NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
1,051 reportsMileage unknown · Feb 4, 2010
Service Brakes, Electric
I JUST READ ABOUT THE 2010 PRIUS BRAKING COMPLAINTS. I HAVE A 2005 PRIUS AND CONSTANTLY EXPERIENCE WHAT IS BEING DESCRIBED. EVERY TIME I HIT A BUMP OR A POT HOLE, THE PRIUS LUNGES FORWARD ESPECIALLY IF I'M BRAKING AT THE TIME. ALSO, WHEN I BRAKE ON SLICK ROADS I OFTEN EXPERIENCE THE PRIUS' BRAKES NOT ENGAGING AS THEY SHOULD. ONC…
Read full complaint
I JUST READ ABOUT THE 2010 PRIUS BRAKING COMPLAINTS. I HAVE A 2005 PRIUS AND CONSTANTLY EXPERIENCE WHAT IS BEING DESCRIBED. EVERY TIME I HIT A BUMP OR A POT HOLE, THE PRIUS LUNGES FORWARD ESPECIALLY IF I'M BRAKING AT THE TIME. ALSO, WHEN I BRAKE ON SLICK ROADS I OFTEN EXPERIENCE THE PRIUS' BRAKES NOT ENGAGING AS THEY SHOULD. ONCE I TRIED TO MAKE A RIGHT HAND TURN, GOING A PROPER RATE OF SPEED, ON A SNOW COVERED ROAD. THE PRIUS' BRAKES DID NOT ENGAGE ENOUGH TO SLOW THE VEHICLE IN ORDER TO MAKE THE TURN. I WAS FORCED TO GO STRAIGHT THROUGH THE INTERSECTION IN ORDER TO AVOID A COLLISION. THIS "PROBLEM" HAS BEEN PRESENT SINCE WE PURCHASED THE VEHICLE IN 2005. I KNEW IT WAS THE COMPUTER SYSTEM CAUSING THE ANOMALY, BUT I FIGURED THAT I JUST NEEDED TO GET USED TO IT. NOW, AFTER READING THE MEDIA REPORTS, I BELIEVE THIS IS INFACT A PROBLEM WITH MY VEHICLES SENSORS AND SOFTWARE. *TR
NHTSA ODI #10305195
Mileage unknown · Feb 4, 2010
Vehicle Speed Control
I HAVE A 2005 PRIUS. THREE TIMES, THE CAR HAS SURGED FOR A FEW SECONDS WHILE STEPPING ON THE BRAKE. THE FIRST TIME IT HAPPENED I WAS SLOWING TO MAKE A RIGHT TURN. I REPORTED IT TO THE DEALER ON 5-25-05. I WAS TOLD THAT SOMETIMES THAT'S THE WAY THE BRAKES OPERATE. ANOTHER PUZZLING OCCURRENCE WHICH I REPORTED TO THE DEALER ON…
Read full complaint
I HAVE A 2005 PRIUS. THREE TIMES, THE CAR HAS SURGED FOR A FEW SECONDS WHILE STEPPING ON THE BRAKE. THE FIRST TIME IT HAPPENED I WAS SLOWING TO MAKE A RIGHT TURN. I REPORTED IT TO THE DEALER ON 5-25-05. I WAS TOLD THAT SOMETIMES THAT'S THE WAY THE BRAKES OPERATE. ANOTHER PUZZLING OCCURRENCE WHICH I REPORTED TO THE DEALER ON 4-25-06, WAS THAT SOMETIMES WHEN I STEP ON THE GAS, NOTHING HAPPENS, AND THEN IT SURGES FORWARD. *TR
NHTSA ODI #10305162
83,000 miles · Feb 4, 2010
Service Brakes, HydraulicCrash
TOYOTA PRIUS BRAKING ISSUES - PRE 2010 MODELS. ON JAN 18TH, WHILE APPROACHING A TRAFFIC LIGHT ON WET PAVEMENT, I APPLIED THE BRAKES ON MY 2005 PRIUS AND FELT WHAT APPEARED TO BE A SLIGHT DELAY IN THE BRAKES ENGAGING. I FIRMLY BELIEVE THIS CONTRIBUTED TO MY SLIDING OUT INTO THE INTERSECTION AND HITTING ANOTHER VEHICLE. HAD I S…
Read full complaint
