NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
2,822 reportsMileage unknown · Jan 24, 2025
Service Brakes
Break booster fail. Will cause the breaks to fail. There was a voluntary recall on these but I never recieveed the letter in the mail. Thr break booster failed after the voluntary recall was up. Toyota said they cannot help with this. Other prius owners i talked to have the same issue with their 2010 prius break boosters and als…
Read full complaint
Break booster fail. Will cause the breaks to fail. There was a voluntary recall on these but I never recieveed the letter in the mail. Thr break booster failed after the voluntary recall was up. Toyota said they cannot help with this. Other prius owners i talked to have the same issue with their 2010 prius break boosters and also did not get the letter in the mail.
NHTSA ODI #11638279
Mileage unknown · Jan 24, 2025
Service Brakes
Abs lights on, traction light on .Actuator running cicle constantly . Breaks felt spongy
NHTSA ODI #11638253
Mileage unknown · Jan 23, 2025
Service BrakesUnknown Or Other
My car, a 2010 Toyota Prius, Level V has about 161,000 miles on it, and I have driven about 140K of those miles over the last 13 years. I have traveled around the DC/Maryland area and also taken the car on long trips. The car has been reliable, safe, and predictable... EXCEPT in one place/instance. I have probably driven a doz…
Read full complaint
My car, a 2010 Toyota Prius, Level V has about 161,000 miles on it, and I have driven about 140K of those miles over the last 13 years. I have traveled around the DC/Maryland area and also taken the car on long trips. The car has been reliable, safe, and predictable... EXCEPT in one place/instance. I have probably driven a dozen times or more to the BWI airport from my home in Chevy Chase. On the return drive on [XXX], as I drive towards an overpass that is just before the [XXX] exit, my Prius goes into "Emergency Approaching Collision" mode. The brakes automatically forcibly apply, the seatbelt/lap harness grab me, and there is an emergency beeping from the system. The first time this happened... probably 10 years ago, it was very startling. My car was traveling about 60-65 mph. Luckily, there were no cars behind me... and I remained calm enough not to overreact. I was so startled that I needed to pull over to regain my composure. In one of the numerous other cases on this happening, my wife was in the car and she basically wanted me to sell the car because she felt it was unsafe. Because I am aware of the situation with my car, I always am cautious when I am driving towards the [XXX] exit. I drive slower, watch carefully for surrounding vehicles beside or behind me. But even yesterday, I was driving very slowly (approximately 35 mph). While I did not feel the system take aggressive avoidance/safety actions, still the warning beeps did take place... a little unnerving, but I had come to expect a problem at that site. In any event, I did want to bring the matter to your agency. Sincerely, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11638175
Mileage unknown · Jan 23, 2025
Service Brakes
ABS Pump/Motor failed. Lost power and control over the breaks . ABS light on
NHTSA ODI #11638170
Mileage unknown · Jan 15, 2025
Service BrakesCrashInjury
I was coming to an intersection where two cars were waiting for a right turn. I pressed on the brakes and nothing happened. The car continued to move without slowing down. The brakes felt "blocked" and unresponsive. I engaged the manual break at the last moment and that slowed me down. But I still hit the car in front of me wh…
Read full complaint
I was coming to an intersection where two cars were waiting for a right turn. I pressed on the brakes and nothing happened. The car continued to move without slowing down. The brakes felt "blocked" and unresponsive. I engaged the manual break at the last moment and that slowed me down. But I still hit the car in front of me which in turn hit another car in front of it. The police report says "following too close". But I was not following other cars. The two cars were already at the intersection. I was just coming to this intersection and attempted to slow down as usual. Except that the brakes did not respond. My car was a total loss.
NHTSA ODI #11636160
Mileage unknown · Jan 15, 2025
Forward Collision AvoidanceService Brakes
Twice while I was driving on the highway, my ABS and brake light came on, and my brakes became less sensitive to pressure. That is to say, it took more effort and I had to push my brakes further towards the floor in order for them to respond. I went to an independent mechanic and got the code C1391 which indicates a brake pump a…
Read full complaint
Twice while I was driving on the highway, my ABS and brake light came on, and my brakes became less sensitive to pressure. That is to say, it took more effort and I had to push my brakes further towards the floor in order for them to respond. I went to an independent mechanic and got the code C1391 which indicates a brake pump accumulator issue. I went to a Toyota dealership and and had the car inspected. They confirmed the C1391 code and said the brake booster assy with master cylinder pump assy was malfunctioning. However, I was never told by Toyota that this issue meant my brakes could fail at any time. My safety and the safety of others was put at risk because my brakes spontaneously became less responsive, my stopping distance was increased, and they were at risk of spontaneous failure.
