I HAVE A 2010 PRIUS. OCCASIONALLY WHEN I GO OVER A BUMP (POTHOLE, TRAIN TRACK, ROUGH ROAD) MY CAR FEELS LIKE IT JOLTS FORWARD FOR A FEW SECONDS. THIS HAPPENS WHEN I AM NOT HITTING THE BRAKES SO I DON'T THINK IT IS COVERED BY THE ANTI-LOCK BRAKING RECALL. IT IS DIFFICULT TO REPLICATE THIS AND I HAVEN'T REPORTED IT TO THE DEALE…
Read full complaint
I HAVE A 2010 PRIUS. OCCASIONALLY WHEN I GO OVER A BUMP (POTHOLE, TRAIN TRACK, ROUGH ROAD) MY CAR FEELS LIKE IT JOLTS FORWARD FOR A FEW SECONDS. THIS HAPPENS WHEN I AM NOT HITTING THE BRAKES SO I DON'T THINK IT IS COVERED BY THE ANTI-LOCK BRAKING RECALL. IT IS DIFFICULT TO REPLICATE THIS AND I HAVEN'T REPORTED IT TO THE DEALER BECAUSE OF THIS, BUT IT HAPPENS ABOUT 1-2/WEEK. IT COULD BE A PROBLEM IN A TRAFFIC SITUATION WHERE CARS ARE FOLLOWING CLOSELY. *TR
NHTSA ODI #10308949
500 miles · Feb 12, 2010
Vehicle Speed Control
THIS PROBLEM HAS EXISTED SINCE THE VEHICLE WAS PURCHASED. CRUISE CONTROL EITHER DOES NOT FUNCTION AT ALL OR FAILS TO FUNCTION CORRECTLY. SOMETIMES THE CRUISE CONTROL WILL NOT ENGAGE. SOMETIMES THE CRUISE CONTROL WILL ENGAGE PROPERLY, BUT AFTER APPLYING THE BRAKES (AND DISENGAGING THE CRUISE CONTROL) THE CRUISE CONTROL CANNO…
Read full complaint
THIS PROBLEM HAS EXISTED SINCE THE VEHICLE WAS PURCHASED. CRUISE CONTROL EITHER DOES NOT FUNCTION AT ALL OR FAILS TO FUNCTION CORRECTLY. SOMETIMES THE CRUISE CONTROL WILL NOT ENGAGE. SOMETIMES THE CRUISE CONTROL WILL ENGAGE PROPERLY, BUT AFTER APPLYING THE BRAKES (AND DISENGAGING THE CRUISE CONTROL) THE CRUISE CONTROL CANNOT BE REENGAGED. TWO OPERATIONS WILL CAUSE THE CRUISE CONTROL TO BEGIN FUNCTIONING PROPERLY AGAIN: 1) TURN THE VEHICLE OFF; 2) PUT THE SHIFT LEVER INTO THE NEUTRAL POSITION, THEN BACK INTO DRIVE. RETURNED VEHICLE TO DEALER THREE TIMES FOR REPAIR. THEY DID NOT FIX THE MALFUNCTION DURING ANY OF THE THREE REPAIR VISITS. THEIR FINAL RESPONSE WAS TO CLAIM THAT THE VEHICLE WAS "FUNCTIONING AS DESIGNED". *TR
NHTSA ODI #10308886
7,000 miles · Feb 12, 2010
Vehicle Speed Control
USING CRUISE CONTROL FEATURE,WHEN I HIT THE BRAKE FOR SPLIT SECOND THE CAR SPEEDS UP BEFORE DISENGAGING CRUISE CONTROL THIS HAPPEN ALL THE TIME NOT ON JUST THE DATE BELOW. *TR
NHTSA ODI #10308868
Mileage unknown · Feb 11, 2010
Service Brakes, HydraulicVehicle Speed Control
I HAVE A 2010 PRIUS. WE HAVE HAD THE PROBLEM WITH THE BRAKES WHEN WE GO OVER A BUMP. IN ADDITION, IF I AM DRIVING IN CRUISE CONTROL AND HAVE TO PUT MY FOOT ON THE BRAKES, THERE IS A BRIEF FEELING OF ACCELERATION SO INSTEAD I HAVE GOTTEN USED TO TURNING OFF THE CRUISE CONTROL BEFORE PUTTING MY FOOT ON THE BRAKES THEREBY DELAYIN…
Read full complaint
