The contact owns a 2012 Toyota Prius. The contact stated that while reversing, the driver's side rear wheel flipped over. The vehicle was towed to the dealer, where it was diagnosed with a corroded I-Beam assembly on the rear wheel. The contact was informed that the driver's side rear hub and the BRG assembly, rear suspension, a…
Read full complaint
The contact owns a 2012 Toyota Prius. The contact stated that while reversing, the driver's side rear wheel flipped over. The vehicle was towed to the dealer, where it was diagnosed with a corroded I-Beam assembly on the rear wheel. The contact was informed that the driver's side rear hub and the BRG assembly, rear suspension, and bolts needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 196,347.
NHTSA ODI #11704752
Mileage unknown · Jan 5, 2025
Service BrakesSuspensionWheels
2012 Prius in very good condition with 180k miles- only 12 years old. Driving on back roads (thankfully) and the drivers side rear wheel compelely fell off while driving. I was doing about 30 MPH and felt like there was a flat tire so I was in the process of pulling over when the whole rear assembly snapped. The wheel hit the re…
Read full complaint
2012 Prius in very good condition with 180k miles- only 12 years old. Driving on back roads (thankfully) and the drivers side rear wheel compelely fell off while driving. I was doing about 30 MPH and felt like there was a flat tire so I was in the process of pulling over when the whole rear assembly snapped. The wheel hit the rear quarter of the car and bounced about 100 feet down the road. I could have been on the highway and this could have been fatal I believe. Very, Very scary. As can be seen in attached photos the issue was rust from the inside. This is very concerning since there was no way for me to know this was an issue. I could have been killed or killed someone else. I believe Toyota needs to look into this since there are other Prius' out there the same thing happened to on this very thread. Although this is a Massachusetts car I have owed it since 25k miles and have maintained it impeccably. I always have the undercarriage cleaned after driving on salty roads. Safety inspection was current- only done the month before. Had that wheel bearing replaced about 2 weeks before the incident and the reputable mechanic reported no issues. There was no warning except for maybe a minute before it happened- the car was vibrating like I had a flat tire. The damage repair estimate on this was $8500. Catastrophic fail Toyota. Is this a rust issue like the Tacoma, Tundra, and Sequoia?????
NHTSA ODI #11634157
Mileage unknown · Jul 12, 2024
Suspension
On 07-June-2024 @14:47 my 2012 Toyota Prius suffered a catastrophic failure. I was attempting to back my 2012 Toyota Prius vehicle a few meters back into my driveway while turning slightly. This was a very slow speed backup. Suddenly, the rear passenger side wheel collapsed inward, and rendered the vehicle unmovable. A video …
Read full complaint
On 07-June-2024 @14:47 my 2012 Toyota Prius suffered a catastrophic failure. I was attempting to back my 2012 Toyota Prius vehicle a few meters back into my driveway while turning slightly. This was a very slow speed backup. Suddenly, the rear passenger side wheel collapsed inward, and rendered the vehicle unmovable. A video of the incident is attached for viewing The vehicle has low mileage approximately 58,000 miles. The vehicle is in excellent condition and the service records provide evidence of proper maintenance, often at Toyota dealership. This vehicle was originally from Cape Cod Massachusetts and perhaps suffered adverse effects from ocean salt air? Although the rest of the vehicle does not show any significant rusting. . I am impressed by the engineering of the Prius hybrid technology, but this point of failure seems to be an engineering weakness.
NHTSA ODI #11601457
9,300 miles · Oct 7, 2014
StructureSuspensionWheelsCrash
TURNING RIGHT FROM A STOP SIGN STOP, THE CAR TOOK OFF IN AN UNINTENDED ACCELERATION AND COULD NOT BE STOPPED UNTIL IT HIT A CURB. THE FORCE BROKE THE BALL JOINT OF THE DRIVER'S SIDE WHEEL CAUSING THE WHEEL TO TURN APPROX 45 DEGREES. THE CAR THEN SKIDDED ABOUT 20 YARDS AND CAME TO A STOP WITH THE MOTOR RACING. IT WAS A SINGLE CAR…
Read full complaint
