The contact owns a 2018 Toyota Prius. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer where it was diagnosed with a failed heat exchanger, catalytic converter, and exhaust system. The contact was informed that the heat exchanger, the cataly…
Read full complaint
The contact owns a 2018 Toyota Prius. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer where it was diagnosed with a failed heat exchanger, catalytic converter, and exhaust system. The contact was informed that the heat exchanger, the catalytic converter, and the exhaust system needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 89,682.
NHTSA ODI #11650717
8,600 miles · Jul 10, 2019
Engine
TL* THE CONTACT OWNS A 2018 TOYOTA PRIUS. WHILE DRIVING 20 MPH, THE ELECTRICAL SYSTEM FAILED AND EVERYTHING IN THE VEHICLE SHUT DOWN. THE VEHICLE DECELERATED AND LOST POWER. WHILE THE VEHICLE COASTED, THE ENGINE RESTARTED ON ITS OWN. THE VEHICLE WAS DRIVEN TO TOYOTA VALLEJO (201 AUTO MALL PARKWAY, VALLEJO, CA 94591, 707-552-454…
Read full complaint
TL* THE CONTACT OWNS A 2018 TOYOTA PRIUS. WHILE DRIVING 20 MPH, THE ELECTRICAL SYSTEM FAILED AND EVERYTHING IN THE VEHICLE SHUT DOWN. THE VEHICLE DECELERATED AND LOST POWER. WHILE THE VEHICLE COASTED, THE ENGINE RESTARTED ON ITS OWN. THE VEHICLE WAS DRIVEN TO TOYOTA VALLEJO (201 AUTO MALL PARKWAY, VALLEJO, CA 94591, 707-552-4545) TO BE DIAGNOSED, BUT THE FAILURE COULD NOT BE REPLICATED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 8,600.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2016-2018 Toyota Prius vehicles. A portion of the engine wire harness connected to the hybrid Power Control Unit (PCU), could contact the cover at this connection and wear, causing an electrical short circuit.
Consequence & remedy
Consequence: An electrical short can increase the risk of a fire.
Remedy: Toyota will notify owners, and dealers will inspect the engine wire harness assembly and replace it if damage is found. A protective sleeve or protective tape will be included to prevent any future damage. These repairs will be performed free of charge. The recall began October 30, 2018. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is J0T.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
2018 Toyota Prius Problems, Complaints & Recalls | Skip That Year
Illustration