← New search

2005 Toyota Prius

Owner reports · Recalls · Investigations

More warning signs than most Prius years

Owner complaints for the 2005 Toyota Prius are substantially higher than the model-year median of 164.

About this comparison →

When problems were reported

Mileage at the reported incident

871 reports with mileage · 180 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Exterior Lighting. Review the 346 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 178 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Service Brakes, Hydraulic. Review the 128 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

102 crash reports4 fire reports46 injury reports

Tires complaints

10 reports
Clear category filter
Mileage unknown · Oct 23, 2014
Tires

I PURCHASED FOUR NEW HIFLY HF201 TIRES, SIZE 185/65R15, ON SEPTEMBER 5, 2014. ON OCTOBER 21, 2014, THE FRONT DRIVER'S SIDE TIRE BLEW OUT WHILE I WAS DRIVING HOME ON THE FREEWAY. THERE WERE A NUMBER OF HOLES -- ONE AS LARGE AS A BASEBALL -- ALONG THE OUTER SIDEWALL OF THE TIRE. AS PREVIOUSLY STATED, THE TIRES WERE A LITTLE OVER O…

Read full complaint

I PURCHASED FOUR NEW HIFLY HF201 TIRES, SIZE 185/65R15, ON SEPTEMBER 5, 2014. ON OCTOBER 21, 2014, THE FRONT DRIVER'S SIDE TIRE BLEW OUT WHILE I WAS DRIVING HOME ON THE FREEWAY. THERE WERE A NUMBER OF HOLES -- ONE AS LARGE AS A BASEBALL -- ALONG THE OUTER SIDEWALL OF THE TIRE. AS PREVIOUSLY STATED, THE TIRES WERE A LITTLE OVER ONE MONTH OLD, WERE PURCHASED NEW, AND WERE PROFESSIONAL INSTALLED. I DRIVE A LOT FOR MY WORK AND HAVE TWO KIDS, WHO ARE OFTEN IN THE CAR WITH ME. MY DAUGHTER IS ABOUT TO GET HER LICENSE AND WILL BE DRIVING MY CAR, AND I'M VERY CONCERNED ABOUT THE SAFETY OF THESE TIRES. THE DEALER WHO SOLD ME THE TIRES GAVE ME A NEW TIRE, FREE OF CHARGE, TO REPLACE THE ONE THAT FAILED, BUT I HAVE LITTLE CONFIDENCE IN THESE TIRES. I HAVE BEEN DRIVING SINCE I WAS 16 (I'M NOW 52) AND I HAVE NEVER SEEN A TIRE FAIL LIKE THIS ONE DID. I'M FILING THIS COMPLAINT BECAUSE I DON'T BELIEVE THESE TIRES ARE SAFE AND DON'T WANT TO SEE ANYONE GET HURT. THANK YOU, AND PLEASE FEEL FREE TO CONTACT ME WITH ANY QUESTIONS. *TR

NHTSA ODI #10649453

103,000 miles · Feb 5, 2014
Tires

TL* THE CONTACT OWNS A 2005 TOYOTA PRIUS EQUIPPED WITH BRIDGESTONE/FIRESTONE INSIGNIA SE200 ALL SEASON TIRES, SIZE: P185/65R 15 86T. THE CONTACT STATED SHE WAS DRIVING 30 MPH WHEN SHE HEARD A FLAPPING NOISE COMING FROM THE REAR PASSENGER'S SIDE TIRE. THE CONTACT CHECKED THE TIRE AND DISCOVERED THAT THE TIRE WAS DEFLATED AND THE …

Read full complaint

TL* THE CONTACT OWNS A 2005 TOYOTA PRIUS EQUIPPED WITH BRIDGESTONE/FIRESTONE INSIGNIA SE200 ALL SEASON TIRES, SIZE: P185/65R 15 86T. THE CONTACT STATED SHE WAS DRIVING 30 MPH WHEN SHE HEARD A FLAPPING NOISE COMING FROM THE REAR PASSENGER'S SIDE TIRE. THE CONTACT CHECKED THE TIRE AND DISCOVERED THAT THE TIRE WAS DEFLATED AND THE SIDE WALL WAS SPLIT. THE CONTACT TOOK THE TIRE TO A TIRE SHOP WHERE THEY PROVIDED HER WITH A REPLACEMENT TIRE. THE TIRE FAILURE MILEAGE WAS 3,500. THE VEHICLE FAILURE MILEAGE WAS 103,000.

