NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes complaints
593 reportsClear category filter6,000 miles · May 6, 2013
Service Brakes
WHILE I WAS BRAKING TO STOP AT THE RED LIGHT, THE CAR ACCELERATED. I MOVED THE STEERING WHEEL TO HIT THE CURB TO PREVENT CROSSING THE RED LIGHT. IT HAPPENED TO ME COUPLE OF TIMES. THEN I REALIZE IT HAPPENS ONLY WHEN I AM DRIVING OVER UNEVEN SURFACE OR OVER BUMPS. IT IS REALLY SCARY. I ALMOST HIT A CAR SEATTLE DOWNTOWN GOING DOWN…
Read full complaint
WHILE I WAS BRAKING TO STOP AT THE RED LIGHT, THE CAR ACCELERATED. I MOVED THE STEERING WHEEL TO HIT THE CURB TO PREVENT CROSSING THE RED LIGHT. IT HAPPENED TO ME COUPLE OF TIMES. THEN I REALIZE IT HAPPENS ONLY WHEN I AM DRIVING OVER UNEVEN SURFACE OR OVER BUMPS. IT IS REALLY SCARY. I ALMOST HIT A CAR SEATTLE DOWNTOWN GOING DOWN THE HIT BECAUSE MY CAR ACCELERATED INSTEAD OF STOPPING. I TOOK IT THE CAR DEALER BUT THEY SAID THERE IS NO PROBLEM. I AM AFRAID THAT I MIGHT GET IN A BIG ACCIDENT. *TR
NHTSA ODI #10510855
32,000 miles · Apr 29, 2013
Electronic Stability Control (esc)Service BrakesVehicle Speed Control
VEHICLE SURGES WHEN BRAKES ARE APPLIED WHILE TRAVELING OVER RAILROAD TRACKS OR ROUGH PAVEMENT. SURGE LASTS FOR 1 TO 2 SECONDS UNTIL BRAKING RESUMES. VEHICLE BEHAVIOR CAN BE EASILY REPLICATED. *TR
NHTSA ODI #10509903
50,450 miles · Apr 17, 2013
Service Brakes
THE BRAKE BOOSTER PUMP BEGAN RUNNING CONTINUOUSLY WHEN THE VEHICLE WAS ON. WARNING LIGHTS ON THE DASH INDICATED BRAKE FAILURE AND ANTI-LOCK SYSTEM FAILURE. AFTER I TOOK THE VEHICLE TO A TOYOTA DEALER, THEY DETERMINED THAT THE BRAKE MASTER CYLINDER/ANTI-LOCK ASSEMBLY HAD FAILED. THE REPAIR TOOK TWO WEEKS AND COST $3000. *TR
NHTSA ODI #10508627
65,800 miles · Apr 11, 2013
Service Brakes
I WAS DRIVING TO WORK THIS MORNING AND A MAN STEPPED OFF THE CURB RIGHT IN FRONT OF ME (NOT IN A CROSSWALK). I HIT MY BRAKES, AND HIT A POTHOLE IN THE ROAD AT THE SAME TIME. THE CAR ACCELERATED AND FELT AS IF IT WAS SHUDDERING, IT WAS NOT BRAKING AT ALL EVEN THOUGH I MASHED THE PEDAL TO THE FLOOR. I WAS FORCED TO SWERVE TO MI…
Read full complaint
I WAS DRIVING TO WORK THIS MORNING AND A MAN STEPPED OFF THE CURB RIGHT IN FRONT OF ME (NOT IN A CROSSWALK). I HIT MY BRAKES, AND HIT A POTHOLE IN THE ROAD AT THE SAME TIME. THE CAR ACCELERATED AND FELT AS IF IT WAS SHUDDERING, IT WAS NOT BRAKING AT ALL EVEN THOUGH I MASHED THE PEDAL TO THE FLOOR. I WAS FORCED TO SWERVE TO MISS THE MAN, WHICH I THANKFULLY DID. AFTER THAT I GOT MOVING AGAIN I APPLIED THE BRAKES AND THEY WORKED FINE. WHEN I ARRIVED AT WORK I TRIED IT AGAIN BY FINDING SOME POTHOLES IN THE PARKING LOT. @ 15 MPH THE PROBLEM OCCURRED AGAIN ONLY WHEN I WAS HITTING THE POTHOLES WHILE APPLYING THE BRAKES. I WENT TO TOYOTA.COM AND FOUND THIS