Service Brakes. Review the 182 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 52 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Exterior Lighting. Review the 36 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

46 crash reports2 fire reports26 injury reports

Visibility/wiper complaints

28 reports

Clear category filter

Mileage unknown · Sep 6, 2023

EngineLane DepartureVisibility/wiper

There is no incident occurring to me .but I change some parts like head light.& whisper .engine .

NHTSA ODI #11543027

Mileage unknown · Jun 10, 2023

Unknown Or OtherVisibility/wiperInjury

The glass sunroof spontaneously exploded or imploded. There was a loud popping sound and I looked up at the sunroof, and it was shattered. glass started falling on me as I was driving on the highway. There have been many reported cases of this happening found online. https://topclassactions.com/lawsuit-settlements/lawsuit-news/t…

Read full complaint

NHTSA ODI #11526364

Mileage unknown · May 1, 2022

Visibility/wiper

Read full complaint

The front windshield wiper no longer performs on high but does perform on the lower settings. We experienced very heavy rain yesterday for the first time in a while and needed the high setting to adequately visualize the road and vehicles. It once switched to high the wipers were inoperable and had to be reduced in speed to even function. This is a significant safety concern as it drastically compromises your visibility in heavy rain conditions, such as those we experienced. Yes it is available for inspection upon request.

NHTSA ODI #11462921

625,000 miles · Dec 12, 2015

Visibility/wiper

WIND SHIELD WIPER SWITCH QUIT WORKING AT 62,500 MILE.THE WIND SHIELD WIPER MOTOR IS NOW MAKING GRINDING NOISES AND NEEDS TO BE REPLACED(74,000 MILES). BOTH PARTS BROKE WHEN WE WERE TRAVELING OUT OF STATE,DURING RAIN STORMS.

NHTSA ODI #10809808

8,500 miles · Dec 23, 2013

Visibility/wiper

Read full complaint

I BOUGHT A 2012 TOYOTA PRIUS PLUG-IN. THE WINDSHIELD CREATES A GHOSTING EFFECT ON LIGHTS, ESPECIALLY AT NIGHT. LIGHTS FROM OTHER CARS AND STREETLIGHTS ARE GLARING THROUGH THE WINDSHIELD WITH A GHOSTED IMAGE ABOVE AND BELOW SO I SEE THREE LIGHTS. THE EFFECT IS SO PRONOUNCED THAT IT IS IMPOSSIBLE TO READ LIT HIGHWAY SAFETY SIGNS AT NIGHT BECAUSE THE GHOSTING OBSCURES THE LETTERS COMPLETELY. THE LIGHTS LOOK FINE THROUGH THE SIDE GLASS, SO IT IS CLEARLY AN ISSUE JUST WITH THE WINDSHIELD. I CONTACTED THE DEALER AND THEY DISMISSED MY COMPLAINT. HOWEVER I SEE THAT MANY PEOPLE HAVE MENTIONED THE EXACT SAME THING ONLINE AND OUR LOCAL NEWS CHANNEL IN THE SAN FRANCISCO AREA KABC CHANNEL 7 HAS BEGIN A "7 ON YOUR SIDE" INVESTIGATION. PLEASE URGE TOYOTA TO RECALL THESE DANGEROUS WINDSHIELDS. *TR

NHTSA ODI #10557011

Mileage unknown · Dec 8, 2013

Visibility/wiper

Read full complaint

PRIUS IS NOT SAFE TO DRIVE AT NIGHT. THE WINDSHIELD DISTORTS LIGHT SOURCES AND CAUSES A GHOSTING/MULTIPLYING EFFECT. TRAFFIC SIGNALS IMAGES ARE DOUBLED, TRIPLED OR MORE - NOT SAFE AS IT IS DISTRACTING AND CONFUSING. THIS ISSUE IS VERY PROMINENT AT NIGHT. IT IS NOT JUST TRAFFIC SIGNALS BUT OTHER LIGHT SOURCES AS WELL. IN DECEMBER 2012, I CONTACTED TOYOTA AND WAS REFERRED TO DEALER. SERVICE MANAGER CONFIRMED ISSUE AND SAID THAT HE IS WAITING ON TOYOTA ON HOW TO FIX - NO RESOLUTION AFTER ONE YEAR OF WAITING. *TR

