NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
33 reportsClear category filter148,469 miles · Feb 21, 2024
Engine And Engine CoolingHybrid Propulsion System
The contact owns a 2010 Toyota Prius. The contact stated that while driving 60-65 MPH, the vehicle lost motive power and went into LIMP Mode. The coolant temperature and several unknown warning lights were illuminated, and the message "Check Hybrid System" was displayed. The contact pulled to the side of the road, where he disco…
Read full complaint
The contact owns a 2010 Toyota Prius. The contact stated that while driving 60-65 MPH, the vehicle lost motive power and went into LIMP Mode. The coolant temperature and several unknown warning lights were illuminated, and the message "Check Hybrid System" was displayed. The contact pulled to the side of the road, where he disconnected and reconnected the battery to reset the Hybrid system. The contact was able to drive to the residence; however, the failure recurred. The contact used an OBD reader to retrieve diagnostic test code: P261B. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact related the failure to NHTSA Campaign Number: 18V684000 (Hybrid Propulsion System) however, the VIN was not included in the recall. The manufacturer was not made aware of the failure. The failure mileage was approximately 148,469.
NHTSA ODI #11573199
93,000 miles · Nov 24, 2014
Engine And Engine CoolingFire
AFTER TAKING MY SON TO SCHOOL WHICH IS 2.2 MILES AWAY, CAME BACK HOME AND PARKED THE VEHICLE ON THE DRIVEWAY AND NOTICED SMOKE FROM THE ENGINE BAY. BEFORE THE VEHICLE WAS SHUT OFF, CAR GAVE OFF "HEATER SMELL" AND THE HEATER WAS TURNED OFF. MY WIFE CAME UP AND GOT ME UP, I WENT DOWN MAYBE 2 MINUTES AWAY AND FOUND THE CAR FULLY …
Read full complaint
AFTER TAKING MY SON TO SCHOOL WHICH IS 2.2 MILES AWAY, CAME BACK HOME AND PARKED THE VEHICLE ON THE DRIVEWAY AND NOTICED SMOKE FROM THE ENGINE BAY. BEFORE THE VEHICLE WAS SHUT OFF, CAR GAVE OFF "HEATER SMELL" AND THE HEATER WAS TURNED OFF. MY WIFE CAME UP AND GOT ME UP, I WENT DOWN MAYBE 2 MINUTES AWAY AND FOUND THE CAR FULLY ENGULFED IN FIRE. FIRE SPREAD TO THE PORTION OF THE GARAGE BEFORE IT WAS PUT OF BY FIRE DEPARTMENT. *TR
NHTSA ODI #10660478
270,000 miles · Nov 1, 2014
Engine And Engine Cooling
I WAS DRIVING ABOUT 55 MPH WITH HEAT ON AND ALL A SUDDEN CHECK ENGINE LIGHT CAME ON AND THE ALL LIGHTS IN DASH BOARD CAME ONE WITH CHECK HYBRID SYSTEM SIGN AND ENGINE LOST POWER AND CAME TO COMPLETE STOP I PULLED OVER AND WAITED FEW MINUTES AFTER IT WAS FINE BUT WHEN EVER I TURN HEAT OR AC ON IT DOES THE SAME I DID MY RESE…
Read full complaint