NHTSA ODI #10563117

Mileage unknown · Feb 24, 2013
Tires

SEQUENTIAL FAILURE OF 4 GOODYEAR ASSURANCE TIRES PLACED ON VEHICLE IN OCTOBER 2004. SINCE OCTOBER OF 2012 THE TIRES HAVE BEEN BLOWING OUT AT THE RATE OF ONE EVERY 6-8 WEEKS. I PLAN ON REPLACING THE ONE REMAINING OF THOSE 2004 TIRES BEFORE IT IMPLODES ALSO WHILE DRIVING. *TR

NHTSA ODI #10499870

12,000 miles · Aug 20, 2008
Tires

I PURCHASED A 2005 TOYOTA PRIUS AND DROVE IT FOR 12,00 MILES AT WHICH TIME THE TIRES WERE COMPLETELY WORE OUT. WHEN I WENT IN TO TOYOTA AND POINTED THIS OUT THEY REPLACED THE TIRES BECAUSE THE CAR WAS STILL UNDER WARRANTY. I TAKE MY CAR IN FOR THE SCHEDULED SERVICES RECOMMENDED BY TOYOTA. TO DATE MY CAR HAS 25,000 MILES AND I A…

Read full complaint

I PURCHASED A 2005 TOYOTA PRIUS AND DROVE IT FOR 12,00 MILES AT WHICH TIME THE TIRES WERE COMPLETELY WORE OUT. WHEN I WENT IN TO TOYOTA AND POINTED THIS OUT THEY REPLACED THE TIRES BECAUSE THE CAR WAS STILL UNDER WARRANTY. I TAKE MY CAR IN FOR THE SCHEDULED SERVICES RECOMMENDED BY TOYOTA. TO DATE MY CAR HAS 25,000 MILES AND I AM EXPERIENCING THE SAME PROBLEMS WITH THE TIRES. THEREFORE THE TIRES ONLY HAVE 13,000 MILES WEAR. I CALLED TOYOTA AND SPOKE TO THE HEAD MANAGER WHO INDICATED THAT THE PRIUS CARS HAVE THIS PROBLEM BECAUSE OF THE BATTERY AND TOYOTA IS AWARE OF THIS. IF THEY ARE AWARE OF THIS PROBLEM, WHY DO THEY USE THE GOODYEAR TIRES WHICH WEAR OUT SO QUICKLY? I HAVE ALSO READ ON THE INTERNET OF OTHER PRIUS OWNERS EXPERIENCING THE SAME PROBLEM WITH THE TIRES AND HAVING BLOW OUTS ON FREEWAYS, ETC. I THINK THERE SHOULD BE A SAFETY RECALL ON TOYOTA PRIUS TIRES SINCE UPON READING INFORMATION ON THE INTERNET THERE HAVE BEEN A MULTITUDE OF OWNERS WHO HAVE EXPERIENCE THE SAME PROBLEM AS I. THEY SHOULD PUT SAFER TIRES ON THE CAR SINCE THEY ARE AWARE OF THIS SITUATION. *TR

