NHTSA owner reports · September 18, 2026 snapshot.
Air Bags complaints
28 reportsClear category filter45,000 miles · Feb 26, 2016
Air BagsElectrical SystemHybrid Propulsion SystemCrashInjury
TL* THE CONTACT OWNED A 2012 TOYOTA PRIUS. WHILE DRIVING 60 MPH, THE ENGINE STALLED. VARIOUS WARNING LIGHTS ILLUMINATED AND A BEEPING NOISE WAS PRESENT. THE CONTACT'S VEHICLE COASTED TO A STOP AND WAS REAR ENDED BY ANOTHER VEHICLE. A POLICE REPORT WAS FILED. THE AIR BAGS DID NOT DEPLOY. THE CONTACT SUSTAINED INJURIES TO THE FORE…
Read full complaint
TL* THE CONTACT OWNED A 2012 TOYOTA PRIUS. WHILE DRIVING 60 MPH, THE ENGINE STALLED. VARIOUS WARNING LIGHTS ILLUMINATED AND A BEEPING NOISE WAS PRESENT. THE CONTACT'S VEHICLE COASTED TO A STOP AND WAS REAR ENDED BY ANOTHER VEHICLE. A POLICE REPORT WAS FILED. THE AIR BAGS DID NOT DEPLOY. THE CONTACT SUSTAINED INJURIES TO THE FOREARM THAT REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V053000 (ELECTRICAL SYSTEM, HYBRID PROPULSION SYSTEM). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS DESTROYED AND TOWED. THE FAILURE MILEAGE WAS APPROXIMATELY 45,000.......UPDATED 04/01/16 *BF *JS CONSUMER STATED THERE HAVE BEEN PREVIOUS STALLS WHICH THERE HAVE BEEN RECALLS. UPDATED 6/7/18*JB
NHTSA ODI #10838647
43,000 miles · Dec 14, 2015
Air BagsCrashInjury
WIFE IN ACCIDENT WITH SIDE IMPACT AND FRONT IMPACT APPROXIMATELY 35-40 MPH RAN OFF OF A ROAD WITH NO SHOULDER SIDE IMPACT WITH OAK TREE THEN FRONT IMPACT WITH ANOTHER OAK TREE. NO AIRBAGS DEPLOYED. VEHICLE TOTALED. EMT AND CHP COMMENTED THAT UNUSUAL THAT AIRBAGS DID NOT DEPLOY. I WAS AMAZED AS WELL!....UPDATED 12/30/15 *BF; UPDA…
Read full complaint
WIFE IN ACCIDENT WITH SIDE IMPACT AND FRONT IMPACT APPROXIMATELY 35-40 MPH RAN OFF OF A ROAD WITH NO SHOULDER SIDE IMPACT WITH OAK TREE THEN FRONT IMPACT WITH ANOTHER OAK TREE. NO AIRBAGS DEPLOYED. VEHICLE TOTALED. EMT AND CHP COMMENTED THAT UNUSUAL THAT AIRBAGS DID NOT DEPLOY. I WAS AMAZED AS WELL!....UPDATED 12/30/15 *BF; UPDATED 05/11/18*JB *TR
NHTSA ODI #10810066
30,000 miles · Nov 14, 2014
Air BagsSeat BeltsStructureCrashInjury
I WAS INVOLVED IN A FRONT END COLLISION WITH A BOBCAT FRONT END LOADER. I STRUCK THE IMPLEMENT BROADSIDE GOING 35 MPH. THERE WAS NO DAMAGE TO THE IMPLEMENT. MY CAR WAS TOTALED AND THE AIRBAG DEPLOYED. AFTER GOING TO THE HOSPITAL AND A CHEST X-RAY, ULTRASOUND, AND CT SCAN, IT WAS DIAGNOSED I HAD FRACTURED MY STERNUM. I AM SIX FE…
Read full complaint
