NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
29 reportsClear category filterMileage unknown · Oct 14, 2025
Engine
Over the course of the past two days, 2013 Toyota RAV4 has engine cut-off while moving on surface streets, tollroads, and Interstate Highways. Thus far, this has occurred 9 times without any warning whatsoever. Car is in otherwise fine mechanical condition, with all four new tires, new brake rotors & ceramic brake pads, new ba…
Read full complaint
Over the course of the past two days, 2013 Toyota RAV4 has engine cut-off while moving on surface streets, tollroads, and Interstate Highways. Thus far, this has occurred 9 times without any warning whatsoever. Car is in otherwise fine mechanical condition, with all four new tires, new brake rotors & ceramic brake pads, new battery & cables inspection, professional throttle body cleaning, 5,000 mile full-synthetic oil change & oil filter, new engine air filter, and all features and functions in what was known as 100% condition with no Engine Fault indicator on or subsequent OBD II codes. Yet it stalls at all speeds, including street traffic speeds and cruise at 70mpg. No indication whatsoever.
NHTSA ODI #11693382
Mileage unknown · Oct 29, 2024
EngineFire
I was traveling south on [XXX] when the vehicle stalled. I started the engine and proceeded. I noticed my Rav4 smoking from the engine so I turned off into a Extra Space Storage parking at 1415 Bergen Boulevard, Fort Lee N.J. 07024 were it stalled again. I then exited the vehicle and opened the hood and observed a burst flames …
Read full complaint
I was traveling south on [XXX] when the vehicle stalled. I started the engine and proceeded. I noticed my Rav4 smoking from the engine so I turned off into a Extra Space Storage parking at 1415 Bergen Boulevard, Fort Lee N.J. 07024 were it stalled again. I then exited the vehicle and opened the hood and observed a burst flames coming from the engine/battery area. I ran to a Wendy's and asked for a fire extinguisher, but the fire escalated rapidly, burning the entire interior and exterior of the vehicle. It was towed to Sanos Towing Company 344 Bergen Blvd. Palisades Park. N.J. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11622497
Mileage unknown · Jun 4, 2024
Electrical SystemEngineFire
I had a 2013 Rav4, while i was driving the car the car started a fire under the hood and burn completely up. Im trying to file a complaint or talk to someone discussing this matter. Toyota says I need to file a bad faith complaint.
NHTSA ODI #11592405
Mileage unknown · Dec 29, 2023
EngineFire
Pulled into driveway, turned off car. Entered house within a couple of minutes front end of car burst into flames. Fire Dept. was called to put out fire. Car was towed to Newburgh NY for insurance adjustor inspection. I was on my way to store and stopped at in-laws. Had I not made this stop, I would have been on thruway. If…
Read full complaint
Pulled into driveway, turned off car. Entered house within a couple of minutes front end of car burst into flames. Fire Dept. was called to put out fire. Car was towed to Newburgh NY for insurance adjustor inspection. I was on my way to store and stopped at in-laws. Had I not made this stop, I would have been on thruway. If car had been a few feet closer to garage, it would have set the garage, with car inside, on fire, and house. Car in garage could have exploded (gas tank). The recall was received days prior to incident, and indicated remedy would be ready in June 2024. Police and Fire Dept were called, insurance reps, I believe have inspected the car. It was towed and I did not meet with insurance rep. There were no warning lights or problems, passed inspection in August 2023. Police Incident Rep #[XXX], 12/20/23, 12:05 p.m. Yonkers PD INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11562628
Mileage unknown · Jul 3, 2023
EngineUnknown Or Other
Car jerks when shifts gears and the problem just appeared one day with no warning. I went to 4 different mechanics and none can confirm if there is metal in transmission but to solely tell the transmission needs to be replaced. Either defective transmission or another problem not related causing jerking in driving.
NHTSA ODI #11530146
Mileage unknown · Jan 1, 2023
Electrical SystemEngineFire
I was driving back home with my kids on 12/31/22 as usual, car suddenly turned off. The engine then caught fire within 2 min of turning off, the whole car was on fire within 8 min.
NHTSA ODI #11499684
Mileage unknown · Apr 28, 2022
Electrical SystemEngineStructureFire
I turned the key and started the RAV4 parked in my driveway. It immediately made unusual noices (gurgling, spitting, etc.). Within a minute, there was a loud "BOOM" under the hood and fire began coming out from underneath the car. I got out of the car and got a safe distance from it. My neighbors came running over as they he…
Read full complaint
I turned the key and started the RAV4 parked in my driveway. It immediately made unusual noices (gurgling, spitting, etc.). Within a minute, there was a loud "BOOM" under the hood and fire began coming out from underneath the car. I got out of the car and got a safe distance from it. My neighbors came running over as they heard subsequent explosions and saw black smoke billowing from my direction. Within a matter of a few minutes, the entire car was engulfed in flames. The fire department came and extinguished it. There is nothing left! BTW, I am 91 years old. This could have had a very different and sad outcome!