TURNING RIGHT FROM A STOP SIGN STOP, THE CAR TOOK OFF IN AN UNINTENDED ACCELERATION AND COULD NOT BE STOPPED UNTIL IT HIT A CURB. THE FORCE BROKE THE BALL JOINT OF THE DRIVER'S SIDE WHEEL CAUSING THE WHEEL TO TURN APPROX 45 DEGREES. THE CAR THEN SKIDDED ABOUT 20 YARDS AND CAME TO A STOP WITH THE MOTOR RACING. IT WAS A SINGLE CAR CRASH WITH NO BODILY INJURY. *TR
NHTSA ODI #10642014
10 miles · Oct 1, 2014
SteeringSuspension
TL* THE CONTACT OWNS A 2012 TOYOTA PRIUS. WHILE DRIVING APPROXIMATELY 45 MPH, THE VEHICLE FAILED TO DRIVE IN A STRAIGHT LINE AND DRIFTED TO THE LEFT AND RIGHT. THE CONTACT HAD TO CONSTANTLY ADJUST THE STEERING WHEEL. THE DEALER WAS UNABLE TO DIAGNOSE THE CAUSE OF THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE FAILU…
Read full complaint
TL* THE CONTACT OWNS A 2012 TOYOTA PRIUS. WHILE DRIVING APPROXIMATELY 45 MPH, THE VEHICLE FAILED TO DRIVE IN A STRAIGHT LINE AND DRIFTED TO THE LEFT AND RIGHT. THE CONTACT HAD TO CONSTANTLY ADJUST THE STEERING WHEEL. THE DEALER WAS UNABLE TO DIAGNOSE THE CAUSE OF THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE FAILURE MILEAGE WAS 10. UPDATED 11/25/14*CN UPDATED 12/02/14*JB
NHTSA ODI #10640448
2,000 miles · Feb 3, 2013
Suspension
ON COLD MORNINGS THE CAR MAKES A GROANING NOISE FROM THE REAR FOR APROX A 1/2 BLOCK. MY DEALER WAS ABLE TO VERIFY THE PROBLEM WHEN I LEFT THE CAR OVERNIGHT PARKED OUTSIDE. THEY SAID THEY ARE WAITING FOR TOYOTA TO COME UP WITH A FIX. THE CAR NOW HAS JUST OVER 10,000 MILES BUT IT HAS BEEN GOING ON FOR MOST OF THE TIME WE HAVE OWNE…
Read full complaint
ON COLD MORNINGS THE CAR MAKES A GROANING NOISE FROM THE REAR FOR APROX A 1/2 BLOCK. MY DEALER WAS ABLE TO VERIFY THE PROBLEM WHEN I LEFT THE CAR OVERNIGHT PARKED OUTSIDE. THEY SAID THEY ARE WAITING FOR TOYOTA TO COME UP WITH A FIX. THE CAR NOW HAS JUST OVER 10,000 MILES BUT IT HAS BEEN GOING ON FOR MOST OF THE TIME WE HAVE OWNED IT. *TR
NHTSA ODI #10496215
6 miles · Jan 9, 2013
StructureSuspension
WHEN STARTING TO DRIVE THE CAR AFTER IS HAS BEEN SITTING FOR ABOUT 3 HOURS AND ESPECIALLY FIRST THING IN THE MORNING, THE VEHICLE MAKES A GROANING NOISE WHICH SEEMS TO BE COMING FROM THE LEFT REAR TIRE AREA. IT LASTS FOR ABOUT THE FIRST 50 FEET AND THEN IT STOPS MAKING THE NOISE. THIS HAS HAPPENED WITH TEMPERATURES VARYING BET…
Read full complaint
WHEN STARTING TO DRIVE THE CAR AFTER IS HAS BEEN SITTING FOR ABOUT 3 HOURS AND ESPECIALLY FIRST THING IN THE MORNING, THE VEHICLE MAKES A GROANING NOISE WHICH SEEMS TO BE COMING FROM THE LEFT REAR TIRE AREA. IT LASTS FOR ABOUT THE FIRST 50 FEET AND THEN IT STOPS MAKING THE NOISE. THIS HAS HAPPENED WITH TEMPERATURES VARYING BETWEEN 40 TO 75 DEGREES. WHEN IT IS REALLY HOT IN THE MORNING, THE NOISE IS NOT PRESENT. THE DEALER HAS LOOKED AT THE VEHICLE SEVERAL TIMES AND THEY SAY THAT THIS IS A NATIONAL PROBLEM WITH NO SOLUTION. I HAVE OWNED THIS CAR FOR 4 DAYS SHORT OF A YEAR WITH 12,250 MILES ON IT AND IT DOES IT ALL THE TIME. THIS IS VERY FRUSTRATING BECAUSE THE CAR IS FINE OTHERWISE. *TR
NHTSA ODI #10492027
2,400 miles · Oct 18, 2012
Service BrakesSuspension
REPEATING SEVERAL-SECOND GROANING OR GRINDING NOISE HEARD FROM REAR WHEEL AREA UPON STARTUP MOTION. THE NOISE IS SEVERE AND SOUNDS LIKE LOW-PITCH METAL GRINDING. IT'S POTENTIALLY BRAKE RELATED BUT COULD BE SUSPENSION BUSHINGS OR OTHER COMPONENTS RUBBING AGAINST ONE ANOTHER. IT DOES NOT SOUND LIKE TYPICAL BRAKE GLAZING. THE NOISE…
Read full complaint
REPEATING SEVERAL-SECOND GROANING OR GRINDING NOISE HEARD FROM REAR WHEEL AREA UPON STARTUP MOTION. THE NOISE IS SEVERE AND SOUNDS LIKE LOW-PITCH METAL GRINDING. IT'S POTENTIALLY BRAKE RELATED BUT COULD BE SUSPENSION BUSHINGS OR OTHER COMPONENTS RUBBING AGAINST ONE ANOTHER. IT DOES NOT SOUND LIKE TYPICAL BRAKE GLAZING. THE NOISE OCCURS IN ALL WEATHER CONDITIONS AND TYPICALLY AFTER VEHICLE HAS BEEN SITTING FOR SEVERAL HOURS OR OVERNIGHT. NOISE CONTINUES FOR SEVERAL MINUTES AT STOP AND START. NOISE IS LOUD ENOUGH TO STARTLE AN EXPERIENCED DRIVER. THE ABSOLUTE SEVERITY AND INDICATION OF THE SOUND IS ENOUGH TO QUESTION SAFE ONGOING FUNCTIONALITY OF BRAKING AND/OR SUSPENSION SYSTEMS. MULTIPLE REPORTS ARE DOCUMENTED ONLINE AT PRIUSCHAT.COM. TOYOTA DOES NOT APPEAR TO HAVE A FIX OR RESOLUTION AT TIME OF WRITING, 10/2012. THIS IS FOR 2012 PRIUS V MODEL FIVE. *TR
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2014 Toyota Prius and 2012-2014 Toyota Prius V vehicles. Excessive voltage in the Intelligent Power Module (IPM) within the inverter may cause the hybrid system to shut down, causing the vehicle to stall while being driven.
