IllustrationEingen faliur acording to dealership Toyota of Anthioc the veicle is on there lot for now but there diagnostic was engine faliure
2005 Toyota Prius
Owner reports · Recalls · Investigations
More warning signs than most Prius years
Owner complaints for the 2005 Toyota Prius are substantially higher than the model-year median of 164.
About this comparison →How this year compares
Owner complaints by model year
Compare all Prius years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1740–25K
10725–50K
13650–75K
12975–100K
185100–150K
140150K+
871 reports with mileage · 180 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Exterior Lighting. Review the 346 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 178 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 128 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
102 crash reports4 fire reports46 injury reports
Engine complaints
15 reportsCAR STOPPED ACCELERATING/ ENGINE DIED WHILE DRIVING AT 20-30 MPH EXITING HOLLAND TUNNEL. COASTED, THEN BRAKED TO STOP, PULLING OVER TO SHOULDER. TURNED AC OFF. RED WARNING LIGHT ON. AC WARNING LIGHT? PRESSED PARK BUTTON. PRESS POWER BUTTON TO TURN OFF CAR. WAITED 5 SEC AND THEN PRESSED POWER BUTTON, KEEPING AC OFF , AND RESUMED…
Read full complaint
CAR STOPPED ACCELERATING/ ENGINE DIED WHILE DRIVING AT 20-30 MPH EXITING HOLLAND TUNNEL. COASTED, THEN BRAKED TO STOP, PULLING OVER TO SHOULDER. TURNED AC OFF. RED WARNING LIGHT ON. AC WARNING LIGHT? PRESSED PARK BUTTON. PRESS POWER BUTTON TO TURN OFF CAR. WAITED 5 SEC AND THEN PRESSED POWER BUTTON, KEEPING AC OFF , AND RESUMED ACCELERATING.
TL* THE CONTACT OWNS A 2005 TOYOTA PRIUS. WHILE DRIVING VARIOUS SPEEDS, SEVERAL UNKNOWN WARNING INDICATORS BEGAN FLASHING AND THE VEHICLE STALLED. THE VEHICLE SHIFTED INTO NEUTRAL AS OTHER UNKNOWN WARNING INDICATORS ILLUMINATED. THE CONTACT COASTED THE VEHICLE TO A STOP AND RESTARTED THE ENGINE. THE CONTACT THEN DROVE THE VEHICL…
Read full complaint
TL* THE CONTACT OWNS A 2005 TOYOTA PRIUS. WHILE DRIVING VARIOUS SPEEDS, SEVERAL UNKNOWN WARNING INDICATORS BEGAN FLASHING AND THE VEHICLE STALLED. THE VEHICLE SHIFTED INTO NEUTRAL AS OTHER UNKNOWN WARNING INDICATORS ILLUMINATED. THE CONTACT COASTED THE VEHICLE TO A STOP AND RESTARTED THE ENGINE. THE CONTACT THEN DROVE THE VEHICLE TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED WITH INVERTED COOLING FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THE CONTACT WOULD HAVE TO PAY FOR DIAGNOSTIC TESTING. THE DEALER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 223,000.