I WAS INVOLVED IN A FRONT END COLLISION WITH A BOBCAT FRONT END LOADER. I STRUCK THE IMPLEMENT BROADSIDE GOING 35 MPH. THERE WAS NO DAMAGE TO THE IMPLEMENT. MY CAR WAS TOTALED AND THE AIRBAG DEPLOYED. AFTER GOING TO THE HOSPITAL AND A CHEST X-RAY, ULTRASOUND, AND CT SCAN, IT WAS DIAGNOSED I HAD FRACTURED MY STERNUM. I AM SIX FEET TALL AND HAD MY SEAT ALL THE WAY BACK. I AM QUESTIONING WHETHER THERE HAVE BEEN ANY OTHER PEOPLE SUSTAINING A FRACTURED STERNUM DUE TO AN AIR BAG DEPLOYMENT AT 35 MPH? *TR
NHTSA ODI #10654927
24,000 miles · Sep 12, 2014
Air BagsCrash
I WAS REAR ENDED WHILE STOPPED, BY A VEHICLE REPORTED TO BE DOING 40 MPH. MY VEHICLE SUSTAINED REAR BUMPER DAMAGE FROM THE CAR HITTING MINE AND FRONT BUMPER / ENGINE COMPARTMENT DAMAGE FROM THE CAR I SUBSEQUENTLY HIT. TOTAL DAMAGE IN EXCESS OF $11,000. THE AIR BAG DID NOT DEPLOY, BUT I DIDN'T KNOW IF THE IMPACT WAS SEVERE ENOUG…
Read full complaint
I WAS REAR ENDED WHILE STOPPED, BY A VEHICLE REPORTED TO BE DOING 40 MPH. MY VEHICLE SUSTAINED REAR BUMPER DAMAGE FROM THE CAR HITTING MINE AND FRONT BUMPER / ENGINE COMPARTMENT DAMAGE FROM THE CAR I SUBSEQUENTLY HIT. TOTAL DAMAGE IN EXCESS OF $11,000. THE AIR BAG DID NOT DEPLOY, BUT I DIDN'T KNOW IF THE IMPACT WAS SEVERE ENOUGH TO ACTIVATE IT. HOWEVER, WHEN REVIEWING THE REPAIR INVOICE, I NOTICED THE AIR BAG SENSOR WAS REPLACED. APPARENTLY IT SHOULD HAVE ACTIVATED THE SYSTEM BUT DIDN'T. *TR
NHTSA ODI #10632748
20,700 miles · Jun 29, 2014
Air BagsCrashInjury
I WAS DRIVING ON THE HIGHWAY 59 FEEDER ROAD SOUTHWARDS TOWARDS UNIVERSITY BLVD IN THE LEFT MOST LANE. A CAR CAME AND HIT THE PASSENGER SIDE OF MY CAR. DUE TO THE IMPACT MY CAR ROLLED OVER ONTO THE CURB, HIT THE GRASS AND FLIPPED BACK INTO THE LANE AGAIN. I WAS IN COMPLETE AND UTTER SHOCK AND TRAUMA AND SOON ENOUGH I NOTICED THE …
Read full complaint
I WAS DRIVING ON THE HIGHWAY 59 FEEDER ROAD SOUTHWARDS TOWARDS UNIVERSITY BLVD IN THE LEFT MOST LANE. A CAR CAME AND HIT THE PASSENGER SIDE OF MY CAR. DUE TO THE IMPACT MY CAR ROLLED OVER ONTO THE CURB, HIT THE GRASS AND FLIPPED BACK INTO THE LANE AGAIN. I WAS IN COMPLETE AND UTTER SHOCK AND TRAUMA AND SOON ENOUGH I NOTICED THE BLOOD ON ME. MY LEFT SIDE (HEAD, SHOULDER AND ELBOW) WAS PAINING BADLY. MY SEAT BELT WAS STILL ON, MY LEG WAS ON THE BRAKE AND WINDOWS SHATTERED AND GLASS WAS ALL OVER THE PLACE, AIR BAGS WERE NOT DEPLOYED. I TURNED OFF THE ENGINE, MOVED SHIFT ROD INTO PARK POSITION AND APPLIED THE HAND BRAKE. A MAN AND HIS SON (I BELIEVE) WITNESSED THE ACCIDENT AND CAME TO ME WITHIN A FEW MINUTES. THEY CALLED EMS. WHILE WAITING FOR EMERGENCY TO ARRIVE, I GOT MY CELL PHONE FROM MY BACKPACK, WHICH WAS ON THE PASSENGER SEAT, AND CALLED MY FATHER. A FEW MINUTES LATER, ANOTHER PERSON, CAME UP TO ME AND SAID HE WITNESSED THE ACCIDENT AS