IllustrationTL* THE CONTACT WAS DRIVING A 2010 TOYOTA PRIUS. THE CONTACT WAS DRIVING 40 MPH WHEN THE VEHICLE STOPPED IN THE STREET. PRIOR TO THE VEHICLE STOPPING, A BEEPING/ALARM SOUNDED, THE SEAT BELT LOCKED IN PLACE AND THE WARNING ON THE DASHBOARD FLASHED BRAKES.
2010 Toyota Prius
Owner reports · Recalls · Investigations
More warning signs than most Prius years
Owner complaints for the 2010 Toyota Prius are substantially higher than the model-year median of 164.
About this comparison →How this year compares
Owner complaints by model year
Compare all Prius years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1,4880–25K
14825–50K
12650–75K
13675–100K
221100–150K
145150K+
2,264 reports with mileage · 558 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 849 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes. Review the 593 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Electric. Review the 502 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
183 crash reports13 fire reports48 injury reports
Electrical System complaints
192 reportsTL* THE CONTACT OWNS A 2010 TOYOTA PRIUS HYBRID. THE CONTACT STATED THAT WHILE DRIVING 10 MPH, THE VEHICLE STALLED AND A HYBRID SYSTEM FAILURE MESSAGE CAME ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO THE DEALER WHO WAS UNABLE TO COME UP WITH A CONCRETE DIAGNOSIS BUT STATED THAT THE FAILURE MIGHT HAD BEEN CAUSED BY A ONE VO…
Read full complaint
TL* THE CONTACT OWNS A 2010 TOYOTA PRIUS HYBRID. THE CONTACT STATED THAT WHILE DRIVING 10 MPH, THE VEHICLE STALLED AND A HYBRID SYSTEM FAILURE MESSAGE CAME ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO THE DEALER WHO WAS UNABLE TO COME UP WITH A CONCRETE DIAGNOSIS BUT STATED THAT THE FAILURE MIGHT HAD BEEN CAUSED BY A ONE VOLT OVER CHARGE ON THE HYBRID BATTERY WHICH HAPPEN AS A RESULT OF EXCESSIVE BRAKING. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 41,000 AND THE CURRENT MILEAGE WAS 43,000.
OUR 2010 PRIUS IS UNSAFE DURING THE DAYTIME DRIVING WHEN WE ARE REQUIRED BY ROAD SIDES TO TURN ON OUR HEADLIGHTS IN CERTAIN ROADS, WHEN WE COMPLY THE HEADLIGHTS GO ON, BUT THE DASH LIGHTS GO DARK AND WE ARE UNABLE TO READ THE SPEEDOMETER ETC. I WENT TO A TOYODA DEALER AND THEY SAID NOTHING COULD BE DONE TO FIX THE PROBLEM. TODAY…
Read full complaint
OUR 2010 PRIUS IS UNSAFE DURING THE DAYTIME DRIVING WHEN WE ARE REQUIRED BY ROAD SIDES TO TURN ON OUR HEADLIGHTS IN CERTAIN ROADS, WHEN WE COMPLY THE HEADLIGHTS GO ON, BUT THE DASH LIGHTS GO DARK AND WE ARE UNABLE TO READ THE SPEEDOMETER ETC. I WENT TO A TOYODA DEALER AND THEY SAID NOTHING COULD BE DONE TO FIX THE PROBLEM. TODAY, AUG 6, I PERSONALLY SPOKE WITH TOYODA MOTOR SALES IN TORRANCE CA., ON MY COMPLAINT 1107281155, AND WAS TOLD TOYODA COULD DO NOTHING ON 2010 PRIUS WHICH ALL HAVE THE SAME PROBLEM. I OFFERED TO PAY TO FIX IT AS I AM ON ROADS REQUIRING DAYLIGHT HEAD LIGHTS ON SEVERAL TIMES A MONTH. I FEEL THAT TOYODA SHOULD RECALL ALL PRIUS AND FIX THAT PROBLEM, THERE IS NO EXCUSE FOR A DANGEROUS SISTUATION LIKE THAT ESPECIALLLY WHEN I CAN RECEIVE A TICKET FOR NOT USING THE HEADLIGHTS DURING THE DAY OR IF I DO NOT BEING ABLE TO READ THE SPEEDOMETER ETC. I FEEL THAT THROUGHOUT THE WEST MANY ROADS REQUIRE ONLIGHT HEADLIGHTS. I WOULD LIKE A FORMAL INVESTIGATION ABOUT THIS MATTER. *TT