NHTSA ODI #10239083

55,000 miles · Nov 30, 2007
Electrical SystemTires

WE HAVE TWO 2005 TOYOTA PRIUSES WHICH HAVE EXHIBITED IDENTICAL STALLING AND SHIFTING PROBLEMS. THE HYBRID SYSTEM WILL STALL OR NOT OPERATE AND WILL NOT ALLOW US TO SHIFT THE VEHICLE INTO GEAR PERIODICALLY. ONE TOYOTA DEALER SAYS WE NEED TO REPLACE THE TRANSAXLE, AND ANOTHER WAS NOT SURE AND SAID THERE BEST "GUESS" WAS TO REFRESH…

Read full complaint

WE HAVE TWO 2005 TOYOTA PRIUSES WHICH HAVE EXHIBITED IDENTICAL STALLING AND SHIFTING PROBLEMS. THE HYBRID SYSTEM WILL STALL OR NOT OPERATE AND WILL NOT ALLOW US TO SHIFT THE VEHICLE INTO GEAR PERIODICALLY. ONE TOYOTA DEALER SAYS WE NEED TO REPLACE THE TRANSAXLE, AND ANOTHER WAS NOT SURE AND SAID THERE BEST "GUESS" WAS TO REFRESH THE ECU AND HYBRID CONTROL MODULE SOFTWARE , HOWEVER AFTER DOING EXTENSIVE RESEARCH ONLINE BELIEVE IT TO BE A COMBINATION OF A SOFTWARE GLITCH ATTRIBUTED TO A LEAK IN WATERPROOFING A GASKET NEAR AN ECU. THE PROBLEM WAS BROUGHT TO THE DEALERS ATTENTION ALMOST A YEAR AGO WHILE THE VEHICLES WERE STILL UNDER WARRANTY. ALL THEY DID WAS SIMPLY "FLASH" OR REFRESH THE MEMORY AND DID NOT ACTUALLY RESOLVE THE PROBLEM. THE PRIUS' HYBRID-RELATED COMPONENTS, INCLUDING THE HYBRID CONTROL MODULE ARE COVERED FOR 8 YEARS/100,000 MILES. WE ALSO MENTIONED TO THE DEALER THE UNUSUAL AND EXCESSIVE TIRE WEAR ON BOTH VEHICLES, SOME OF THE TIRES HAD NO TREAD AND WERE ALREADY BALD AFTER ONLY 12,000 MILES. I AM WONDERING IF THIS COULD BE RELATED TO THE STEERING OR TRACTION CONTROL ISSUES PREVALENT WITH THIS MODEL. *TR

NHTSA ODI #10210426

21,000 miles · Oct 10, 2006
Tires

WE HAD TO REPLACE THE TIRES WITH ONLY 20,000 MILES ON IN ORDER FOR OUR VEHICLE TO PASS INSPECTION. TIRES ARE RATED AT 50,000. DEALER CLAIMED IT WAS BECAUSE OUR REAR WHEELS WERE OUT OF ALIGNMENT YET THEY HAD NO WAY OF ALIGNING THE REAR WHEELS SO NOTHING WAS DONE TO CORRECT THE PROBLEM BUT PAY ABOVE MSRP FOR TWO NEW TIRES. A FEW W…

Read full complaint

WE HAD TO REPLACE THE TIRES WITH ONLY 20,000 MILES ON IN ORDER FOR OUR VEHICLE TO PASS INSPECTION. TIRES ARE RATED AT 50,000. DEALER CLAIMED IT WAS BECAUSE OUR REAR WHEELS WERE OUT OF ALIGNMENT YET THEY HAD NO WAY OF ALIGNING THE REAR WHEELS SO NOTHING WAS DONE TO CORRECT THE PROBLEM BUT PAY ABOVE MSRP FOR TWO NEW TIRES. A FEW WEEKS LATER WE WENT TO A LOCAL TIRE STORE FOR TWO MORE AS WE WERE TRAVELING AND DIDN'T WANT TO TAKE ANY CHANCES.