TOYOTA PRIUS BRAKING ISSUES - PRE 2010 MODELS. ON JAN 18TH, WHILE APPROACHING A TRAFFIC LIGHT ON WET PAVEMENT, I APPLIED THE BRAKES ON MY 2005 PRIUS AND FELT WHAT APPEARED TO BE A SLIGHT DELAY IN THE BRAKES ENGAGING. I FIRMLY BELIEVE THIS CONTRIBUTED TO MY SLIDING OUT INTO THE INTERSECTION AND HITTING ANOTHER VEHICLE. HAD I STOPPED AN INCH OR TWO EARLIER I WOULD NOT HAVE HIT THE OTHER VEHICLE. TOYOTA HAS ADMITTED TO ITS DEALERS THAT THERE ARE BRAKING ISSUES WITH ITS 2010 MODEL AND I BELIEVE THESE ISSUES MAY GO BACK TO PREVIOUS MODELS ALSO. THE HYBRID SYSTEM HAS NOT CHANGED SIGNIFICANTLY IN THE PAST 5 TO 6 YEARS. TOYOTA SHOULD BE REQUIRED TO THOROUGHLY TEST THIS SYSTEM ON ALL PRIUS MODELS. *TR
NHTSA ODI #10305111
112,000 miles · Feb 4, 2010
Service Brakes, HydraulicCrash
TL*THE CONTACT OWNS A 2005 TOYOTA PRIUS. THE CONTACT WAS DRIVING BETWEEN 5-19 MPH ON AN ICY ROAD SURFACE WHEN THE BRAKES WERE APPLIED AND THE ANTI-LOCK BRAKE SYSTEM WAS INACTIVATION AND FAILED TO DEACTIVATE. THE VEHICLE FAILED TO SLOW DOWN AND CRASHED INTO A VEHICLE ON THE FRONT DRIVER SIDE. THE FAILURE OCCURRED WHENEVER ENCOUN…
Read full complaint
TL*THE CONTACT OWNS A 2005 TOYOTA PRIUS. THE CONTACT WAS DRIVING BETWEEN 5-19 MPH ON AN ICY ROAD SURFACE WHEN THE BRAKES WERE APPLIED AND THE ANTI-LOCK BRAKE SYSTEM WAS INACTIVATION AND FAILED TO DEACTIVATE. THE VEHICLE FAILED TO SLOW DOWN AND CRASHED INTO A VEHICLE ON THE FRONT DRIVER SIDE. THE FAILURE OCCURRED WHENEVER ENCOUNTERING ABNORMAL ROADS INCLUDING ICY ROAD SURFACES. THERE WERE NO INJURES. THE POLICE WAS NOT CALLED TO THE SCENE. BOTH VEHICLES WERE DAMAGED. THE VEHICLE WAS NOT INSPECTED FOR THE MALFUNCTION. THE FAILURE MILEAGE WAS 112,000.
NHTSA ODI #10305100
1,000 miles · Feb 4, 2010
Service Brakes, HydraulicTraction Control System
I READ LOTS OF NEWS REPORTS YESTERDAY THAT THE 2010 PRIUS HAS A BRAKING ISSUE WHEN RUN OVER SPEED BUMPS. MY 2005 PRIUS HAS A SIMILAR BEHAVIOR WHICH SEMI-KNOWN CAUSE WHICH MIGHT EXPLAIN THIS, WHILE BEING SLIGHTLY DANGEROUS IN ANOTHER WAY. WHEN ONE DRIVES A 2005 PRIUS TOO FAST OVER A SPEED BUMP, OR THROUGH ANOTHER SITUATION WH…
Read full complaint
I READ LOTS OF NEWS REPORTS YESTERDAY THAT THE 2010 PRIUS HAS A BRAKING ISSUE WHEN RUN OVER SPEED BUMPS. MY 2005 PRIUS HAS A SIMILAR BEHAVIOR WHICH SEMI-KNOWN CAUSE WHICH MIGHT EXPLAIN THIS, WHILE BEING SLIGHTLY DANGEROUS IN ANOTHER WAY. WHEN ONE DRIVES A 2005 PRIUS TOO FAST OVER A SPEED BUMP, OR THROUGH ANOTHER SITUATION WHICH CAUSES THE CAR TO THINK ONE OF ITS WHEELS IS SLIPPING OR SPINNING AT A DIFFERENT RATE THAN THE OTHERS, THE CAR TEMPORARILY (AS I BELIEVE IS IN THE INSTRUCTION MANUAL) FLASHES A BRIEFLY APPEARING INDICATOR LIGHT ON THE FRONT PANEL INDICATING IT IS SLIPPING, AND TEMPORARILY CUTS BACK ON ENGINE POWER. AVOIDING THIS REQUIRES KNOWING THE DRIVING BEHAVIOR OF THE PRIUS, AND I WONDER IF THIS IS THE BEHAVIOR CERTAIN 2010 PRIUS OWNERS MAY BE NOTING. {IF ONE IS LOOKING AT THE ROAD AND SCARED BY THE SUDDEN DROP IN ENGINE POWER, ONE MAY NEVER LOOK DOWN AT THE DASH TO SEE THE INDICATOR FLASH FOR 1-2 SECONDS EITHER.