NHTSA ODI #10555224

400 miles · Oct 25, 2013

Exterior LightingVisibility/wiper

I HAVE NOTICED GHOSTING OF IMAGES MOST OBVIOUS WHILE NIGHT DRIVING. PARTICULARLY NOTICEABLE IN LED LIGHTS. IT LOOKS LIKE A DUPLICATE IMAGE OF THE LIGHTS CREATED. IT CAN BE VERY GLARING AND HARD TO JUDGE DISTANCE OF OTHER VEHICLES. *TR

NHTSA ODI #10549531

17,570 miles · Oct 23, 2013

Visibility/wiper

Read full complaint

ON OCT. 23, 2013 AT 6AM IN THE MORNING IN ABOUT 45 DEGREES FAHRENHEIT, MY TOYOTA PRIUS 2012 REAR WINDOW EMITTED A LOUD PUNCHING SOUND AND THEN SHATTERED WHEN I TURNED ON THE REAR WIPER. I GOOGLED THE INCIDENT AND WE'RE NOT THE ONLY ONES WHO EXPERIENCE THIS. THERE HAVE BEEN SIMILAR INCIDENTS ON OTHER PRIUS IN OTHER YEARS AS WELL. THUS, WE ARE REPORTING IT AND HOPE THIS WILL BE LOOKED INTO. OUR CAR IS BARELY A YEAR OLD AND UNDER WARRANTY BUT OUR LOCAL TOYOTA DEALER SAID WARRANTY WILL NOT COVER THIS. THANK GOODNESS OUR AUTO POLICY WILL AND WE DON'T HAVE TO PAY A DEDUCTIBLE. *TR

NHTSA ODI #10549196

72 miles · Sep 9, 2013

StructureVisibility/wiper

Read full complaint

THE WINDSHIELD CAUSES MOST LIGHT SOURCES, PARTICULARLY LED LIGHTS, STREET LIGHTS, AND ONCOMING HEADLIGHTS (BASICALLY ANY BRIGHT LIGHT SOURCE), TO APPEAR WITH A "GHOSTING" IMAGE. THE "GHOSTING" APPEARS IN THE WINDSHIELD VERTICALLY BELOW THE LIGHT SOURCE AS ONE, TWO, OR EVEN THREE IMAGES. THE DEALER HAS REPLACED THE WINDSHIELD TWICE ALREADY, BUT THERE HAS BEEN NO IMPROVEMENT. IN FACT, THE FIRST AND SECOND REPLACEMENTS ARE WORSE THAN THE ORIGINAL. I ALSO OWN A 2008 TOYOTA SIENNA, AND I DRIVE VARIOUS CHEVY EQUINOXES AND FORD ESCAPES WHERE I WORK - I DO NOT EXPERIENCE THE "GHOSTING" EFFECT IN THOSE VEHICLES. PERSONNEL FROM THE DEALER'S SERVICE DEPARTMENT AS WELL AS REPRESENTATIVES FROM TOYOTA HAVE ALSO OBSERVED THIS PHENOMENA WITH THE WINDSHIELDS IN MY PRIUS PLUG-IN. I WAS TOLD BY A REPRESENTATIVE IN THE SERVICE DEPARTMENT AFTER THE LAST REPLACEMENT THAT EVEN THE TOYOTA ENGINEERS WEREN'T HAPPY WITH THE REPLACEMENT. IT HAS NOW BEEN TWO WEEKS SINCE THE LAST WINDSHIELD WAS INSTALLED. I NOTIFIED THE SERVICE DEPARTMENT (DURING MY DRIVE HOME THAT SAME DAY) AT THE DEALERSHIP THAT THE WINDSHIELD WAS UNSATISFACTORY, AND I WAS TOLD THAT THEY WOULD NOTIFY ME WHEN TOYOTA DECIDED WHAT TO DO ABOUT IT NEXT. TO DATE NOT ONLY HAVE I HEARD NOTHING, BUT THE LAST THREE PHONE CALLS TO THE SERVICE ADVISER HAVE GONE TO VOICE MAIL, AND I RECEIVED NO REPLY. *TR

