NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
2,822 reportsMileage unknown · Jul 31, 2014
Exterior Lighting
THE HEADLIGHTS BURN OUT ON A REGULAR BASIS. SHORTLY AFTER REPLACING THE BULB IT WILL BURN OUT AGAIN (USUALLY WITHIN A WEEK). AT TIMES BOTH SIDES BURN OUT AT THE SAME TIME WITHOUT WARNING CAUSING A SAFETY HAZARD. THIS IS A KNOWN PROBLEM FOR TOYOTA PRIUS PRODUCTS. WE HAVE CONTACTED THE COMPANY WHO STATES THIS PROBLEM WAS RESOL…
Read full complaint
THE HEADLIGHTS BURN OUT ON A REGULAR BASIS. SHORTLY AFTER REPLACING THE BULB IT WILL BURN OUT AGAIN (USUALLY WITHIN A WEEK). AT TIMES BOTH SIDES BURN OUT AT THE SAME TIME WITHOUT WARNING CAUSING A SAFETY HAZARD. THIS IS A KNOWN PROBLEM FOR TOYOTA PRIUS PRODUCTS. WE HAVE CONTACTED THE COMPANY WHO STATES THIS PROBLEM WAS RESOLVED WITH THE 09 MODEL YEAR AND REFUSE TO ADMIT OR ASSIST WITH REPAIRS OF THE KNOWN ELECTRICAL DEFECT. *TR
NHTSA ODI #10617830
133,508 miles · Jul 30, 2014
Electrical SystemEngineHybrid Propulsion System
THE HYBRID INVERTER ASSEMBLY FAILED WHEN I TRIED TO ACCELERATE FROM A STOP ONTO A RURAL HIGHWAY. THIS OCCURRED APPROXIMATELY TWO MONTHS AFTER RECEIVING THE MOTOR GENERATOR ECU AND POWER MANAGEMENT ECU SOFTWARE UPDATE THAT WAS INTENDED TO PREVENT THIS TYPE OF FAILURE.I WAS NOTIFIED OF THIS UPDATE/RECALL IN LATE MARCH 2014 AND HAD…
Read full complaint
THE HYBRID INVERTER ASSEMBLY FAILED WHEN I TRIED TO ACCELERATE FROM A STOP ONTO A RURAL HIGHWAY. THIS OCCURRED APPROXIMATELY TWO MONTHS AFTER RECEIVING THE MOTOR GENERATOR ECU AND POWER MANAGEMENT ECU SOFTWARE UPDATE THAT WAS INTENDED TO PREVENT THIS TYPE OF FAILURE.I WAS NOTIFIED OF THIS UPDATE/RECALL IN LATE MARCH 2014 AND HAD THE UPDATE COMPLETED AT A AUTHORIZED TOYOTA SERVICE CENTER. *TR
NHTSA ODI #10617731
48,000 miles · Jul 30, 2014
Service Brakes
TL* THE CONTACT OWNS A 2010 TOYOTA PRIUS. WHILE DRIVING 40 MPH OVER A BUMP IN THE ROAD, THE VEHICLE LOST BRAKING CAPABILITY FOR A FEW SECONDS. THE FAILURE OCCURRED EACH TIME THE VEHICLE WAS DRIVEN OVER A BUMP OR POTHOLE. THE DEALER ADJUSTED THE BRAKES, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAI…
Read full complaint
TL* THE CONTACT OWNS A 2010 TOYOTA PRIUS. WHILE DRIVING 40 MPH OVER A BUMP IN THE ROAD, THE VEHICLE LOST BRAKING CAPABILITY FOR A FEW SECONDS. THE FAILURE OCCURRED EACH TIME THE VEHICLE WAS DRIVEN OVER A BUMP OR POTHOLE. THE DEALER ADJUSTED THE BRAKES, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 48,000. UPDATED 09/02/14*LJ
NHTSA ODI #10617667
27,000 miles · Jul 26, 2014
Service Brakes
EXITING FROM THE HIGHWAY, I SLOWED WHILE I APPROACHED A STOP SIGN. AS THE PRIUS WENT OVER A BUMP, DECELERATION WAS INTERRUPTED. THE PRIUS MOMENTARILY SEEMED TO LURCH FORWARD; BUT WITHIN A SHORT TIME BRAKING RESUMED. THIS IS DISTURBING CAR BEHAVIOR. IF THERE WAS A CAR DIRECTLY IN FRONT OF ME, I WOULD HAVE HIT IT. *TR