2005 TOYOTA PRIUS. CONSUMER WRITES IN REGARDS TO RED AND WHITE SERVICE LIGHT INDICATOR. *LD THE CONSUMER INQUIRED ABOUT AN AD TO HAVE TO THE VEHICLE BE AT NO COST. *JS
TOYOTA PRIUS COMBINATION METER NOT WORKING FOR 2 DAYS WHEN I REPEATLY TURN IT ON AND TURN IT OFF....THEN WORKS ONE DAY THEN IS NOT WORKING NOW---I CAN'T SEE THE INSTRUMENT PANEL AND HOW FAST I AM DRIVING AND THEN I CAN NOT SHUT THE CAR OFF FOR SEVERAL MINUTES....VERY UNSAFE. AND I JUST HAD THE CAR SERVICED FOR A MESSED UP BATTER…
Read full complaint
TOYOTA PRIUS COMBINATION METER NOT WORKING FOR 2 DAYS WHEN I REPEATLY TURN IT ON AND TURN IT OFF....THEN WORKS ONE DAY THEN IS NOT WORKING NOW---I CAN'T SEE THE INSTRUMENT PANEL AND HOW FAST I AM DRIVING AND THEN I CAN NOT SHUT THE CAR OFF FOR SEVERAL MINUTES....VERY UNSAFE. AND I JUST HAD THE CAR SERVICED FOR A MESSED UP BATTERY. THIS IS A USED CAR THAT I BOUGHT TO REPLACE THE 2001 TOYOTA PRIUS THAT WAS REARENDED IN DEC 2016 THEN THE DEALER SOLD ME A JUNK CAR IN APRIL 2017 NOW HAVING TO FIX ALL THESE PROBLEMS. I WILL SELL THIS CAR AS A PIECE OF JUNK TO THE JUNK YARD AS STRAP METAL BECAUSE THAT WHAT IT IS. VERY UNSAFE AND THE NHTSA IS ALLOWING THIS TO HAPPEN. STARTED ON 08/22/2017 & 08/23/2017 & 08/25/2017 I CAN'T SEE THE PANEL.
TL* THE CONTACT OWNS A 2005 TOYOTA PRIUS. WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE STALLED AND ALL THE WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED WITH AN INVERTER WATER PUMP FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AN…
Read full complaint
TL* THE CONTACT OWNS A 2005 TOYOTA PRIUS. WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE STALLED AND ALL THE WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED WITH AN INVERTER WATER PUMP FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 12V563000 (ENGINE AND ENGINE COOLING, HYBRID PROPULSION SYSTEM). THE FAILURE MILEAGE WAS APPROXIMATELY 160,000.
THIS IS THE FIRST CAR WE EVER OWNED THAT ATE OIL. WE ARE METICULOUS ABOUT SERVICING THE CAR AS RECOMMENDED EVERY 5000 MILES. AT THE SERVICE FOR 100,000 MILES WHICH WE DID AT 99,400 MILES, THERE WAS NO OIL ON THE DIPSTICK. AT 103,000 MILES THE ALARMS WENT OFF 3 TIMES TO INDICATE THERE WAS NO OIL. WE PUT IN 2 QUARTS AND TOOK I…
Read full complaint
THIS IS THE FIRST CAR WE EVER OWNED THAT ATE OIL. WE ARE METICULOUS ABOUT SERVICING THE CAR AS RECOMMENDED EVERY 5000 MILES. AT THE SERVICE FOR 100,000 MILES WHICH WE DID AT 99,400 MILES, THERE WAS NO OIL ON THE DIPSTICK. AT 103,000 MILES THE ALARMS WENT OFF 3 TIMES TO INDICATE THERE WAS NO OIL. WE PUT IN 2 QUARTS AND TOOK IT TO THE SHOP FOR A DIAGNOSTIC. GOOGLING SHOWED MANY OTHER PEOPLE WITH THE SAME PROBLEM - NO OIL LEAK ANYWHERE, BUT NO OIL IN THE CAR EITHER. TOYOTA APPARENTLY KNOWS OF THE PROBLEM AND HAS INFORMED SERVICE PROVIDERS BUT WILL NOT ACKNOWLEDGE THIS PROBLEM TO THE CAR OWNERS. WE NOW CARRY OIL IN THE CAR AND CHECK EVERY TIME WE PUT IN GAS TO MAKE SURE WE ALSO HAVE OIL. THE SERVICE SHOP SUGGESTS A $3500+ REBUILD OF THE ENGINE. WE CAN AFFORD TO CHECK OIL AND ADD IT AS NECESSARY INSTEAD OF REBUILDING AN ENGINE THAT WILL END UP WITH THE SAME ISSUE. IT IS UNACCEPTABLE THAT THE EXPECTATION IS TO ADD OIL BETWEEN EVERY 5000 MILES, AS RECOMMENDED BY MANUFACTURER, INSTEAD OF THE ASSURANCE THAT THE CAR WILL BE ABLE TO MAKE IT TO EACH 5000 MILE INTERVAL WITHOUT ADDING ADDITIONAL OIL. WE ALSO CANNOT AFFORD TO HAVE THE ENGINE SEIZE UP IN WHAT IS MARKETED AS A VERY DEPENDABLE CAR FROM A VERY DEPENDABLE MANUFACTURER. APPARENTLY TOYOTA DOESN'T MAKE CARS THAT EXCEED A LIFETIME OF 100,000 MILES AND ARE ALSO A VERY UNDEPENDABLE MANUFACTURER OF CARS.