HAS BEEN AN ISSUE SINCE FEB 2010. I PURCHASED MY CAR IN NOV 2010; I THEN CALLED MY SERVICE DEALER AND TALKED TO THE SERVICE MANAGER WHO CLAIMED TO HAVE NEVER HEARD OF THAT PROBLEM EVEN THOUGH I TOLD HIM I FOUND THE INFO AT THE PRESSROOM.TOYOTA.COM WEBSITE. HE THEN PROCEEDED TO LET ME KNOW I SHOULD NOT BELIEVE EVERYTHING I READ IN THE INTERNET AND OFFERED TO LET ME BRING IT IN AND HE WILL LOOK AT IT. I AM LEAVING WORK EARLY TODAY TO HAVE IT LOOKED AT. *TR
NHTSA ODI #10505917
Mileage unknown · Apr 5, 2013
Service Brakes
MULTIPLIE INCIDENTS: WE WILL BE DRIVING THE VEHICLE AND HIT A BUMP / POT HOLE AND BE BRAKING, BUT THE CAR WILL ACCELERATE. *TR
NHTSA ODI #10507261
52,300 miles · Apr 5, 2013
Service Brakes
IN THE MORNING I STARTED MY CAR AND THE ABS LIGHT AND WARNING LIGHTS CAME ON AND STARTED BEEPING. I REVERSED MY CAR SLIGHTLY TO CHECK THE BRAKES AND NOTICED MY BRAKES WERE NOT BEING RESPONSIVE. I PUT THE VEHICLE INTO PARK AND CALLED THE WONDRIES TOYOTA DEALERSHIP AND TOLD THEM MY BRAKES WERE NOT FUNCTIONING PROPERLY AND MY ABS W…
Read full complaint
IN THE MORNING I STARTED MY CAR AND THE ABS LIGHT AND WARNING LIGHTS CAME ON AND STARTED BEEPING. I REVERSED MY CAR SLIGHTLY TO CHECK THE BRAKES AND NOTICED MY BRAKES WERE NOT BEING RESPONSIVE. I PUT THE VEHICLE INTO PARK AND CALLED THE WONDRIES TOYOTA DEALERSHIP AND TOLD THEM MY BRAKES WERE NOT FUNCTIONING PROPERLY AND MY ABS WARNING LIGHT WAS ON. DESPITE MY HAVING INFORMED THEM OF MY BRAKE FAILURE, THEY TOLD ME TO BRING THE CAR INTO THE DEALERSHIP. I REVERSED OUT OF MY GARAGE, SHIFTED THE CAR INTO DRIVE, AND PROCEEDED DOWN THE HILL WITH CAUTION. I DID NOT PRESS ON THE ACCELERATOR. MY CAR BEGAN TO ACCELERATE DOWN THE HILL DUE TO GRAVITY AND REACHED A SPEED OF APPROXIMATELY 15 MPH, AT WHICH TIME I PUMPED THE BRAKE PEDAL BUT THE CAR WOULD NOT STOP OR SLOW DOWN, AND IT CONTINUED MOVING DOWN THE HILL. AT THE BOTTOM OF THE HILL, AFTER TRAVELING APPROXIMATELY 1/4 OF A MILE, I TURNED RIGHT INTO A SMALL STREET WITH A SLIGHT INCLINE IN ORDER TO STOP THE MOMENTUM. MY CAR SLOWED AND I PUT ON THE EMERGENCY BRAKE AND PUT THE CAR INTO PARK. I CALLED MY BROTHER FOR HELP. WHEN HE ARRIVED, I TURNED THE CAR ON TO SHOW HIM THE FLASHING ABS WARNING. IT FLASHED FOR ABOUT ANOTHER 15 SECONDS BEFORE SUDDENLY STOPPING. MY BRAKES THEN BEGAN FUNCTIONING AGAIN THOUGH THEY FELT SPONGY WHEN I PRESSED DOWN ON IT. I TURNED ON MY EMERGENCY LIGHTS AND DROVE SLOWLY TO THE DEALERSHIP. I PARKED THE CAR AND TURNED OFF THE ENGINE. WHEN A REPRESENTATIVE CAME BY, I TURNED ON THE CAR AND SHE PRESSED DOWN ON THE BRAKE TO FEEL THEM. THE ABS LIGHTS SUDDENLY CAME ON AGAIN AND SHE SAID THE BRAKE PRESSURE DID NOT FEEL RIGHT AND THERE WAS SOMETHING DEFINITELY WRONG WITH MY BRAKES. AFTER IT WAS ASSESSED I WAS INFORMED I NEEDED A NEW ABS ACTUATOR ASSEMBLY AND AN ACCUMULATOR PUMP FOR THE MASTER CYLINDER. TOTAL COST WAS ESTIMATED AS $4600. *TR