HAVING A CAR ACCIDENT ON HIGHWAY. THIS ACCIDENT RAISES THE CONCERN ABOUT SAFETY ISSUE OF TOYOTA PRIUS.ONE PART OF MAIN BATTERY CABLE UNDERNEATH THE CAR WAS NOT WELL PROTECTED OR COVERED. WHEN A SOLID OBJECT RIGHT HITTING THE CABLE WITH BLAST SOUND , THE CABLE WAS BROKEN APART., WE LOST ALL THE POWER, THE CAR TOTALLY WAS DEA…
Read full complaint
HAVING A CAR ACCIDENT ON HIGHWAY. THIS ACCIDENT RAISES THE CONCERN ABOUT SAFETY ISSUE OF TOYOTA PRIUS.ONE PART OF MAIN BATTERY CABLE UNDERNEATH THE CAR WAS NOT WELL PROTECTED OR COVERED. WHEN A SOLID OBJECT RIGHT HITTING THE CABLE WITH BLAST SOUND , THE CABLE WAS BROKEN APART., WE LOST ALL THE POWER, THE CAR TOTALLY WAS DEAD ON THE HIGHWAY. WE HAVE 3 PEOPLE IN THE CAR, MY 85YR OLD MOTHER, MY WIFE AND ME. IT IS HORRIBLE. *KB
SECOND OCCURRENCE OF THIS PROBLEM IN THREE WEEKS. DRIVING DOWNHILL ON A RESIDENTIAL STREET AT 25 MPH, SLOWING TO A STOP WITHOUT APPLYING THE ACCELERATOR. SUDDENLY LOST ENGINE POWER. APPLIED ACCELERATOR, NO RESPONSE. CONTINUED TO LOSE SPEED AS I ROLLED SILENTLY DOWNHILL TOWARD THE INTERSECTION. APPLIED BRAKES AND STOPPED. RESTA…
Read full complaint
SECOND OCCURRENCE OF THIS PROBLEM IN THREE WEEKS. DRIVING DOWNHILL ON A RESIDENTIAL STREET AT 25 MPH, SLOWING TO A STOP WITHOUT APPLYING THE ACCELERATOR. SUDDENLY LOST ENGINE POWER. APPLIED ACCELERATOR, NO RESPONSE. CONTINUED TO LOSE SPEED AS I ROLLED SILENTLY DOWNHILL TOWARD THE INTERSECTION. APPLIED BRAKES AND STOPPED. RESTARTED THE ENGINE AND IT STARTED UP FINE. THE PREVIOUS INCIDENT ALSO OCCURRED ON A DOWNHILL GRADE, ON AN EXIT RAMP FROM AN PARKING GARAGE. FORTUNATELY BOTH INCIDENTS HAPPENED AT LOW SPEED AND NOT IN HEAVY TRAFFIC. I PREVIOUSLY REPORTED THE FIRST INCIDENT. TOYOTA DEALER CHECKED VEHICLE AFTER EACH INCIDENT AND COULD NOT REPLICATE THE INCIDENT OR FIND A COMPUTER CODE THAT WOULD EXPLAIN IT. SINCE THIS WAS THE SECOND OCCURRENCE AND WAS FAMILIAR TO ME, AND SINCE I WAS NOT IN TRAFFIC, I LET IT HAPPEN WHILE OBSERVING MY OWN ACTIONS, TRYING TO CHECK FOR DRIVER ERROR. MY FOOT WAS NOT ON THE BRAKE.THE CAR WAS IN DRIVE. WHILE THE CAR WAS SLOWING, I TRIED PRESSING THE ACCELERATOR DEEPLY AND THEN PUMPING THE ACCELERATOR TO SEE WHAT WOULD HAPPEN.. THERE WAS NO RESPONSE, AND NO SOUND. THE SAME WAS TRUE THREE WEEKS AGO-NO RESPONSE TO PUSHING THE ACCELERATOR, EVEN DEEPLY, AND NO SOUND. THREE WEEKS AGO, THE FIRST TIME IT HAPPENED, I ALSO TRIED CYCLING THROUGH THE "MODES" (EV, PRIUS, ECO, POWER) WITH NO EFFECT. EACH TIME, I HIT THE POWER BUTTON TO POWER OFF, AND THEN I HIT IT AGAIN TO RESTART. POWERING OFF AND THEN RESTARTING, BOTH TIMES, SEEMED LIKE "REBOOTING" A COMPUTER. FORTUNATELY TRAFFIC CONDITIONS BOTH TIMES GAVE ME AMPLE TIME TO REBOOT. WILL THIS HAPPEN AGAIN? *TR
TL* THE CONTACT OWNS A 2010 TOYOTA PRIUS. THE CONTACT STATED THAT THE VEHICLE FAILED TO START AFTER SITTING IDLE FOR A FEW DAYS. THE VEHICLE WAS TOWED TO A DEALER AND THEY ADVISED THE CONTACT THAT THE FAILURE WAS DUE TO THE BATTERY BEING UNUSED FOR MORE THAN 10 DAYS. THE DEALER ADVISED THAT THE BATTERY SHOULD HAVE BEEN DISCONNEC…