I HAVE A 2010 PRIUS. WE HAVE HAD THE PROBLEM WITH THE BRAKES WHEN WE GO OVER A BUMP. IN ADDITION, IF I AM DRIVING IN CRUISE CONTROL AND HAVE TO PUT MY FOOT ON THE BRAKES, THERE IS A BRIEF FEELING OF ACCELERATION SO INSTEAD I HAVE GOTTEN USED TO TURNING OFF THE CRUISE CONTROL BEFORE PUTTING MY FOOT ON THE BRAKES THEREBY DELAYING BRAKING FOR A BRIEF MOMENT. *TR
NHTSA ODI #10308765
100 miles · Feb 10, 2010
Vehicle Speed Control
I OWN A TOYOTA 2010 PRIUS. I COMPLAINED TO THE DEALERSHIP WHERE I BOUGHT MY CAR IN JULY AT MY FIRST SERVICE/OIL CHANGE ABOUT A SUDDEN SURGE IN SPEED WHILE DRIVING OVER BUMPY SURFACES. I PRESENTED THEM WITH INTERNET INFORMATION I HAD COPIED FROM CONSUMERS HAVING THE SAME PROBLEM BUT THEY WOULD NOT TAKE THEM FROM ME. THEY SERV…
Read full complaint
I OWN A TOYOTA 2010 PRIUS. I COMPLAINED TO THE DEALERSHIP WHERE I BOUGHT MY CAR IN JULY AT MY FIRST SERVICE/OIL CHANGE ABOUT A SUDDEN SURGE IN SPEED WHILE DRIVING OVER BUMPY SURFACES. I PRESENTED THEM WITH INTERNET INFORMATION I HAD COPIED FROM CONSUMERS HAVING THE SAME PROBLEM BUT THEY WOULD NOT TAKE THEM FROM ME. THEY SERVICED THE CAR, DROVE IT AND RETURNED IT TO ME SAYING THEY FOUND NO PROBLEMS AND THAT I WAS THE ONLY PERSON WHO HAD EVER COMPLAINED ABOUT IT. THEY SAID THEY KNEW OF NO OTHER SIMILAR COMPLAINTS. I ASKED THEM TO PUT ON MY BILL THE FACT THAT THIS WAS HAPPENING TO MY CAR SO THAT IT WOULD BE DOCUMENTED FOR THE FUTURE. THEY DID NOT SEEM AT ALL CONCERNED AT THE TIME. IT REMAINS AN ONGOING PROBLEM WHEN I DRIVE. *TR
NHTSA ODI #10308390
150 miles · Feb 9, 2010
Vehicle Speed Control
2010 TOYOTA PRIUS, PURCHASED NOV. 2009. USING CRUISE CONTROL, THE CAR ACCELERATED QUICKLY ON IT'S OWN WHEN I ATTEMPTED TO CHANGE SPEED BY USING THE CRUISE CONTROL LEVER ON THE STEERING WHEEL. HAPPENED TWICE, THEN I STOPPED EXPERIMENTING FOR REASONS OF SAFETY. THE PROBLEM IS IDENTICAL TO THE ONE DESCRIBED BY STEVE WOSNIAK IN PUB…
Read full complaint
2010 TOYOTA PRIUS, PURCHASED NOV. 2009. USING CRUISE CONTROL, THE CAR ACCELERATED QUICKLY ON IT'S OWN WHEN I ATTEMPTED TO CHANGE SPEED BY USING THE CRUISE CONTROL LEVER ON THE STEERING WHEEL. HAPPENED TWICE, THEN I STOPPED EXPERIMENTING FOR REASONS OF SAFETY. THE PROBLEM IS IDENTICAL TO THE ONE DESCRIBED BY STEVE WOSNIAK IN PUBLIC TWO WEEKS AGO--ONE THAT GOT A LOT OF PRESS. ACCELERATION STOPPED WHEN BRAKE PEDAL WAS TAPPED OR CRUISE CONTROL WAS TURNED OFF. *TR
NHTSA ODI #10308201
1,000 miles · Feb 9, 2010
Service Brakes, HydraulicVehicle Speed Control
I HAVE EXPERIENCED TWO PROBLEMS WITH MY 2010 PRIUS V THAT I PURCHASED LAST SUMMER. FIRST, ON APPROXIMATELY 6-8 OCCASIONS, MY CAR HAS NOT STOPPED IMMEDIATELY WHEN I APPLIED THE BRAKES. THIS OCCURRED 3-4 TIMES WHEN I APPROACHED A STOP SIGN ON A ROAD BETWEEN MY HOME AND CHURCH. THE SURFACE OF THE ROAD APPROACHING THE STOP SIGN HAD…
Read full complaint