NHTSA ODI #11636126
Mileage unknown · Jan 4, 2025
Service Brakes
I recently had an issue with the brake actuator on my 2010 Toyota Prius, showing error code C1391. This caused reduced braking efficiency, and research shows it’s a common safety concern with Priuses. While there was a recall, it has expired, leaving owners like me without support. I kindly request an investigation to address th…
Read full complaint
I recently had an issue with the brake actuator on my 2010 Toyota Prius, showing error code C1391. This caused reduced braking efficiency, and research shows it’s a common safety concern with Priuses. While there was a recall, it has expired, leaving owners like me without support. I kindly request an investigation to address this critical issue for the safety of all affected drivers.
NHTSA ODI #11634124
105,336 miles · Jan 3, 2025
Service Brakes, Hydraulic
The contact owns a 2010 Toyota Prius. The contact stated that while her husband was driving 25 MPH, the brake pedal was depressed but the vehicle failed to respond. The contact stated that several unknown warning lights illuminated with an audible chime being heard. The contact's husband pulled over to the side of the road and d…
Read full complaint
The contact owns a 2010 Toyota Prius. The contact stated that while her husband was driving 25 MPH, the brake pedal was depressed but the vehicle failed to respond. The contact stated that several unknown warning lights illuminated with an audible chime being heard. The contact's husband pulled over to the side of the road and depressed the brake pedal and the pedal went to the floorboard and the brakes started to respond as needed. The vehicle was towed to an independent mechanic where it was diagnosed and determined that the brake pads and rotors needed to be replaced. The vehicle was repaired but the failure persisted. The contact stated while driving at an undisclosed speed, the brake pedal was depressed, and there was an abnormal sound coming from the brakes. The contact stated that the brake pedal went to the floorboard. The contact then towed the vehicle to the residence. The vehicle was taken to the dealer but was not yet diagnosed or repaired. The manufacturer was made aware of the failure and offered a Customer Satisfaction Program Extended warranty repair. The failure mileage was approximately 105,336.
NHTSA ODI #11633892
Mileage unknown · Dec 24, 2024
Engine
At around 1000,000 miles my Toyota Prius started burning oil like crazy. The dealer did an oil consumption test and confirmed the problem. I had to have my engine rebuilt because the rings were not seating properly. I had to bear all costs even though this is clearly a manufacturing default.
NHTSA ODI #11632271
117,000 miles · Dec 18, 2024
Service Brakes, Hydraulic
The contact owns a 2010 Toyota Prius. The contact stated while driving at undisclosed speeds, while depressing the brake pedal the vehicle failed to come to a complete stop and the brake pedal was firm. No warning light was illuminated. The vehicle was towed to a local independent mechanic where it was diagnosed and determined t…
Read full complaint
The contact owns a 2010 Toyota Prius. The contact stated while driving at undisclosed speeds, while depressing the brake pedal the vehicle failed to come to a complete stop and the brake pedal was firm. No warning light was illuminated. The vehicle was towed to a local independent mechanic where it was diagnosed and determined that the brake module needed to be replaced. The local dealer was not contacted. The vehicle was not diagnosed or repaired due to the cost. The manufacturer was made aware of the failure. The failure mileage was approximately 117,000.
NHTSA ODI #11631483
Official recalls
10Oct 4, 2018
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2014 Toyota Prius and 2012-2014 Toyota Prius V vehicles. Excessive voltage in the Intelligent Power Module (IPM) within the inverter may cause the hybrid system to shut down, causing the vehicle to stall while being driven.
Consequence & remedy
Consequence: If the hybrid system shuts down unexpectedly, it can increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will update the software for the motor/generator control electronic control unit (ECU) and the hybrid control ECU as necessary, free of charge. The recall began January 22, 2019. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is J0V. Note: The software updates in this recall are needed even if the vehicle had the software previously updated under recalls 14V-053 or 15V-449.
