IllustrationThe rear axle beam broke off near the passenger side rear wheel. The wheel flops around and the vehicle is totally unsafe to drive.
2010 Toyota Prius
Owner reports · Recalls · Investigations
More warning signs than most Prius years
Owner complaints for the 2010 Toyota Prius are substantially higher than the model-year median of 164.
About this comparison →How this year compares
Owner complaints by model year
Compare all Prius years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1,4880–25K
14825–50K
12650–75K
13675–100K
221100–150K
145150K+
2,264 reports with mileage · 558 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 849 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes. Review the 593 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Electric. Review the 502 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
183 crash reports13 fire reports48 injury reports
Wheels complaints
17 reportsI had begun to notice a slight shimmy at highway speed for a few days, but it wasn't pronounced enough to cause concern, especially since the weather was very windy and already subjecting the car to heavy crosswinds. On Monday, [XXX], the shimmy became suddenly more pronounced, so I pulled off the highway ([XXX]) and parallel-pa…
Read full complaint
I had begun to notice a slight shimmy at highway speed for a few days, but it wasn't pronounced enough to cause concern, especially since the weather was very windy and already subjecting the car to heavy crosswinds. On Monday, [XXX], the shimmy became suddenly more pronounced, so I pulled off the highway ([XXX]) and parallel-parked on street in Cambridge, MA. While parking, I heard a loud creaking and grinding sound, and the car no longer responded to steering inputs. I exited the car and noticed the rear driver's side wheel protruding at a strange angle from the wheel well. I called AAA and the tow truck driver discovered that, behind the wheel, where the wheel meets the rear axle, the arm had rusted clean through. In other words, the wheel had completely fallen off, and was being held to the car only by the brake line. I was towed to a mechanic in Salem, MA. Both the Salem mechanic and the AAA tow truck driver said that they had never seen anything like this in all the years they'd been servicing cars. I told them that the car had never been in a flood or otherwise involved in the kind of extraordinary event that would cause more than typical rust exposure. Had the wheel come off at highway speed, I could have been seriously injured or killed. The issue did not seem to have been caused by driver/owner oversight or normal wear and tear. It seems highly unusual and potentially indicative of a defect or manufacturing error. I hope other 2010 Prius owners are aware of the vehicle's susceptibility to this issue. And I would like Toyota to take some responsibility for the high cost of repair. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
I was driving my 2010 Toyota Prius and my car started beeping when I was driving when I tried to slow down the car was not able to stop the breaking system ABS started displaying and my car started to beep and it won’t stop beeping. I did take my car to the dealer for a recalled inspection after my car broke down and I was no lo…
Read full complaint
I was driving my 2010 Toyota Prius and my car started beeping when I was driving when I tried to slow down the car was not able to stop the breaking system ABS started displaying and my car started to beep and it won’t stop beeping. I did take my car to the dealer for a recalled inspection after my car broke down and I was no longer able to drive for my own safety. After I took the car to Downey Toyota for hybrid recall they didn’t tell me anything but on the document they gave me it did state that the ABS was a problem. Now my car is still not able to be used because of my own safety concerns since the vehicle won’t break when I put the brake pedal and a none stop beeping sound that won’t stop at all.
Low pitched rumbling sound from front wheel well when car is moving between 5-25 mph.