I HAVE EXPERIENCED TWO PROBLEMS WITH MY 2010 PRIUS V THAT I PURCHASED LAST SUMMER. FIRST, ON APPROXIMATELY 6-8 OCCASIONS, MY CAR HAS NOT STOPPED IMMEDIATELY WHEN I APPLIED THE BRAKES. THIS OCCURRED 3-4 TIMES WHEN I APPROACHED A STOP SIGN ON A ROAD BETWEEN MY HOME AND CHURCH. THE SURFACE OF THE ROAD APPROACHING THE STOP SIGN HAD BEEN SCRAPED AND ROUGHENED TO GET READY FOR RE-PAVING. AS I APPROACHED AND APPLIED THE BRAKES, MY CAR SURGED FORWARD FOR ABOUT A SECOND, BUT I WAS ABLE TO STOP. THIS HAPPENED 3-4 TIMES IN OTHER LOCATIONS, AS WELL. IT IS AN INCREDIBLY STRANGE AND HELPLESS SENSATION. THIS PROBLEM WAS PROBABLY NOTED BETWEEN LATE AUGUST 2009 AND LAST OCCURRED ABOUT THREE WEEKS AGO. EVEN THOUGH I WAS FORCED TO PUT AN EXACT DATE IN THE FIELD BELOW, I HAVE NO IDEA NOW WHEN THE EXACT DATES WERE IN WHICH THIS BRAKING ISSUE OCCURRED. WHEN I BROUGHT MY CAR TO THE DEALER FOR ITS FIRST OIL CHANGE, I DESCRIBED WHAT HAD HAPPENED BUT WAS TOLD THIS HAD NOTHING TO DO WITH THE OTHER PROBLEMS THAT HAD BEEN IDENTIFIED IN THE MEDIA AS TO OTHER CARS. THE PERSON AT THE SERVICE DESK JUST KIND OF IGNORED MY COMMENTS AND WAS NOT INTERESTED IN HEARING ABOUT THE BRAKING ISSUE FURTHER. THE SECOND PROBLEM I HAVE EXPERIENCED IS THAT WHEN USING THE CRUISE CONTROL ACCELERATE FUNCTION THE CAR JUST CONTINUED ACCELERATING EVEN THOUGH I WAS NO LONGER TURNING THE CRUISE FUNCTION LEVER. THIS STOPPED WHEN I APPLIED MY BRAKES. IT DID CAUSE ME TO STOP USING THE CRUISE CONTROL DURING THAT TRIP THOUGH. THE CRUISE CONTROL ISSUE PROBABLY OCCURRED LAST AUGUST IN I-5. *TR
NHTSA ODI #10307891
Mileage unknown · Feb 9, 2010
Vehicle Speed Control
TO THE NHTSA: I AM AN OWNER OF A 2010 TOYOTA PRIUS THAT I PURCHASED IN JUNE 2009. SINCE OWNING THE VEHICLE, I HAVE HAD ABOUT A HALF-DOZEN TO A DOZEN OCCURRENCES OF THE SAME PROBLEM. AT LOW SPEEDS, WHEN THE REAR WHEEL HITS A BUMP, FOR A SPLIT-SECOND THE CAR FEELS LIKE THERE IS A BURST OF ACCELERATION AND IS OUT OF CONTROL. THIS …
Read full complaint
TO THE NHTSA: I AM AN OWNER OF A 2010 TOYOTA PRIUS THAT I PURCHASED IN JUNE 2009. SINCE OWNING THE VEHICLE, I HAVE HAD ABOUT A HALF-DOZEN TO A DOZEN OCCURRENCES OF THE SAME PROBLEM. AT LOW SPEEDS, WHEN THE REAR WHEEL HITS A BUMP, FOR A SPLIT-SECOND THE CAR FEELS LIKE THERE IS A BURST OF ACCELERATION AND IS OUT OF CONTROL. THIS LASTS ONLY A SPLIT-SECOND. I SAW ANOTHER CONSUMER IN A NEWS ARTICLE ABOUT THE PRIUS BRAKE ISSUE DESCRIBE IT THE EXACT SAME WAY. I ACTUALLY MENTIONED THIS TO MY DEALER (BERNARDI TOYOTA, FRAMINGHAM, MA) WHEN I BROUGHT THE CAR IN FOR THE 5,000 MILE SERVICE A MONTH OR SO AGO. THE SERVICE DEPT TOLD ME THAT THE BEHAVIOR IS NORMAL FOR THE HYBRID VEHICLES, AND KNOWN BY TOYOTA -- NO FIX OR ADJUSTMENT RECOMMENDED. THIS SEEMED LIKE AN ODD RESPONSE, BUT BECAUSE THEY TOLD ME THERE WAS NO SAFETY ISSUE, I LEFT IT AT THAT. I AM PROVIDING MY EXPERIENCE TO AID THE NHTSA APPLY PRESSURE ON TOYOTA TO FIX THIS PROBLEM IN THE PRIUS. *TR