Consequence & remedy
Consequence: If the hybrid system shuts down unexpectedly, it can increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will update the software for the motor/generator control electronic control unit (ECU) and the hybrid control ECU as necessary, free of charge. The recall began January 22, 2019. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is J0V. Note: The software updates in this recall are needed even if the vehicle had the software previously updated under recalls 14V-053 or 15V-449.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2010-2012 Toyota Prius, 2010 and 2012 Toyota Prius Plug-in Hybrid, and 2011-2012 Lexus CT200h vehicles. A weld in the curtain shield air bag inflator may crack causing one or both portions of the inflator to eject into the passenger cabin.
Consequence & remedy
Consequence: If either portion of the curtain shield air bag inflator ejects into the passenger cabin, there is an increased risk of injury to vehicle occupants.
Remedy: Toyota will notify owners, and dealers will install retention brackets to the curtain shield air bags, free of charge. The recall began on October 17, 2016. Owners may contact Toyota Customer Service Department at 1-800-331-4331. Toyota's number for this recall is Toyota G0U, and Lexus GLJ.
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence & remedy
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Additional source detail variants (2)
Hybrid Propulsion System: Inverter
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Electrical System:software
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Southeast Toyota is recalling certain model year 2008 and 2010-2013 Toyota Tundra, 2010-2012 Rav4, 2012 Toyota Sequoia, 2010-2011 Toyota Corolla, 2010-2011 Toyota Camry and Camry Hybrid, 2010-2013 Toyota Highlander and Highlander Hybrid, 2010-2013 Toyota FJ Cruiser, 2011 Toyota Land Cruiser, 2010-2013 Toyota Venza, 2010-2011 Toyota 4Runner, 2010-2013 Toyota Tacoma, 2011-2012 Toyota Sienna, 2012 Toyota Prius, 2013 Scion FR-S, 2011 Scion XD, 2011 Scion XB, and 2012 Scion TC vehicles. These vehicles were sold with labels that were outside the allowable one percent of accuracy of actual weight added. Thus, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) Number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: An inaccurate label could lead to owners overloading their vehicles and tires. An overloaded vehicle can result in a tire failure which may result in a vehicle crash, personal injury, or property damage.
Remedy: Southeast Toyota will notify owners and provide a corrected label with instructions concerning its installation. A small group of the affected vehicles will need additonal remedies which are still being developed. The recall began on May 28, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence & remedy
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Additional source detail variants (2)
Seats
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
DP23005 · Brake Actuator Valve Wear
Opened Nov 22, 2023 · No close date supplied
Status: open (inferred from source dates) · Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP19004 · Brake Actuator Valve Wear
Opened Sep 30, 2019 · Closed Jan 21, 2021
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist
On September 19, 2019, the Office of Defects Investigation (ODI) received a defect petition from Mr. Roger Hogan requesting that the Agency investigate and recall certain Toyota Prius, Prius PHV, Camry Hybrid and Avalon Hybrid vehicles for a brake actuator valve wear condition covered under Toyota Customer Support Programs ZJB and ZKK (subject CSP?s). In support of his request, the petitioner identified 117 NHTSA complaints allegedly related to the subject CSP condition, including 60 reporting crashes. On September 30, 2019, ODI opened Defect Petition DP19-004 to evaluate the petitioner?s request for an investigation. In August 2020, the petitioner notified the Agency that he was withdrawing his petition. Because the petitioner has withdrawn the petition, we are denying the petition as moot and no further analysis of this petition is necessary.NHTSA is authorized to issue an order requiring notification and remedy of a defect if the Agency?s investigation shows a defect in the design, construction, or performance of a motor vehicle that presents an unreasonable risk to safety. 49 U.S.C. ?? 30102(a)(9), 30118. Because the petitioner has with withdrawn the petition, the petition is denied as moot. This action does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency notes that it is not required to receive a defect petition prior to opening a defect investigation and will take further action if warranted by future circumstances.
2012 Toyota Prius Problems, Complaints & Recalls | Skip That Year
Illustration