} NORMALLY THIS IS MIGHT SEEM LIKE REASONABLE, BUT THIS BECOMES POTENTIALLY EXTREMELY HAZARDOUS SHOULD ONE TRY TO MAKE A SHARP RIGHT TURN ONTO A HIGHER-SPEED MAIN ROAD (40 MPH+) FROM A DEAD STOP ON A SIDE ROAD WITH A HIGH RATE OF ACCELERATION TO ATTEMPT MERGE INTO HIGH-VOLUME, FAST-MOVING TRAFFIC. IN SUCH CASES (ESPECIALLY IF WATER IS PRESENT, BUT EVEN IF THE ROAD IS DRY), I HAVE HAD THE ANTI-SKID FEATURE KICK IN AND CUT BACK ON ENGINE POWER FOR A HALF-SECOND OR SO, WHICH RISKS STALLING THE CAR TEMPORARILY IN FRONT OF AN ONCOMING VEHICLE. AS A RESULT, I TRY NOT TO DO ANY MANEUVERS LIKE THIS, EVEN THOUGH OTHER CARS OFTEN CAN "BURN RUBBER" A BIT AND DO THIS. NOTHING HAS BEEN DONE TO ATTEMPT TO CORRECT THE ISSUE, AS IT IS PRESUMED TO BE NORMAL BEHAVIOR FOR THE CAR, AND I NEVER HAD A CAR WITH ANTI-SKID ABILITIES BEFORE. SEEING THIS WAS COMMON FOR ME AT FIRST, BUT IS NOW SOMEWHAT RARE (LESS THAN ONCE/MONTH) DUE TO CHANGING MY DRIVING HABITS. (MY2005 PRIUS LACKS VEHICLE STABILITY CONTROL; BUT HAS THE STANDARD ANTI-SKID SAFETY FEATURE.) *TR
NHTSA ODI #10305084
38,000 miles · Feb 4, 2010
Service Brakes, Hydraulic
I DRIVE A 2005 TOYOTA PRIUS. I RECENTLY HEARD ABOUT TOYOTA ADMITTING THERE IS A PROBLEM WITH THE BRAKING SYSTEM. I HAVE EXPERIENCED THIS PROBLEM IN MY DRIVING. WHEN I EITHER BEGIN BRAKING OR HAVE BEEN BRAKING AND HIT A POTHOLE OR ROUGH PAVEMENT, IT FEELS LIKE THE PRIUS STOPS BRAKING MOMENTARILY AND THEN QUICKLY RESUMES. THE …
Read full complaint
I DRIVE A 2005 TOYOTA PRIUS. I RECENTLY HEARD ABOUT TOYOTA ADMITTING THERE IS A PROBLEM WITH THE BRAKING SYSTEM. I HAVE EXPERIENCED THIS PROBLEM IN MY DRIVING. WHEN I EITHER BEGIN BRAKING OR HAVE BEEN BRAKING AND HIT A POTHOLE OR ROUGH PAVEMENT, IT FEELS LIKE THE PRIUS STOPS BRAKING MOMENTARILY AND THEN QUICKLY RESUMES. THE DURATION IS MAYBE A SECOND, BUT A LOT CAN HAPPEN IN A SECOND. LUCKILY THIS LAPSE IN BRAKING HASN'T HAPPENED WHEN THERE HAS BEEN A CAR RIGHT IN FRONT OF ME. I THINK IF IT DID, I WOULD HIT THE CAR BECAUSE I HAVE NO CONTROL OF THIS BRAKING LAPSE. I AM CONCERNED ABOUT THIS AND IF THIS IS A DEFECT THAT COULD BE FIXED, WHY WOULDN'T IT BE FIXED. THIS HAS BEEN AN ONGOING ISSUE FROM WHEN I FIRST BOUGHT THE PRIUS IN 2008. I DIDN'T THINK ABOUT COMPLAINING UNTIL I JUST READ THE NEWS ARTICLE RECENTLY. *TR
NHTSA ODI #10305058
80,000 miles · Feb 3, 2010
Vehicle Speed ControlCrash
05 TOYOTA PRIUS ( MY CAR) WAS RUNNING AT 25 MILES/HOUR IN LOCAL TRAFFIC. I FOUND THE CAR IN FRONT OF ME WAS SLOWED DOWN, SO I STEPPED DOWN MY PRIUS' BRAKE FIRMLY. MY PRIUS'S RESPONSE THE EVENT OF BRAKE BEING STEPPED DOWN WAS NOT AGILE ENOUGH , SO PRIUS HIT THE FRONT CAR'S BACK BUMPER. I WOULD LIKE TO REPORT THIS SLUGGISH OF PRI…
Read full complaint