NHTSA ODI #10307710
Mileage unknown · Feb 8, 2010
Service Brakes, ElectricService Brakes, HydraulicVehicle Speed Control
THE BRAKES ON MY 2010 TOYOTA PRIUS AT TIMES DO NOT ENGAGE IMMEDIATELY. IT MAY BE NECESSARY AT THOSE TIMES TO DEPRESS THE BRAKE PEDAL BY 1/3RD BEFORE BRAKING BEGINS. THERE IS A SIMILAR DELAY WHEN BRAKING IS USED TO TURN OFF CRUISE CONTROL. NEITHER OF THESE HAVE CAUSED AN ACCIDENT, BUT IN BOTH CASES THERE IS SOME RISK.
NHTSA ODI #10307470
250 miles · Feb 7, 2010
Vehicle Speed Control
SOON AFTER I GOT MY 2010 PRIUS IN AUGUST, I EXPERIENCED A BRAKING PROBLEM. THIS HAS HAPPENED ABOUT 8 MORE TIMES SO FAR. WHILE BRAKING AS I SLOWLY APPROACH A STOP SIGN OR LIGHT, IF I SIMULTANEOUSLY GO OVER A BUMP OR BREAK IN THE ROAD, THE CAR WILL LURCH FORWARD A COUPLE OF YARDS REQUIRING ME TO PUSH HARDER ON THE BRAKE WHICH TH…
Read full complaint
SOON AFTER I GOT MY 2010 PRIUS IN AUGUST, I EXPERIENCED A BRAKING PROBLEM. THIS HAS HAPPENED ABOUT 8 MORE TIMES SO FAR. WHILE BRAKING AS I SLOWLY APPROACH A STOP SIGN OR LIGHT, IF I SIMULTANEOUSLY GO OVER A BUMP OR BREAK IN THE ROAD, THE CAR WILL LURCH FORWARD A COUPLE OF YARDS REQUIRING ME TO PUSH HARDER ON THE BRAKE WHICH THEN STOPS THE CAR. THIS PROBLEM HAS ALSO HAPPENED 2 TIMES IN THE LAST WEEK WHILE DRIVING SLOWLY AND THEN BRAKING WHEN I ENCOUNTER ICE ON THE ROAD. LUCKILY, NO CARS HAVE BEEN DIRECTLY IN FRONT OF ME WHEN THIS HAS HAPPENED. I HAVE NOT REPORTED THIS TO TOYOTA BECAUSE I HAVE NOT YET SERVICED MY CAR. *TW
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2014 Toyota Prius and 2012-2014 Toyota Prius V vehicles. Excessive voltage in the Intelligent Power Module (IPM) within the inverter may cause the hybrid system to shut down, causing the vehicle to stall while being driven.
Consequence & remedy
Consequence: If the hybrid system shuts down unexpectedly, it can increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will update the software for the motor/generator control electronic control unit (ECU) and the hybrid control ECU as necessary, free of charge. The recall began January 22, 2019. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is J0V. Note: The software updates in this recall are needed even if the vehicle had the software previously updated under recalls 14V-053 or 15V-449.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2010-2012 Toyota Prius, 2010 and 2012 Toyota Prius Plug-in Hybrid, and 2011-2012 Lexus CT200h vehicles. A weld in the curtain shield air bag inflator may crack causing one or both portions of the inflator to eject into the passenger cabin.