TL* THE CONTACT OWNS A 2005 TOYOTA PRIUS. WHILE WASHING THE VEHICLE, THE CONTACT NOTICED 2-3 DROPS OF WATER ENTERING THE FRONT PASSENGER SIDE WINDOW. THE WINDOW WAS CLOSED AT THE TIME OF THE FAILURE. ADDITIONALLY, WHEN THE VEHICLE WAS STARTED, THE CONTACT NOTICED THAT THE INSTRUMENT PANEL FAILED AND WOULD NOT ILLUMINATE. THE CON…
Read full complaint
TL* THE CONTACT OWNS A 2005 TOYOTA PRIUS. WHILE WASHING THE VEHICLE, THE CONTACT NOTICED 2-3 DROPS OF WATER ENTERING THE FRONT PASSENGER SIDE WINDOW. THE WINDOW WAS CLOSED AT THE TIME OF THE FAILURE. ADDITIONALLY, WHEN THE VEHICLE WAS STARTED, THE CONTACT NOTICED THAT THE INSTRUMENT PANEL FAILED AND WOULD NOT ILLUMINATE. THE CONTACT ENGAGED THE PUSH-TO-START BUTTON WITH THE BRAKES APPLIED TO SHUT OFF THE VEHICLE, BUT TO NO AVAIL. THE CONTACT THEN SHIFTED INTO PARK AND ATTEMPTED TO EXIT THE VEHICLE WHEN THE VEHICLE ABNORMALLY ACCELERATED. THE CONTACT WAS KNOCKED TO THE GROUND BY THE DRIVER SIDE DOOR AND SUSTAINED MINOR INJURIES. AS A RESULT. THE DEALER STATED THAT THE INSTRUMENT PANEL COMPUTER NEEDED TO BE REPLACED. THE DEALER FAILED TO PERFORM A DIAGNOSTIC TO DETERMINE THE CAUSE OF THE ELECTRICAL FAILURE OR THE ACCELERATION FAILURE. THE DEALER ALSO ADVISED THE CONTACT THAT THE MANUFACTURER EXTENDED A WARRANTY TO COVER THE FAILURE, BUT THE CONTACT'S VEHICLE WAS OVER THE MILEAGE LIMITATION BY 4,000 MILES. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 174,000. THE VIN WAS NOT AVAILABLE.
CAR STARTED SKIDDING ON THE ROAD, COULDN'T TAKE CONTROL BECAUSE CAR STARTED TO SPEED UP AND THEN RAMMED INTO THE CONCRETE BARRIER, SPUN AROUND AND ENDED UP FACING ONCOMING TRAFFIC. LUCKILY, THERE WASN'T ANY CAR RIGHT BEHIND ME AND I MANAGED TO PUSH OPEN THE DRIVER'S SIDE DOOR ALTHOUGH IT WOULDN'T OPEN COMPLETELY AND OPENED JUST …
Read full complaint
CAR STARTED SKIDDING ON THE ROAD, COULDN'T TAKE CONTROL BECAUSE CAR STARTED TO SPEED UP AND THEN RAMMED INTO THE CONCRETE BARRIER, SPUN AROUND AND ENDED UP FACING ONCOMING TRAFFIC. LUCKILY, THERE WASN'T ANY CAR RIGHT BEHIND ME AND I MANAGED TO PUSH OPEN THE DRIVER'S SIDE DOOR ALTHOUGH IT WOULDN'T OPEN COMPLETELY AND OPENED JUST ENOUGH FOR ME TO SQUEEZE THROUGH AND RAN OUT OF THE CAR. AT NO TIME DID THE AIRBAG OPEN UP AT ALL. I WAS LUCKY THAT I SUSTAINED NO MAJOR INJURY EXCEPT FOR A BADLY KNOCKING MY LEFT KNEE ON THE DASH. MY QUESTION TO TOYOTA WOULD BE WHY THE AIRBAD DIDN'T OPEN! WHAT IF ANOTHER CAR HAD HIT MINE AND I WOULDN'T HAVE BEEN PROTECTED BY THE AIRBAG!