I WAS DRIVING ABOUT 55 MPH WITH HEAT ON AND ALL A SUDDEN CHECK ENGINE LIGHT CAME ON AND THE ALL LIGHTS IN DASH BOARD CAME ONE WITH CHECK HYBRID SYSTEM SIGN AND ENGINE LOST POWER AND CAME TO COMPLETE STOP I PULLED OVER AND WAITED FEW MINUTES AFTER IT WAS FINE BUT WHEN EVER I TURN HEAT OR AC ON IT DOES THE SAME I DID MY RESEARCH IT LOOK LIKE INVERTER ISSUE OR THEY HAVE SOME CODE IN THERE SOFTWARE BECAUSE WE BOUGHT 2 CAR PRETTY MUCH SAME TIME AND BOTH HAS SAME PROBLEM SAME TIME AND THIS YEAR BOTH CARS HAD HYBRID BATTERY ISSUE WITH BOTH CAR SAME TIME TOYOTA SEND LETTERS TO 2013 AND 2014 PRIUS OWNER IF THEY EXPERIENCE SAME ISSUE ITS COVERED UNDER WARRANTY BUT WE HAVE SAME ISSUE BUT THEY DIDN'T ADDRESS IT MEANS THEY KNOW. *TR
NHTSA ODI #10651793
46,033 miles · Jan 3, 2014
Engine And Engine Cooling
AROUND 4PM ON THU JAN 2ND 2014, WE WERE DRIVING EASTBOUND ON BEL-RED RD JUST ABOUT TO COME TO THE INTERSECTION OF NE 116TH ST WHEN I NOTICED THE ABS LIT UP, ALONG WITH THAT A WHOLE BUNCH OF OTHER LIGHTS LIT UP ON THE DASHBOARD AND I LOST POWER TO THE CAR (NO ACCELERATOR/BRAKE/STEERING). ALL ELECTRICALS SEEMED TO WORK. I TRIED TO…
Read full complaint
AROUND 4PM ON THU JAN 2ND 2014, WE WERE DRIVING EASTBOUND ON BEL-RED RD JUST ABOUT TO COME TO THE INTERSECTION OF NE 116TH ST WHEN I NOTICED THE ABS LIT UP, ALONG WITH THAT A WHOLE BUNCH OF OTHER LIGHTS LIT UP ON THE DASHBOARD AND I LOST POWER TO THE CAR (NO ACCELERATOR/BRAKE/STEERING). ALL ELECTRICALS SEEMED TO WORK. I TRIED TO POWER DOWN AND RESTART THE CAR. I CALLED TOYOTA OF KIRKLAND AND CHECKED IF THEY HAD A TOWING SERVICE, THEY DIDN'T. A COP OFFERED TO CALL A TOWING SERVICE. THE TOW TRUCK CAME BY AND HE AGREED TO GIVE ME A RIDE TO TOYOTA OF KIRKLAND AS WELL. AT THE DEALERSHIP, THEY JUST DID THE PAPERWORK AND SAID THEY'D CALL TOMORROW. FRIDAY JAN 3RD 2014 I WAITED UNTIL 11:15AM. NO CALL FROM TOYOTA OF KIRKLAND. I CALLED THEM. I SPECIFICALLY ASKED FOR THE ERROR CODES. HE CALLED BACK A LITTLE WHILE LATER AND SAID THAT IT LOOKED LIKE THE INVERTER WAS FAULTY. THIS WOULD BE COVERED UNDER THE DRIVE TRAIN WARRANTY WHICH WAS FOR 3 YEARS OR 36,000 MILES WHICHEVER CAME FIRST. SO, I WOULD BE LOOKING AT PAYING ABOUT $3300 FOR THE PART, $300 FOR LABOR, $110 FOR THE DIAGNOSTIC TEST AND TAXES. THEY COULD GET THE PART IN TOMORROW AND POTENTIALLY HAVE IT FIXED SAT OR LATEST MONDAY. THE ERROR CODES WERE P0A94 & P324E I LOOKED UP ONLINE FOR THESE ERROR CODES. THERE WERE SOME OTHER COMPLAINTS THAT WERE VERY SIMILAR TO THE ONE I HAD AND THE PROBLEM WAS THE INVERTER. AND IT ALSO SEEMED THAT THERE WAS A RECALL ON THE INVERTER (OR PARTS) FOR THE MODELS FROM 2005-2009. SO, CALLED 1-800-331-4331 (TOYOTA CUSTOMER SOMETHING). SHE TOOK DOWN ALL THE DETAILS. WHILE SHE PUT ME ON HOLD TO LOOK UP THE WARRANTY INFORMATION, TOYOTA OF KIRKLAND CALLED AND LEFT A MESSAGE SAYING THAT HE HAD MISUNDERSTOOD THE WARRANTY AND THAT IT WAS ALL COVERED AND HE COULD ORDER THE PART IN, IT WOULD BE THERE TOMORROW (SAT) AND THE CAR WOULD BE READY MONDAY! THE CASE # WITH TOYOTA IS [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10558377