NHTSA ODI #10616524
70,000 miles · Jul 19, 2014
Service BrakesCrash
I BROUGHT MY 2010 PRIUS INTO THE TOYOTA MARIN (CALIFORNIA) DEALER IN JANUARY 2014 IN RESPONSE TO THEIR RECALL RELATED TO PROBLEMS WITH STEPPING ON THE BRAKE AND HAVING THE PRIUS ACCELERATE RATHER THAN STOP. THE CORRECTIVE SOFTWARE WAS PRESUMABLY INSTALLED. FAST FORWARD TO FATHER'S DAY, JUNE 15, 2014. I AM PARKING MY PRIUS FOR…
Read full complaint
I BROUGHT MY 2010 PRIUS INTO THE TOYOTA MARIN (CALIFORNIA) DEALER IN JANUARY 2014 IN RESPONSE TO THEIR RECALL RELATED TO PROBLEMS WITH STEPPING ON THE BRAKE AND HAVING THE PRIUS ACCELERATE RATHER THAN STOP. THE CORRECTIVE SOFTWARE WAS PRESUMABLY INSTALLED. FAST FORWARD TO FATHER'S DAY, JUNE 15, 2014. I AM PARKING MY PRIUS FOR A FATHER'S DAY BRUNCH. I'M GOING ABOUT TWO MILES PER HOUR INTO A PARKING SPACE. I PUT MY FOOT ON THE BRAKE. THE CAR ACCELERATES. I MENTALLY DOUBLE CHECK THAT I HAVE MY FOOT ON THE BRAKE. I DO. OUT OF CONTROL, THE CAR JUMPS THE CURB AND SMASHES RIGHT INTO A TREE. MY WIFE ASKS IF MY FOOT IS ON THE BRAKE. I TRIPLE CHECK. IT STILL IS--I HAVEN'T MOVED IT. A WEEK LATER I FEEL THE TRAUMA OF CONSTANTLY VISUALIZING THE POSSIBILITY OF HAVING TRIED TO STOP AT A CROSS WALK AND KILLING A FAMILY ON THE WAY TO THEIR FATHER'S DAY BRUNCH. --IT TOOK THREE DAYS OF CONSTANT CALLING AND DYSFUNCTIONAL EXTENSIONS TO CONNECT WITH A PRIUS CASE MANAGER. THEN SHE INFORMED ME IT WOULD TAKE ME MORE THAN A MONTH TO HAVE MY CAR INSPECTED AND GET AN ASSESSMENT. IF I RENTED A CAR THERE WOULD BE NO ASSURANCE IT WOULD BE COVERED. --THIS PROBLEM HAPPENED AFTER I RESPONDED TO THE RECALL. HOW CAN I TRUST A CAR THAT IS AUTOMATICALLY CRASHING AFTER THAT PRECISE PROBLEM HAS ALLEGEDLY BEEN ADDRESSED? --I JUST RECEIVED (JULY 19, 2014) A LETTER FROM TOYOTA SALES SAYING THE CAR'S BRAKES AND ACCELERATOR WERE TESTED AND "ALL IS FINE." HOWEVER, IN MY AND OTHERS' SIMILAR EXPERIENCES THE SURGE HAPPENS ONLY OCCASIONALLY. WE BOUGHT THE CAR USED, HAVE GONE ABOUT 20,000 MILES WITH IT, AND NEVER HAD THE PROBLEM. SO A TEST EVEN FOR A YEAR AT A TIME IS IRRELEVANT. --MY "ASK": SINCE OTHERS SHARE THIS EXPERIENCE AND IT COULD RESULT IN DEATH, I WANT TOYOTA TO SELL THIS CAR FOR PARTS AND RECALL THE 2010 PRIUS UNTIL A SOLUTION CAN BE FOUND. I AM SHOCKED AT PRIUS' IRRESPONSIBILITY. *TR
NHTSA ODI #10614771
50,000 miles · Jul 2, 2014
Electrical SystemElectronic Stability Control (esc)Engine
WAS TRAVELING ABOUT 65 MPH ON ROUTE 11 IN CT WHEN RED LIGHTS COME ON AND CAR SLOWS TO 20 MPH.PULLE TO SIDE OF ROAD AND CALLED AAA/TOWED TO HARTFORD TOYOTA IN HARTFORD CT. FIRST TOLD IT WAS A HYBRID BATTERY THEN TOLD IT WAS THE INVERTER WHICH THEY SAID IS ON BACK ORDER. NOW I,M GETTING THE RUN AROUND FROM THE MAIN OFFICE IN CALI…
Read full complaint