THE CAR I HAVE 3 DASH LIGHTS WE PULL THE CODE THROUGH COMPUTER IT WAS C13 91. THAT MEANS THE CAR HAVE AN ACTUATOR IT'S NOT WORKING SO THE BRAKE SYSTEM IS NOT WORKING PROPERLY AND THE ABS LIGHT TRACTION LIGHT THE BRAKE LIGHT ARE ON ALL THE TIME . SOMETIME THEY GO OFF AND SOMETIMES THEY TURN BACK ON USUALLY IT'S MORE ON TIME THAN…
Read full complaint
THE CAR I HAVE 3 DASH LIGHTS WE PULL THE CODE THROUGH COMPUTER IT WAS C13 91. THAT MEANS THE CAR HAVE AN ACTUATOR IT'S NOT WORKING SO THE BRAKE SYSTEM IS NOT WORKING PROPERLY AND THE ABS LIGHT TRACTION LIGHT THE BRAKE LIGHT ARE ON ALL THE TIME . SOMETIME THEY GO OFF AND SOMETIMES THEY TURN BACK ON USUALLY IT'S MORE ON TIME THAN OFF TIME. I DID RESEARCH AND FIND OUT VERY COMMON WITH 2010-2015 PRIUS MODEL WENT TO TOYOTA DEALERSHIP AT RIVERDALE WEST SPRINGFIELD MASSACHUSETTS NO HELP. IT'S A KNOWN PROBLEM THEY AGREE BUT MY CAR IS 10 YEARS OLD OR 150000 MILES OVER SO NO WARRANTY PLEASE HELP I AM A POOR UBER DRIVER 4 DAUGHTER AND WIFE I AM THE ONLY BIRD FEEDER [XXX] IS MY CELL AND [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
TL* THE CONTACT OWNED A 2010 TOYOTA PRIUS. WHILE DRIVING 60 MPH, THE FRONT WHEELS SHOOK AND THE CONTACT LOST CONTROL OF THE STEERING WHEEL. THE CONTACT CRASHED INTO ANTHER VEHICLE, WHICH THEN CAUSED THE OTHER VEHICLE TO CRASH HEAD ON INTO A MEDIAN. THE AIR BAGS DEPLOYED. THERE WERE NO INJURIES. A POLICE REPORT WAS FILED. THE VEH…
Read full complaint
TL* THE CONTACT OWNED A 2010 TOYOTA PRIUS. WHILE DRIVING 60 MPH, THE FRONT WHEELS SHOOK AND THE CONTACT LOST CONTROL OF THE STEERING WHEEL. THE CONTACT CRASHED INTO ANTHER VEHICLE, WHICH THEN CAUSED THE OTHER VEHICLE TO CRASH HEAD ON INTO A MEDIAN. THE AIR BAGS DEPLOYED. THERE WERE NO INJURIES. A POLICE REPORT WAS FILED. THE VEHICLE WAS DEEMED TOTALED AND WAS TOWED TO THE CONTACT'S HOME, AWAITING AN INVESTIGATION. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 18V684000 (HYBRID PROPULSION SYSTEM). THE FAILURE MILEAGE WAS APPROXIMATELY 120,000.
AT APPROXIMATELY 85,000 MILES, I NOTICED A LOW HUMMING/RUBBING SOUND COMING FROM MY WHEELS. AFTER HAVING THE VEHICLE INSPECTED, IT WAS FOUND THAT THE FRONT RIGHT WHEEL BEARING NEEDED TO BE REPLACED. WHEEL BEARINGS TYPICALLY DON'T NEED TO BE REPLACED UNTIL AROUND 150,000-200,000 MILES, ON AVERAGE. THE TECHNICIAN TOLD ME THAT IT W…
Read full complaint
AT APPROXIMATELY 85,000 MILES, I NOTICED A LOW HUMMING/RUBBING SOUND COMING FROM MY WHEELS. AFTER HAVING THE VEHICLE INSPECTED, IT WAS FOUND THAT THE FRONT RIGHT WHEEL BEARING NEEDED TO BE REPLACED. WHEEL BEARINGS TYPICALLY DON'T NEED TO BE REPLACED UNTIL AROUND 150,000-200,000 MILES, ON AVERAGE. THE TECHNICIAN TOLD ME THAT IT WASN'T YET LOOSE AND THAT I COULD REPLACE IT WITHIN A COUPLE OF MONTHS. I HAVE NOW NOTICED LOOSE STEERING AND THE SOUND HAS GROWN LOUDER, SO I WILL BE REPLACING THE BEARING SO THAT I DO NOT RISK THE WHEEL BREAKING OFF FROM MY VEHICLE WHILE DRIVING ON THE HIGHWAY TO AND FROM WORK. HAVING TO REPLACE THE BEARING THIS EARLY IN THE VEHICLE'S LIFE SEEMS EXCESSIVE, AND FROM MY ONLINE RESEARCH, IT SEEMS THAT I AM NOT THE ONLY ONE TO REALIZE THIS. I'VE ALSO HAD TROUBLE TRACKING DOWN THE PART THROUGH MY LOCAL PARTS STORES, WHICH CONCERNS ME AS WELL BECAUSE THEY DON'T KNOW WHY THEY DON'T CARRY THE PART, OR WHY IT IS SO EXPENSIVE TO ORDER ONLINE. HAS THERE BEEN A SHORTAGE OF THIS PART BECAUSE OF A DEFECT OR NUMEROUS REPLACEMENTS? IF THE WHEEL WERE TO BREAK OFF WHILE DRIVING ON THE FREEWAY, IT COULD EASILY RESULT IN A FATAL ACCIDENT. PLEASE INVESTIGATE. *TR