Read full complaint
TL* THE CONTACT OWNS A 2010 TOYOTA PRIUS. THE CONTACT STATED THAT THE VEHICLE FAILED TO START AFTER SITTING IDLE FOR A FEW DAYS. THE VEHICLE WAS TOWED TO A DEALER AND THEY ADVISED THE CONTACT THAT THE FAILURE WAS DUE TO THE BATTERY BEING UNUSED FOR MORE THAN 10 DAYS. THE DEALER ADVISED THAT THE BATTERY SHOULD HAVE BEEN DISCONNECTED BEFORE ALLOWING THE VEHICLE TO SIT IDLE FOR SO LONG. THE CONTACT WAS ABLE TO RESTART THE VEHICLE AFTER RECEIVING A JUMP START. THE FAILURE MILEAGE WAS APPROXIMATELY 6,500.
PASSENGER DOOR LATCH FAILED IN MY TOYOTA PRIUS, IT OPENED AS I WAS MOVING, THEN I CLOSED FROM INSIDE AND WHEN I GOT TO MY DESTINATION IT DID NOT OPEN ANYWAY,EVEN WITH REMOTE. SO I GOT OUT THRU OTHER DOOR. *TR
MY WINDSHIELD WIPERS STOPPED WORKING FOR A SHORT TIME. I HAVE AN IDEA OF WHAT COULD CAUSE THIS ISSUE AMONG OTHER PROBLEMS. I HAD A PROBLEM WITH A VEHICLE I ONCE OWNED THAT THE ENGINE WOULD STOP FOR NO REASON. THE DEALER COULD NOT FIND A PROBLEM BUT AS A PRECAUTION HE REPLACED THE SMALL WIRING HARNESS. MY CAR NEVER FAILED AGAIN. …
Read full complaint
MY WINDSHIELD WIPERS STOPPED WORKING FOR A SHORT TIME. I HAVE AN IDEA OF WHAT COULD CAUSE THIS ISSUE AMONG OTHER PROBLEMS. I HAD A PROBLEM WITH A VEHICLE I ONCE OWNED THAT THE ENGINE WOULD STOP FOR NO REASON. THE DEALER COULD NOT FIND A PROBLEM BUT AS A PRECAUTION HE REPLACED THE SMALL WIRING HARNESS. MY CAR NEVER FAILED AGAIN. ABOUT 6 MONTHS LATER AMC CAME OUT WITH A DIRECTIVE TO REPLACE THE SMALL WIRING HARNESS ON ALL OF THESE CARS. THE PROBLEM WAS THAT THE TWO ENDS OF THE HARNESS WERE MANUFACTURED BY DIFFERENT COMPANIES THAT USED DIFFERENT PLASTIC.THE PLASTIC IN THE CONNECTORS WOULD REACT WITH ONE ANOTHER AND PRODUCE A GAS. THE GAS WOULD COAT THE CONTACTS AND CAUSE THEM TO GO OPEN. IN MY CASE WHEN I RESTARTED MY CAR THE CONTACTS WOULD ARC AND IT WOULD RUN OKAY UNTIL THE CONTACTS GOT COATED AGAIN. I THINK THIS CONDITION COULD CAUSE ALMOST EVERY PROBLEM TOYOTA IS HAVING. I DON'T KNOW IF THIS CONDITION IS RELATED TO ANY OF THE PROBLEMS THEY ARE HAVING BUT IT MIGHT BE WORTH LOOKING INTO IT. *TR
TL* THE CONTACT OWNS A 2010 TOYOTA PRIUS. THE CONTACT STATED THAT HE ENGAGED THE PANIC STOP BUTTON BUT THE VEHICLE HESITATED BEFORE STOPPING AND CAUSED THE CONTACT TO CRASH INTO THE REAR OF ANOTHER VEHICLE. A POLICE REPORT WAS AVAILABLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER BUT THE DEALER WAS UNABLE TO DUPLICATE THE FAI…
Read full complaint
TL* THE CONTACT OWNS A 2010 TOYOTA PRIUS. THE CONTACT STATED THAT HE ENGAGED THE PANIC STOP BUTTON BUT THE VEHICLE HESITATED BEFORE STOPPING AND CAUSED THE CONTACT TO CRASH INTO THE REAR OF ANOTHER VEHICLE. A POLICE REPORT WAS AVAILABLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER BUT THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS APPROXIMATELY 1,700 AND THE CURRENT MILEAGE WAS APPROXIMATELY 2,000. UPDATED 02/02/11 *CN
TL*THE CONTACT OWNS A 2010 TOYOTA PRIUS. WHILE DRIVING THE VEHICLE AT VARIOUS SPEEDS USING THE HEADLIGHTS DURING THE DAY THE CONTACT NOTICED THAT THE INSTRUMENT PANEL BECAME VERY DIFFICULT TO SEE. THE VEHICLE WAS TAKEN TO THE DEALERSHIP WHERE THE CONTACT WAS INFORMED THAT THE FAILURE COULD NOT BE DETERMINED. THE CURRENT AND FAIL…