NHTSA ODI #10507199
59,970 miles · Mar 25, 2013
Service Brakes
I WAS DRIVING MY 2010 PRIUS IN A CONGESTED AREA AND CARS IN FRONT OF ME STOPPED SUDDENLY. AS I BRAKED HARD, THE CAR SEEMED TO LURCH FORWARD FOR ABOUT ONE SECOND, MAYBE LONGER, AND THEN THE BRAKES KICKED IN. I NOTICED THAT THE ROAD WAS ROUGH. THE SURFACE WAS DRY. FORTUNATELY, I HAD ALLOWED AMPLE DISTANCE FROM THE CAR IN FRONT OF …
Read full complaint
I WAS DRIVING MY 2010 PRIUS IN A CONGESTED AREA AND CARS IN FRONT OF ME STOPPED SUDDENLY. AS I BRAKED HARD, THE CAR SEEMED TO LURCH FORWARD FOR ABOUT ONE SECOND, MAYBE LONGER, AND THEN THE BRAKES KICKED IN. I NOTICED THAT THE ROAD WAS ROUGH. THE SURFACE WAS DRY. FORTUNATELY, I HAD ALLOWED AMPLE DISTANCE FROM THE CAR IN FRONT OF ME, AND THERE WAS NO COLLISION, BUT IT WAS VERY UNSETTLING. IN THE PREVIOUS MONTH, I HAD THREE OR FOUR LESS INTENSE SENSATIONS OF "LURCHING FORWARD," WHICH OCCURRED WHEN I STOPPED AT A PARTICULAR INTERSECTION WHEN I HAD JUST STARTED THE CAR, BUT THE ROAD WAS SMOOTH. *TR
NHTSA ODI #10504487
39,000 miles · Mar 19, 2013
Service Brakes
I HAD BEEN HEARING A LOT OF GRINDING NOISES THAT JUST GOT WORSE. WHEN I WENT TO THE DEALER, THEY DISCOVERED THAT MY BRAKE PADS HAD FAILED/FROZEN. THEY REPLACED MY PADS AND MACHINED MY ROTORS. THEY COULD NOT EXPLAIN WHY A CAR I HAD FOR ONLY A LITTLE OVER A YEAR HAD THIS PROBLEM. THEY AT FIRST BLAMED MY DRIVING, AND THEN THE ROADS…
Read full complaint
I HAD BEEN HEARING A LOT OF GRINDING NOISES THAT JUST GOT WORSE. WHEN I WENT TO THE DEALER, THEY DISCOVERED THAT MY BRAKE PADS HAD FAILED/FROZEN. THEY REPLACED MY PADS AND MACHINED MY ROTORS. THEY COULD NOT EXPLAIN WHY A CAR I HAD FOR ONLY A LITTLE OVER A YEAR HAD THIS PROBLEM. THEY AT FIRST BLAMED MY DRIVING, AND THEN THE ROADS (I.E. TOO MANY GRAVEL ROADS). NOW, AT 68,300 MILES THOSE PADS HAVE NOW FAILED AGAIN. ONE IS COMPLETELY WORN DOWN AND THE ROTOR IS NOW RUSTED THROUGH. NO ONE CAN EXPLAIN WHY THIS IS HAPPENING. WHEN I DEMANDED AN ANSWER, THEY TOLD ME THAT A "BULLETIN" HAD GONE OUT TO THE DEALERS ONLY STATING THAT DUE TO THE PADS FAILING, THEY WERE "REDESIGNING" THEM. BUT, THEY WOULD ONLY REPLACE FOR FREE THOSE THAT FELL UNDER THE 36,000 MILE WARRANTY. I DON'T UNDERSTAND WHY, IN LESS THAN 69,000 MILES I HAVE HAD TO HAVE THIS REPAIR DONE NOT ONCE, BUT TWICE. THEY TELL ME NO OTHER OWNER HAS HAD THIS PROBLEM, BUT I FIND THAT HARD TO BELIEVE. CAN ANYONE TELL ME IF THERE ARE OTHER COMPLAINTS OF THIS TYPE, AND WHAT CAN BE DONE TO RECTIFY THIS PROBLEM. *TR
NHTSA ODI #10503572
52,500 miles · Mar 15, 2013
Service Brakes