REAR WHEEL BEARINGS FAILED AT 61000 MILES. *TR
I TURNED INTO A PARKING LOT AND STAYED WAY TO THE RIGHT BECAUSE OF A LARGE TRUCK ON THE DRIVERS SIDE AND WENT OVER THE CURB AND BOTH TIRES BLEW. *TR
THIS A SECOND PAIR OF NEW TIRES WE BUY. THEY WERE WORN UNEVENLY. WE DO TIRE ROTATION EVERY 5,000 MILES AND ALIGNMENT EVERY 10,000 MILES. HOWEVER, THE CAR ITS THE TIRES VERY UNEVENLY. THE TIRE PRESSURE IS CHECKED AND KEPT AT THE GIVEN MANUFACTURER RECOMMENDATIONS. ALL MY FRIENDS THAT OWN TOYOTA'S HAVE SIMILAR PROBLEMS. THIS IS A …
Read full complaint
THIS A SECOND PAIR OF NEW TIRES WE BUY. THEY WERE WORN UNEVENLY. WE DO TIRE ROTATION EVERY 5,000 MILES AND ALIGNMENT EVERY 10,000 MILES. HOWEVER, THE CAR ITS THE TIRES VERY UNEVENLY. THE TIRE PRESSURE IS CHECKED AND KEPT AT THE GIVEN MANUFACTURER RECOMMENDATIONS. ALL MY FRIENDS THAT OWN TOYOTA'S HAVE SIMILAR PROBLEMS. THIS IS A SERIOUS ISSUE THAT COULD LEAD TO AN ACCIDENT IF THE TIRES GET TORN WHEN DRIVING. PLUS WE ARE DAMAGING THE ENVIRONMENT WHEN WE ARE REPLACING THE TIRES SO OFTEN. I HAD SIMILAR TIRES IN A DIFFERENT CAR, THEY LASTED 90,000 MILES. HERE I CANNOT GET 25,000 MILES OUT OF THEM. *TR
Official recalls
1018V684000 · Hybrid Propulsion System
Oct 4, 2018
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2014 Toyota Prius and 2012-2014 Toyota Prius V vehicles. Excessive voltage in the Intelligent Power Module (IPM) within the inverter may cause the hybrid system to shut down, causing the vehicle to stall while being driven.
Consequence & remedy
Consequence: If the hybrid system shuts down unexpectedly, it can increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will update the software for the motor/generator control electronic control unit (ECU) and the hybrid control ECU as necessary, free of charge. The recall began January 22, 2019. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is J0V. Note: The software updates in this recall are needed even if the vehicle had the software previously updated under recalls 14V-053 or 15V-449.
16V487000 · Air Bags:side/window
Jun 30, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2010-2012 Toyota Prius, 2010 and 2012 Toyota Prius Plug-in Hybrid, and 2011-2012 Lexus CT200h vehicles. A weld in the curtain shield air bag inflator may crack causing one or both portions of the inflator to eject into the passenger cabin.
Consequence & remedy
Consequence: If either portion of the curtain shield air bag inflator ejects into the passenger cabin, there is an increased risk of injury to vehicle occupants.
Remedy: Toyota will notify owners, and dealers will install retention brackets to the curtain shield air bags, free of charge. The recall began on October 17, 2016. Owners may contact Toyota Customer Service Department at 1-800-331-4331. Toyota's number for this recall is Toyota G0U, and Lexus GLJ.
