NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
2,822 reports200,000 miles · Jul 2, 2019
Service Brakes
EVEN THOUGH THE BREAK PADS ARE NEW, THE BREAKS ARE NOT WORKING AT ALL WHEN VEHICLE IS IN MOTION. THEY DO NOT FEEL TIGHT. THE VEHICLE LOOSES STABILITY IN CURVES AT A LOW SPEED ( SLIPS) AND KEEPS MOVING EVEN WHEN BREAKS ARE PUSHED TO THE END. ALL THE BREAK LIGHTS ARE ON. THERE ARE SEVERAL RECALLS REGARDING THE BREAKS OF THIS VEHI…
Read full complaint
EVEN THOUGH THE BREAK PADS ARE NEW, THE BREAKS ARE NOT WORKING AT ALL WHEN VEHICLE IS IN MOTION. THEY DO NOT FEEL TIGHT. THE VEHICLE LOOSES STABILITY IN CURVES AT A LOW SPEED ( SLIPS) AND KEEPS MOVING EVEN WHEN BREAKS ARE PUSHED TO THE END. ALL THE BREAK LIGHTS ARE ON. THERE ARE SEVERAL RECALLS REGARDING THE BREAKS OF THIS VEHICLE YEAR 2010 AND NONE APPLIES TO THE VEHICLE VIN NUMBER. IT IT NOT RELIABLE AT ALL IN THE HIGHWAY. IN ORDER TO BRAKE THE SPEED MUST BE VERY SLOW AND THE DISTANCE MUST BE WAY MORE THAN NORMAL
NHTSA ODI #11229070
93,000 miles · Jun 26, 2019
Service BrakesCrash
TL* THE CONTACT OWNS A 2010 TOYOTA PRIUS. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 5 MPH, THE BRAKE PEDAL WAS DEPRESSED BUT FAILED TO OPERATE. THE VEHICLE CRASHED INTO THE REAR OF ANOTHER VEHICLE. A POLICE REPORT WAS FILED. THERE WERE NO INJURIES SUSTAINED. THE VEHICLE WAS DRIVEN FROM THE CRASH SITE TO THE RESIDENC…
Read full complaint
TL* THE CONTACT OWNS A 2010 TOYOTA PRIUS. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 5 MPH, THE BRAKE PEDAL WAS DEPRESSED BUT FAILED TO OPERATE. THE VEHICLE CRASHED INTO THE REAR OF ANOTHER VEHICLE. A POLICE REPORT WAS FILED. THERE WERE NO INJURIES SUSTAINED. THE VEHICLE WAS DRIVEN FROM THE CRASH SITE TO THE RESIDENCE. SUNNYSIDE TOYOTA LOCATED AT 27000 LORAIN RD, NORTH OLMSTED, OH 44070, (440) 777-9911, WAS CONTACTED AND AN APPOINTMENT WAS SCHEDULED TO HAVE THE VEHICLE DIAGNOSED WHICH WAS STILL PENDING. THE VEHICLE WAS NOT REPAIRED. THE CONTACT STATED THAT THE FAILURE WAS INTERMITTENT. THE MANUFACTURER WAS NOT CONTACTED OR NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 93,000.
NHTSA ODI #11222718
117,000 miles · Jun 23, 2019
Service Brakes
ALL BRAKE, ABS, AND TRACTION CONTROL LIGHTS CAME ON. CHECKED ABS CODE AND RECEIVED C1391. MECHANIC CAN HERE THE ACTUATOR CONTINUOUSLY RUNNING AND BELIEVE THE PUMP/ACTUATOR IS BAD. I HAVE SEEN THIS RECALLED ON 2010 MADE BETWEEN MARCH 2009, AND OCTOBER 2009. MY MANUFACTURE DATE IS SEPT 2010. VEHICLE WAS IN MOTION WHEN THE LIGH…
Read full complaint
ALL BRAKE, ABS, AND TRACTION CONTROL LIGHTS CAME ON. CHECKED ABS CODE AND RECEIVED C1391. MECHANIC CAN HERE THE ACTUATOR CONTINUOUSLY RUNNING AND BELIEVE THE PUMP/ACTUATOR IS BAD. I HAVE SEEN THIS RECALLED ON 2010 MADE BETWEEN MARCH 2009, AND OCTOBER 2009. MY MANUFACTURE DATE IS SEPT 2010. VEHICLE WAS IN MOTION WHEN THE LIGHTS CAME ON. THE CAR BECAME HARD TO STOP AND REGENERATIVE BRAKING IS NO LONGER WORKING.