I BROUGHT MY CAR IN FOR A RECALL ON STEERING MECHANISM WHICH RESULTED IN A BOLT REPLACEMENT. THE SERVICE ADVISER ADVISED ME I NEEDED TO REPLACE WATER PUMP. THIS CAR ALREADY HAD ONE PUMP REPLACED ON A RECALL, WHY WAS THE OTHER PUMP NOT RECALLED? *TR
Official recalls
612V536000 · Engine And Engine Cooling; Hybrid Propulsion System: Inverter
Nov 14, 2012
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence & remedy
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Additional source detail variants (2)
Hybrid Propulsion System: Inverter
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Engine And Engine Cooling
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
12V537000 · Steering; Steering:gear Box:shaft Sector
Nov 14, 2012
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence & remedy
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Additional source detail variants (2)
Steering:gear Box:shaft Sector
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Steering
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
10V036000 · Equipment:other:labels
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
09V388000 · Vehicle Speed Control:accelerator Pedal
Oct 5, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
06V188000 · Steering:electric Power Assist System
May 31, 2006
THE INTERMEDIATE SHAFT AND SLIDING YOKE IN THE ELECTRIC POWER STEERING SYSTEM CAN CRACK WHEN LARGE FORCES ARE APPLIED AND THE CONNECTION MAY SEPARATE OR THE SLEEVE MAY FRACTURE.
Consequence & remedy
Consequence: THIS COULD RESULT IN A LOSS OF STEERING CONTROL OF THE VEHICLE.
Remedy: TOYOTA WILL REPLACE THE STEERING INTERMEDIATE SHAFT AND INSPECT THE SLIDING YOKE AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON JUNE 9, 2006. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
06V096000 · Air Bags
Apr 3, 2006
ON CERTAIN VEHICLES, DUE TO IMPROPER ASSEMBLY OF THE AIR BAG INFLATOR, WHICH IS USED IN THE SIDE AIR BAG, THE CURTAIN SHIELD AIR BAG, AND THE KNEE AIR BAG ASSEMBLY, SOME INFLATORS WERE PRODUCED WITH AN INSUFFICIENT AMOUNT OF THE HEATING AGENTS NECESSARY FOR PROPER AIR BAG DEPLOYMENT. IN THIS CONDITION, THE EXPANSION FORCE OF THE GAS MAY BE INSUFFICIENT TO PROPERLY INFLATE THE AIR BAG WHEN THE SRS SYSTEM IS ACTIVATED DURING A CRASH.