WAS TRAVELING ABOUT 65 MPH ON ROUTE 11 IN CT WHEN RED LIGHTS COME ON AND CAR SLOWS TO 20 MPH.PULLE TO SIDE OF ROAD AND CALLED AAA/TOWED TO HARTFORD TOYOTA IN HARTFORD CT. FIRST TOLD IT WAS A HYBRID BATTERY THEN TOLD IT WAS THE INVERTER WHICH THEY SAID IS ON BACK ORDER. NOW I,M GETTING THE RUN AROUND FROM THE MAIN OFFICE IN CALIFORNIA.. BROUGHT CAR IN FOR A RECALL ON SOFTWARE UPDATE IN FEB 2014 AND FROM WHAT I READ THIS MAY CAUSE THE INVERT TO FAIL THANKS FOR YOUR ATTENTION IN THIS MATTER. *TR
NHTSA ODI #10607655
2,000 miles · Jun 27, 2014
Service Brakes
BACK IN 2010, WE NOTICED THAT, WHEN BRAKING, THE CAR WOULD LURCH FORWARD. THIS HAPPENED SEVERAL TIMES AT RANDOM. AT THAT TIME, WE TOOK THE CAR IN TO FIX THE PROBLEM. VICTORY TOYOTA IN CANTON, MICHIGAN, TOLD US THAT THERE WAS NOTHING WRONG; THEIR DIAGNOSIS AND COMPUTERS SHOWED THAT NO ERRORS HAD OCCURRED. WE DROVE IT FOR A SHO…
Read full complaint
BACK IN 2010, WE NOTICED THAT, WHEN BRAKING, THE CAR WOULD LURCH FORWARD. THIS HAPPENED SEVERAL TIMES AT RANDOM. AT THAT TIME, WE TOOK THE CAR IN TO FIX THE PROBLEM. VICTORY TOYOTA IN CANTON, MICHIGAN, TOLD US THAT THERE WAS NOTHING WRONG; THEIR DIAGNOSIS AND COMPUTERS SHOWED THAT NO ERRORS HAD OCCURRED. WE DROVE IT FOR A SHORT TIME, AND IT CONTINUED TO HAVE THE ISSUE. WE TOOK IT BACK IN TO THE DEALERSHIP, THEY AGAIN SAID THAT THERE WAS NOTHING WRONG. THEY SAID THAT THEY TOOK IT FOR A TEST DRIVE, AND NOTHING HAPPENED. WE WERE MADE TO THINK THAT THE ISSUE WAS IN OUR HEADS, SO WE TOOK THE CAR BACK AND TRIED TO DEAL WITH THE ISSUE, EVEN THOUGH IT CONTINUED OVER THE YEARS. FINALLY, THIS YEAR, WE NEARLY GOT INTO TWO SEPARATE ACCIDENTS AS A DIRECT RESULT OF THIS SUDDEN LURCHING FORWARD. I TOOK THE CAR BACK INTO THE SERVICE DEPARTMENT OF VICTORY TOYOTA, AND WAS TOLD BLUNTLY THAT THERE WAS NEVER A RECALL FOR THIS ISSUE, THAT, UNLESS I COULD RECREATE THE PROBLEM WITH A TECHNICIAN IN THE CAR, I WAS MAKING THINGS UP. THAT IS WHAT LEAD TO THIS COMPLAINT. I DID SOME RESEARCH AND FOUND THAT THE CAR HAD INDEED BEEN RECALLED FOR THIS BRAKE ISSUE WITH RECALL ID # 68066. SO THEY LIED ABOUT THE RECALL HISTORY FOR MY CAR. ALSO, RECREATING SOMETHING THAT HAPPENS AT RANDOM DURING A FINITE TIME PERIOD, SUCH AS A TEST DRIVE, IS IMPROBABLE, AND TO MAKE SERVICING THE CAR CONTINGENT ON THAT TEST DRIVE IS LUDICROUS. I AM HOPING THAT, BY LODGING THIS COMPLAINT SOMETHING WILL GET DONE BEFORE MY WIFE, ME, OR/AND SOMEONE ELSE IS/ARE KILLED BECAUSE OF THIS ISSUE. *TR
NHTSA ODI #10606419
32,979 miles · Jun 24, 2014
Tires
TL* THE CONTACT OWNS A 2010 TOYOTA PRIUS. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, THE DRIVER SIDE TIRE BECAME LOW ON AIR. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO NOTICED THAT THE VALVE STEM SENSOR WAS DEFECTIVE AND HAD IT REPLACED. TWENTY MINUTES LATER THE TIRE SENSOR WARNING ILLUMINATED AND THE REAR PASSENGER…
Read full complaint