NHTSA ODI #11222016
213,492 miles · Jun 18, 2019
Electrical SystemFuel/propulsion SystemVehicle Speed Control
CAR WORKED FLAWLESSLY AND WE MAINTAINED IT REGULARLY. TOOK IT IN TO ADDRESS RECALL OF JOV UPDATE PWR MGMT ECU AT DEALER. DEALER COMPLETED RECALL WORK. 2 DAYS LATER ENGINE LITE CHECK HYBRID SYSTEM AND THE ! ON AND TRIANGLE ON. THE CAR CONTINUED RUN BUT NOW WAS STUDDERING WHEN WAS NOT BEFORE THE RECALL WORK. TOOK IT BACK TO T…
Read full complaint
CAR WORKED FLAWLESSLY AND WE MAINTAINED IT REGULARLY. TOOK IT IN TO ADDRESS RECALL OF JOV UPDATE PWR MGMT ECU AT DEALER. DEALER COMPLETED RECALL WORK. 2 DAYS LATER ENGINE LITE CHECK HYBRID SYSTEM AND THE ! ON AND TRIANGLE ON. THE CAR CONTINUED RUN BUT NOW WAS STUDDERING WHEN WAS NOT BEFORE THE RECALL WORK. TOOK IT BACK TO THE DEALER AND HE SAID WE NEED A NEW HYBRID BATTERY. WE BELIEVE THE SOFTWARE UPDATE THEY DID CREATED A THIS ISSUE. DEALER ACTING IGNORANT AND SAYING IT NEEDS NEW BATTERY BECAUSE OF NUMBER OF MILES ON CAR. ASKED FOR DIAGNOSTIC PRINT OUT FROM WHEN THEY DID RECALL WORK TO THEY NEW DIAGNOSIS AND THEY WOULD NOT PROVIDE. WE BELIEVE THE RECALL UPDATE CREATED A TECHNICAL PROBLEM WITH OUR HYBRID BATTERY. WE ALSO BELIEVE THAT DEALER NOT BEING HONEST REGARDING ISSUES WITH THIS RECALL UPDATE AND IS USING IT AS AN OPPORTUNITY TO REDUCE LIABILITY FOR TOYOTA ON FAILED RECALL WORK AND TO USE IT AS AN OPPORTUNITY TO BRING IN LARGE TICKET SALES REPAIR IE THEY QUOTED US A NEW HYBRID BATTERY FOR 5,500.
NHTSA ODI #11221081
120,000 miles · Jun 9, 2019
Service Brakes
LOUD SCREECHING NOISE AND VIBRATION AT BRAKE PEDAL. ABS BRAKE AND TRACTION LIGHTS ALL LIT UP ALONG WITH BEEPING. HAS HAPPENED SPORADICALLY OVER LAST 2 YEARS. HAVE OWENS CAR 5 YES. APPROX 120,000 MILES. WHEN THE BRAKE NOISE AND ALL LIGHTS APPEAR ON DASH VERY LOW BRAKING ABILITY. HAPPENS WHEN DRIVING OR STARING CAR. ON 6/6 LIGHTS …
Read full complaint
LOUD SCREECHING NOISE AND VIBRATION AT BRAKE PEDAL. ABS BRAKE AND TRACTION LIGHTS ALL LIT UP ALONG WITH BEEPING. HAS HAPPENED SPORADICALLY OVER LAST 2 YEARS. HAVE OWENS CAR 5 YES. APPROX 120,000 MILES. WHEN THE BRAKE NOISE AND ALL LIGHTS APPEAR ON DASH VERY LOW BRAKING ABILITY. HAPPENS WHEN DRIVING OR STARING CAR. ON 6/6 LIGHTS AND BRAKING FAILED AND DO NOT TURN OFF. TOOK TO SERVICE AT TOYOTA DEALER & TECH SAYS $3000 PLUS FOR REPAIRS. POSSIBLE LEAK IN ABS PUMP??
NHTSA ODI #11218777
305,000 miles · Jun 3, 2019
Service Brakes
WITHOUT WARNING, TOTAL FAILURE OF POWER ASSIST TO BRAKES. NUMEROUS DASH WARNING LIGHTS AND LOUD BUZZER SOUNDS. REQUIRES EXTREME BRAKE PEDAL FORCE TO STOP THE CAR. EXTREMELY UNNERVING AND DANGEROUS SITUATION.