WELL AND STAYED NEAR MY CAR. I DID NOT MOVE FROM THE DRIVERS SEAT OR OPEN THE DOOR BECAUSE I WAS TOO AFRAID TO OPEN THE DOOR...FEW MINUTES LATER, THE EMERGENCY PERSONNEL CAME. THEY OPENED THE CAR DOOR AND CLEARED A FEW THINGS AND PUT ME ON A STRETCHER. THEY PUT A NECK BRACE AND RESTRAINED MY HEAD FROM MOVING AND STRAPPED ME ONTO THE STRETCHER. THEY PICKED UP MY BACKPACK AS WELL. MY DAD CAME AS THEY WERE PUTTING ME ON THE STRETCHER. I WAS IMMEDIATELY RUSHED TO THE NEAREST ER. .. I HAVE CONCERN ABOUT THE AIRBAG. WHY THE AIRBAGS DID NOT DEPLOY?. WOULD YOU BE ABLE TO INVESTIGATE? I AUTHORIZE MY FATHER (PHONE NUMBER PROVIDED BELOW) TO DISCUSS ABOUT THIS INCIDENT. UPDATED 08-20-14 *BF UPDATED 8/28/2014 *JS ..UPDATED 09-09-14 *BF
NHTSA ODI #10606831
20,000 miles · May 26, 2014
Air BagsCrashInjury
AT APPROXIMATELY 14:35 ON SATURDAY MAY 24 2014, THE CAR BEHIND ME WAS HIT BY AN SUV THAT DIDN'T BRAKE WHEN HE CAME TO A TOTALLY STOPPED LONG LINE OF TRAFFIC ON HWY 101 SB. I ESTIMATE THAT THE SUV WAS TRAVELING AT A SPEED OF AT LEAST 55 MPH WHEN IT STRUCK THE CAR BEHIND ME. THE CAR BEHIND ME THEN STRUCK THE BACK OF MY 2012 PRIUS…
Read full complaint
AT APPROXIMATELY 14:35 ON SATURDAY MAY 24 2014, THE CAR BEHIND ME WAS HIT BY AN SUV THAT DIDN'T BRAKE WHEN HE CAME TO A TOTALLY STOPPED LONG LINE OF TRAFFIC ON HWY 101 SB. I ESTIMATE THAT THE SUV WAS TRAVELING AT A SPEED OF AT LEAST 55 MPH WHEN IT STRUCK THE CAR BEHIND ME. THE CAR BEHIND ME THEN STRUCK THE BACK OF MY 2012 PRIUS PLUG-IN VEHICLE PUSHING THE FRONT OF MY CAR INTO ANOTHER SUV IN FRONT OF ME. 4 VEHICLES WERE INVOLVED, OTHERS TOOK HEAVY DAMAGE. NONE OF MY AIRBAGS DEPLOYED, AND I BEGAN FEELING LOWER LEFT SIDE NECK PAINS THE DAY AFTER THE ACCIDENT. *TR
NHTSA ODI #10594053
22,000 miles · May 16, 2014
Air BagsCrashInjury
TL* THE CONTACT OWNS A 2012 TOYOTA PRIUS. THE CONTACT STATED THAT WHILE TRAVELING APPROXIMATELY 40 MPH, ANOTHER VEHICLE CRASHED INTO THE REAR PASSENGER SIDE OF THE VEHICLE. THE AIR BAGS DID NOT DEPLOY. THE VEHICLE SPUN AROUND AND ROLLED OVER. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED A HEAD CONCUSSION AND A BULGING DISK I…
Read full complaint
TL* THE CONTACT OWNS A 2012 TOYOTA PRIUS. THE CONTACT STATED THAT WHILE TRAVELING APPROXIMATELY 40 MPH, ANOTHER VEHICLE CRASHED INTO THE REAR PASSENGER SIDE OF THE VEHICLE. THE AIR BAGS DID NOT DEPLOY. THE VEHICLE SPUN AROUND AND ROLLED OVER. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED A HEAD CONCUSSION AND A BULGING DISK IN HIS BACK INJURY. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 13V014000 (AIR BAGS). THE APPROXIMATE FAILURE MILEAGE WAS 22,000.