NHTSA ODI #10170334

20,000 miles · Aug 27, 2006
Tires

PRIUS TIRE WEAR - GOODYEAR INTEGRITY TIRES HAVE WORN TO THE POINT OF "RECOMMENDED" REPLACEMENT AT 20000 MILES. TOYOTA CUSTOMER EXPERIENCE CENTER & DEALER CLAIM THAT PRIUS TIRES "WEAR FASTER THAN MOST CARS"... I HAVE NOT HEARD OF A 50,000 MILE TIRE LASTING ONLY 20,000 MILES - TOYOTA SHOULD BE FORCED TO INVESTIGATE WHY THE PRIUS…

Read full complaint

PRIUS TIRE WEAR - GOODYEAR INTEGRITY TIRES HAVE WORN TO THE POINT OF "RECOMMENDED" REPLACEMENT AT 20000 MILES. TOYOTA CUSTOMER EXPERIENCE CENTER & DEALER CLAIM THAT PRIUS TIRES "WEAR FASTER THAN MOST CARS"... I HAVE NOT HEARD OF A 50,000 MILE TIRE LASTING ONLY 20,000 MILES - TOYOTA SHOULD BE FORCED TO INVESTIGATE WHY THE PRIUS RUINS TIRES SO QUICKLY. CONSUMER AFFAIRS ALSO IS TAKING COMPLAINTS ON PRIUS TIRE WEAR. *JB

NHTSA ODI #10166654

14,000 miles · May 3, 2006
Tires

DT*: THE CONTACT STATED WHILE THE VEHICLE WAS AT THE DEALER FOR ROUTINE MAINTENANCE, THE MECHANIC NOTICED A TREAD SEPARATION PROBLEM ON THE FRONT DRIVER SIDE TIRE. THE CONTACT WAS REFERRED TO THE TIRE DEALER AND UPON INSPECTION THE TIRE DEALER DETERMINED THE TREAD SEPARATION WAS RELATED TO IMPACT DAMAGE. BUT, THE VEHICLE WAS …

Read full complaint

DT*: THE CONTACT STATED WHILE THE VEHICLE WAS AT THE DEALER FOR ROUTINE MAINTENANCE, THE MECHANIC NOTICED A TREAD SEPARATION PROBLEM ON THE FRONT DRIVER SIDE TIRE. THE CONTACT WAS REFERRED TO THE TIRE DEALER AND UPON INSPECTION THE TIRE DEALER DETERMINED THE TREAD SEPARATION WAS RELATED TO IMPACT DAMAGE. BUT, THE VEHICLE WAS NEVER INVOLVED IN AN ACCIDENT OR OTHER TYPE OF IMPACT. THE TIRES HAD BEEN REGULARLY ROTATED EVERY FIVE THOUSAND MILES AS RECOMMENDED BY THE MANUFACTURER. THE TIRE WAS REPLACED WITH A LIKE TIRE BY THE TIRE DEALER. THE FAILED TIRE WAS A GOOD YEAR, INTEGRITY, P185/65/R15.

NHTSA ODI #10156680

13,000 miles · Apr 26, 2006
Tires

BULGES HAVE APPEARED IN THE SIDEWALLS OF TWO OF THE FOUR GOODYEAR POTENZA TIRES ON OUR 2005 TOYOTA PRIUS. I CAN PROVIDE PHOTOS. THE TIRES WERE MAINTAINED BY HAVING THEM ROTATED AND PRESSURE CHECKED AT 5,000-MILE INTERVALS BY THE TOYOTA DEALER. THE CAR HAS BEEN DRIVEN ONLY ON PAVED STREETS AND ROADS. CURRENT MILEAGE ON THE CA…

Read full complaint

BULGES HAVE APPEARED IN THE SIDEWALLS OF TWO OF THE FOUR GOODYEAR POTENZA TIRES ON OUR 2005 TOYOTA PRIUS. I CAN PROVIDE PHOTOS. THE TIRES WERE MAINTAINED BY HAVING THEM ROTATED AND PRESSURE CHECKED AT 5,000-MILE INTERVALS BY THE TOYOTA DEALER. THE CAR HAS BEEN DRIVEN ONLY ON PAVED STREETS AND ROADS. CURRENT MILEAGE ON THE CAR IS 13,000. I HAVE ELECTED TO REPLACE ALL FOUR TIRES WITH MICHELINS. *JB

