2026 Toyota RAV4 Hybrid

While driving my 2026 Toyota RAV4 Hybrid (VIN [XXX], approximately 354 miles on the odometer), I was involved in a frontal collision. Event Data Recorder (EDR) data retrieved from the vehicle's Airbag Control Module via Bosch CDR tool confirms the following: The Pre-Collision System (PCS) On/Off switch was ON and the system reported "Enable" status (no fault/DTC) throughout the 5-second pre-crash window. The Automatic Emergency Braking (AEB) system status was recorded as "On, Non-Engaged" for the entire pre-crash window. The PCS-PBA Request Flag (which would indicate the system requested automatic brake assist) remained OFF for the entire pre-crash window — the system never requested autonomous braking. The PCS-ALM Request Flag (forward collision alert/warning) also remained OFF for the entire pre-crash window — no forward collision warning was issued to the driver at any point. No Diagnostic Trouble Codes (DTCs) were present at the time of the event. All braking that occurred was driver-initiated: the EDR shows Service Brake changing from Off to On only 0.27 seconds before impact, with brake pedal position reaching 100% by the time of impact. The primary point of impact was recorded as Front (12 o'clock position), a squarely centered frontal impact — the type of scenario Toyota's own marketing materials describe the Pre-Collision System as designed to detect and respond to. The vehicle's Pre-Collision System and Automatic Emergency Braking — both active, switched on, and reporting no internal fault — did not provide any forward collision warning and did not request automatic braking at any point before this frontal impact occurred. This is the first-model-year rollout of Toyota Safety Sense 4.0 on the redesigned 2026 RAV4. I am filing this report to document this incident for NHTSA's records and to flag a potential pattern concern for this new-generation safety system. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I am reporting two serious safety concerns involving my 2026 Toyota RAV4 Hybrid. First, while I was making a normal left turn, the vehicle suddenly activated the automatic emergency braking system and came to an abrupt stop in the middle of the roadway. A vehicle ahead of me was also completing a left turn, and it appears that my RAV4 incorrectly detected an imminent collision. The unexpected braking created a significant accident hazard because a vehicle behind me could have rear-ended my vehicle. Second, the overhead sunglass holder does not remain securely closed. While driving, the holder opened unexpectedly and my glasses fell into the driver’s footwell near the brake pedal. The glasses interfered with my ability to operate the brake pedal safely, creating an additional risk of a crash. I reported these concerns to a Toyota dealership, but the dealership stated that it could not identify a problem with the emergency braking system. These issues are intermittent but present a serious safety risk. I am requesting that NHTSA investigate the automatic emergency braking system and the defective overhead sunglass-holder latch on the 2026 Toyota RAV4.

As I was traveling on the highway, the sunglasses holder opened and my sunglasses fell out and impaired my vision. FORTUNATELY, I was able to maintain control of the vehicle and the glasses did not fall to the floor and interfere with the gas or brake pedal operation. The sunglass holder latch does not operate properly and does not latch or stay closed. Called Toyota and was informed there were no other reports or TSP advisory, however encountered many similar incidents on. Reddit threads.