NHTSA ODI #10542760

15,815 miles · Aug 13, 2013

StructureVisibility/wiper

Read full complaint

WHILE DRIVING, A LOUD POPPING NOISE (CRACKING) WAS HEARD WITH NO OBSERVED DAMAGE, AND LATER THAT DAY THE WINDSHIELD GREW A LONG CRACK IN WINDSHIELD WHILE THE CAR WAS PARKED. AN EDGE CRACK FORMED ON THE WINDSHIELD EXTREME OUTER EDGE IN THE CHAMFER ABOUT 2/3 OF THE WAY UP ON THE DRIVER?S SIDE A-PILLAR. THE WINDSHIELD BY IT?S DESIGN APPEARS TO BE RATHER THIN, AND THE WINDSHIELD EDGE IS EXPOSED, NOT COVERED OR EMBEDDED IN PLASTIC OR RUBBER OR TRIM MATERIAL. THE WINDSHIELD EDGE AS OBSERVED HAS A VERY SMALL CHAMFER AND DOES NOT HAVE A GENEROUS BEVEL (ROUND) THAT IS HIGHLY POLISHED SUCH AS FOUND ON THE PASSENGER WINDOW EDGES OR OLDER WINDSHIELDS I AM FAMILIAR WITH. I TOOK THE CAR TO TOYOTA OF BOWIE AND WAS TOLD BY THE SERVICE MANAGER, HE BELIEVES THERE WAS AN IMPACT TO THE WINDSHIELD AT THE VERY EXTREME EDGE OF THE WINDSHIELD WHERE THE CRACK ROOT IS ON THE CHAMFER AND THEIR DEALERSHIP WOULD NOT REPLACE IT UNDER ANY WARRANTY. THE SERVICE MANGER DID NOT LOOK AT THE CRACK WITH ANY TOOLS, FOR EXAMPLE, A MAGNIFYING CLASS OR THE USE OF A BALL POINT PEN TO DETERMINE ANY IMPACT LOCATION OR IF IT IS IN FACT A STRESS CRACK THAT HAS FORMED. THE SERVICE MANAGER DID NOT OFFER TO ARRANGE TO HAVE THE CAR REPAIRED AND TOLD ME TO GO TO A GLASS COMPANY. WHEN THE SERVICE MANAGER WAS ASKED ABOUT ANY PROBLEMS OR CONCERNS WITH TOYOTA WINDSHIELDS OR EXPOSED GLASS EDGE WINDSHIELDS WITH A SMALL CHAMFER, HE SAID THERE WERE NO PROBLEMS OR RECALLS. I HAVE ONLY OWNED THE CAR EIGHT MONTHS AND PLAN TO WRITE TOYOTA TO LEARN WHEN A MORE ROBUST CRACK RESISTANT WINDSHIELD CAN BE MADE AVAILABLE. NOTE: PICTURES CAN BE MADE AVAILABLE. *TR

NHTSA ODI #10535048

Official recalls

18V684000 · Hybrid Propulsion System

Oct 4, 2018

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2014 Toyota Prius and 2012-2014 Toyota Prius V vehicles. Excessive voltage in the Intelligent Power Module (IPM) within the inverter may cause the hybrid system to shut down, causing the vehicle to stall while being driven.

Consequence & remedy

Consequence: If the hybrid system shuts down unexpectedly, it can increase the risk of a crash.

Remedy: Toyota will notify owners, and dealers will update the software for the motor/generator control electronic control unit (ECU) and the hybrid control ECU as necessary, free of charge. The recall began January 22, 2019. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is J0V. Note: The software updates in this recall are needed even if the vehicle had the software previously updated under recalls 14V-053 or 15V-449.

16V487000 · Air Bags:side/window

Jun 30, 2016

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2010-2012 Toyota Prius, 2010 and 2012 Toyota Prius Plug-in Hybrid, and 2011-2012 Lexus CT200h vehicles. A weld in the curtain shield air bag inflator may crack causing one or both portions of the inflator to eject into the passenger cabin.

Consequence & remedy

Consequence: If either portion of the curtain shield air bag inflator ejects into the passenger cabin, there is an increased risk of injury to vehicle occupants.