63,512 miles · Nov 12, 2013
Air BagsEngine And Engine CoolingStructure
WE NOTICED THAT THE CARPET WAS SATURATED. THE DEALER TOLD US IT WAS BECAUSE THERE WERE SPIDER WEBS BLOCKING THE DRAIN FROM THE A/C. IT WAS REPAIRED AT A COST OF $1,554, THE WORK INCLUDED DRYING THE AIR BAG MODULE AND REPLACEMENT OF CARPET. WE BELIEVE THIS SHOULD BE THE SUBJECT OF A RECALL AS IT IS THE IDENTICAL PROBLEM RECALL…
Read full complaint
WE NOTICED THAT THE CARPET WAS SATURATED. THE DEALER TOLD US IT WAS BECAUSE THERE WERE SPIDER WEBS BLOCKING THE DRAIN FROM THE A/C. IT WAS REPAIRED AT A COST OF $1,554, THE WORK INCLUDED DRYING THE AIR BAG MODULE AND REPLACEMENT OF CARPET. WE BELIEVE THIS SHOULD BE THE SUBJECT OF A RECALL AS IT IS THE IDENTICAL PROBLEM RECALLED FOR THE TOYOTA CAMRY. *TR
NHTSA ODI #10551895
5,089,894 miles · Jun 12, 2013
Engine And Engine Cooling
IN THE LAST YEAR OR SO, MOST NOTICEABLY RANGING 50K MILEAGE, I'VE STARTED FALLING ASLEEP AT THE WHEEL. I'VE NEVER FALLEN ASLEEP DRIVING NOR HAVE I FELT THIS WAY WHILE OPERATING ANY OF THE 4 VEHICLES I'VE OWNED. IT HAPPENS DURING MY COMMUTE TO/FRO WORK GENERALLY 40-70 MINUTES LONG, LONG AND SHORT DRIVES BUT MORE OFTEN ON COMMUTE …
Read full complaint
IN THE LAST YEAR OR SO, MOST NOTICEABLY RANGING 50K MILEAGE, I'VE STARTED FALLING ASLEEP AT THE WHEEL. I'VE NEVER FALLEN ASLEEP DRIVING NOR HAVE I FELT THIS WAY WHILE OPERATING ANY OF THE 4 VEHICLES I'VE OWNED. IT HAPPENS DURING MY COMMUTE TO/FRO WORK GENERALLY 40-70 MINUTES LONG, LONG AND SHORT DRIVES BUT MORE OFTEN ON COMMUTE AND 30 MIN OR LONGER TRIPS. ITS AT RANDOM AND I'VE ANALYZED ITS NOT THE BASIC AND OBVIOUS ISSUES CAUSING IT; LACK OF SLEEP, FOOD, ADEQUATE HYDRATION ETC. IT GOT SO BAD I COULD NOT DRIVE TO WORK IN THE MORNING OR EVENINGS WITHOUT PULLING OVER AND TAKING A 20 MINUTE NAP. SOMETIMES ITS WORSE THAN OTHER TIMES AND IT FEELS LIKE I'M PASSING OUT, NOT QUITE TIRED AND DROWSY, I AM ALL-OUT CAN'T KEEP MY EYES OPEN, ROLLING EYES, HEAD BOBBING. EVENTUALLY WHEN I MAKE IT HOME SAFE, THINKING I'LL GO TO BED RIGHT AWAY I AM ALERT AND ACTIVE ALL NIGHT - THIS IS THE BEHAVIOR OVER AND OVER. I'VE DISCUSSED WITH THE DOCTOR AS WELL AND I'VE BEEN GENERALLY FATIGUED FOR A FEW YEARS NOW, I'VE OWNED THE PRIUS SINCE 2011. SOMEONE SAID ONLINE IN A FORUM "ITS A COMMON OCCURRENCE OF PEOPLE WHEN THEY'RE EXPOSED TO HIGH LEVELS OF ELECTROMAGNETIC RADIATION TO FEEL EXTREMELY TIRED AND FATIGUED." BUT FOLKS SAY ITS NOT ENOUGH TO CAUSE THIS TYPE OF BEHAVIOR. ANOTHER USER ALSO MENTIONS FALLING ASLEEP IN THIS FORUM (JUNE 5TH 2013) AND THERE'S BEEN OTHER NOTATIONS ON THE INTERNET, FOR EXAMPLE HTTP://PRIUSCHAT.COM/THREADS/PRIUS-EMF-RADIATION-AND-TOYOTAS-BOLD-FACE.116044/PAGE-6#IXZZ2VYI4P2S7. *TR
NHTSA ODI #10519402
35,643 miles · May 1, 2012
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2010 TOYOTA PRIUS. WHILE TRAVELING 40 MPH, THE CONTACT NOTICED A BEEPING SOUND COMING FROM THE VEHICLE FOLLOWED BY THE SEAT BELTS LOCKING. MOMENTS LATER, THE VEHICLE DECELERATED TO A COMPLETE STOP INDEPENDENTLY. THE CONTACT WAS ABLE TO RESUME NORMAL OPERATION. THE VEHICLE WAS NOT DIAGNOSED AND OR REPAIRED…
Read full complaint
TL* THE CONTACT OWNS A 2010 TOYOTA PRIUS. WHILE TRAVELING 40 MPH, THE CONTACT NOTICED A BEEPING SOUND COMING FROM THE VEHICLE FOLLOWED BY THE SEAT BELTS LOCKING. MOMENTS LATER, THE VEHICLE DECELERATED TO A COMPLETE STOP INDEPENDENTLY. THE CONTACT WAS ABLE TO RESUME NORMAL OPERATION. THE VEHICLE WAS NOT DIAGNOSED AND OR REPAIRED. THE CURRENT AND THE FAILURE MILEAGES WERE 35,643.
NHTSA ODI #10457072
35,643 miles · Apr 27, 2012
Electrical SystemEngine And Engine CoolingService Brakes, Hydraulic
TL* THE CONTACT WAS DRIVING A 2010 TOYOTA PRIUS. THE CONTACT WAS DRIVING 40 MPH WHEN THE VEHICLE STOPPED IN THE STREET. PRIOR TO THE VEHICLE STOPPING, A BEEPING/ALARM SOUNDED, THE SEAT BELT LOCKED IN PLACE AND THE WARNING ON THE DASHBOARD FLASHED BRAKES.
NHTSA ODI #10456728
Mileage unknown · Apr 9, 2012
Engine And Engine Cooling
DURING COLD TEMPERATURE STARTUPS THE ENGINE KNOCKS LOUDLY FOR ABOUT 7 SECONDS. THE PROBLEM HAPPENS ONLY DURING COLD TEMPERATURE. THIS HAS HAPPENED ABOUT FOUR TIMES. WENT TO DEALER AND THEY WERE NOT ABLE TO FIX OR FIND THE CAUSE. 2ND TRIP THEY REPLACED THE ENGINE MOUNT BUT THE PROBLEM IS STILL THERE. *TR
NHTSA ODI #10454498
14,000 miles · Oct 19, 2011
Engine And Engine Cooling
ENGINE KNOCKS UPON STARTING BUT GOES AWAY AFTER ABOUT 10 SECONDS. THE VEHICLE DOESN'T DO THIS VERY OFTEN AND IT IS DIFFICULT TO DUPLICATE. REFERENCE THIS YOUTUBE VIDEO FOR AN EXACT REPLICATION OF THE PROBLEM: HTTP://YOUTU.BE/TCBG97UBX5S. *TR
NHTSA ODI #10430785
Official recalls
10Oct 4, 2018
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2014 Toyota Prius and 2012-2014 Toyota Prius V vehicles. Excessive voltage in the Intelligent Power Module (IPM) within the inverter may cause the hybrid system to shut down, causing the vehicle to stall while being driven.
Consequence & remedy
Consequence: If the hybrid system shuts down unexpectedly, it can increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will update the software for the motor/generator control electronic control unit (ECU) and the hybrid control ECU as necessary, free of charge. The recall began January 22, 2019. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is J0V. Note: The software updates in this recall are needed even if the vehicle had the software previously updated under recalls 14V-053 or 15V-449.
Jun 30, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2010-2012 Toyota Prius, 2010 and 2012 Toyota Prius Plug-in Hybrid, and 2011-2012 Lexus CT200h vehicles. A weld in the curtain shield air bag inflator may crack causing one or both portions of the inflator to eject into the passenger cabin.