TL* THE CONTACT OWNS A 2010 TOYOTA PRIUS. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, THE DRIVER SIDE TIRE BECAME LOW ON AIR. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO NOTICED THAT THE VALVE STEM SENSOR WAS DEFECTIVE AND HAD IT REPLACED. TWENTY MINUTES LATER THE TIRE SENSOR WARNING ILLUMINATED AND THE REAR PASSENGER TIRE WAS ALSO LOW AND THE STEM VALVE HAD TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 32,979.
NHTSA ODI #10605572
36,000 miles · Jun 24, 2014
Exterior Lighting
LOW BEAM HEADLIGHT BULBS BURN OUT MUCH FASTER THAN THEY SHOULD. I HAVE REPLACED BOTH LOW BEAM BULBS AT LEAST 6 TIMES IN THE LAST 2 YEARS. TYPICAL BULBS SHOULD LAST WELL OVER A YEAR, WHEREAS MINE ONLY LAST 2-3 MONTHS. I DO NOT DRIVE WITH HEADLIGHTS ON DURING THE DAY. THIS HAPPENS WITH BOTH LOW BEAMS, BUT NOT SIMULTANEOUSLY. AS A …
Read full complaint
LOW BEAM HEADLIGHT BULBS BURN OUT MUCH FASTER THAN THEY SHOULD. I HAVE REPLACED BOTH LOW BEAM BULBS AT LEAST 6 TIMES IN THE LAST 2 YEARS. TYPICAL BULBS SHOULD LAST WELL OVER A YEAR, WHEREAS MINE ONLY LAST 2-3 MONTHS. I DO NOT DRIVE WITH HEADLIGHTS ON DURING THE DAY. THIS HAPPENS WITH BOTH LOW BEAMS, BUT NOT SIMULTANEOUSLY. AS A RESULT, I AM INSTALLING NEW BULBS EVERY OTHER MONTH. I NEVER TOUCH THE BULBS (ALWAYS WEAR DISPOSABLE GLOVES) SO THIS IS NOT A RESULT OF FINGER OIL REDUCING THE BULB LIFE. *TR
NHTSA ODI #10605550
36,000 miles · Jun 24, 2014
Service Brakes
WHEN BRAKING AT A SLOW SPEED THE CAR WILL SUDDENLY STOP BRAKING, WITH BRAKES STILL BEING APPLIED, WHENEVER A ROUGH SURFACE IS ENCOUNTERED, FOR EXAMPLE BUMPS OR POTHOLES. THIS LOSS OF BRAKING HAPPENS EVERYTIME A ROUGH SURFACE IS ENCOUNTERED DURING BRAKING AND IS EASY TO REPLICATE. *TR
NHTSA ODI #10605546
Official recalls
10Oct 4, 2018
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2014 Toyota Prius and 2012-2014 Toyota Prius V vehicles. Excessive voltage in the Intelligent Power Module (IPM) within the inverter may cause the hybrid system to shut down, causing the vehicle to stall while being driven.
Consequence & remedy
Consequence: If the hybrid system shuts down unexpectedly, it can increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will update the software for the motor/generator control electronic control unit (ECU) and the hybrid control ECU as necessary, free of charge. The recall began January 22, 2019. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is J0V. Note: The software updates in this recall are needed even if the vehicle had the software previously updated under recalls 14V-053 or 15V-449.
Jun 30, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2010-2012 Toyota Prius, 2010 and 2012 Toyota Prius Plug-in Hybrid, and 2011-2012 Lexus CT200h vehicles. A weld in the curtain shield air bag inflator may crack causing one or both portions of the inflator to eject into the passenger cabin.