Jun 30, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2010-2012 Toyota Prius, 2010 and 2012 Toyota Prius Plug-in Hybrid, and 2011-2012 Lexus CT200h vehicles. A weld in the curtain shield air bag inflator may crack causing one or both portions of the inflator to eject into the passenger cabin.
Consequence & remedy
Consequence: If either portion of the curtain shield air bag inflator ejects into the passenger cabin, there is an increased risk of injury to vehicle occupants.
Remedy: Toyota will notify owners, and dealers will install retention brackets to the curtain shield air bags, free of charge. The recall began on October 17, 2016. Owners may contact Toyota Customer Service Department at 1-800-331-4331. Toyota's number for this recall is Toyota G0U, and Lexus GLJ.
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Feb 12, 2014
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence & remedy
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Additional source detail variants (2)
Hybrid Propulsion System: Inverter
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Electrical System:software
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Jun 5, 2013
Toyota is recalling certain model year 2010 Prius vehicles manufactured March 31, 2009, through October 9, 2009; and model year 2010 Lexus HS250h vehicles manufactured June 19, 2009, through October 9, 2009. Nitrogen gas from a component of the brake booster pump assembly could leak into the brake fluid.
Consequence & remedy
Consequence: As nitrogen is released into the brake fluid, the brake pedal may have reduced hydraulic pressure. Under certain circumstances, this condition could affect stopping distance and increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the affected brake booster pump assemblies. The recall began on August 7, 2013. Owners may contact Toyota at 1-800-331-4331.
Jan 16, 2013
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence & remedy
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Additional source detail variants (2)
Seats
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Feb 9, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2010 TOYOTA PRIUS AND LEXUS HS250H PASSENGER VEHICLES. CUSTOMERS HAVE EXPERIENCED INCONSISTENT BRAKE FEEL AFTER ABS ACTUATION DURING SLOW AND STEADY APPLICATION OF THE BRAKES ON ROUGH OR SLICK ROAD SURFACES. STOPPING DISTANCES MAY BE INCREASED COMPARED WITH A CUSTOMER'S EXPECTATION FOR A GIVEN PEDAL FORCE.
Consequence & remedy
Consequence: VEHICLE STOPPING DISTANCES MAY INCREASE RELATIVE TO A CUSTOMER'S EXPECTATION INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REWRITE THE PROGRAMMING OF THE ABS CONTROL UNIT FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 3, 2010, AND IS EXPECTED TO BE COMPLETED IN LATE MARCH 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 AND LEXUS AT 1-800-255-3987.
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4DP23005 · Brake Actuator Valve Wear
Opened Nov 22, 2023 · No close date supplied
Status: open (inferred from source dates) · Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP19004 · Brake Actuator Valve Wear
Opened Sep 30, 2019 · Closed Jan 21, 2021
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist
On September 19, 2019, the Office of Defects Investigation (ODI) received a defect petition from Mr. Roger Hogan requesting that the Agency investigate and recall certain Toyota Prius, Prius PHV, Camry Hybrid and Avalon Hybrid vehicles for a brake actuator valve wear condition covered under Toyota Customer Support Programs ZJB and ZKK (subject CSP?s). In support of his request, the petitioner identified 117 NHTSA complaints allegedly related to the subject CSP condition, including 60 reporting crashes. On September 30, 2019, ODI opened Defect Petition DP19-004 to evaluate the petitioner?s request for an investigation. In August 2020, the petitioner notified the Agency that he was withdrawing his petition. Because the petitioner has withdrawn the petition, we are denying the petition as moot and no further analysis of this petition is necessary.NHTSA is authorized to issue an order requiring notification and remedy of a defect if the Agency?s investigation shows a defect in the design, construction, or performance of a motor vehicle that presents an unreasonable risk to safety. 49 U.S.C. ?? 30102(a)(9), 30118. Because the petitioner has with withdrawn the petition, the petition is denied as moot. This action does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency notes that it is not required to receive a defect petition prior to opening a defect investigation and will take further action if warranted by future circumstances.
PE10006 · Braking Performance, Hybrid Vehicle
Opened Feb 3, 2010 · Closed Jul 12, 2010
Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module ; Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:foundation Components:disc; Service Brakes, Hydraulic:power Assist; Service Brakes, Hydraulic:power Assist:hydraulic
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Additional source detail variants (7)
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:foundation Components:disc
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:foundation Components
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:power Assist:hydraulic
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:power Assist
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Illustration