NHTSA ODI #10156141

Mileage unknown · Apr 7, 2005
Tires

EXTREME SENSITIVITY & INSTABILITY IN STRONG CROSSWINDS. THE STANDARD INTEGRITY TIRES THAT COME WITH THE CAR ARE A JOKE! *AK

NHTSA ODI #10116540

Official recalls

6

12V536000 · Engine And Engine Cooling; Hybrid Propulsion System: Inverter

Nov 14, 2012

Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.

Consequence & remedy

Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.

Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.

Additional source detail variants (2)

Hybrid Propulsion System: Inverter

Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.

Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.

Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.

Engine And Engine Cooling

Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.

Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.

Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.

12V537000 · Steering; Steering:gear Box:shaft Sector

Nov 14, 2012

Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.

Consequence & remedy

Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.

Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.

Additional source detail variants (2)

Steering:gear Box:shaft Sector

Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.

Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.

Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.

Steering

Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.

Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.

Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.

10V036000 · Equipment:other:labels

Feb 3, 2010

SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Consequence & remedy

Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.

Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.

09V388000 · Vehicle Speed Control:accelerator Pedal

Oct 5, 2009

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.

Consequence & remedy

Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.

Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.

06V188000 · Steering:electric Power Assist System

May 31, 2006

THE INTERMEDIATE SHAFT AND SLIDING YOKE IN THE ELECTRIC POWER STEERING SYSTEM CAN CRACK WHEN LARGE FORCES ARE APPLIED AND THE CONNECTION MAY SEPARATE OR THE SLEEVE MAY FRACTURE.

Consequence & remedy

Consequence: THIS COULD RESULT IN A LOSS OF STEERING CONTROL OF THE VEHICLE.

Remedy: TOYOTA WILL REPLACE THE STEERING INTERMEDIATE SHAFT AND INSPECT THE SLIDING YOKE AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON JUNE 9, 2006. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

06V096000 · Air Bags

Apr 3, 2006

ON CERTAIN VEHICLES, DUE TO IMPROPER ASSEMBLY OF THE AIR BAG INFLATOR, WHICH IS USED IN THE SIDE AIR BAG, THE CURTAIN SHIELD AIR BAG, AND THE KNEE AIR BAG ASSEMBLY, SOME INFLATORS WERE PRODUCED WITH AN INSUFFICIENT AMOUNT OF THE HEATING AGENTS NECESSARY FOR PROPER AIR BAG DEPLOYMENT. IN THIS CONDITION, THE EXPANSION FORCE OF THE GAS MAY BE INSUFFICIENT TO PROPERLY INFLATE THE AIR BAG WHEN THE SRS SYSTEM IS ACTIVATED DURING A CRASH.

Consequence & remedy

Consequence: THIS MAY INCREASE THE RISK OF INJURY TO THE OCCUPANT IN THE INVOLVED SEATING POSITION IN THE EVENT OF A CRASH.

Remedy: DEALERS WILL REPLACE THE SPECIFIC SRS AIR BAG. THE RECALL BEGAN ON APRIL 6, 2006. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371, SCION AT 1-866-548-1851, OR LEXUS AT 1-800-255-3987.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

3

DP22005 · Pedestrian Alert Sounds

Opened Jan 27, 2023 · Closed Aug 7, 2023

Status: closed (inferred from source dates) · Electrical System:propulsion System

NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.