05 TOYOTA PRIUS ( MY CAR) WAS RUNNING AT 25 MILES/HOUR IN LOCAL TRAFFIC. I FOUND THE CAR IN FRONT OF ME WAS SLOWED DOWN, SO I STEPPED DOWN MY PRIUS' BRAKE FIRMLY. MY PRIUS'S RESPONSE THE EVENT OF BRAKE BEING STEPPED DOWN WAS NOT AGILE ENOUGH , SO PRIUS HIT THE FRONT CAR'S BACK BUMPER. I WOULD LIKE TO REPORT THIS SLUGGISH OF PRIUS BRAKE TO FIGURE OUT WHETHER MY CAR'S SAFETY IS COMPROMISED OR NOT. *TR
NHTSA ODI #10304770
82,000 miles · Feb 3, 2010
Vehicle Speed Control
ON MY 2005 TOYOTA PRIUS, I HAVE OCCASIONALLY EXPERIENCED, WHEN BRAKING, IF THERE IS A BUMP IN THE ROAD OR THE ROAD IS A LITTLE SLICK, THE CAR SEEMINGLY JERKS FORWARD/ACCELERATES FOR A SPLIT SECOND. THE MOST RECENT TIME WAS FEBRUARY 1, 2010. *TR
NHTSA ODI #10304649
Mileage unknown · Feb 3, 2010
Service Brakes, Hydraulic
TEMPORARY LOSS OF BRAKING WHEN GOING OVER A POTHOLE OR RIPPLED SURFACE. I HAVE REPORTED THIS TWICE TO THE TOYOTA DEALER, BUT WAS TOLD THIS IS JUST THE WAY ABS WORKS. THE NEW YORK TIMES REPORTS TODAY THIS IS A PROBLEM WITH THE 2010 PRIUS, BUT THIS HAS BEEN HAPPENING IN MY 2005 PRIUS SINCE THE BEGINNING. *TR
NHTSA ODI #10304622
Mileage unknown · Feb 3, 2010
Service Brakes, Electric
I HAVE A 2005 PRIUS THAT HAS AN EXTRA OPTION OF STABILITY CONTROL. THE CAR DOES AS OTHERS ARE REPORTING IN THE 2010 MODELS. IF I HIT A BUMP OR ICY PATCH WHILE APPLYING THE BRAKE OR AS I AM APPLYING THE BRAKE THE CAR LURCHES FORWARD AND THE BRAKE DOES NOT ENGAGE. THUS FAR I AM ABLE TO HIT HARDER AND HOLD THE BRAKE A SECOND TIM…
Read full complaint
I HAVE A 2005 PRIUS THAT HAS AN EXTRA OPTION OF STABILITY CONTROL. THE CAR DOES AS OTHERS ARE REPORTING IN THE 2010 MODELS. IF I HIT A BUMP OR ICY PATCH WHILE APPLYING THE BRAKE OR AS I AM APPLYING THE BRAKE THE CAR LURCHES FORWARD AND THE BRAKE DOES NOT ENGAGE. THUS FAR I AM ABLE TO HIT HARDER AND HOLD THE BRAKE A SECOND TIME AND THE CAR THEN BEHAVES AS EXPECTED AND STOPS. *TR
NHTSA ODI #10304561
Official recalls
6Nov 14, 2012
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence & remedy
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Additional source detail variants (2)
Hybrid Propulsion System: Inverter
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Engine And Engine Cooling
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Nov 14, 2012
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence & remedy
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Additional source detail variants (2)
Steering:gear Box:shaft Sector
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Steering
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Oct 5, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
May 31, 2006
THE INTERMEDIATE SHAFT AND SLIDING YOKE IN THE ELECTRIC POWER STEERING SYSTEM CAN CRACK WHEN LARGE FORCES ARE APPLIED AND THE CONNECTION MAY SEPARATE OR THE SLEEVE MAY FRACTURE.
Consequence & remedy
Consequence: THIS COULD RESULT IN A LOSS OF STEERING CONTROL OF THE VEHICLE.