Consequence & remedy
Consequence: THIS MAY INCREASE THE RISK OF INJURY TO THE OCCUPANT IN THE INVOLVED SEATING POSITION IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SPECIFIC SRS AIR BAG. THE RECALL BEGAN ON APRIL 6, 2006. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371, SCION AT 1-866-548-1851, OR LEXUS AT 1-800-255-3987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP13001 · Intermediate Steering Shaft Separation
Opened Feb 21, 2013 · Closed Apr 8, 2020
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:linkages
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Additional source detail variants (3)
Steering:column
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Steering:linkages
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Steering
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
PE05029 · Engine Stalling
Opened May 31, 2005 · Closed Oct 12, 2005
Status: closed (inferred from source dates) · Engine And Engine Cooling; Engine And Engine Cooling:engine; Unknown Or Other
ODI OPENED PE05-029 BASED ON 33 REPORTS OF ALLEGED GASOLINE ENGINE STALLING ON THE SUBJECT VEHICLES.THE SUBJECT VEHICLES ARE GASOLINE/ ELECTRIC HYBRID VEHICLES THAT CAN BE OPERATED IN GASOLINE OR ELECTRIC MODES, OR A COMBINATION OF BOTH DEPENDING ON THE POWER DEMAND.ALL REPORTS ALLEGE THAT THE GASOLINE ENGINE SHUT DOWN SUDDENLY WITHOUT WARNING.SOME OF THE COMPLAINANTS REPORTED THAT THE VEHICLE CONTINUED TO OPERATE USING THE ELECTRIC MODE FOR A PERIOD OF TIME AFTER THE GAS ENGINE STALLED AND SOME REPORTED THAT THE VEHICLE SHUT DOWN AT THE SAME TIME THAT THEY FELT THE GAS ENGINE STALLED.SOME CONSUMERS REPORTED THAT THEY WERE ABLE TO RESTART THE VEHICLE EITHER IMMEDIATELY OR AFTER ALLOWING THE VEHICLE SIT FOR A SHORT TIME, WHEREAS OTHERS REPORTED THAT THEY HAD THEIR VEHICLE TOWED.DURING PE05-029, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.THE COMPLAINT DATA REPRESENTS INCIDENTS WHERE ENGINE STALLING WAS ALLEGED OR WHERE THE VEHICLE WAS ALLEGED TO HAVE ONE OF THE VARIOUS CONDITIONS THAT CAUSES THE GAS ENGINE TO STALL.IN ITS AUGUST 26, 2005 RESPONSE TO ODI'S INFORMATION REQUEST, TOYOTA IDENTIFIED VARIOUS CONDITIONS THAT COULD CAUSE THE SUBJECT VEHICLES TO EXPERIENCE A GAS ENGINE STALL.IF THIS HAPPENS, THE DRIVER IS ALERTED BY AN AUDIBLE SOUND AND VARIOUS WARNING LIGHTS.THE VEHICLE WILL CONTINUE TO OPERATE IN THE ELECTRIC MODE AND THE ELECTRICALLY-POWERED BRAKE AND STEERING OPERATION WILL CONTINUE TO FUNCTION NORMALLY. ANALYSIS OF THE WARRANTY DATA INDICATED THAT OVER 97% OF VEHICLES EXPERIENCING A GAS ENGINE STALL RESULTED FROM AN ISSUE WITH THE PROGRAM LOGIC IN THE ELECTRONIC CONTROL MODULE (ECM) SYSTEM, WHICH MAY CAUSE THE ECM SYSTEM TO NOT START THE GAS ENGINE WHEN REQUIRED.AS A RESULT, THE VEHICLE WILL ENTER THE LIMITED OPERATION MODE DESCRIBED ABOVE.THE MAJORITY OF THE ODI COMPLAINTS ALSO