Remedy: Toyota will notify owners, and dealers will install retention brackets to the curtain shield air bags, free of charge. The recall began on October 17, 2016. Owners may contact Toyota Customer Service Department at 1-800-331-4331. Toyota's number for this recall is Toyota G0U, and Lexus GLJ.

16V396000 · Seats:front Assembly:seat Heater/cooler

Jun 2, 2016

Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.

Consequence & remedy

Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.

Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.

14V053000 · Electrical System:software; Hybrid Propulsion System: Inverter

Feb 12, 2014

Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.

Consequence & remedy

Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.

Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.

Additional source detail variants (2)

Hybrid Propulsion System: Inverter

Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.

Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.

Electrical System:software

13V123000 · Equipment:other:labels

Apr 9, 2013

Southeast Toyota is recalling certain model year 2008 and 2010-2013 Toyota Tundra, 2010-2012 Rav4, 2012 Toyota Sequoia, 2010-2011 Toyota Corolla, 2010-2011 Toyota Camry and Camry Hybrid, 2010-2013 Toyota Highlander and Highlander Hybrid, 2010-2013 Toyota FJ Cruiser, 2011 Toyota Land Cruiser, 2010-2013 Toyota Venza, 2010-2011 Toyota 4Runner, 2010-2013 Toyota Tacoma, 2011-2012 Toyota Sienna, 2012 Toyota Prius, 2013 Scion FR-S, 2011 Scion XD, 2011 Scion XB, and 2012 Scion TC vehicles. These vehicles were sold with labels that were outside the allowable one percent of accuracy of actual weight added. Thus, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) Number 110, "Tire Selection and Rims."

Consequence & remedy

Consequence: An inaccurate label could lead to owners overloading their vehicles and tires. An overloaded vehicle can result in a tire failure which may result in a vehicle crash, personal injury, or property damage.

Remedy: Southeast Toyota will notify owners and provide a corrected label with instructions concerning its installation. A small group of the affected vehicles will need additonal remedies which are still being developed. The recall began on May 28, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.

13V014000 · Air Bags:frontal:sensor/control MODULE-INACTIVE ; Seats

Jan 16, 2013

Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.

Consequence & remedy

Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.

Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.

Additional source detail variants (2)

Seats

Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.

Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.

Air Bags:frontal:sensor/control MODULE-INACTIVE

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

DP23005 · Brake Actuator Valve Wear

Opened Nov 22, 2023 · No close date supplied

Status: open (inferred from source dates) · Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:power Assist

The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.

Additional source detail variants (2)

Service Brakes, Hydraulic:foundation Components

Service Brakes, Hydraulic:power Assist

DP22005 · Pedestrian Alert Sounds

Opened Jan 27, 2023 · Closed Aug 7, 2023

Status: closed (inferred from source dates) · Electrical System:propulsion System

NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.

DP19004 · Brake Actuator Valve Wear

Opened Sep 30, 2019 · Closed Jan 21, 2021

Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist

On September 19, 2019, the Office of Defects Investigation (ODI) received a defect petition from Mr. Roger Hogan requesting that the Agency investigate and recall certain Toyota Prius, Prius PHV, Camry Hybrid and Avalon Hybrid vehicles for a brake actuator valve wear condition covered under Toyota Customer Support Programs ZJB and ZKK (subject CSP?s). In support of his request, the petitioner identified 117 NHTSA complaints allegedly related to the subject CSP condition, including 60 reporting crashes. On September 30, 2019, ODI opened Defect Petition DP19-004 to evaluate the petitioner?s request for an investigation. In August 2020, the petitioner notified the Agency that he was withdrawing his petition. Because the petitioner has withdrawn the petition, we are denying the petition as moot and no further analysis of this petition is necessary.NHTSA is authorized to issue an order requiring notification and remedy of a defect if the Agency?s investigation shows a defect in the design, construction, or performance of a motor vehicle that presents an unreasonable risk to safety. 49 U.S.C. ?? 30102(a)(9), 30118. Because the petitioner has with withdrawn the petition, the petition is denied as moot. This action does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency notes that it is not required to receive a defect petition prior to opening a defect investigation and will take further action if warranted by future circumstances.