ON DEC 2, 2020 WHILE DRIVING ON THE FREEWAY AT ABOUT 45-50 MPH OUR SUNROOF EXPLODED CAUSING US TO GET TO THE SIDE OF THE ROAD. THE SHADE WAS CLOSED WHICH SAVED US FROM EXPLODING GLASS. THERE WERE NO ROAD HAZARDS, NO ISSUES OTHER THAN A SPONTANEOUS EXPLODING OF OUR SUNROOF. THE ORLANDO POLICE DEPT WAS SUMMONED AND THE ROADRANGERS…
Read full complaint
ON DEC 2, 2020 WHILE DRIVING ON THE FREEWAY AT ABOUT 45-50 MPH OUR SUNROOF EXPLODED CAUSING US TO GET TO THE SIDE OF THE ROAD. THE SHADE WAS CLOSED WHICH SAVED US FROM EXPLODING GLASS. THERE WERE NO ROAD HAZARDS, NO ISSUES OTHER THAN A SPONTANEOUS EXPLODING OF OUR SUNROOF. THE ORLANDO POLICE DEPT WAS SUMMONED AND THE ROADRANGERS STOPPED TO ASSIST US. I TOOK THE CAR DIRECTLY TO THE TOYOTA DEALERSHIP IN CLERMONT, FL AND THEY REPAIRED THE GLASS AT NO CHARGE BUT TOLD ME HAD THE CAR NOT BEEN UNDER MANUFACTURER WARRANTY I WOULD HAVE BEEN RESPONSIBLE FOR THE COST OF REPLACEMENT. IF THE SHADE HAD NOT BEEN CLOSED THE ENTIRE PASSENGERS WITHIN THE CABIN WOULD HAVE BEEN SPLATTERED WITH SHATTERED GLASS.
NHTSA ODI #11397301
4,500 miles · Oct 26, 2019
Service BrakesStructureCrash
I WAS DRIVING UP TO MY GARAGE ON THE SIDE OF MY HOUSE ON A CLEAR DAY, EARLY AFTERNOON. I WAS TRAVELING ABOUT 3 MPH AND TRIED TO STOP TO PARK IN FRONT OF THE GARAGE DOOR. I DEPRESSED THE BRAKE PEDAL AND IT DID NOT ENGAGE, BUT LURCHED FORWARD INTO THE GARAGE, CRASHING INTO THE GARAGE AND CAUSING DAMAGE TO BOTH THE GARAGE AND THE A…
Read full complaint
I WAS DRIVING UP TO MY GARAGE ON THE SIDE OF MY HOUSE ON A CLEAR DAY, EARLY AFTERNOON. I WAS TRAVELING ABOUT 3 MPH AND TRIED TO STOP TO PARK IN FRONT OF THE GARAGE DOOR. I DEPRESSED THE BRAKE PEDAL AND IT DID NOT ENGAGE, BUT LURCHED FORWARD INTO THE GARAGE, CRASHING INTO THE GARAGE AND CAUSING DAMAGE TO BOTH THE GARAGE AND THE AUTO.
NHTSA ODI #11271167
3,000 miles · Oct 11, 2019
Structure
THE HEAT SHIELD ON THE UNDERSIDE OF THE CAR, BY THE STORAGE BATTERY CAME LOSE WHILE DRIVING AND WAS DAMAGED. IT IS HELD IN PLACE BY ONLY FOUR PLASTIC PINS. THE CAR IS SO LOW TO THE GROUND THAT IT IS HARD TO CLEAR NORMAL SPEED BUMPS LET ALONE OLDER LARGER ONES. WE WERE TRAVELING A HOUSING ADDITION LESS THAN 20 MPH AND JUST WENT O…
Read full complaint
THE HEAT SHIELD ON THE UNDERSIDE OF THE CAR, BY THE STORAGE BATTERY CAME LOSE WHILE DRIVING AND WAS DAMAGED. IT IS HELD IN PLACE BY ONLY FOUR PLASTIC PINS. THE CAR IS SO LOW TO THE GROUND THAT IT IS HARD TO CLEAR NORMAL SPEED BUMPS LET ALONE OLDER LARGER ONES. WE WERE TRAVELING A HOUSING ADDITION LESS THAN 20 MPH AND JUST WENT OVER AN OLDER HIGH SPEED-BUMP AND PUDDLE WHEN IT OCCURRED. WE DROVE THE LAST 100 OR SO FEET HOME AND WIRED IT UP OUT OF THE WAY SO THE CAR COULD BE DRIVEN AT LOW SPEED TOO THE DEALERSHIP. THE DEALERSHIP TOLD US THIS WAS DAMAGE DUE TO OUR DRIVING NEGLIGENCE IE: "WE HIT SOMETHING". WHEN THIS SHIELD COMES OFF IT FALLS STRAIGHT INTO THE VEHICLE EXHAUST PIPE AND GROUND, THERE IS NO SIMPLE WAY TO REMOVE THE PIECE UNTIL A FULL REPAIR CAN BE COMPLETED. IT MUST BE WIRED UP OFF THE GROUND OR PART OF THE WHEEL AND EXHAUST MUST BE DISCONNECTED. IT TOOK THE DEALERSHIP THREE TRIES AND OVER A MONTH TO GET THE CORRECT SHIELD IN AND PERFORM THE REPAIR. THE PART NUMBER IN THE TOYOTA PARTS SPECIFICATION AND THE REPAIR PARTS WAREHOUSE OR NOT THE SAME.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2016-2018 Toyota Prius vehicles. A portion of the engine wire harness connected to the hybrid Power Control Unit (PCU), could contact the cover at this connection and wear, causing an electrical short circuit.
Consequence & remedy
Consequence: An electrical short can increase the risk of a fire.
Remedy: Toyota will notify owners, and dealers will inspect the engine wire harness assembly and replace it if damage is found. A protective sleeve or protective tape will be included to prevent any future damage. These repairs will be performed free of charge. The recall began October 30, 2018. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is J0T.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
2018 Toyota Prius Problems, Complaints & Recalls | Skip That Year
Illustration