Consequence & remedy
Consequence: If either portion of the curtain shield air bag inflator ejects into the passenger cabin, there is an increased risk of injury to vehicle occupants.
Remedy: Toyota will notify owners, and dealers will install retention brackets to the curtain shield air bags, free of charge. The recall began on October 17, 2016. Owners may contact Toyota Customer Service Department at 1-800-331-4331. Toyota's number for this recall is Toyota G0U, and Lexus GLJ.
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Feb 12, 2014
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence & remedy
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Additional source detail variants (2)
Hybrid Propulsion System: Inverter
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Electrical System:software
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Jun 5, 2013
Toyota is recalling certain model year 2010 Prius vehicles manufactured March 31, 2009, through October 9, 2009; and model year 2010 Lexus HS250h vehicles manufactured June 19, 2009, through October 9, 2009. Nitrogen gas from a component of the brake booster pump assembly could leak into the brake fluid.
Consequence & remedy
Consequence: As nitrogen is released into the brake fluid, the brake pedal may have reduced hydraulic pressure. Under certain circumstances, this condition could affect stopping distance and increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the affected brake booster pump assemblies. The recall began on August 7, 2013. Owners may contact Toyota at 1-800-331-4331.
Jan 16, 2013
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence & remedy
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Additional source detail variants (2)
Seats
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Feb 9, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2010 TOYOTA PRIUS AND LEXUS HS250H PASSENGER VEHICLES. CUSTOMERS HAVE EXPERIENCED INCONSISTENT BRAKE FEEL AFTER ABS ACTUATION DURING SLOW AND STEADY APPLICATION OF THE BRAKES ON ROUGH OR SLICK ROAD SURFACES. STOPPING DISTANCES MAY BE INCREASED COMPARED WITH A CUSTOMER'S EXPECTATION FOR A GIVEN PEDAL FORCE.
Consequence & remedy
Consequence: VEHICLE STOPPING DISTANCES MAY INCREASE RELATIVE TO A CUSTOMER'S EXPECTATION INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REWRITE THE PROGRAMMING OF THE ABS CONTROL UNIT FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 3, 2010, AND IS EXPECTED TO BE COMPLETED IN LATE MARCH 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 AND LEXUS AT 1-800-255-3987.
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4DP23005 · Brake Actuator Valve Wear
Opened Nov 22, 2023 · No close date supplied
Status: open (inferred from source dates) · Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP19004 · Brake Actuator Valve Wear
Opened Sep 30, 2019 · Closed Jan 21, 2021
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist
On September 19, 2019, the Office of Defects Investigation (ODI) received a defect petition from Mr. Roger Hogan requesting that the Agency investigate and recall certain Toyota Prius, Prius PHV, Camry Hybrid and Avalon Hybrid vehicles for a brake actuator valve wear condition covered under Toyota Customer Support Programs ZJB and ZKK (subject CSP?s). In support of his request, the petitioner identified 117 NHTSA complaints allegedly related to the subject CSP condition, including 60 reporting crashes. On September 30, 2019, ODI opened Defect Petition DP19-004 to evaluate the petitioner?s request for an investigation. In August 2020, the petitioner notified the Agency that he was withdrawing his petition. Because the petitioner has withdrawn the petition, we are denying the petition as moot and no further analysis of this petition is necessary.NHTSA is authorized to issue an order requiring notification and remedy of a defect if the Agency?s investigation shows a defect in the design, construction, or performance of a motor vehicle that presents an unreasonable risk to safety. 49 U.S.C. ?? 30102(a)(9), 30118. Because the petitioner has with withdrawn the petition, the petition is denied as moot. This action does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency notes that it is not required to receive a defect petition prior to opening a defect investigation and will take further action if warranted by future circumstances.
PE10006 · Braking Performance, Hybrid Vehicle
Opened Feb 3, 2010 · Closed Jul 12, 2010
Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module ; Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:foundation Components:disc; Service Brakes, Hydraulic:power Assist; Service Brakes, Hydraulic:power Assist:hydraulic
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Additional source detail variants (7)
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:foundation Components:disc
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:foundation Components
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:power Assist:hydraulic
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:power Assist
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Illustration