EXPERIENCED A COMPLETE BRAKE FAILURE WHILE DRIVING 2010 PRIUS. DEALER INDICATES BRAKE BOOSTER FAILING AND LEAKED NITROGEN INTO MASTER CYLINDER WHICH SHOULD THEN ALSO BE REPLACED. DEALER INSIST IT IS ONE ASSEMBLY AND ESTIMATES REPLACEMENT TO BE $5,166 ($1,638 FOR BOOSTER AND $2,466 FOR MASTER CYLINDER). DUE TO THE COMPLETE WAR…
Read full complaint
EXPERIENCED A COMPLETE BRAKE FAILURE WHILE DRIVING 2010 PRIUS. DEALER INDICATES BRAKE BOOSTER FAILING AND LEAKED NITROGEN INTO MASTER CYLINDER WHICH SHOULD THEN ALSO BE REPLACED. DEALER INSIST IT IS ONE ASSEMBLY AND ESTIMATES REPLACEMENT TO BE $5,166 ($1,638 FOR BOOSTER AND $2,466 FOR MASTER CYLINDER). DUE TO THE COMPLETE WARNINGLESS FAILURE OF BRAKES WHILE IN OPERATION IT WOULD SEEM TO A CRITICAL SAFETY HAZARD DUE TO THE DESIGN FLAW IN THE COMBINED BRAKE BOOSTER AND MASTER CYLINDER BRAKE ASSEMBLY CAUSING A BRAKE FAILURE IN OPERATION. *TR
NHTSA ODI #10503192
2,156 miles · Mar 13, 2013
Equipment Adaptive/mobilityService BrakesVehicle Speed Control
ON MULTIPLE OCCASIONS, I HAVE EXPERIENCED ISSUES WITH THE CAR SUDDENLY ACCELERATING WHILE I'M PRESSING THE BRAKES. SPECIFICALLY, THIS APPEARS TO OCCUR WHEN BRAKING ON UNEVEN SURFACES (IE CONSTRUCTION AREAS, POT HOLES, ETC.). THIS CAN OBVIOUSLY BECOME A DEADLY SITUATION IF ONE IS TRYING TO STOP THE VEHICLE AND WITH THIS PROBLEM…
Read full complaint
ON MULTIPLE OCCASIONS, I HAVE EXPERIENCED ISSUES WITH THE CAR SUDDENLY ACCELERATING WHILE I'M PRESSING THE BRAKES. SPECIFICALLY, THIS APPEARS TO OCCUR WHEN BRAKING ON UNEVEN SURFACES (IE CONSTRUCTION AREAS, POT HOLES, ETC.). THIS CAN OBVIOUSLY BECOME A DEADLY SITUATION IF ONE IS TRYING TO STOP THE VEHICLE AND WITH THIS PROBLEM RUN INTO THE CAR/VEHICLE AHEAD. MOST RECENTLY THIS OCCURRED ON THE SURFACE STREETS IN LOW SPEED, IN TRAFFIC. IT FEELS LIKE THE CAR LURCHES AHEAD WHILE APPLYING THE BRAKE. I WAS TOLD BY THE SERVICE PEOPLE AT TOYOTA THAT I WAS MAKING THIS UP. I CAN RECREATE IT GIVEN THE RIGHT SURFACE. *TR
NHTSA ODI #10502596
Official recalls
10Oct 4, 2018
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2014 Toyota Prius and 2012-2014 Toyota Prius V vehicles. Excessive voltage in the Intelligent Power Module (IPM) within the inverter may cause the hybrid system to shut down, causing the vehicle to stall while being driven.
Consequence & remedy
Consequence: If the hybrid system shuts down unexpectedly, it can increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will update the software for the motor/generator control electronic control unit (ECU) and the hybrid control ECU as necessary, free of charge. The recall began January 22, 2019. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is J0V. Note: The software updates in this recall are needed even if the vehicle had the software previously updated under recalls 14V-053 or 15V-449.