Remedy: TOYOTA WILL REPLACE THE STEERING INTERMEDIATE SHAFT AND INSPECT THE SLIDING YOKE AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON JUNE 9, 2006. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Apr 3, 2006
ON CERTAIN VEHICLES, DUE TO IMPROPER ASSEMBLY OF THE AIR BAG INFLATOR, WHICH IS USED IN THE SIDE AIR BAG, THE CURTAIN SHIELD AIR BAG, AND THE KNEE AIR BAG ASSEMBLY, SOME INFLATORS WERE PRODUCED WITH AN INSUFFICIENT AMOUNT OF THE HEATING AGENTS NECESSARY FOR PROPER AIR BAG DEPLOYMENT. IN THIS CONDITION, THE EXPANSION FORCE OF THE GAS MAY BE INSUFFICIENT TO PROPERLY INFLATE THE AIR BAG WHEN THE SRS SYSTEM IS ACTIVATED DURING A CRASH.
Consequence & remedy
Consequence: THIS MAY INCREASE THE RISK OF INJURY TO THE OCCUPANT IN THE INVOLVED SEATING POSITION IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SPECIFIC SRS AIR BAG. THE RECALL BEGAN ON APRIL 6, 2006. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371, SCION AT 1-866-548-1851, OR LEXUS AT 1-800-255-3987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP13001 · Intermediate Steering Shaft Separation
Opened Feb 21, 2013 · Closed Apr 8, 2020
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:linkages
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Additional source detail variants (3)
Steering:column
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Steering:linkages
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Steering
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
PE05029 · Engine Stalling
Opened May 31, 2005 · Closed Oct 12, 2005
Status: closed (inferred from source dates) · Engine And Engine Cooling; Engine And Engine Cooling:engine; Unknown Or Other
ODI OPENED PE05-029 BASED ON 33 REPORTS OF ALLEGED GASOLINE ENGINE STALLING ON THE SUBJECT VEHICLES.THE SUBJECT VEHICLES ARE GASOLINE/ ELECTRIC HYBRID VEHICLES THAT CAN BE OPERATED IN GASOLINE OR ELECTRIC MODES, OR A COMBINATION OF BOTH DEPENDING ON THE POWER DEMAND.ALL REPORTS ALLEGE THAT THE GASOLINE ENGINE SHUT DOWN SUDDENLY WITHOUT WARNING.SOME OF THE COMPLAINANTS REPORTED THAT THE VEHICLE CONTINUED TO OPERATE USING THE ELECTRIC MODE FOR A PERIOD OF TIME AFTER THE GAS ENGINE STALLED AND SOME REPORTED THAT THE VEHICLE SHUT DOWN AT THE SAME TIME THAT THEY FELT THE GAS ENGINE STALLED.SOME CONSUMERS REPORTED THAT THEY WERE ABLE TO RESTART THE VEHICLE EITHER IMMEDIATELY OR AFTER ALLOWING THE VEHICLE SIT FOR A SHORT TIME, WHEREAS OTHERS REPORTED THAT THEY HAD THEIR VEHICLE TOWED.DURING PE05-029, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.THE COMPLAINT DATA REPRESENTS INCIDENTS WHERE ENGINE STALLING WAS ALLEGED OR WHERE THE VEHICLE WAS ALLEGED TO HAVE ONE OF THE VARIOUS CONDITIONS THAT CAUSES THE GAS ENGINE TO STALL.IN ITS AUGUST 26, 2005 RESPONSE TO ODI'S INFORMATION REQUEST, TOYOTA IDENTIFIED VARIOUS CONDITIONS THAT COULD CAUSE THE SUBJECT VEHICLES TO EXPERIENCE A GAS ENGINE STALL.IF THIS HAPPENS, THE DRIVER IS ALERTED BY AN AUDIBLE SOUND AND VARIOUS WARNING LIGHTS.THE VEHICLE WILL CONTINUE TO OPERATE IN THE