Consequence & remedy
Consequence: If either portion of the curtain shield air bag inflator ejects into the passenger cabin, there is an increased risk of injury to vehicle occupants.
Remedy: Toyota will notify owners, and dealers will install retention brackets to the curtain shield air bags, free of charge. The recall began on October 17, 2016. Owners may contact Toyota Customer Service Department at 1-800-331-4331. Toyota's number for this recall is Toyota G0U, and Lexus GLJ.
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence & remedy
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Additional source detail variants (2)
Hybrid Propulsion System: Inverter
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Electrical System:software
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Toyota is recalling certain model year 2010 Prius vehicles manufactured March 31, 2009, through October 9, 2009; and model year 2010 Lexus HS250h vehicles manufactured June 19, 2009, through October 9, 2009. Nitrogen gas from a component of the brake booster pump assembly could leak into the brake fluid.
Consequence & remedy
Consequence: As nitrogen is released into the brake fluid, the brake pedal may have reduced hydraulic pressure. Under certain circumstances, this condition could affect stopping distance and increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the affected brake booster pump assemblies. The recall began on August 7, 2013. Owners may contact Toyota at 1-800-331-4331.
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence & remedy
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Additional source detail variants (2)
Seats
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2010 TOYOTA PRIUS AND LEXUS HS250H PASSENGER VEHICLES. CUSTOMERS HAVE EXPERIENCED INCONSISTENT BRAKE FEEL AFTER ABS ACTUATION DURING SLOW AND STEADY APPLICATION OF THE BRAKES ON ROUGH OR SLICK ROAD SURFACES. STOPPING DISTANCES MAY BE INCREASED COMPARED WITH A CUSTOMER'S EXPECTATION FOR A GIVEN PEDAL FORCE.
Consequence & remedy
Consequence: VEHICLE STOPPING DISTANCES MAY INCREASE RELATIVE TO A CUSTOMER'S EXPECTATION INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REWRITE THE PROGRAMMING OF THE ABS CONTROL UNIT FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 3, 2010, AND IS EXPECTED TO BE COMPLETED IN LATE MARCH 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 AND LEXUS AT 1-800-255-3987.
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4
DP23005 · Brake Actuator Valve Wear
Opened Nov 22, 2023 · No close date supplied
Status: open (inferred from source dates) · Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP19004 · Brake Actuator Valve Wear
Opened Sep 30, 2019 · Closed Jan 21, 2021
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist
On September 19, 2019, the Office of Defects Investigation (ODI) received a defect petition from Mr. Roger Hogan requesting that the Agency investigate and recall certain Toyota Prius, Prius PHV, Camry Hybrid and Avalon Hybrid vehicles for a brake actuator valve wear condition covered under Toyota Customer Support Programs ZJB and ZKK (subject CSP?s). In support of his request, the petitioner identified 117 NHTSA complaints allegedly related to the subject CSP condition, including 60 reporting crashes. On September 30, 2019, ODI opened Defect Petition DP19-004 to evaluate the petitioner?s request for an investigation. In August 2020, the petitioner notified the Agency that he was withdrawing his petition. Because the petitioner has withdrawn the petition, we are denying the petition as moot and no further analysis of this petition is necessary.NHTSA is authorized to issue an order requiring notification and remedy of a defect if the Agency?s investigation shows a defect in the design, construction, or performance of a motor vehicle that presents an unreasonable risk to safety. 49 U.S.C. ?? 30102(a)(9), 30118. Because the petitioner has with withdrawn the petition, the petition is denied as moot. This action does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency notes that it is not required to receive a defect petition prior to opening a defect investigation and will take further action if warranted by future circumstances.
PE10006 · Braking Performance, Hybrid Vehicle
Opened Feb 3, 2010 · Closed Jul 12, 2010
Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module ; Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:foundation Components:disc; Service Brakes, Hydraulic:power Assist; Service Brakes, Hydraulic:power Assist:hydraulic
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Additional source detail variants (7)
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:foundation Components:disc
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:foundation Components
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:power Assist:hydraulic
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:power Assist
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
2010 Toyota Prius Problems, Complaints & Recalls | Skip That Year
Illustration