm. - A "minor mis-installation" would describe the three retention components installed in the prescribed location, however not to the correct torque values. - The "major mis-installation" condition would constitute a retention component missing or disconnected from the system. Toyota's own testing used five exemplar batteries installed on a subject vehicle in each battery categorization resulted in: - Contact between the B+ terminal and hold down bracket in "major mis-installations" - Movement of the battery in "minor mis-installations" - No observable motion in "correct" installations. ODI conducted its own evaluation of the Toyota- specified replacement battery and 5 aftermarket Group 35 batteries. The six batteries tested conformed to the Group 35 Battery Council International (BCI) standard on overall dimensional tolerance and terminal location. That standard does not define the edge shape or material of battery casing. Physical interaction between the hold down bracket and the battery case and the friction between the casing material and the battery tray resulted in a large variability in movement forces required to incite movement when the battery was installed in the "correct" condition. Resulting in movement at an induced lateral load between 0.6 G and 1.91 G equivalent force across each battery. This force is higher than a typical vehicle could exert in a steady state turn and would only experience loads through brief shock or impulses. Multiple shock or impulse loads across time would contribute to a delay between the replacement battery installation and the fire event. Likelihood of a fire event increases as the installation method degraded from the "correct", to "minor mis-installation", and then to "major mis-installation". Protruding vent caps atop some of the batteries tested aided in restricting battery movement relative to the hold down. An absence of vent caps permitted additional movement. Following several discussions and vehicle inspections with ODI during this investigation, on 01 November 2023, Toyota filed a safety recall (NHTSA 23V-734) of 1,853,568 MY 2013 through MY 2018 Toyota RAV4 vehicles to reduce the risk of a vehicle fire with redesigned battery retention components. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration