NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
192 reportsClear category filterMileage unknown · Oct 29, 2023
Electrical SystemService BrakesUnknown Or Other
Hi I want submit issues with the master cylinder and abs pump assy I have 2 vehicles same model with average same mileage and both had issues with this system if I drove any distance below 25 mph in a constant time the dash lights comes on traction control, abs light, brake light , and the brake pedal goes low and barely brakes …
Read full complaint
Hi I want submit issues with the master cylinder and abs pump assy I have 2 vehicles same model with average same mileage and both had issues with this system if I drove any distance below 25 mph in a constant time the dash lights comes on traction control, abs light, brake light , and the brake pedal goes low and barely brakes make this situation dangerous when I stop if you try turn it off the engine and on again lights stay there but if I reset the codes the pump works again for some while and then again when you don’t expected lose pressure and I am really afraid for my safety and my family, and I am not the only one with this problem is too many Prius owners who have the issues I went from dealer and they advice $3000 dlls fix situation who motivate people to lose money for $1200 in parts and $1800 dlls in labor for something they can resolve it because in reality is an manufactured defect
NHTSA ODI #11552461
Mileage unknown · Apr 1, 2023
Electrical SystemPower Train
Purchased new a 2010 Toyota Prius third generation level 4 in July of 2009. Hybrid battery pack failed just after 150,000 warranty lapsed at 155,000 miles. January 2023 floods in Merced, CA damaged one of blocks in Hybrid battery pack driving through waters at 191000 miles on odometer. This threw DTC POA 080 'Check Hybrid Sy…
Read full complaint
Purchased new a 2010 Toyota Prius third generation level 4 in July of 2009. Hybrid battery pack failed just after 150,000 warranty lapsed at 155,000 miles. January 2023 floods in Merced, CA damaged one of blocks in Hybrid battery pack driving through waters at 191000 miles on odometer. This threw DTC POA 080 'Check Hybrid System' message. The following month February 2023 at 191500 miles I notice loud cooling fan for hybrid battery operating for the first time ever! Fan is located in rear seat behind front passenger. Air vent is clearly visible. I believe defective fan led to overheating of hybrid battery premature failure at 155,000 miles.
NHTSA ODI #11514893
Mileage unknown · Feb 3, 2023
Electrical SystemEngine
Car slows down to a stop when driving on the freeway. With no power to accelerate, it makes it hard to get to the side of the road to be towed. Been to the dealer twice to address the problem, and was told that if I don't pay $200, that there is nothing they can do. Then when I did pay the money for evaluation, they told me the …
Read full complaint
Car slows down to a stop when driving on the freeway. With no power to accelerate, it makes it hard to get to the side of the road to be towed. Been to the dealer twice to address the problem, and was told that if I don't pay $200, that there is nothing they can do. Then when I did pay the money for evaluation, they told me the problem could be one of several things that would start the never-ending process of repairs that will keep me paying until they solve it. I would think that with a $200 code reading, that the dealers software could narrow it down to the exact repair needed. I mentioned to the dealer about the JOV update I had done earlier to the car, but dealer refuses to recognize that there is a recall on my vehicle, and that I needed to pay money(that I don't have) to do anything. My check hybrid system light and orange triangle comes on when the car dies
NHTSA ODI #11505407
Mileage unknown · Jan 24, 2023
Electrical System
I had just gotten back in my car from a quick store trip. My prius turned on like normal but soon after when I was driving different kind of warning lights turned on. My steering was affected ,the car slowed down considerably to the point I was almost rear-ended. The triangle of death, check engine, brake and steering lights al…
Read full complaint
I had just gotten back in my car from a quick store trip. My prius turned on like normal but soon after when I was driving different kind of warning lights turned on. My steering was affected ,the car slowed down considerably to the point I was almost rear-ended. The triangle of death, check engine, brake and steering lights all came on with the check hybrid system warning. Before this i had no prior issues with my car. I had it checked by an independent mechanic who states it is the inverter that caused this
NHTSA ODI #11503502
Mileage unknown · Jan 24, 2023
Electrical SystemEngine
I was driving home from work when all the warning light all came on at once. The car suddenly stopped accelerating and the “check hybrid system” was showing on my dash. I was lucky enough to be going down hill so I can make it to a shoulder to get off the road. Tried troubleshooting everything but to no avail and needed to get t…
Read full complaint
I was driving home from work when all the warning light all came on at once. The car suddenly stopped accelerating and the “check hybrid system” was showing on my dash. I was lucky enough to be going down hill so I can make it to a shoulder to get off the road. Tried troubleshooting everything but to no avail and needed to get towed because the Prius would not move at all. Haven’t got the vehicle checked yet because the vehicle will not move and can only be moved if towed.
NHTSA ODI #11503318
Mileage unknown · Aug 4, 2022
Electrical SystemService BrakesSteering
Hello there, my name is Lashyrah and I do not know much about cars so most of this is unknown. The person I bought my vehicle from did not give me much information and I was desperate at the time so I bought it. Most of the lights on the dashboard are on: ABS, Brake system, Engine, Tire/Safety Alert, Fuel pump reset warning, and…
Read full complaint
Hello there, my name is Lashyrah and I do not know much about cars so most of this is unknown. The person I bought my vehicle from did not give me much information and I was desperate at the time so I bought it. Most of the lights on the dashboard are on: ABS, Brake system, Engine, Tire/Safety Alert, Fuel pump reset warning, and Stability control are lights that come and go. I have used the code system to try to reset these things and they go away then pop back up. Sometimes while I am driving, all the dashboard lights disappear and the breaks start getting really touchy and it feels completely different driving until the previous lights all come back on. This has been an issue before and when I last went to Toyota to get my car serviced, I asked them to check the lights and system, and if they could do a multi-point inspection. They wanted me to pay $300 just to find out why the lights keep coming back on. Please help me get this fixed at no cost I am a single mom and college student working part time so I need my car to get around or a free loaner car to get around until this is fixed. I strongly feel these are recalls that did not get taken care of or are not showing up in the recall system. I need assistance as soon as possible and would like to know my options, especially after getting a notice in the mail a few days ago from Toyota about my car possibly being affected. My fuel gauge is also empty at around 3 bars or sometimes 2 bars instead of going all the way down to empty, costing me more money on gas having to fill it up more often. Thank you for your time and help.
NHTSA ODI #11477501
Mileage unknown · Jul 21, 2022
Electrical SystemEngine
2010 Prius started up in the garage 3 hours after being shut down. I am certain the car was NOT still running while we unloaded groceries from hatchback and left the garage. * Nothing was retrieved from the front seat so no accidental start could have occurred. * My son "heard it start" almost 3 hours after the vehicle had…
Read full complaint
2010 Prius started up in the garage 3 hours after being shut down. I am certain the car was NOT still running while we unloaded groceries from hatchback and left the garage. * Nothing was retrieved from the front seat so no accidental start could have occurred. * My son "heard it start" almost 3 hours after the vehicle had been shut off while in another room near the garage. * I heard nothing from the upstairs. * The Prius key fob was nowhere near the vicinity of the vehicle at the time it started nor was any person. In fact, both key fobs were upstairs and only the currently used 1 had a battery and was stored inside a tin so as to always know where it was. *Toyota executives were made aware of incident but essentially denied the Toyota could start without the key fob: "Toyota is not aware for any possible way for the vehicle to be started without the key."
NHTSA ODI #11475101
Mileage unknown · Jul 1, 2022
Electrical SystemService Brakes
The ABS, Brake, and traction control light came on. The braking became difficult. The car did stop but if it was in an emergency circumstance there may have been a collision. I called Toyota about the issue and was informed that there was a brake actuater and master cylinder issues with this make and model. Toyota replaced them…
Read full complaint
The ABS, Brake, and traction control light came on. The braking became difficult. The car did stop but if it was in an emergency circumstance there may have been a collision. I called Toyota about the issue and was informed that there was a brake actuater and master cylinder issues with this make and model. Toyota replaced them in cars that had this issue under a special warranty that was over in 2021. It is a $3500 issue. I purchased this car new and have never received a notice about bad braking system. I have lived at the same address since the purchase. Toyota informed me that notices were not sent out, however if the owner came in with this issue before 2021 it would have been repaired and replaced. I can not understand how ALL owners were not informed. I do not understand how a recall wasn't enforced. I live in Florida where the speed limit is 70mph. This could have been deadly. I looked on forums online and apparently this has been an issue for many many 2010 Toyota Prius. I have a case in with Toyota American. 220701001489. I can use any help I can get with this issue. It may save a life.
NHTSA ODI #11472054
Mileage unknown · May 13, 2022
Electrical SystemService Brakes
Hi- I have a Toyota Prius 2010 model and I encountered a braking failure yesterday. My ABS lights, brake lights and another light came up on my dashboard of the car. Upon diagnosis, I was informed by Toyota dealership that my car has a faulty C1391 - Abnormal leak in accumulator. This condition may be caused by small internal…
Read full complaint
Hi- I have a Toyota Prius 2010 model and I encountered a braking failure yesterday. My ABS lights, brake lights and another light came up on my dashboard of the car. Upon diagnosis, I was informed by Toyota dealership that my car has a faulty C1391 - Abnormal leak in accumulator. This condition may be caused by small internal brake fluid leak inside the brake booster assembly with master cylinder. This is a known issue by Toyota and lots of press coverage on this issue since the past few years. I was told today that if this issue occurred within 10 year or purchase or <150K then the repair work would be covered by Toyota. I purchased the car in 2010 and I past the 10 year mark but mileage coverage is 125K (<150K). Toyota is unwilling to bear the cost and would want me to pay for the fix. This is a known issue with Toyota and the braking system can fail anytime before/or after 10 year mark. It is now costing me $3000 to repair. I am shocked with the Toyota's response in this matter. There are lots of blogs I read online who have similar issue. Class Action lawsuit: https://www.classaction.org/news/toyota-hit-with-class-action-over-alleged-refusal-to-fix-braking-system-defect-in-hybrid-vehicles Here is one example: https://www.youtube.com/watch?v=xA9jyrbZDWo Thanks.
NHTSA ODI #11464485
Mileage unknown · May 3, 2022
Electrical SystemExterior Lighting
Hazard lights flashing, flashes faster at higher speeds. Hazard button useless. Mechanic not sure what is the problem; reset codes. Problem went away for a few days and then came back.
NHTSA ODI #11463255
Official recalls
10Oct 4, 2018
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2014 Toyota Prius and 2012-2014 Toyota Prius V vehicles. Excessive voltage in the Intelligent Power Module (IPM) within the inverter may cause the hybrid system to shut down, causing the vehicle to stall while being driven.
Consequence & remedy
Consequence: If the hybrid system shuts down unexpectedly, it can increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will update the software for the motor/generator control electronic control unit (ECU) and the hybrid control ECU as necessary, free of charge. The recall began January 22, 2019. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is J0V. Note: The software updates in this recall are needed even if the vehicle had the software previously updated under recalls 14V-053 or 15V-449.
Jun 30, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2010-2012 Toyota Prius, 2010 and 2012 Toyota Prius Plug-in Hybrid, and 2011-2012 Lexus CT200h vehicles. A weld in the curtain shield air bag inflator may crack causing one or both portions of the inflator to eject into the passenger cabin.
Consequence & remedy
Consequence: If either portion of the curtain shield air bag inflator ejects into the passenger cabin, there is an increased risk of injury to vehicle occupants.