ELECTRIC MODE AND THE ELECTRICALLY-POWERED BRAKE AND STEERING OPERATION WILL CONTINUE TO FUNCTION NORMALLY. ANALYSIS OF THE WARRANTY DATA INDICATED THAT OVER 97% OF VEHICLES EXPERIENCING A GAS ENGINE STALL RESULTED FROM AN ISSUE WITH THE PROGRAM LOGIC IN THE ELECTRONIC CONTROL MODULE (ECM) SYSTEM, WHICH MAY CAUSE THE ECM SYSTEM TO NOT START THE GAS ENGINE WHEN REQUIRED.AS A RESULT, THE VEHICLE WILL ENTER THE LIMITED OPERATION MODE DESCRIBED ABOVE.THE MAJORITY OF THE ODI COMPLAINTS ALSO INDICATED THAT THE DRIVER EXPERIENCED THIS CONDITION IN CONJUNCTION WITH THE ENGINE STALL. DURING OCTOBER 2005, TOYOTA INFORMED ODI THAT IT WOULD INITIATE A SPECIAL SERVICE CAMPAIGN (SSC) TO REPROGRAM THE ECM SOFTWARE ON APPROXIMATELY 75,000 MY 2004 AND EARLY 2005 SUBJECT VEHICLES TO ADDRESS THE GAS ENGINE STALLING CONDITION.DURING THIS SSC, DEALERS WILL ALSO APPLY SPECIAL DIELECTRIC GREASE TO A TRANSAXLE CONNECTOR TO PREVENT WATER INTRUSION WHICH MAY ALSO CAUSE SIMILAR LIMITED OPERATION CONDITIONS.BASED ON ODI'S ANALYSIS, THIS REMEDY SHOULD ADDRESS MOST OF THE INCIDENTS RESULTING IN A LIMITED OPERATION MODE.GIVEN THESE CIRCUMSTANCES, FURTHER USE OF THE AGENCY RESOURCES IN THIS MATTER DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Additional source detail variants (3)
Engine And Engine Cooling:engine
ODI OPENED PE05-029 BASED ON 33 REPORTS OF ALLEGED GASOLINE ENGINE STALLING ON THE SUBJECT VEHICLES.THE SUBJECT VEHICLES ARE GASOLINE/ ELECTRIC HYBRID VEHICLES THAT CAN BE OPERATED IN GASOLINE OR ELECTRIC MODES, OR A COMBINATION OF BOTH DEPENDING ON THE POWER DEMAND.ALL REPORTS ALLEGE THAT THE GASOLINE ENGINE SHUT DOWN SUDDENLY WITHOUT WARNING.SOME OF THE COMPLAINANTS REPORTED THAT THE VEHICLE CONTINUED TO OPERATE USING THE ELECTRIC MODE FOR A PERIOD OF TIME AFTER THE GAS ENGINE STALLED AND SOME REPORTED THAT THE VEHICLE SHUT DOWN AT THE SAME TIME THAT THEY FELT THE GAS ENGINE STALLED.SOME CONSUMERS REPORTED THAT THEY WERE ABLE TO RESTART THE VEHICLE EITHER IMMEDIATELY OR AFTER ALLOWING THE VEHICLE SIT FOR A SHORT TIME, WHEREAS OTHERS REPORTED THAT THEY HAD THEIR VEHICLE TOWED.DURING PE05-029, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.THE COMPLAINT DATA REPRESENTS INCIDENTS WHERE ENGINE STALLING WAS ALLEGED OR WHERE THE VEHICLE WAS ALLEGED TO HAVE ONE OF THE VARIOUS CONDITIONS THAT CAUSES THE GAS ENGINE TO STALL.IN ITS AUGUST 26, 2005 RESPONSE TO ODI'S INFORMATION REQUEST, TOYOTA IDENTIFIED VARIOUS CONDITIONS THAT COULD CAUSE THE SUBJECT VEHICLES TO EXPERIENCE A GAS ENGINE STALL.IF THIS HAPPENS, THE DRIVER IS ALERTED BY AN AUDIBLE SOUND AND VARIOUS WARNING LIGHTS.THE VEHICLE WILL CONTINUE TO OPERATE IN THE ELECTRIC MODE AND THE ELECTRICALLY-POWERED BRAKE AND STEERING OPERATION WILL CONTINUE TO FUNCTION NORMALLY. ANALYSIS OF THE WARRANTY DATA INDICATED THAT OVER 97% OF VEHICLES EXPERIENCING A GAS ENGINE STALL RESULTED FROM AN ISSUE WITH THE PROGRAM LOGIC IN THE ELECTRONIC CONTROL MODULE (ECM) SYSTEM, WHICH MAY CAUSE THE ECM SYSTEM TO NOT START THE GAS ENGINE WHEN REQUIRED.AS A RESULT, THE VEHICLE WILL ENTER THE LIMITED OPERATION MODE DESCRIBED ABOVE.THE MAJORITY OF THE ODI COMPLAINTS ALSO INDICATED THAT THE DRIVER EXPERIENCED THIS CONDITION IN CONJUNCTION WITH THE ENGINE STALL. DURING OCTOBER 2005, TOYOTA INFORMED ODI THAT IT WOULD INITIATE A SPECIAL SERVICE CAMPAIGN (SSC) TO REPROGRAM THE ECM SOFTWARE ON APPROXIMATELY 75,000 MY 2004 AND EARLY 2005 SUBJECT VEHICLES TO ADDRESS THE GAS ENGINE STALLING CONDITION.DURING THIS SSC, DEALERS WILL ALSO APPLY SPECIAL DIELECTRIC GREASE TO A TRANSAXLE CONNECTOR TO PREVENT WATER INTRUSION WHICH MAY ALSO CAUSE SIMILAR LIMITED OPERATION CONDITIONS.BASED ON ODI'S ANALYSIS, THIS REMEDY SHOULD ADDRESS MOST OF THE INCIDENTS RESULTING IN A LIMITED OPERATION MODE.GIVEN THESE CIRCUMSTANCES, FURTHER USE OF THE AGENCY RESOURCES IN THIS MATTER DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Engine And Engine Cooling
ODI OPENED PE05-029 BASED ON 33 REPORTS OF ALLEGED GASOLINE ENGINE STALLING ON THE SUBJECT VEHICLES.THE SUBJECT VEHICLES ARE GASOLINE/ ELECTRIC HYBRID VEHICLES THAT CAN BE OPERATED IN GASOLINE OR ELECTRIC MODES, OR A COMBINATION OF BOTH DEPENDING ON THE POWER DEMAND.ALL REPORTS ALLEGE THAT THE GASOLINE ENGINE SHUT DOWN SUDDENLY WITHOUT WARNING.SOME OF THE COMPLAINANTS REPORTED THAT THE VEHICLE CONTINUED TO OPERATE USING THE ELECTRIC MODE FOR A PERIOD OF TIME AFTER THE GAS ENGINE STALLED AND SOME REPORTED THAT THE VEHICLE SHUT DOWN AT THE SAME TIME THAT THEY FELT THE GAS ENGINE STALLED.SOME CONSUMERS REPORTED THAT THEY WERE ABLE TO RESTART THE VEHICLE EITHER IMMEDIATELY OR AFTER ALLOWING THE VEHICLE SIT FOR A SHORT TIME, WHEREAS OTHERS REPORTED THAT THEY HAD THEIR VEHICLE TOWED.DURING PE05-029, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.THE COMPLAINT DATA REPRESENTS INCIDENTS WHERE ENGINE STALLING WAS ALLEGED OR WHERE THE VEHICLE WAS ALLEGED TO HAVE ONE OF THE VARIOUS CONDITIONS THAT CAUSES THE GAS ENGINE TO STALL.IN ITS AUGUST 26, 2005 RESPONSE TO ODI'S INFORMATION REQUEST, TOYOTA IDENTIFIED VARIOUS CONDITIONS THAT COULD CAUSE THE SUBJECT VEHICLES TO EXPERIENCE A GAS ENGINE STALL.IF THIS HAPPENS, THE DRIVER IS ALERTED BY AN AUDIBLE SOUND AND VARIOUS WARNING LIGHTS.THE VEHICLE WILL CONTINUE TO OPERATE IN THE ELECTRIC MODE AND THE ELECTRICALLY-POWERED BRAKE AND STEERING OPERATION WILL CONTINUE TO FUNCTION NORMALLY. ANALYSIS OF THE WARRANTY DATA INDICATED THAT OVER 97% OF VEHICLES EXPERIENCING A GAS ENGINE STALL RESULTED FROM AN ISSUE WITH THE PROGRAM LOGIC IN THE ELECTRONIC CONTROL MODULE (ECM) SYSTEM, WHICH MAY CAUSE THE ECM SYSTEM TO NOT START THE GAS ENGINE WHEN REQUIRED.AS A RESULT, THE VEHICLE WILL ENTER THE LIMITED OPERATION MODE DESCRIBED ABOVE.THE MAJORITY OF THE ODI COMPLAINTS ALSO INDICATED THAT THE DRIVER EXPERIENCED THIS CONDITION IN CONJUNCTION WITH THE ENGINE STALL. DURING OCTOBER 2005, TOYOTA INFORMED ODI THAT IT WOULD INITIATE A SPECIAL SERVICE CAMPAIGN (SSC) TO REPROGRAM THE ECM SOFTWARE ON APPROXIMATELY 75,000 MY 2004 AND EARLY 2005 SUBJECT VEHICLES TO ADDRESS THE GAS ENGINE STALLING CONDITION.DURING THIS SSC, DEALERS WILL ALSO APPLY SPECIAL DIELECTRIC GREASE TO A TRANSAXLE CONNECTOR TO PREVENT WATER INTRUSION WHICH MAY ALSO CAUSE SIMILAR LIMITED OPERATION CONDITIONS.BASED ON ODI'S ANALYSIS, THIS REMEDY SHOULD ADDRESS MOST OF THE INCIDENTS RESULTING IN A LIMITED OPERATION MODE.GIVEN THESE CIRCUMSTANCES, FURTHER USE OF THE AGENCY RESOURCES IN THIS MATTER DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Unknown Or Other