DP13001 · Intermediate Steering Shaft Separation

Opened Feb 21, 2013 · Closed Apr 8, 2020

Status: closed (inferred from source dates) · Steering; Steering:column; Steering:linkages

The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606

Additional source detail variants (3)

Steering:column

The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606

Steering:linkages

The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606

Steering

The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606

PE05029 · Engine Stalling

Opened May 31, 2005 · Closed Oct 12, 2005

Status: closed (inferred from source dates) · Engine And Engine Cooling; Engine And Engine Cooling:engine; Unknown Or Other

ODI OPENED PE05-029 BASED ON 33 REPORTS OF ALLEGED GASOLINE ENGINE STALLING ON THE SUBJECT VEHICLES.THE SUBJECT VEHICLES ARE GASOLINE/ ELECTRIC HYBRID VEHICLES THAT CAN BE OPERATED IN GASOLINE OR ELECTRIC MODES, OR A COMBINATION OF BOTH DEPENDING ON THE POWER DEMAND.ALL REPORTS ALLEGE THAT THE GASOLINE ENGINE SHUT DOWN SUDDENLY WITHOUT WARNING.SOME OF THE COMPLAINANTS REPORTED THAT THE VEHICLE CONTINUED TO OPERATE USING THE ELECTRIC MODE FOR A PERIOD OF TIME AFTER THE GAS ENGINE STALLED AND SOME REPORTED THAT THE VEHICLE SHUT DOWN AT THE SAME TIME THAT THEY FELT THE GAS ENGINE STALLED.SOME CONSUMERS REPORTED THAT THEY WERE ABLE TO RESTART THE VEHICLE EITHER IMMEDIATELY OR AFTER ALLOWING THE VEHICLE SIT FOR A SHORT TIME, WHEREAS OTHERS REPORTED THAT THEY HAD THEIR VEHICLE TOWED.DURING PE05-029, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.THE COMPLAINT DATA REPRESENTS INCIDENTS WHERE ENGINE STALLING WAS ALLEGED OR WHERE THE VEHICLE WAS ALLEGED TO HAVE ONE OF THE VARIOUS CONDITIONS THAT CAUSES THE GAS ENGINE TO STALL.IN ITS AUGUST 26, 2005 RESPONSE TO ODI'S INFORMATION REQUEST, TOYOTA IDENTIFIED VARIOUS CONDITIONS THAT COULD CAUSE THE SUBJECT VEHICLES TO EXPERIENCE A GAS ENGINE STALL.IF THIS HAPPENS, THE DRIVER IS ALERTED BY AN AUDIBLE SOUND AND VARIOUS WARNING LIGHTS.THE VEHICLE WILL CONTINUE TO OPERATE IN THE ELECTRIC MODE AND THE ELECTRICALLY-POWERED BRAKE AND STEERING OPERATION WILL CONTINUE TO FUNCTION NORMALLY. ANALYSIS OF THE WARRANTY DATA INDICATED THAT OVER 97% OF VEHICLES EXPERIENCING A GAS ENGINE STALL RESULTED FROM AN ISSUE WITH THE PROGRAM LOGIC IN THE ELECTRONIC CONTROL MODULE (ECM) SYSTEM, WHICH MAY CAUSE THE ECM SYSTEM TO NOT START THE GAS ENGINE WHEN REQUIRED.AS A RESULT, THE VEHICLE WILL ENTER THE LIMITED OPERATION MODE DESCRIBED ABOVE.THE MAJORITY OF THE ODI COMPLAINTS ALSO INDICATED THAT THE DRIVER EXPERIENCED THIS CONDITION IN CONJUNCTION WITH THE ENGINE STALL. DURING OCTOBER 2005, TOYOTA INFORMED ODI THAT IT WOULD INITIATE A SPECIAL SERVICE CAMPAIGN (SSC) TO REPROGRAM THE ECM SOFTWARE ON APPROXIMATELY 75,000 MY 2004 AND EARLY 2005 SUBJECT VEHICLES TO ADDRESS THE GAS ENGINE STALLING CONDITION.DURING THIS SSC, DEALERS WILL ALSO APPLY SPECIAL DIELECTRIC GREASE TO A TRANSAXLE CONNECTOR TO PREVENT WATER INTRUSION WHICH MAY ALSO CAUSE SIMILAR LIMITED OPERATION CONDITIONS.BASED ON ODI'S ANALYSIS, THIS REMEDY SHOULD ADDRESS MOST OF THE INCIDENTS RESULTING IN A LIMITED OPERATION MODE.GIVEN THESE CIRCUMSTANCES, FURTHER USE OF THE AGENCY RESOURCES IN THIS MATTER DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.