INDICATED THAT THE DRIVER EXPERIENCED THIS CONDITION IN CONJUNCTION WITH THE ENGINE STALL. DURING OCTOBER 2005, TOYOTA INFORMED ODI THAT IT WOULD INITIATE A SPECIAL SERVICE CAMPAIGN (SSC) TO REPROGRAM THE ECM SOFTWARE ON APPROXIMATELY 75,000 MY 2004 AND EARLY 2005 SUBJECT VEHICLES TO ADDRESS THE GAS ENGINE STALLING CONDITION.DURING THIS SSC, DEALERS WILL ALSO APPLY SPECIAL DIELECTRIC GREASE TO A TRANSAXLE CONNECTOR TO PREVENT WATER INTRUSION WHICH MAY ALSO CAUSE SIMILAR LIMITED OPERATION CONDITIONS.BASED ON ODI'S ANALYSIS, THIS REMEDY SHOULD ADDRESS MOST OF THE INCIDENTS RESULTING IN A LIMITED OPERATION MODE.GIVEN THESE CIRCUMSTANCES, FURTHER USE OF THE AGENCY RESOURCES IN THIS MATTER DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Additional source detail variants (3)
Engine And Engine Cooling:engine
ODI OPENED PE05-029 BASED ON 33 REPORTS OF ALLEGED GASOLINE ENGINE STALLING ON THE SUBJECT VEHICLES.THE SUBJECT VEHICLES ARE GASOLINE/ ELECTRIC HYBRID VEHICLES THAT CAN BE OPERATED IN GASOLINE OR ELECTRIC MODES, OR A COMBINATION OF BOTH DEPENDING ON THE POWER DEMAND.ALL REPORTS ALLEGE THAT THE GASOLINE ENGINE SHUT DOWN SUDDENLY WITHOUT WARNING.SOME OF THE COMPLAINANTS REPORTED THAT THE VEHICLE CONTINUED TO OPERATE USING THE ELECTRIC MODE FOR A PERIOD OF TIME AFTER THE GAS ENGINE STALLED AND SOME REPORTED THAT THE VEHICLE SHUT DOWN AT THE SAME TIME THAT THEY FELT THE GAS ENGINE STALLED.SOME CONSUMERS REPORTED THAT THEY WERE ABLE TO RESTART THE VEHICLE EITHER IMMEDIATELY OR AFTER ALLOWING THE VEHICLE SIT FOR A SHORT TIME, WHEREAS OTHERS REPORTED THAT THEY HAD THEIR VEHICLE TOWED.DURING PE05-029, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.THE COMPLAINT DATA REPRESENTS INCIDENTS WHERE ENGINE STALLING WAS ALLEGED OR WHERE THE VEHICLE WAS ALLEGED TO HAVE ONE OF THE VARIOUS CONDITIONS THAT CAUSES THE GAS ENGINE TO STALL.IN ITS AUGUST 26, 2005 RESPONSE TO ODI'S INFORMATION REQUEST, TOYOTA IDENTIFIED VARIOUS CONDITIONS THAT COULD CAUSE THE SUBJECT VEHICLES TO EXPERIENCE A GAS ENGINE STALL.IF THIS HAPPENS, THE DRIVER IS ALERTED BY AN AUDIBLE SOUND AND VARIOUS WARNING LIGHTS.THE VEHICLE WILL CONTINUE TO OPERATE IN THE ELECTRIC MODE AND THE ELECTRICALLY-POWERED BRAKE AND STEERING OPERATION WILL CONTINUE TO FUNCTION NORMALLY. ANALYSIS OF THE WARRANTY DATA INDICATED THAT OVER 97% OF VEHICLES EXPERIENCING A GAS ENGINE STALL RESULTED FROM AN ISSUE WITH THE PROGRAM LOGIC IN THE ELECTRONIC CONTROL MODULE (ECM) SYSTEM, WHICH MAY CAUSE THE ECM SYSTEM TO NOT START THE GAS ENGINE WHEN REQUIRED.AS A RESULT, THE VEHICLE WILL ENTER THE LIMITED OPERATION MODE DESCRIBED ABOVE.THE MAJORITY OF THE ODI COMPLAINTS ALSO INDICATED THAT THE DRIVER EXPERIENCED THIS CONDITION IN CONJUNCTION WITH THE ENGINE STALL. DURING OCTOBER 2005, TOYOTA INFORMED ODI THAT IT WOULD INITIATE A SPECIAL SERVICE CAMPAIGN (SSC) TO REPROGRAM THE ECM SOFTWARE