2012 Toyota Prius

Our 2012 Toyota Prius experienced brake failure due to the Accuator and Accumulator. I contacted Toyota Corporate office, which advised it is a known problem and had a customer support program that expired last year. The Toyota rep advised me to not drive the vehicle because of the brake failure and opened a ticket advising it is a known issue. After researching online, it is a very common issue. https://www.aboutautomobile.com/Consumer-Complaint/2010/Toyota/Prius/Brake

The contact owns a 2012 Toyota Prius. The contact stated that while driving at an undisclosed speed, the ABS warning light illuminated. The vehicle was taken to the dealer to be diagnosed. The contact was informed that the ABS module software needed to be updated. The manufacturer was not made aware of the failure. The failure mileage was approximately 53,000.

The contact owns a 2012 Toyota Prius. The contact stated that the passenger's side low-beam headlight failed to provide adequate illumination while driving. The vehicle was taken to the dealer who informed the contact that no issues were found; however, the dealer replaced the headlight bulb. The contact stated that the headlight bulb was replaced several times; however, the failure persisted. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 100,000.

Suspected Brake Booster failure. We have been experiencing our brake booster running several times a minute and something felt off. In December, we took it to the dealership who said they "were unable to replicate the issue". We found that odd since we experience the issue every few minutes, but we believed them when they said that there was nothing wrong with our brakes. Yesterday, about one month later, we were driving on a busy street when our brakes appeared to fail. We couldn't make the car stop, three dashboard lights came on (the ABS and two others) and eventually we realized the brakes had to be pressed really hard to get the car to stop. We avoided an accident, pulled into a parking lot, turned off the car, checked the brake fluid (the brake fluid was fine), restarted the car and the lights still remained and the brakes continued to not compress easily. We called our Toyota dealer who said that there is no recall on our Brake Booster and that this is not a known issue, and yet there are hundreds of readily available accounts of 2012 prius owners who experience the same fail.

The engine caught fire while sitting in my garage. I had driven it for a few hours doing deliveries for a store and parked it in my garage around 2:30pm. About 1.5 hours later, my wife was coming home and opened the garage door and saw smoke above the hood of my car and then a few seconds later it burst into flames. I believe that it was smouldering for a while and the gust of wind when the big garage door opened gave it the extra push to ignite. The car was bought used and had a front end accident prior to my purchasing it so the electrical system could have melted and started the fire but the inspector that Toyota sent did not give me any copy of his report. It is a 2012 model. I bought the car in 2014, and had it for about 5 years until this happened and completed burned up the car and all the contents of my garage. I had a T-Mobile Sync-up module in the OBD port and it recorded a drop in voltage from around 12 to 5 volts at the time of the fire which I believe was transferred to my phone when I was near it.

Toyota Program ZJB, internal malfunctions of the brake booster assemblies. A known failure of the brake booster than Toyota did extend the warranty on for 10 years BUT would not honor the warranty unless specific diagnostic codes appeared on the vehicle. My issue is that all of the symptoms of the failure occurred on my vehicle (pump constantly running, varying hydraulic pressure resulting in pulsing brake stops, soft brake pedal) but the warranty would not be honored because the diagnostic did not manifest itself. Had technicians tell me that it definitely was this booster failure, but Toyota would not pay for it unless the diagnostic came up. I am now left with a vehicle that has a failed brake system and no monetary support from Toyota. Quoted $2500 to $3000 to repair. Not safe to drive in my opinion with a known failure that I am having trouble getting funding to repair. Contacted Toyota customer support and they reiterated that they would not pay for the repair without the diagnostic occurring and now their extended warranty expired August 31, 2021. Inspection available upon request Safety issue as braking is inconsistent and not predictable Problem was identified by Toyota dealer service department No diagnostic alarms - which is the only symptom not present

The contact owns a 2012 Toyota Prius. The contact stated while driving approximately 40 MPH, the brakes became inoperable. The ABS and traction control warning lights were illuminated. The vehicle was taken to an unknown local dealer where it was diagnosed that the brake booster and brake pump assembly needed to be replaced. The vehicle was not repaired. The manufacturer was contacted but no additional assistance was provided. The failure mileage was approximately 335,000.

Headlamp Lens Issue Vehicle Manufacturers Must Correct ISSUE 1. The increase in pedestrian-vehicular accidents and fatalities is, at times, related to the driver not seeing the person in time to stop. Not seeing a person in time may be related to poor street lighting or a decrease in front visibility caused by fogged headlamp lenses. Current nighttime traffic has a variety of vehicles operating with varying front light visibility. 2. For certain vehicles, the lens alone is replaceable. With other vehicle models, the entire front lamp must be replaced. The exorbitant cost of replacing the front lamp is causing some people to opt to drive with densely fogged front headlight lenses risking pedestrian safety. 3. Some car dealership offer a "defogging" cleaning service for greater visibility but does not guarantee to restore the car's front illumination to minimum required safety standards. Recommendation Require vehicle manufacturers to make front headlights with detachable lenses, or make the lenses fog proof. A replaceable lens is cost effective for all income individuals. Making lens replacement affordable may decrease the number of pedestrian-vehicular accidents and fatalities. Discussion The headlight lens of my car became increasingly fogged, overtime, decreasing night visibility ahead. The Toyota dealership offered a $300 cleaning service for both lenses or replacing the headlamp at about $300 each; $600. I opted for the cleaning. When completed, the headlight lens of my vehicle looking much less fogged. When I asked, the dealership told me that their cleaning service does not guarantee compliance with minimum front safety illumination for night driving. I was told that my car does not come with removable lenses. To ensure minimum safety front night visibility, I purchase new headlamps total costing about $300 each; I spent $900 because the $300 cleaning service was completed and not deductible. I contacted Toyota management and went up the chain of command

The Brake Booster or Actuator is failing, without any indication or warning lights on the dash alarming us to the problem. The car has been making weird sounds, but after being inspected, this, according to the Authorized Toyota Dealer, on December 22, 2022, is a life-threatening and very dangerous malfunction to myself and others around me when driving. This is the first hybrid car we have owned, and we thought the noises we had been hearing for a couple years was normal, because there were no warning lights coming on to tell us otherwise. The dealer did not want us to drive the car any further due to the danger of the problem. We asked the dealer to repair the problem without charge, but that request was denied by the Toyota Brand Engagement Center (Case 221222000587). The dealer is currently repairing the malfunction at a cost of approximately $2650 plus tax). We are highly disappointed with Toyota not repairing this known problem under a dealer recall.

The contact owns a 2012 Toyota Prius. The contact stated that while driving at an undisclosed speed, the brake warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed that the brake master cylinder and brake booster needed to be replaced; however, the dealer informed the contact that the repair was not covered under warranty. The vehicle was not repaired. The contact stated that the failure recurred while driving and the vehicle hesitated while the brake pedal was depressed. The contact slammed on the brake pedal and the vehicle came to a complete stop. The vehicle was towed to the residence. The manufacturer was not made aware of the failure. The failure mileage was 185,519.