NHTSA ODI #11462559
Mileage unknown · Mar 21, 2022
Engine
While driving , the dashboard lights start flicker off first as a warning before the entire car shuts completely down. The car was start having those issues back in 2014 and delaer told us it was the battery negative wire that causing the issue. Suddenly, it start doing the same thing and in my opinion very dangerous to drive on…
Read full complaint
While driving , the dashboard lights start flicker off first as a warning before the entire car shuts completely down. The car was start having those issues back in 2014 and delaer told us it was the battery negative wire that causing the issue. Suddenly, it start doing the same thing and in my opinion very dangerous to drive on street and highways. No one wnats to have a car that just suddenly stalled on highway.
NHTSA ODI #11457691
Mileage unknown · Feb 15, 2022
Engine
car is consuming 2 Quarts of oil in a very short time.
NHTSA ODI #11452123
63,000 miles · Jan 28, 2022
EngineFire
The contact owned a 2013 Toyota RAV-4. The contact stated that while his daughter was driving at an unknown speed, she detected a burning odor inside the vehicle as smoke was coming through the vents. As well as flames from under the hood. The contact's daughter pulled and stopped upon exiting the vehicle the front was engulfed …
Read full complaint
The contact owned a 2013 Toyota RAV-4. The contact stated that while his daughter was driving at an unknown speed, she detected a burning odor inside the vehicle as smoke was coming through the vents. As well as flames from under the hood. The contact's daughter pulled and stopped upon exiting the vehicle the front was engulfed in flames. The fire department was called and extinguished the fire. A fire department report was not filed nor a police department was not filed as they were on the scene. The vehicle was towed to the contact's residence. The vehicle was not diagnosed by a dealer or an independent mechanic. The insurance company deemed the vehicle a total loss. The manufacturer was notified and a case was opened. The contact stated researched failure online and found an investigation by NHTSA. The approximate failure mileage was 63,000.
NHTSA ODI #11449223
Official recalls
2Nov 1, 2023
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2013-2018 RAV4 vehicles. Certain replacement 12-volt batteries may not fit properly in the battery tray, allowing the battery to move and contact the hold-down bracket, possibly causing a short circuit.
Consequence & remedy
Consequence: A battery short circuit increases the risk of a fire.
Remedy: Dealers will replace the battery clamp sub-assembly, battery tray, and positive terminal cover, free of charge. Owner letters were mailed December 27, 2024, to 2013-2014 RAV4 owners. Additional owner notification letters will be mailed in phases, phase 2 will begin on May 14, 2025, and phase 3 in late July 2025. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 23TB13 and 23TA13.
Jan 16, 2015
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2013-2015 Toyota Rav4 vehicles manufactured June 1, 2013, to December 29, 2014, and equipped with an accessory trailer light module. The software within the module may incorrectly detect an electrical short and preventively turn off the electrical current and the trailer lights.
Consequence & remedy
Consequence: If the system incorrectly detects an electrical short and turns off the trailer lights while the trailer is being towed at night, there is an increased risk of a crash.
Remedy: SET will notify owners, and dealers will replace the trailer light module with a new unit with corrected software, free of charge. The recall began on March 17, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET-15A.
Additional source detail variants (2)
Trailer Hitches
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2013-2015 Toyota Rav4 vehicles manufactured June 1, 2013, to December 29, 2014, and equipped with an accessory trailer light module. The software within the module may incorrectly detect an electrical short and preventively turn off the electrical current and the trailer lights.
Consequence: If the system incorrectly detects an electrical short and turns off the trailer lights while the trailer is being towed at night, there is an increased risk of a crash.
Remedy: SET will notify owners, and dealers will replace the trailer light module with a new unit with corrected software, free of charge. The recall began on March 17, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET-15A.
Exterior Lighting
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2013-2015 Toyota Rav4 vehicles manufactured June 1, 2013, to December 29, 2014, and equipped with an accessory trailer light module. The software within the module may incorrectly detect an electrical short and preventively turn off the electrical current and the trailer lights.
Consequence: If the system incorrectly detects an electrical short and turns off the trailer lights while the trailer is being towed at night, there is an increased risk of a crash.