16V396000 · Seats:front Assembly:seat Heater/cooler
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
14V743000 · Seats:front Assembly:seat Heater/cooler
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
14V053000 · Electrical System:software; Hybrid Propulsion System: Inverter
Feb 12, 2014
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence & remedy
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Additional source detail variants (2)
Hybrid Propulsion System: Inverter
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Electrical System:software
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
13V235000 · Service Brakes
Jun 5, 2013
Toyota is recalling certain model year 2010 Prius vehicles manufactured March 31, 2009, through October 9, 2009; and model year 2010 Lexus HS250h vehicles manufactured June 19, 2009, through October 9, 2009. Nitrogen gas from a component of the brake booster pump assembly could leak into the brake fluid.
Consequence & remedy
Consequence: As nitrogen is released into the brake fluid, the brake pedal may have reduced hydraulic pressure. Under certain circumstances, this condition could affect stopping distance and increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the affected brake booster pump assemblies. The recall began on August 7, 2013. Owners may contact Toyota at 1-800-331-4331.
13V014000 · Air Bags:frontal:sensor/control MODULE-INACTIVE ; Seats
Jan 16, 2013
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence & remedy
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Additional source detail variants (2)
Seats
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
10V039000 · Service Brakes, Air:antilock:control Unit/module
Feb 9, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2010 TOYOTA PRIUS AND LEXUS HS250H PASSENGER VEHICLES. CUSTOMERS HAVE EXPERIENCED INCONSISTENT BRAKE FEEL AFTER ABS ACTUATION DURING SLOW AND STEADY APPLICATION OF THE BRAKES ON ROUGH OR SLICK ROAD SURFACES. STOPPING DISTANCES MAY BE INCREASED COMPARED WITH A CUSTOMER'S EXPECTATION FOR A GIVEN PEDAL FORCE.
Consequence & remedy
Consequence: VEHICLE STOPPING DISTANCES MAY INCREASE RELATIVE TO A CUSTOMER'S EXPECTATION INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REWRITE THE PROGRAMMING OF THE ABS CONTROL UNIT FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 3, 2010, AND IS EXPECTED TO BE COMPLETED IN LATE MARCH 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 AND LEXUS AT 1-800-255-3987.
10V035000 · Equipment:other:labels
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
10V036000 · Equipment:other:labels
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4DP23005 · Brake Actuator Valve Wear
Opened Nov 22, 2023 · No close date supplied
Status: open (inferred from source dates) · Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP19004 · Brake Actuator Valve Wear
Opened Sep 30, 2019 · Closed Jan 21, 2021
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist
On September 19, 2019, the Office of Defects Investigation (ODI) received a defect petition from Mr. Roger Hogan requesting that the Agency investigate and recall certain Toyota Prius, Prius PHV, Camry Hybrid and Avalon Hybrid vehicles for a brake actuator valve wear condition covered under Toyota Customer Support Programs ZJB and ZKK (subject CSP?s). In support of his request, the petitioner identified 117 NHTSA complaints allegedly related to the subject CSP condition, including 60 reporting crashes. On September 30, 2019, ODI opened Defect Petition DP19-004 to evaluate the petitioner?s request for an investigation. In August 2020, the petitioner notified the Agency that he was withdrawing his petition. Because the petitioner has withdrawn the petition, we are denying the petition as moot and no further analysis of this petition is necessary.NHTSA is authorized to issue an order requiring notification and remedy of a defect if the Agency?s investigation shows a defect in the design, construction, or performance of a motor vehicle that presents an unreasonable risk to safety. 49 U.S.C. ?? 30102(a)(9), 30118. Because the petitioner has with withdrawn the petition, the petition is denied as moot. This action does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency notes that it is not required to receive a defect petition prior to opening a defect investigation and will take further action if warranted by future circumstances.
PE10006 · Braking Performance, Hybrid Vehicle
Opened Feb 3, 2010 · Closed Jul 12, 2010
Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module ; Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:foundation Components:disc; Service Brakes, Hydraulic:power Assist; Service Brakes, Hydraulic:power Assist:hydraulic
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Additional source detail variants (7)
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:foundation Components:disc
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:foundation Components
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:power Assist:hydraulic
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:power Assist
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.