Jun 30, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2010-2012 Toyota Prius, 2010 and 2012 Toyota Prius Plug-in Hybrid, and 2011-2012 Lexus CT200h vehicles. A weld in the curtain shield air bag inflator may crack causing one or both portions of the inflator to eject into the passenger cabin.
Consequence & remedy
Consequence: If either portion of the curtain shield air bag inflator ejects into the passenger cabin, there is an increased risk of injury to vehicle occupants.
Remedy: Toyota will notify owners, and dealers will install retention brackets to the curtain shield air bags, free of charge. The recall began on October 17, 2016. Owners may contact Toyota Customer Service Department at 1-800-331-4331. Toyota's number for this recall is Toyota G0U, and Lexus GLJ.
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Feb 12, 2014
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence & remedy
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Additional source detail variants (2)
Hybrid Propulsion System: Inverter
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Electrical System:software
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Jun 5, 2013
Toyota is recalling certain model year 2010 Prius vehicles manufactured March 31, 2009, through October 9, 2009; and model year 2010 Lexus HS250h vehicles manufactured June 19, 2009, through October 9, 2009. Nitrogen gas from a component of the brake booster pump assembly could leak into the brake fluid.
Consequence & remedy
Consequence: As nitrogen is released into the brake fluid, the brake pedal may have reduced hydraulic pressure. Under certain circumstances, this condition could affect stopping distance and increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the affected brake booster pump assemblies. The recall began on August 7, 2013. Owners may contact Toyota at 1-800-331-4331.
Jan 16, 2013
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence & remedy
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Additional source detail variants (2)
Seats
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Feb 9, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2010 TOYOTA PRIUS AND LEXUS HS250H PASSENGER VEHICLES. CUSTOMERS HAVE EXPERIENCED INCONSISTENT BRAKE FEEL AFTER ABS ACTUATION DURING SLOW AND STEADY APPLICATION OF THE BRAKES ON ROUGH OR SLICK ROAD SURFACES. STOPPING DISTANCES MAY BE INCREASED COMPARED WITH A CUSTOMER'S EXPECTATION FOR A GIVEN PEDAL FORCE.
Consequence & remedy
Consequence: VEHICLE STOPPING DISTANCES MAY INCREASE RELATIVE TO A CUSTOMER'S EXPECTATION INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REWRITE THE PROGRAMMING OF THE ABS CONTROL UNIT FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 3, 2010, AND IS EXPECTED TO BE COMPLETED IN LATE MARCH 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 AND LEXUS AT 1-800-255-3987.
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4DP23005 · Brake Actuator Valve Wear
Opened Nov 22, 2023 · No close date supplied
Status: open (inferred from source dates) · Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP19004 · Brake Actuator Valve Wear
Opened Sep 30, 2019 · Closed Jan 21, 2021
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist
On September 19, 2019, the Office of Defects Investigation (ODI) received a defect petition from Mr. Roger Hogan requesting that the Agency investigate and recall certain Toyota Prius, Prius PHV, Camry Hybrid and Avalon Hybrid vehicles for a brake actuator valve wear condition covered under Toyota Customer Support Programs ZJB and ZKK (subject CSP?s). In support of his request, the petitioner identified 117 NHTSA complaints allegedly related to the subject CSP condition, including 60 reporting crashes. On September 30, 2019, ODI opened Defect Petition DP19-004 to evaluate the petitioner?s request for an investigation. In August 2020, the petitioner notified the Agency that he was withdrawing his petition. Because the petitioner has withdrawn the petition, we are denying the petition as moot and no further analysis of this petition is necessary.NHTSA is authorized to issue an order requiring notification and remedy of a defect if the Agency?s investigation shows a defect in the design, construction, or performance of a motor vehicle that presents an unreasonable risk to safety. 49 U.S.C. ?? 30102(a)(9), 30118. Because the petitioner has with withdrawn the petition, the petition is denied as moot. This action does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency notes that it is not required to receive a defect petition prior to opening a defect investigation and will take further action if warranted by future circumstances.
PE10006 · Braking Performance, Hybrid Vehicle
Opened Feb 3, 2010 · Closed Jul 12, 2010
Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module ; Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:foundation Components:disc; Service Brakes, Hydraulic:power Assist; Service Brakes, Hydraulic:power Assist:hydraulic
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Additional source detail variants (7)
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:foundation Components:disc
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:foundation Components
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:power Assist:hydraulic
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:power Assist
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Illustration