Read full complaint
TL*THE CONTACT OWNS A 2010 TOYOTA PRIUS. WHILE DRIVING THE VEHICLE AT VARIOUS SPEEDS USING THE HEADLIGHTS DURING THE DAY THE CONTACT NOTICED THAT THE INSTRUMENT PANEL BECAME VERY DIFFICULT TO SEE. THE VEHICLE WAS TAKEN TO THE DEALERSHIP WHERE THE CONTACT WAS INFORMED THAT THE FAILURE COULD NOT BE DETERMINED. THE CURRENT AND FAILURE MILEAGES WERE 13000.
Official recalls
1018V684000 · Hybrid Propulsion System
Oct 4, 2018
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2014 Toyota Prius and 2012-2014 Toyota Prius V vehicles. Excessive voltage in the Intelligent Power Module (IPM) within the inverter may cause the hybrid system to shut down, causing the vehicle to stall while being driven.
Consequence & remedy
Consequence: If the hybrid system shuts down unexpectedly, it can increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will update the software for the motor/generator control electronic control unit (ECU) and the hybrid control ECU as necessary, free of charge. The recall began January 22, 2019. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is J0V. Note: The software updates in this recall are needed even if the vehicle had the software previously updated under recalls 14V-053 or 15V-449.
16V487000 · Air Bags:side/window
Jun 30, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2010-2012 Toyota Prius, 2010 and 2012 Toyota Prius Plug-in Hybrid, and 2011-2012 Lexus CT200h vehicles. A weld in the curtain shield air bag inflator may crack causing one or both portions of the inflator to eject into the passenger cabin.
Consequence & remedy
Consequence: If either portion of the curtain shield air bag inflator ejects into the passenger cabin, there is an increased risk of injury to vehicle occupants.
Remedy: Toyota will notify owners, and dealers will install retention brackets to the curtain shield air bags, free of charge. The recall began on October 17, 2016. Owners may contact Toyota Customer Service Department at 1-800-331-4331. Toyota's number for this recall is Toyota G0U, and Lexus GLJ.
16V396000 · Seats:front Assembly:seat Heater/cooler
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
14V743000 · Seats:front Assembly:seat Heater/cooler
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
14V053000 · Electrical System:software; Hybrid Propulsion System: Inverter
Feb 12, 2014
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence & remedy
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Additional source detail variants (2)
Hybrid Propulsion System: Inverter
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Electrical System:software
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
13V235000 · Service Brakes
Jun 5, 2013
Toyota is recalling certain model year 2010 Prius vehicles manufactured March 31, 2009, through October 9, 2009; and model year 2010 Lexus HS250h vehicles manufactured June 19, 2009, through October 9, 2009. Nitrogen gas from a component of the brake booster pump assembly could leak into the brake fluid.