NHTSA ODI #10588901
43,230 miles · Apr 22, 2014
Air BagsCrash
TL* THE CONTACT OWNS A 2012 TOYOTA PRIUS. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, HE LOST CONTROL OF THE VEHICLE AND CRASHED. THE CONTACT COULD NOT RECALL WHAT THEY CRASHED INTO. UPON IMPACT THE AIR BAGS FAILED TO DEPLOY. THERE WERE NO INJURIES. THE VEHICLE WAS TAKEN TO A INDEPENDENT MECHANIC WHERE THE FAILURE WAS NOT DIAG…
Read full complaint
TL* THE CONTACT OWNS A 2012 TOYOTA PRIUS. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, HE LOST CONTROL OF THE VEHICLE AND CRASHED. THE CONTACT COULD NOT RECALL WHAT THEY CRASHED INTO. UPON IMPACT THE AIR BAGS FAILED TO DEPLOY. THERE WERE NO INJURIES. THE VEHICLE WAS TAKEN TO A INDEPENDENT MECHANIC WHERE THE FAILURE WAS NOT DIAGNOSED. THE MANUFACTURER WAS INFORMED OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 43,230.
NHTSA ODI #10584300
60,000 miles · Apr 10, 2014
Air BagsService BrakesCrash
TL* THE CONTACT OWNS A 2012 TOYOTA PRIUS. THE CONTACT STATED THAT WHILE DRIVING 25 MPH, THE VEHICLE WAS CRASHED INTO FROM THE REAR. THE DRIVER ATTEMPTED TO ENGAGE THE BRAKES HOWEVER, THE BRAKES BECAME UNRESPONSIVE. AS A RESULT, THE DRIVER CRASHED INTO ANOTHER VEHICLE AND THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED …
Read full complaint
TL* THE CONTACT OWNS A 2012 TOYOTA PRIUS. THE CONTACT STATED THAT WHILE DRIVING 25 MPH, THE VEHICLE WAS CRASHED INTO FROM THE REAR. THE DRIVER ATTEMPTED TO ENGAGE THE BRAKES HOWEVER, THE BRAKES BECAME UNRESPONSIVE. AS A RESULT, THE DRIVER CRASHED INTO ANOTHER VEHICLE AND THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED AND NO INJURIES WERE REPORTED. THE VEHICLE WAS TOWED TO THE DEALER AND THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 60,000.
NHTSA ODI #10578888
27,000 miles · Nov 18, 2013
Air BagsExterior LightingCrash
MY 2012 PRIUS WAS HIT IN BACK ON PASSENGER SIDE AT APPROXIMATELY 80-85 MILES/HOUR WHILE MY SPEED WAS 62 M/H. WITH IMPACT FROM HIT IN THE BACK, MY CAR WENT FLYING HEAD ON INTO THE MEDIAN WALL (THOSE TEMPORARY CEMENT WALLS USED DURING RECONSTRUCTION). TWO THINGS HAPPENED WERE: 1. AFTER THE FIRST IMPACT MY PRIUS HAD TOTAL POWE…
Read full complaint
MY 2012 PRIUS WAS HIT IN BACK ON PASSENGER SIDE AT APPROXIMATELY 80-85 MILES/HOUR WHILE MY SPEED WAS 62 M/H. WITH IMPACT FROM HIT IN THE BACK, MY CAR WENT FLYING HEAD ON INTO THE MEDIAN WALL (THOSE TEMPORARY CEMENT WALLS USED DURING RECONSTRUCTION). TWO THINGS HAPPENED WERE: 1. AFTER THE FIRST IMPACT MY PRIUS HAD TOTAL POWER LOSS, NOT EVEN EMERGENCY FLASHER LIGHT WOULD TURN ON; 2. NON OF AIRBAGS DEPLOYED. I AM WONDERING IF ALL THIS IS NORMAL FOR THIS CAR OR THERE IS SOME SORT OF MALFUNCTION OR MANUFACTURING DEFECT? *TR
NHTSA ODI #10552662
Official recalls
6Oct 4, 2018
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2014 Toyota Prius and 2012-2014 Toyota Prius V vehicles. Excessive voltage in the Intelligent Power Module (IPM) within the inverter may cause the hybrid system to shut down, causing the vehicle to stall while being driven.