NHTSA ODI #11217633
81,400 miles · May 8, 2019
Service Brakes
STARTED CAR ONE MORNING, IMMEDIATELY NOTICED THE 'ABS', 'BRAKE', AND 'TRACTION CONTROL' WARNING LIGHTS WERE ON SIMULTANEOUSLY. TOOK THE CAR FOR A DRIVE AROUND THE CORNER, AND IMMEDIATELY NOTICED BRAKES WERE VERY SOFT AND UNRESPONSIVE. PEDAL LITERALLY SINKS TO THE FLOOR WHILE AIR CAN BE HEARD LEAKING FROM THE SYSTEM/PEDAL. . ALSO…
Read full complaint
STARTED CAR ONE MORNING, IMMEDIATELY NOTICED THE 'ABS', 'BRAKE', AND 'TRACTION CONTROL' WARNING LIGHTS WERE ON SIMULTANEOUSLY. TOOK THE CAR FOR A DRIVE AROUND THE CORNER, AND IMMEDIATELY NOTICED BRAKES WERE VERY SOFT AND UNRESPONSIVE. PEDAL LITERALLY SINKS TO THE FLOOR WHILE AIR CAN BE HEARD LEAKING FROM THE SYSTEM/PEDAL. . ALSO NOTICED THE BRAKES NO LONGER RECHARGE THE SYSTEM, AND THEY ALSO FEEL JERKY AT TIMES. I CHECKED THE BRAKE FLUID RESERVOIR, AND NOTICED FLUID WAS HALFWAY BETWEEN MAX AND LOW. PERHAPS A LEAK SOMEWHERE IN THE SYSTEM? I CONTACTED MY LOCAL TOYOTA DEALER AND WILL HAVE THEM TAKE A LOOK AT IT ON 05/10/2019 ACCORDING TO SOME RESEARCH I CONDUCTED, THIS IS A KNOWN ISSUE IN THE 2010/2011 MODELS. SUPPOSEDLY, OVER TIME, VIBRATIONS CAN ACTUALLY CRACK THE LINE(S) FEEDING INTO THE BRAKE MASTER CYLINDER, AND THUS RESULTING IN THIS FAULT. TOYOTA SHOULD DEFINITELY BE MORE COMMUNICATIVE ABOUT THESE ISSUES. I HAVE OWNED THIS CAR FOR 4 YEARS, AND HAVE NEVER HEARD OF THIS BEFORE. CURRENTLY NOT DRIVING THE CAR AT THE MOMENT, AS I DO NOT FEEL SAFE
NHTSA ODI #11206162
180,000 miles · May 3, 2019
Fuel/propulsion System
TL* THE CONTACT OWNS A 2010 TOYOTA PRIUS. WHILE DRIVING 70 MPH, THE VEHICLE STALLED AND THE "HYPER" SYSTEM FAILURE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TOWED TO TOYOTA OF SEATTLE (1925 AIRPORT WAY S, SEATTLE, WA 98134, (206) 382-4300) WHERE IT WAS DIAGNOSED THAT THE EGR VALVE AND INTAKE MANIFOLD NEEDED TO BE REPAIRED. …
Read full complaint
TL* THE CONTACT OWNS A 2010 TOYOTA PRIUS. WHILE DRIVING 70 MPH, THE VEHICLE STALLED AND THE "HYPER" SYSTEM FAILURE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TOWED TO TOYOTA OF SEATTLE (1925 AIRPORT WAY S, SEATTLE, WA 98134, (206) 382-4300) WHERE IT WAS DIAGNOSED THAT THE EGR VALVE AND INTAKE MANIFOLD NEEDED TO BE REPAIRED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE DEALER STATED THAT THE FUEL PUMP NEEDED TO BE REPLACED. THE FUEL PUMP WAS REPAIRED BY AN INDEPENDENT MECHANIC. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 180,000.