ODI OPENED PE05-029 BASED ON 33 REPORTS OF ALLEGED GASOLINE ENGINE STALLING ON THE SUBJECT VEHICLES.THE SUBJECT VEHICLES ARE GASOLINE/ ELECTRIC HYBRID VEHICLES THAT CAN BE OPERATED IN GASOLINE OR ELECTRIC MODES, OR A COMBINATION OF BOTH DEPENDING ON THE POWER DEMAND.ALL REPORTS ALLEGE THAT THE GASOLINE ENGINE SHUT DOWN SUDDENLY WITHOUT WARNING.SOME OF THE COMPLAINANTS REPORTED THAT THE VEHICLE CONTINUED TO OPERATE USING THE ELECTRIC MODE FOR A PERIOD OF TIME AFTER THE GAS ENGINE STALLED AND SOME REPORTED THAT THE VEHICLE SHUT DOWN AT THE SAME TIME THAT THEY FELT THE GAS ENGINE STALLED.SOME CONSUMERS REPORTED THAT THEY WERE ABLE TO RESTART THE VEHICLE EITHER IMMEDIATELY OR AFTER ALLOWING THE VEHICLE SIT FOR A SHORT TIME, WHEREAS OTHERS REPORTED THAT THEY HAD THEIR VEHICLE TOWED.DURING PE05-029, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.THE COMPLAINT DATA REPRESENTS INCIDENTS WHERE ENGINE STALLING WAS ALLEGED OR WHERE THE VEHICLE WAS ALLEGED TO HAVE ONE OF THE VARIOUS CONDITIONS THAT CAUSES THE GAS ENGINE TO STALL.IN ITS AUGUST 26, 2005 RESPONSE TO ODI'S INFORMATION REQUEST, TOYOTA IDENTIFIED VARIOUS CONDITIONS THAT COULD CAUSE THE SUBJECT VEHICLES TO EXPERIENCE A GAS ENGINE STALL.IF THIS HAPPENS, THE DRIVER IS ALERTED BY AN AUDIBLE SOUND AND VARIOUS WARNING LIGHTS.THE VEHICLE WILL CONTINUE TO OPERATE IN THE ELECTRIC MODE AND THE ELECTRICALLY-POWERED BRAKE AND STEERING OPERATION WILL CONTINUE TO FUNCTION NORMALLY. ANALYSIS OF THE WARRANTY DATA INDICATED THAT OVER 97% OF VEHICLES EXPERIENCING A GAS ENGINE STALL RESULTED FROM AN ISSUE WITH THE PROGRAM LOGIC IN THE ELECTRONIC CONTROL MODULE (ECM) SYSTEM, WHICH MAY CAUSE THE ECM SYSTEM TO NOT START THE GAS ENGINE WHEN REQUIRED.AS A RESULT, THE VEHICLE WILL ENTER THE LIMITED OPERATION MODE DESCRIBED ABOVE.THE MAJORITY OF THE ODI COMPLAINTS ALSO INDICATED THAT THE DRIVER EXPERIENCED THIS CONDITION IN CONJUNCTION WITH THE ENGINE STALL. DURING OCTOBER 2005, TOYOTA INFORMED ODI THAT IT WOULD INITIATE A SPECIAL SERVICE CAMPAIGN (SSC) TO REPROGRAM THE ECM SOFTWARE ON APPROXIMATELY 75,000 MY 2004 AND EARLY 2005 SUBJECT VEHICLES TO ADDRESS THE GAS ENGINE STALLING CONDITION.DURING THIS SSC, DEALERS WILL ALSO APPLY SPECIAL DIELECTRIC GREASE TO A TRANSAXLE CONNECTOR TO PREVENT WATER INTRUSION WHICH MAY ALSO CAUSE SIMILAR LIMITED OPERATION CONDITIONS.BASED ON ODI'S ANALYSIS, THIS REMEDY SHOULD ADDRESS MOST OF THE INCIDENTS RESULTING IN A LIMITED OPERATION MODE.GIVEN THESE CIRCUMSTANCES, FURTHER USE OF THE AGENCY RESOURCES IN THIS MATTER DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Illustration