Remedy: Toyota will notify owners, and dealers will install retention brackets to the curtain shield air bags, free of charge. The recall began on October 17, 2016. Owners may contact Toyota Customer Service Department at 1-800-331-4331. Toyota's number for this recall is Toyota G0U, and Lexus GLJ.
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Feb 12, 2014
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence & remedy
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Additional source detail variants (2)
Hybrid Propulsion System: Inverter
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Electrical System:software
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Jun 5, 2013
Toyota is recalling certain model year 2010 Prius vehicles manufactured March 31, 2009, through October 9, 2009; and model year 2010 Lexus HS250h vehicles manufactured June 19, 2009, through October 9, 2009. Nitrogen gas from a component of the brake booster pump assembly could leak into the brake fluid.
Consequence & remedy
Consequence: As nitrogen is released into the brake fluid, the brake pedal may have reduced hydraulic pressure. Under certain circumstances, this condition could affect stopping distance and increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the affected brake booster pump assemblies. The recall began on August 7, 2013. Owners may contact Toyota at 1-800-331-4331.
Jan 16, 2013
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence & remedy
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Additional source detail variants (2)
Seats
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Feb 9, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2010 TOYOTA PRIUS AND LEXUS HS250H PASSENGER VEHICLES. CUSTOMERS HAVE EXPERIENCED INCONSISTENT BRAKE FEEL AFTER ABS ACTUATION DURING SLOW AND STEADY APPLICATION OF THE BRAKES ON ROUGH OR SLICK ROAD SURFACES. STOPPING DISTANCES MAY BE INCREASED COMPARED WITH A CUSTOMER'S EXPECTATION FOR A GIVEN PEDAL FORCE.
Consequence & remedy
Consequence: VEHICLE STOPPING DISTANCES MAY INCREASE RELATIVE TO A CUSTOMER'S EXPECTATION INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REWRITE THE PROGRAMMING OF THE ABS CONTROL UNIT FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 3, 2010, AND IS EXPECTED TO BE COMPLETED IN LATE MARCH 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 AND LEXUS AT 1-800-255-3987.
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4DP23005 · Brake Actuator Valve Wear
Opened Nov 22, 2023 · No close date supplied
Status: open (inferred from source dates) · Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP19004 · Brake Actuator Valve Wear
Opened Sep 30, 2019 · Closed Jan 21, 2021
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist
On September 19, 2019, the Office of Defects Investigation (ODI) received a defect petition from Mr. Roger Hogan requesting that the Agency investigate and recall certain Toyota Prius, Prius PHV, Camry Hybrid and Avalon Hybrid vehicles for a brake actuator valve wear condition covered under Toyota Customer Support Programs ZJB and ZKK (subject CSP?s). In support of his request, the petitioner identified 117 NHTSA complaints allegedly related to the subject CSP condition, including 60 reporting crashes. On September 30, 2019, ODI opened Defect Petition DP19-004 to evaluate the petitioner?s request for an investigation. In August 2020, the petitioner notified the Agency that he was withdrawing his petition. Because the petitioner has withdrawn the petition, we are denying the petition as moot and no further analysis of this petition is necessary.NHTSA is authorized to issue an order requiring notification and remedy of a defect if the Agency?s investigation shows a defect in the design, construction, or performance of a motor vehicle that presents an unreasonable risk to safety. 49 U.S.C. ?? 30102(a)(9), 30118. Because the petitioner has with withdrawn the petition, the petition is denied as moot. This action does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency notes that it is not required to receive a defect petition prior to opening a defect investigation and will take further action if warranted by future circumstances.
PE10006 · Braking Performance, Hybrid Vehicle
Opened Feb 3, 2010 · Closed Jul 12, 2010
Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module ; Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:foundation Components:disc; Service Brakes, Hydraulic:power Assist; Service Brakes, Hydraulic:power Assist:hydraulic
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Additional source detail variants (7)
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:foundation Components:disc
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:foundation Components
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:power Assist:hydraulic
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:power Assist
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Illustration