ON APPROXIMATELY 75,000 MY 2004 AND EARLY 2005 SUBJECT VEHICLES TO ADDRESS THE GAS ENGINE STALLING CONDITION.DURING THIS SSC, DEALERS WILL ALSO APPLY SPECIAL DIELECTRIC GREASE TO A TRANSAXLE CONNECTOR TO PREVENT WATER INTRUSION WHICH MAY ALSO CAUSE SIMILAR LIMITED OPERATION CONDITIONS.BASED ON ODI'S ANALYSIS, THIS REMEDY SHOULD ADDRESS MOST OF THE INCIDENTS RESULTING IN A LIMITED OPERATION MODE.GIVEN THESE CIRCUMSTANCES, FURTHER USE OF THE AGENCY RESOURCES IN THIS MATTER DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Engine And Engine Cooling
ODI OPENED PE05-029 BASED ON 33 REPORTS OF ALLEGED GASOLINE ENGINE STALLING ON THE SUBJECT VEHICLES.THE SUBJECT VEHICLES ARE GASOLINE/ ELECTRIC HYBRID VEHICLES THAT CAN BE OPERATED IN GASOLINE OR ELECTRIC MODES, OR A COMBINATION OF BOTH DEPENDING ON THE POWER DEMAND.ALL REPORTS ALLEGE THAT THE GASOLINE ENGINE SHUT DOWN SUDDENLY WITHOUT WARNING.SOME OF THE COMPLAINANTS REPORTED THAT THE VEHICLE CONTINUED TO OPERATE USING THE ELECTRIC MODE FOR A PERIOD OF TIME AFTER THE GAS ENGINE STALLED AND SOME REPORTED THAT THE VEHICLE SHUT DOWN AT THE SAME TIME THAT THEY FELT THE GAS ENGINE STALLED.SOME CONSUMERS REPORTED THAT THEY WERE ABLE TO RESTART THE VEHICLE EITHER IMMEDIATELY OR AFTER ALLOWING THE VEHICLE SIT FOR A SHORT TIME, WHEREAS OTHERS REPORTED THAT THEY HAD THEIR VEHICLE TOWED.DURING PE05-029, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.THE COMPLAINT DATA REPRESENTS INCIDENTS WHERE ENGINE STALLING WAS ALLEGED OR WHERE THE VEHICLE WAS ALLEGED TO HAVE ONE OF THE VARIOUS CONDITIONS THAT CAUSES THE GAS ENGINE TO STALL.IN ITS AUGUST 26, 2005 RESPONSE TO ODI'S INFORMATION REQUEST, TOYOTA IDENTIFIED VARIOUS CONDITIONS THAT COULD CAUSE THE SUBJECT VEHICLES TO EXPERIENCE A GAS ENGINE STALL.IF THIS HAPPENS, THE DRIVER IS ALERTED BY AN AUDIBLE SOUND AND VARIOUS WARNING LIGHTS.THE VEHICLE WILL CONTINUE TO OPERATE IN THE ELECTRIC MODE AND THE ELECTRICALLY-POWERED BRAKE AND STEERING OPERATION WILL CONTINUE TO FUNCTION NORMALLY. ANALYSIS OF THE WARRANTY DATA INDICATED THAT OVER 97% OF VEHICLES EXPERIENCING A GAS ENGINE STALL RESULTED FROM AN ISSUE WITH THE PROGRAM LOGIC IN THE ELECTRONIC CONTROL MODULE (ECM) SYSTEM, WHICH MAY CAUSE THE ECM SYSTEM TO NOT START THE GAS ENGINE WHEN REQUIRED.AS A RESULT, THE VEHICLE WILL ENTER THE LIMITED OPERATION MODE DESCRIBED ABOVE.THE MAJORITY OF THE ODI COMPLAINTS ALSO INDICATED THAT THE DRIVER EXPERIENCED THIS CONDITION IN CONJUNCTION WITH THE ENGINE STALL. DURING OCTOBER 2005, TOYOTA INFORMED ODI THAT IT WOULD INITIATE A SPECIAL SERVICE CAMPAIGN (SSC) TO REPROGRAM THE ECM SOFTWARE ON APPROXIMATELY 75,000 MY 2004 AND EARLY 2005 SUBJECT VEHICLES TO ADDRESS THE GAS ENGINE STALLING CONDITION.DURING THIS SSC, DEALERS WILL ALSO APPLY SPECIAL DIELECTRIC GREASE TO A TRANSAXLE CONNECTOR TO PREVENT WATER INTRUSION WHICH MAY ALSO CAUSE SIMILAR LIMITED OPERATION CONDITIONS.BASED ON ODI'S ANALYSIS, THIS REMEDY SHOULD ADDRESS MOST OF THE INCIDENTS RESULTING IN A LIMITED OPERATION MODE.GIVEN THESE CIRCUMSTANCES, FURTHER USE OF THE AGENCY RESOURCES IN THIS MATTER DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Unknown Or Other