Remedy: SET will notify owners, and dealers will replace the trailer light module with a new unit with corrected software, free of charge. The recall began on March 17, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET-15A.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE21005 · Battery Hold Down Bracket Thermal Events
Opened Feb 25, 2021 · Closed Aug 12, 2024
Status: closed (inferred from source dates) · Electrical SYSTEM:12V/24V/48V Battery
The Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) to understand the contributing factors and frequency of vehicle fires originating from the battery region of the engine compartment in Model Year (MY) 2013-2018 Toyota RAV4 vehicles on 25 February 2021. At the time of opening, ODI attributed eleven allegations and additional EWR events to this PE. PE21005 focused on replacement batteries installed in the subject vehicles. No reported fire event identified in PE21005 involved the originally supplied 12V battery. The reported fires took place in vehicles known to contain aftermarket batteries or whose age exceeded the expected life of the original equipment battery. ODI identified battery dimensioning as it relates to the battery retention system (hold down bracket, radiator support bolt, J-hook, and battery tray) as the main factor set in the contact between the battery hold down bracket contacting the positive terminal of the 12V battery. The subject vehicles carried over the same battery tray and retention system from the prior generation (MY2006 – MY2012) of RAV4 vehicles. However, the subject vehicles were equipped with a dimensionally smaller battery (Group 35) than the prior generation (Group 24F). The smaller- length measurement in the Group 35 battery size in a battery tray originally designed to fit a Group 24F battery contributed to increased potential for battery movement which was exacerbated by the diversity in aftermarket battery configuration and irregularities intrinsic to battery replacement procedures. Battery movement coupled with the proximity of the B+ terminal on the battery and the grounded electrically conductive hold down bracket set the stage for a short to ground leading to an engine stall (if in operation) followed by a vehicle fire. This investigation was not able to classify the installation status, battery size, or cause of every allegation due to the fire event causing damage to the area, inaccessible vehicle, modification to the battery retention system after the event, and/or inconclusive photographic evidence. Toyota's investigation of the issue identified aftermarket battery catalogs that listed an improper battery replacement size (Group 26R) that would nevertheless fit into the subject vehicles whose battery retention system is incapable of reliably restraining a Group 26R battery. On 18 November 2021, Toyota initiated a consumer advisory campaign (21TG01) to the subject vehicle owners, notifying them of the correct size battery and offering a free inspection of the battery and retention hardware, a caution label to affix to the hold down bracket, and a discounted replacement 12V battery. This investigation with Toyota established three broad categories to characterize the battery retention system state of a given vehicle: "correct", "minor mis-installation", and "major mis-installation". - The "correct" terminology references the front bolt, bracket, and J-hook installed in a position not in contact with the positive battery terminal and the front bolt torqued to 17 Nm and the J-hook engaged with the tray hole and torqued to 4.9 Nm. - A "minor mis-installation" would describe the three retention components installed in the prescribed location, however not to the correct torque values. - The "major mis-installation" condition would constitute a retention component missing or disconnected from the system. Toyota's own testing used five exemplar batteries installed on a subject vehicle in each battery categorization resulted in: - Contact between the B+ terminal and hold down bracket in "major mis-installations" - Movement of the battery in "minor mis-installations" - No observable motion in "correct" installations. ODI conducted its own evaluation of the Toyota- specified replacement battery and 5 aftermarket Group 35 batteries. The six batteries tested conformed to the Group 35 Battery Council International (BCI) standard on overall dimensional tolerance and terminal location. That standard does not define the edge shape or material of battery casing. Physical interaction between the hold down bracket and the battery case and the friction between the casing material and the battery tray resulted in a large variability in movement forces required to incite movement when the battery was installed in the "correct" condition. Resulting in movement at an induced lateral load between 0.6 G and 1.91 G equivalent force across each battery. This force is higher than a typical vehicle could exert in a steady state turn and would only experience loads through brief shock or impulses. Multiple shock or impulse loads across time would contribute to a delay between the replacement battery installation and the fire event. Likelihood of a fire event increases as the installation method degraded from the "correct", to "minor mis-installation", and then to "major mis-installation". Protruding vent caps atop some of the batteries tested aided in restricting battery movement relative to the hold down. An absence of vent caps permitted additional movement. Following several discussions and vehicle inspections with ODI during this investigation, on 01 November 2023, Toyota filed a safety recall (NHTSA 23V-734) of 1,853,568 MY 2013 through MY 2018 Toyota RAV4 vehicles to reduce the risk of a vehicle fire with redesigned battery retention components. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration