NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
422 reports45,000 miles · Feb 26, 2016
Air BagsElectrical SystemHybrid Propulsion SystemCrashInjury
TL* THE CONTACT OWNED A 2012 TOYOTA PRIUS. WHILE DRIVING 60 MPH, THE ENGINE STALLED. VARIOUS WARNING LIGHTS ILLUMINATED AND A BEEPING NOISE WAS PRESENT. THE CONTACT'S VEHICLE COASTED TO A STOP AND WAS REAR ENDED BY ANOTHER VEHICLE. A POLICE REPORT WAS FILED. THE AIR BAGS DID NOT DEPLOY. THE CONTACT SUSTAINED INJURIES TO THE FORE…
Read full complaint
TL* THE CONTACT OWNED A 2012 TOYOTA PRIUS. WHILE DRIVING 60 MPH, THE ENGINE STALLED. VARIOUS WARNING LIGHTS ILLUMINATED AND A BEEPING NOISE WAS PRESENT. THE CONTACT'S VEHICLE COASTED TO A STOP AND WAS REAR ENDED BY ANOTHER VEHICLE. A POLICE REPORT WAS FILED. THE AIR BAGS DID NOT DEPLOY. THE CONTACT SUSTAINED INJURIES TO THE FOREARM THAT REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V053000 (ELECTRICAL SYSTEM, HYBRID PROPULSION SYSTEM). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS DESTROYED AND TOWED. THE FAILURE MILEAGE WAS APPROXIMATELY 45,000.......UPDATED 04/01/16 *BF *JS CONSUMER STATED THERE HAVE BEEN PREVIOUS STALLS WHICH THERE HAVE BEEN RECALLS. UPDATED 6/7/18*JB
NHTSA ODI #10838647
35,000 miles · Dec 29, 2015
Exterior Lighting
I HAVE TO REPLACE BOTH LOW BEAM HEAD LAMPS APPROXIMATELY EVERY THREE WEEKS. I HAVE BOUGHT AND REPLACED 5 SETS SINCE OWNING THE CAR IN JUNE 2015. I CURRENTLY HAVE 40,000 MILES ON THE CAR.
NHTSA ODI #10816911
43,000 miles · Dec 14, 2015
Air BagsCrashInjury
WIFE IN ACCIDENT WITH SIDE IMPACT AND FRONT IMPACT APPROXIMATELY 35-40 MPH RAN OFF OF A ROAD WITH NO SHOULDER SIDE IMPACT WITH OAK TREE THEN FRONT IMPACT WITH ANOTHER OAK TREE. NO AIRBAGS DEPLOYED. VEHICLE TOTALED. EMT AND CHP COMMENTED THAT UNUSUAL THAT AIRBAGS DID NOT DEPLOY. I WAS AMAZED AS WELL!....UPDATED 12/30/15 *BF; UPDA…
Read full complaint
WIFE IN ACCIDENT WITH SIDE IMPACT AND FRONT IMPACT APPROXIMATELY 35-40 MPH RAN OFF OF A ROAD WITH NO SHOULDER SIDE IMPACT WITH OAK TREE THEN FRONT IMPACT WITH ANOTHER OAK TREE. NO AIRBAGS DEPLOYED. VEHICLE TOTALED. EMT AND CHP COMMENTED THAT UNUSUAL THAT AIRBAGS DID NOT DEPLOY. I WAS AMAZED AS WELL!....UPDATED 12/30/15 *BF; UPDATED 05/11/18*JB *TR
NHTSA ODI #10810066
625,000 miles · Dec 12, 2015
Visibility/wiper
WIND SHIELD WIPER SWITCH QUIT WORKING AT 62,500 MILE.THE WIND SHIELD WIPER MOTOR IS NOW MAKING GRINDING NOISES AND NEEDS TO BE REPLACED(74,000 MILES). BOTH PARTS BROKE WHEN WE WERE TRAVELING OUT OF STATE,DURING RAIN STORMS.
NHTSA ODI #10809808
91,000 miles · Nov 25, 2015
Unknown Or Other
MY PASSENGER SIDE SUN VISOR JUST COMPLETELY FELL OUT WHILE DRIVING DOWN THE ROAD. IT HAS RARELY BEEN USED (MY CAR IS A 2012 WITH HIGH MILES AND MOST OF THE TIME I TRAVEL ALONE). THIS COULD HAVE EASILY CAUSED A DISTRACTION OR CRASH. I NOTICED THAT THERE ARE SEVERAL COMPLAINTS ABOUT OTHER TOYOTA MODELS / YEARS.
NHTSA ODI #10806773
20,000 miles · Oct 1, 2015
Service BrakesVehicle Speed ControlCrashInjury
TL* THE CONTACT OWNS A 2012 TOYOTA PRIUS. THE CONTACT STATED THAT THE VEHICLE INDEPENDENTLY ACCELERATED WHILE PULLING INTO A PARKING SPACE WITH THE BRAKE PEDAL APPLIED. THE CONTACT APPLIED EXTREME FORCE AND THE VEHICLE CONTINUED TO UNINTENDEDLY ACCELERATE AT A HIGH RATE OF SPEED. THE VEHICLE TURNED RIGHT AND CRASHED INTO A TRASH…
Read full complaint
TL* THE CONTACT OWNS A 2012 TOYOTA PRIUS. THE CONTACT STATED THAT THE VEHICLE INDEPENDENTLY ACCELERATED WHILE PULLING INTO A PARKING SPACE WITH THE BRAKE PEDAL APPLIED. THE CONTACT APPLIED EXTREME FORCE AND THE VEHICLE CONTINUED TO UNINTENDEDLY ACCELERATE AT A HIGH RATE OF SPEED. THE VEHICLE TURNED RIGHT AND CRASHED INTO A TRASH DUMPSTER. THE DRIVER AND FRONT PASSENGER SUSTAINED WHIPLASH. MEDICAL ATTENTION WAS NOT REQUIRED. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO THE DEALER'S COLLISION CENTER WHO REPAIRED THE BODY DAMAGES AND WAS TO SEND A THIRD PARTY TO INVESTIGATE THE CAUSE OF THE FAILURE. THE CONTACT WAS WAITING ON THE DEALER AND THE MANUFACTURER TO DETERMINE THE REMEDY TO REPAIR THE VEHICLE. THE APPROXIMATE FAILURE MILEAGE WAS 20,000.
NHTSA ODI #10779130
46,500 miles · Sep 30, 2015
Seat BeltsSeatsCrashInjury
MY WIFE WAS INVOLVED IN A TWO CAR CRASH WHEN A CAR COMING IN THE OPPOSITE DIRECTION MADE AN ILLEGAL LEFT TURN DIRECTLY IN FRONT OF HER. IT HAPPENED SO QUICK THAT SHE NEVER HAD TIME TO HIT HER BRAKES. SHE WAS TRAVELING BETWEEN 30 AND 35 MPH IN A 35 MPH ZONE ON A TWO LANE ROAD. I WOULD THINK THAT AT THAT SPEED IF ALL HER SAFETY EQ…
Read full complaint
MY WIFE WAS INVOLVED IN A TWO CAR CRASH WHEN A CAR COMING IN THE OPPOSITE DIRECTION MADE AN ILLEGAL LEFT TURN DIRECTLY IN FRONT OF HER. IT HAPPENED SO QUICK THAT SHE NEVER HAD TIME TO HIT HER BRAKES. SHE WAS TRAVELING BETWEEN 30 AND 35 MPH IN A 35 MPH ZONE ON A TWO LANE ROAD. I WOULD THINK THAT AT THAT SPEED IF ALL HER SAFETY EQUIPMENT WORKED SHE WOULD NOT SUFFER ANY INJURIES. HER SEAT BELT FAILED CAUSING THE SEAT LATCH TO FAIL AND SHE ENDED UP JAMMED INTO THE BOTTOM AND UNDER SIDE OF THE DASHBOARD. SHE SUFFERED A BLOW TO HER CHEST AND INJURIES TO HER KNEES, LOWER LEGS AND FOOT. SHE HAD SURGERY ON HER RIGHT KNEE SO WE COULD GET HER ON HER FEET AGAIN AND IS AWAITING SURGERY ON HER RIGHT SHOULDER. SHE HAD A PRE EXISTING HEART CONDITION THAT WAS RAISED TO EMERGENCY STATUS AFTER THE BLOW TO HER CHEST AND SHE HAD SURGERY FOR THAT AND THEY FOUND A SHORT CIRCUIT IN THE MIDDLE OF HER HEART AND ZAPPED IT. THERE IS ONLY A 2% CHANCE IT WILL EVER RETURN. I HAVE PICTURES OF THE FAILED SEAT BELT AND SEAT. THE SEAT BELT IS IN THE FULLY EXTENDED POSITION AND LOCKED AND CAN NOT BE RELEASED EVEN BY YANKING ON IT. I AM WRITING THIS REPORT SO THIS SITUATION CAN BE CHECKED AND IF FOUND FAULTY CAN BE CORRECTED BEFORE ANY ONE ELSE GOES THROUGH WHAT MY WIFE IS GOING THROUGH.
NHTSA ODI #10778889
Mileage unknown · Sep 23, 2015
Engine
STARTING IN SPRING 2013 AND CONTINUING DURING THE REST OF THE SPRING, SUMMER AND EARLY FALL IN THE HOTTEST MONTHS, AFTER PARKING MY PRIUS C OUTSIDE, IT ALWAYS HAD ISSUES STARTING, WHICH CONTINUES TO THIS DAY. I WILL PUT THE KEY IN THE IGNITION, START THE CAR, ALL THE DASH LIGHTS COME ON AND THE CAR WILL USUALLY NOT ALLOW ME TO P…
Read full complaint
STARTING IN SPRING 2013 AND CONTINUING DURING THE REST OF THE SPRING, SUMMER AND EARLY FALL IN THE HOTTEST MONTHS, AFTER PARKING MY PRIUS C OUTSIDE, IT ALWAYS HAD ISSUES STARTING, WHICH CONTINUES TO THIS DAY. I WILL PUT THE KEY IN THE IGNITION, START THE CAR, ALL THE DASH LIGHTS COME ON AND THE CAR WILL USUALLY NOT ALLOW ME TO PUT IT INTO REVERSE OR DRIVE. I HAVE TO TAKE THE KEY OUT OF THE IGNITION AND START IT AGAIN AT LEAST TWICE BEFORE IT STARTS NORMALLY AS IT DOES WHEN THE WEATHER IS COOLER AND/OR WHEN THE CAR IS PARKED IN MY GARAGE. A COUPLE OF TIMES, I MANAGED TO GET THE CAR TO GO INTO REVERSE, BUT IT WAS ALMOST IMPOSSIBLE TO STEER AS IF THE PARKING BRAKE WAS ON. THEN THE VEHICLE STOPPED, LEAVING ME IN THE PATH OF ONCOMING TRAFFIC. THIS HAS BEEN HAPPENING SINCE I BOUGHT THE CAR AND THE DEALERSHIP SAYS THEY CAN'T FIX IT UNLESS THEY CAN RECREATE THE PROBLEM. I HAVE TAKEN PICTURES AND VISEO, BUT THAT MAKES NO DIFFERENCE TO THEM. THIS IS A DANGEROUS PROBLEM AND NEEDS TO BE FIXED. THIS IS THE SECOND COMPLAINT I HAVE FILED RE: THIS MATTER AS MY FIRST DOES NOT SEEM TO APPEAR HERE.
NHTSA ODI #10775337
9,000 miles · Aug 18, 2015
Service BrakesCrash
VEHICLE HAD LITTLE OR NO BRAKING POWER IN A PANIC STOP SITUATION. THIS WAS LIKELY CAUSE BY A DELAY SWITCHING FROM REGENERATIVE BRAKING TO MECHANICAL BRAKES.
NHTSA ODI #10749388
57,421 miles · Jul 13, 2015
Electrical System
OVER THE LAST NINE MONTHS I HAVE HAD TO REPLACE THE BULBS IN MY 2012 TOYOTA PRIUS 6 TIMES. WHEN I BROUGHT IT TO THE DEALER THEY STATED THAT IT WAS BECAUSE I WAS NOT USING TOYOTA CERTIFIED BULB AND I PAID OVER $150 TO HAVE THEM INSPECT THE HEADLIGHTS AND REPLACE THE BULBS. AFTER I HAD THE CERTIFIED BULBS INSTALLED, A BULB WENT O…
Read full complaint
OVER THE LAST NINE MONTHS I HAVE HAD TO REPLACE THE BULBS IN MY 2012 TOYOTA PRIUS 6 TIMES. WHEN I BROUGHT IT TO THE DEALER THEY STATED THAT IT WAS BECAUSE I WAS NOT USING TOYOTA CERTIFIED BULB AND I PAID OVER $150 TO HAVE THEM INSPECT THE HEADLIGHTS AND REPLACE THE BULBS. AFTER I HAD THE CERTIFIED BULBS INSTALLED, A BULB WENT OUT AGAIN. WHEN I RETURNED TO THE DEALER, I WAS TOLD THAT I NEEDED NEW WIRING FOR A COST IN EXCESS OF $250.00. THE TECHNICIAN STATED THAT TSB-0204-12 WAS ISSUED FOR FOR 2010-11 PRIUS FOR THIS PROBLEM AND THAT THE 2012 PRIUS HAVE THE EXACT SAME WIRING HARNESS, BUT THAT TOYOTA WAS NOT GOING TO FIX THAT PROBLEM FOR TEH 2012 MODELS AND THAT I WOULD HAVE TO ABSORB THE COST MYSELF.
NHTSA ODI #10733546
Official recalls
6Oct 4, 2018
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2014 Toyota Prius and 2012-2014 Toyota Prius V vehicles. Excessive voltage in the Intelligent Power Module (IPM) within the inverter may cause the hybrid system to shut down, causing the vehicle to stall while being driven.
Consequence & remedy
Consequence: If the hybrid system shuts down unexpectedly, it can increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will update the software for the motor/generator control electronic control unit (ECU) and the hybrid control ECU as necessary, free of charge. The recall began January 22, 2019. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is J0V. Note: The software updates in this recall are needed even if the vehicle had the software previously updated under recalls 14V-053 or 15V-449.
Jun 30, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2010-2012 Toyota Prius, 2010 and 2012 Toyota Prius Plug-in Hybrid, and 2011-2012 Lexus CT200h vehicles. A weld in the curtain shield air bag inflator may crack causing one or both portions of the inflator to eject into the passenger cabin.
Consequence & remedy
Consequence: If either portion of the curtain shield air bag inflator ejects into the passenger cabin, there is an increased risk of injury to vehicle occupants.
Remedy: Toyota will notify owners, and dealers will install retention brackets to the curtain shield air bags, free of charge. The recall began on October 17, 2016. Owners may contact Toyota Customer Service Department at 1-800-331-4331. Toyota's number for this recall is Toyota G0U, and Lexus GLJ.
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Feb 12, 2014
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence & remedy
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Additional source detail variants (2)
Hybrid Propulsion System: Inverter
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Electrical System:software
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Apr 9, 2013
Southeast Toyota is recalling certain model year 2008 and 2010-2013 Toyota Tundra, 2010-2012 Rav4, 2012 Toyota Sequoia, 2010-2011 Toyota Corolla, 2010-2011 Toyota Camry and Camry Hybrid, 2010-2013 Toyota Highlander and Highlander Hybrid, 2010-2013 Toyota FJ Cruiser, 2011 Toyota Land Cruiser, 2010-2013 Toyota Venza, 2010-2011 Toyota 4Runner, 2010-2013 Toyota Tacoma, 2011-2012 Toyota Sienna, 2012 Toyota Prius, 2013 Scion FR-S, 2011 Scion XD, 2011 Scion XB, and 2012 Scion TC vehicles. These vehicles were sold with labels that were outside the allowable one percent of accuracy of actual weight added. Thus, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) Number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: An inaccurate label could lead to owners overloading their vehicles and tires. An overloaded vehicle can result in a tire failure which may result in a vehicle crash, personal injury, or property damage.
Remedy: Southeast Toyota will notify owners and provide a corrected label with instructions concerning its installation. A small group of the affected vehicles will need additonal remedies which are still being developed. The recall began on May 28, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Jan 16, 2013
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence & remedy
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Additional source detail variants (2)
Seats
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3DP23005 · Brake Actuator Valve Wear
Opened Nov 22, 2023 · No close date supplied
Status: open (inferred from source dates) · Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP19004 · Brake Actuator Valve Wear
Opened Sep 30, 2019 · Closed Jan 21, 2021
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist
On September 19, 2019, the Office of Defects Investigation (ODI) received a defect petition from Mr. Roger Hogan requesting that the Agency investigate and recall certain Toyota Prius, Prius PHV, Camry Hybrid and Avalon Hybrid vehicles for a brake actuator valve wear condition covered under Toyota Customer Support Programs ZJB and ZKK (subject CSP?s). In support of his request, the petitioner identified 117 NHTSA complaints allegedly related to the subject CSP condition, including 60 reporting crashes. On September 30, 2019, ODI opened Defect Petition DP19-004 to evaluate the petitioner?s request for an investigation. In August 2020, the petitioner notified the Agency that he was withdrawing his petition. Because the petitioner has withdrawn the petition, we are denying the petition as moot and no further analysis of this petition is necessary.NHTSA is authorized to issue an order requiring notification and remedy of a defect if the Agency?s investigation shows a defect in the design, construction, or performance of a motor vehicle that presents an unreasonable risk to safety. 49 U.S.C. ?? 30102(a)(9), 30118. Because the petitioner has with withdrawn the petition, the petition is denied as moot. This action does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency notes that it is not required to receive a defect petition prior to opening a defect investigation and will take further action if warranted by future circumstances.
Illustration