ODI OPENED PE05-029 BASED ON 33 REPORTS OF ALLEGED GASOLINE ENGINE STALLING ON THE SUBJECT VEHICLES.THE SUBJECT VEHICLES ARE GASOLINE/ ELECTRIC HYBRID VEHICLES THAT CAN BE OPERATED IN GASOLINE OR ELECTRIC MODES, OR A COMBINATION OF BOTH DEPENDING ON THE POWER DEMAND.ALL REPORTS ALLEGE THAT THE GASOLINE ENGINE SHUT DOWN SUDDENLY WITHOUT WARNING.SOME OF THE COMPLAINANTS REPORTED THAT THE VEHICLE CONTINUED TO OPERATE USING THE ELECTRIC MODE FOR A PERIOD OF TIME AFTER THE GAS ENGINE STALLED AND SOME REPORTED THAT THE VEHICLE SHUT DOWN AT THE SAME TIME THAT THEY FELT THE GAS ENGINE STALLED.SOME CONSUMERS REPORTED THAT THEY WERE ABLE TO RESTART THE VEHICLE EITHER IMMEDIATELY OR AFTER ALLOWING THE VEHICLE SIT FOR A SHORT TIME, WHEREAS OTHERS REPORTED THAT THEY HAD THEIR VEHICLE TOWED.DURING PE05-029, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.THE COMPLAINT DATA REPRESENTS INCIDENTS WHERE ENGINE STALLING WAS ALLEGED OR WHERE THE VEHICLE WAS ALLEGED TO HAVE ONE OF THE VARIOUS CONDITIONS THAT CAUSES THE GAS ENGINE TO STALL.IN ITS AUGUST 26, 2005 RESPONSE TO ODI'S INFORMATION REQUEST, TOYOTA IDENTIFIED VARIOUS CONDITIONS THAT COULD CAUSE THE SUBJECT VEHICLES TO EXPERIENCE A GAS ENGINE STALL.IF THIS HAPPENS, THE DRIVER IS ALERTED BY AN AUDIBLE SOUND AND VARIOUS WARNING LIGHTS.THE VEHICLE WILL CONTINUE TO OPERATE IN THE ELECTRIC MODE AND THE ELECTRICALLY-POWERED BRAKE AND STEERING OPERATION WILL CONTINUE TO FUNCTION NORMALLY. ANALYSIS OF THE WARRANTY DATA INDICATED THAT OVER 97% OF VEHICLES EXPERIENCING A GAS ENGINE STALL RESULTED FROM AN ISSUE WITH THE PROGRAM LOGIC IN THE ELECTRONIC CONTROL MODULE (ECM) SYSTEM, WHICH MAY CAUSE THE ECM SYSTEM TO NOT START THE GAS ENGINE WHEN REQUIRED.AS A RESULT, THE VEHICLE WILL ENTER THE LIMITED OPERATION MODE DESCRIBED ABOVE.THE MAJORITY OF THE ODI COMPLAINTS ALSO INDICATED THAT THE DRIVER EXPERIENCED THIS CONDITION IN CONJUNCTION WITH THE ENGINE STALL. DURING OCTOBER 2005, TOYOTA INFORMED ODI THAT IT WOULD INITIATE A SPECIAL SERVICE CAMPAIGN (SSC) TO REPROGRAM THE ECM SOFTWARE ON APPROXIMATELY 75,000 MY 2004 AND EARLY 2005 SUBJECT VEHICLES TO ADDRESS THE GAS ENGINE STALLING CONDITION.DURING THIS SSC, DEALERS WILL ALSO APPLY SPECIAL DIELECTRIC GREASE TO A TRANSAXLE CONNECTOR TO PREVENT WATER INTRUSION WHICH MAY ALSO CAUSE SIMILAR LIMITED OPERATION CONDITIONS.BASED ON ODI'S ANALYSIS, THIS REMEDY SHOULD ADDRESS MOST OF THE INCIDENTS RESULTING IN A LIMITED OPERATION MODE.GIVEN THESE CIRCUMSTANCES, FURTHER USE OF THE AGENCY RESOURCES IN THIS MATTER DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.