Consequence & remedy
Consequence: As nitrogen is released into the brake fluid, the brake pedal may have reduced hydraulic pressure. Under certain circumstances, this condition could affect stopping distance and increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the affected brake booster pump assemblies. The recall began on August 7, 2013. Owners may contact Toyota at 1-800-331-4331.
13V014000 · Air Bags:frontal:sensor/control MODULE-INACTIVE ; Seats
Jan 16, 2013
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence & remedy
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Additional source detail variants (2)
Seats
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
10V039000 · Service Brakes, Air:antilock:control Unit/module
Feb 9, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2010 TOYOTA PRIUS AND LEXUS HS250H PASSENGER VEHICLES. CUSTOMERS HAVE EXPERIENCED INCONSISTENT BRAKE FEEL AFTER ABS ACTUATION DURING SLOW AND STEADY APPLICATION OF THE BRAKES ON ROUGH OR SLICK ROAD SURFACES. STOPPING DISTANCES MAY BE INCREASED COMPARED WITH A CUSTOMER'S EXPECTATION FOR A GIVEN PEDAL FORCE.
Consequence & remedy
Consequence: VEHICLE STOPPING DISTANCES MAY INCREASE RELATIVE TO A CUSTOMER'S EXPECTATION INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REWRITE THE PROGRAMMING OF THE ABS CONTROL UNIT FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 3, 2010, AND IS EXPECTED TO BE COMPLETED IN LATE MARCH 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 AND LEXUS AT 1-800-255-3987.
10V035000 · Equipment:other:labels
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
10V036000 · Equipment:other:labels
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4DP23005 · Brake Actuator Valve Wear
Opened Nov 22, 2023 · No close date supplied
Status: open (inferred from source dates) · Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP19004 · Brake Actuator Valve Wear
Opened Sep 30, 2019 · Closed Jan 21, 2021
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist
On September 19, 2019, the Office of Defects Investigation (ODI) received a defect petition from Mr. Roger Hogan requesting that the Agency investigate and recall certain Toyota Prius, Prius PHV, Camry Hybrid and Avalon Hybrid vehicles for a brake actuator valve wear condition covered under Toyota Customer Support Programs ZJB and ZKK (subject CSP?s). In support of his request, the petitioner identified 117 NHTSA complaints allegedly related to the subject CSP condition, including 60 reporting crashes. On September 30, 2019, ODI opened Defect Petition DP19-004 to evaluate the petitioner?s request for an investigation. In August 2020, the petitioner notified the Agency that he was withdrawing his petition. Because the petitioner has withdrawn the petition, we are denying the petition as moot and no further analysis of this petition is necessary.NHTSA is authorized to issue an order requiring notification and remedy of a defect if the Agency?s investigation shows a defect in the design, construction, or performance of a motor vehicle that presents an unreasonable risk to safety. 49 U.S.C. ?? 30102(a)(9), 30118. Because the petitioner has with withdrawn the petition, the petition is denied as moot. This action does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency notes that it is not required to receive a defect petition prior to opening a defect investigation and will take further action if warranted by future circumstances.
PE10006 · Braking Performance, Hybrid Vehicle
Opened Feb 3, 2010 · Closed Jul 12, 2010
Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module ; Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:foundation Components:disc; Service Brakes, Hydraulic:power Assist; Service Brakes, Hydraulic:power Assist:hydraulic
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Additional source detail variants (7)
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:foundation Components:disc
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:foundation Components
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:power Assist:hydraulic
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic:power Assist
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.
Service Brakes, Hydraulic
The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Information Report, Toyota advised the agency of its plans to conduct a safety recall to address inconsistent brake feel and increased stopping distances that may occur during braking events requiring ABS operation, such as would occur when braking on rough or low friction road surfaces.Toyota will reprogram the ABS control unit with improved software that addresses this condition.Based on Toyota's action the investigation is closed. ODI will continue to monitor the subject vehicles' performance and will take further action as future circumstances dictate.