Consequence & remedy
Consequence: If either portion of the curtain shield air bag inflator ejects into the passenger cabin, there is an increased risk of injury to vehicle occupants.
Remedy: Toyota will notify owners, and dealers will install retention brackets to the curtain shield air bags, free of charge. The recall began on October 17, 2016. Owners may contact Toyota Customer Service Department at 1-800-331-4331. Toyota's number for this recall is Toyota G0U, and Lexus GLJ.
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Feb 12, 2014
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence & remedy
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Additional source detail variants (2)
Hybrid Propulsion System: Inverter
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Electrical System:software
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Jun 5, 2013
Toyota is recalling certain model year 2010 Prius vehicles manufactured March 31, 2009, through October 9, 2009; and model year 2010 Lexus HS250h vehicles manufactured June 19, 2009, through October 9, 2009. Nitrogen gas from a component of the brake booster pump assembly could leak into the brake fluid.
Consequence & remedy
Consequence: As nitrogen is released into the brake fluid, the brake pedal may have reduced hydraulic pressure. Under certain circumstances, this condition could affect stopping distance and increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the affected brake booster pump assemblies. The recall began on August 7, 2013. Owners may contact Toyota at 1-800-331-4331.
Jan 16, 2013
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence & remedy
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Additional source detail variants (2)
Seats
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Feb 9, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2010 TOYOTA PRIUS AND LEXUS HS250H PASSENGER VEHICLES. CUSTOMERS HAVE EXPERIENCED INCONSISTENT BRAKE FEEL AFTER ABS ACTUATION DURING SLOW AND STEADY APPLICATION OF THE BRAKES ON ROUGH OR SLICK ROAD SURFACES. STOPPING DISTANCES MAY BE INCREASED COMPARED WITH A CUSTOMER'S EXPECTATION FOR A GIVEN PEDAL FORCE.
Consequence & remedy
Consequence: VEHICLE STOPPING DISTANCES MAY INCREASE RELATIVE TO A CUSTOMER'S EXPECTATION INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REWRITE THE PROGRAMMING OF THE ABS CONTROL UNIT FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 3, 2010, AND IS EXPECTED TO BE COMPLETED IN LATE MARCH 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 AND LEXUS AT 1-800-255-3987.
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4DP23005 · Brake Actuator Valve Wear
Opened Nov 22, 2023 · No close date supplied
Status: open (inferred from source dates) · Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP19004 · Brake Actuator Valve Wear
Opened Sep 30, 2019 · Closed Jan 21, 2021
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist
On September 19, 2019, the Office of Defects Investigation (ODI) received a defect petition from Mr. Roger Hogan requesting that the Agency investigate and recall certain Toyota Prius, Prius PHV, Camry Hybrid and Avalon Hybrid vehicles for a brake actuator valve wear condition covered under Toyota Customer Support Programs ZJB and ZKK (subject CSP?s). In support of his request, the petitioner identified 117 NHTSA complaints allegedly related to the subject CSP condition, including 60 reporting crashes. On September 30, 2019, ODI opened Defect Petition DP19-004 to evaluate the petitioner?s request for an investigation. In August 2020, the petitioner notified the Agency that he was withdrawing his petition. Because the petitioner has withdrawn the petition, we are denying the petition as moot and no further analysis of this petition is necessary.NHTSA is authorized to issue an order requiring notification and remedy of a defect if the Agency?s investigation shows a defect in the design, construction, or performance of a motor vehicle that presents an unreasonable risk to safety. 49 U.S.C. ?? 30102(a)(9), 30118. Because the petitioner has with withdrawn the petition, the petition is denied as moot. This action does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency notes that it is not required to receive a defect petition prior to opening a defect investigation and will take further action if warranted by future circumstances.
PE10006 · Braking Performance, Hybrid Vehicle
Opened Feb 3, 2010 · Closed Jul 12, 2010
Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module ; Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:foundation Components:disc; Service Brakes, Hydraulic:power Assist; Service Brakes, Hydraulic:power Assist:hydraulic
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Additional source detail variants (7)
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:foundation Components:disc
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:foundation Components
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:power Assist:hydraulic
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:power Assist
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Illustration