NHTSA ODI #11205545
165,000 miles · May 2, 2019
Engine
DRIVING WITH CRUSE CONTROL SET AT 72 MPH, DRIVING ON 4 LANE INTERSTATE. MASTER WARNING LIGHT CAME ON ALONG WITH THE FOLLOWING WARNINGS "CHECK HYBRID SYSTEM" & "CHECK PCS SYSTEM", ALL DASH LIGHTS LIT UP. ENGINE STALLED UNEXPECTEDLY AND RESULTED IN NO POWER WHEN PUSHING GAS PEDAL. STEERING WAS NOT COMPROMISED. WAS ABLE TO CROSS 3 …
Read full complaint
DRIVING WITH CRUSE CONTROL SET AT 72 MPH, DRIVING ON 4 LANE INTERSTATE. MASTER WARNING LIGHT CAME ON ALONG WITH THE FOLLOWING WARNINGS "CHECK HYBRID SYSTEM" & "CHECK PCS SYSTEM", ALL DASH LIGHTS LIT UP. ENGINE STALLED UNEXPECTEDLY AND RESULTED IN NO POWER WHEN PUSHING GAS PEDAL. STEERING WAS NOT COMPROMISED. WAS ABLE TO CROSS 3 LANES ON THE INTERSTATE TO THE SHOULDER WITH NO POWER AND THE CAR DECELERATING RAPIDLY, AGAIN WITH NO PRIOR WARNING OF ANY ISSUES. TURNED CAR OFF AND RESTARTED, WAS ABLE TO DRIVE APPROX. 25 FEET BEFORE THE ENGINE SHUT OFF UNEXPECTEDLY AGAIN LEADING TO A COMPLETE LOSS OF POWER. BREAKING AND STEERING WERE AFFECTED AFTER RESTARTING THE CAR.
NHTSA ODI #11205298
153,000 miles · Apr 22, 2019
Service Brakes
THE ABS/BRAKE LIGHT/ SLIP INIDICATOR WARNING TRIANGLE ON & OFF. MY 2010 TOYOTA PRIUS II HAS 153K MILE. THIS HAS GONE ON/OFF FOR A FEW WEEKS NOW. THE BRAKE SEEMS TO LOOSE THE HYDRAULIC POWER BRAKE. I FEEL LIKE THE BRAKES HAVE FAILED A FEW TIMES WHILE DRIVING AT HIGHER SPEEDS. I HAVE TO PUMP BRAKE AND VEHICLE BEGINS TO BRAKE ON 2…
Read full complaint
THE ABS/BRAKE LIGHT/ SLIP INIDICATOR WARNING TRIANGLE ON & OFF. MY 2010 TOYOTA PRIUS II HAS 153K MILE. THIS HAS GONE ON/OFF FOR A FEW WEEKS NOW. THE BRAKE SEEMS TO LOOSE THE HYDRAULIC POWER BRAKE. I FEEL LIKE THE BRAKES HAVE FAILED A FEW TIMES WHILE DRIVING AT HIGHER SPEEDS. I HAVE TO PUMP BRAKE AND VEHICLE BEGINS TO BRAKE ON 2ND PUMP. I'VE HAD TO TRIPLE MY STOPPING DISTANCE AS TO NOT REAR ANYONE. I WENT TO AUTOSHOP, THEY SAID IT'S THE BRAKE ACTUATOR/SENSORS THAT NEED TO BE REPLACED AND IT'S EXPENSIVE $2-3K. THEY SAID IT NEED TO BE FIX SOON BECAUSE BRAKE MIGHT FAIL AT ANY TIME. I CALLED CAMELBACK TOYOTA, PHOENIX, AZ, ED IN SERVICE DEPT SAID THERE IS NO SAFETY RECALL FOR THIS EVEN THOUGH THEY KNOW IT HAS BEEN A COMMON PROBLEM WITH PRIUSES . I CHECKED VEHICLE REPAIR HISTORY LOOKS LIKE ABS PROGRAMMING WAS FLASHED BACK IN 2/11/2010, WHEN VEHICLE WAS STILL ON THE MANUFACTURER, 3 MILES. I HAVE NOT FIXED YET. PLEASE RESEARCH THIS ISSUE FURTHER FOR SAFETY REASONS. I DO NOT WANT TO KILL ANYONE WHEN BRAKES WILL EVENTUALLY FAIL.
NHTSA ODI #11202964
Official recalls
10Oct 4, 2018
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2014 Toyota Prius and 2012-2014 Toyota Prius V vehicles. Excessive voltage in the Intelligent Power Module (IPM) within the inverter may cause the hybrid system to shut down, causing the vehicle to stall while being driven.
Consequence & remedy
Consequence: If the hybrid system shuts down unexpectedly, it can increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will update the software for the motor/generator control electronic control unit (ECU) and the hybrid control ECU as necessary, free of charge. The recall began January 22, 2019. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is J0V. Note: The software updates in this recall are needed even if the vehicle had the software previously updated under recalls 14V-053 or 15V-449.