Consequence & remedy
Consequence: If the hybrid system shuts down unexpectedly, it can increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will update the software for the motor/generator control electronic control unit (ECU) and the hybrid control ECU as necessary, free of charge. The recall began January 22, 2019. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is J0V. Note: The software updates in this recall are needed even if the vehicle had the software previously updated under recalls 14V-053 or 15V-449.
Jun 30, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2010-2012 Toyota Prius, 2010 and 2012 Toyota Prius Plug-in Hybrid, and 2011-2012 Lexus CT200h vehicles. A weld in the curtain shield air bag inflator may crack causing one or both portions of the inflator to eject into the passenger cabin.
Consequence & remedy
Consequence: If either portion of the curtain shield air bag inflator ejects into the passenger cabin, there is an increased risk of injury to vehicle occupants.
Remedy: Toyota will notify owners, and dealers will install retention brackets to the curtain shield air bags, free of charge. The recall began on October 17, 2016. Owners may contact Toyota Customer Service Department at 1-800-331-4331. Toyota's number for this recall is Toyota G0U, and Lexus GLJ.
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Feb 12, 2014
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence & remedy
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Additional source detail variants (2)
Hybrid Propulsion System: Inverter
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Electrical System:software
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Apr 9, 2013
Southeast Toyota is recalling certain model year 2008 and 2010-2013 Toyota Tundra, 2010-2012 Rav4, 2012 Toyota Sequoia, 2010-2011 Toyota Corolla, 2010-2011 Toyota Camry and Camry Hybrid, 2010-2013 Toyota Highlander and Highlander Hybrid, 2010-2013 Toyota FJ Cruiser, 2011 Toyota Land Cruiser, 2010-2013 Toyota Venza, 2010-2011 Toyota 4Runner, 2010-2013 Toyota Tacoma, 2011-2012 Toyota Sienna, 2012 Toyota Prius, 2013 Scion FR-S, 2011 Scion XD, 2011 Scion XB, and 2012 Scion TC vehicles. These vehicles were sold with labels that were outside the allowable one percent of accuracy of actual weight added. Thus, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) Number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: An inaccurate label could lead to owners overloading their vehicles and tires. An overloaded vehicle can result in a tire failure which may result in a vehicle crash, personal injury, or property damage.
Remedy: Southeast Toyota will notify owners and provide a corrected label with instructions concerning its installation. A small group of the affected vehicles will need additonal remedies which are still being developed. The recall began on May 28, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Jan 16, 2013
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence & remedy
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Additional source detail variants (2)
Seats
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3DP23005 · Brake Actuator Valve Wear
Opened Nov 22, 2023 · No close date supplied
Status: open (inferred from source dates) · Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP19004 · Brake Actuator Valve Wear
Opened Sep 30, 2019 · Closed Jan 21, 2021
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist
On September 19, 2019, the Office of Defects Investigation (ODI) received a defect petition from Mr. Roger Hogan requesting that the Agency investigate and recall certain Toyota Prius, Prius PHV, Camry Hybrid and Avalon Hybrid vehicles for a brake actuator valve wear condition covered under Toyota Customer Support Programs ZJB and ZKK (subject CSP?s). In support of his request, the petitioner identified 117 NHTSA complaints allegedly related to the subject CSP condition, including 60 reporting crashes. On September 30, 2019, ODI opened Defect Petition DP19-004 to evaluate the petitioner?s request for an investigation. In August 2020, the petitioner notified the Agency that he was withdrawing his petition. Because the petitioner has withdrawn the petition, we are denying the petition as moot and no further analysis of this petition is necessary.NHTSA is authorized to issue an order requiring notification and remedy of a defect if the Agency?s investigation shows a defect in the design, construction, or performance of a motor vehicle that presents an unreasonable risk to safety. 49 U.S.C. ?? 30102(a)(9), 30118. Because the petitioner has with withdrawn the petition, the petition is denied as moot. This action does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency notes that it is not required to receive a defect petition prior to opening a defect investigation and will take further action if warranted by future circumstances.
Illustration