Jun 30, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2010-2012 Toyota Prius, 2010 and 2012 Toyota Prius Plug-in Hybrid, and 2011-2012 Lexus CT200h vehicles. A weld in the curtain shield air bag inflator may crack causing one or both portions of the inflator to eject into the passenger cabin.
Consequence & remedy
Consequence: If either portion of the curtain shield air bag inflator ejects into the passenger cabin, there is an increased risk of injury to vehicle occupants.
Remedy: Toyota will notify owners, and dealers will install retention brackets to the curtain shield air bags, free of charge. The recall began on October 17, 2016. Owners may contact Toyota Customer Service Department at 1-800-331-4331. Toyota's number for this recall is Toyota G0U, and Lexus GLJ.
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Feb 12, 2014
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence & remedy
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Additional source detail variants (2)
Hybrid Propulsion System: Inverter
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Electrical System:software
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Jun 5, 2013
Toyota is recalling certain model year 2010 Prius vehicles manufactured March 31, 2009, through October 9, 2009; and model year 2010 Lexus HS250h vehicles manufactured June 19, 2009, through October 9, 2009. Nitrogen gas from a component of the brake booster pump assembly could leak into the brake fluid.
Consequence & remedy
Consequence: As nitrogen is released into the brake fluid, the brake pedal may have reduced hydraulic pressure. Under certain circumstances, this condition could affect stopping distance and increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the affected brake booster pump assemblies. The recall began on August 7, 2013. Owners may contact Toyota at 1-800-331-4331.
Jan 16, 2013
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence & remedy
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Additional source detail variants (2)
Seats
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Feb 9, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2010 TOYOTA PRIUS AND LEXUS HS250H PASSENGER VEHICLES. CUSTOMERS HAVE EXPERIENCED INCONSISTENT BRAKE FEEL AFTER ABS ACTUATION DURING SLOW AND STEADY APPLICATION OF THE BRAKES ON ROUGH OR SLICK ROAD SURFACES. STOPPING DISTANCES MAY BE INCREASED COMPARED WITH A CUSTOMER'S EXPECTATION FOR A GIVEN PEDAL FORCE.
Consequence & remedy
Consequence: VEHICLE STOPPING DISTANCES MAY INCREASE RELATIVE TO A CUSTOMER'S EXPECTATION INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REWRITE THE PROGRAMMING OF THE ABS CONTROL UNIT FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 3, 2010, AND IS EXPECTED TO BE COMPLETED IN LATE MARCH 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 AND LEXUS AT 1-800-255-3987.
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4DP23005 · Brake Actuator Valve Wear
Opened Nov 22, 2023 · No close date supplied
Status: open (inferred from source dates) · Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP19004 · Brake Actuator Valve Wear
Opened Sep 30, 2019 · Closed Jan 21, 2021
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist
On September 19, 2019, the Office of Defects Investigation (ODI) received a defect petition from Mr. Roger Hogan requesting that the Agency investigate and recall certain Toyota Prius, Prius PHV, Camry Hybrid and Avalon Hybrid vehicles for a brake actuator valve wear condition covered under Toyota Customer Support Programs ZJB and ZKK (subject CSP?s). In support of his request, the petitioner identified 117 NHTSA complaints allegedly related to the subject CSP condition, including 60 reporting crashes. On September 30, 2019, ODI opened Defect Petition DP19-004 to evaluate the petitioner?s request for an investigation. In August 2020, the petitioner notified the Agency that he was withdrawing his petition. Because the petitioner has withdrawn the petition, we are denying the petition as moot and no further analysis of this petition is necessary.NHTSA is authorized to issue an order requiring notification and remedy of a defect if the Agency?s investigation shows a defect in the design, construction, or performance of a motor vehicle that presents an unreasonable risk to safety. 49 U.S.C. ?? 30102(a)(9), 30118. Because the petitioner has with withdrawn the petition, the petition is denied as moot. This action does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency notes that it is not required to receive a defect petition prior to opening a defect investigation and will take further action if warranted by future circumstances.
PE10006 · Braking Performance, Hybrid Vehicle
Opened Feb 3, 2010 · Closed Jul 12, 2010
Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module ; Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:foundation Components:disc; Service Brakes, Hydraulic:power Assist; Service Brakes, Hydraulic:power Assist:hydraulic
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Additional source detail variants (7)
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:foundation Components:disc
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:foundation Components
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:power Assist:hydraulic
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:power Assist
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Illustration