Additional source detail variants (3)

Engine And Engine Cooling:engine

ODI OPENED PE05-029 BASED ON 33 REPORTS OF ALLEGED GASOLINE ENGINE STALLING ON THE SUBJECT VEHICLES.THE SUBJECT VEHICLES ARE GASOLINE/ ELECTRIC HYBRID VEHICLES THAT CAN BE OPERATED IN GASOLINE OR ELECTRIC MODES, OR A COMBINATION OF BOTH DEPENDING ON THE POWER DEMAND.ALL REPORTS ALLEGE THAT THE GASOLINE ENGINE SHUT DOWN SUDDENLY WITHOUT WARNING.SOME OF THE COMPLAINANTS REPORTED THAT THE VEHICLE CONTINUED TO OPERATE USING THE ELECTRIC MODE FOR A PERIOD OF TIME AFTER THE GAS ENGINE STALLED AND SOME REPORTED THAT THE VEHICLE SHUT DOWN AT THE SAME TIME THAT THEY FELT THE GAS ENGINE STALLED.SOME CONSUMERS REPORTED THAT THEY WERE ABLE TO RESTART THE VEHICLE EITHER IMMEDIATELY OR AFTER ALLOWING THE VEHICLE SIT FOR A SHORT TIME, WHEREAS OTHERS REPORTED THAT THEY HAD THEIR VEHICLE TOWED.DURING PE05-029, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.THE COMPLAINT DATA REPRESENTS INCIDENTS WHERE ENGINE STALLING WAS ALLEGED OR WHERE THE VEHICLE WAS ALLEGED TO HAVE ONE OF THE VARIOUS CONDITIONS THAT CAUSES THE GAS ENGINE TO STALL.IN ITS AUGUST 26, 2005 RESPONSE TO ODI'S INFORMATION REQUEST, TOYOTA IDENTIFIED VARIOUS CONDITIONS THAT COULD CAUSE THE SUBJECT VEHICLES TO EXPERIENCE A GAS ENGINE STALL.IF THIS HAPPENS, THE DRIVER IS ALERTED BY AN AUDIBLE SOUND AND VARIOUS WARNING LIGHTS.THE VEHICLE WILL CONTINUE TO OPERATE IN THE ELECTRIC MODE AND THE ELECTRICALLY-POWERED BRAKE AND STEERING OPERATION WILL CONTINUE TO FUNCTION NORMALLY. ANALYSIS OF THE WARRANTY DATA INDICATED THAT OVER 97% OF VEHICLES EXPERIENCING A GAS ENGINE STALL RESULTED FROM AN ISSUE WITH THE PROGRAM LOGIC IN THE ELECTRONIC CONTROL MODULE (ECM) SYSTEM, WHICH MAY CAUSE THE ECM SYSTEM TO NOT START THE GAS ENGINE WHEN REQUIRED.AS A RESULT, THE VEHICLE WILL ENTER THE LIMITED OPERATION MODE DESCRIBED ABOVE.THE MAJORITY OF THE ODI COMPLAINTS ALSO INDICATED THAT THE DRIVER EXPERIENCED THIS CONDITION IN CONJUNCTION WITH THE ENGINE STALL. DURING OCTOBER 2005, TOYOTA INFORMED ODI THAT IT WOULD INITIATE A SPECIAL SERVICE CAMPAIGN (SSC) TO REPROGRAM THE ECM SOFTWARE ON APPROXIMATELY 75,000 MY 2004 AND EARLY 2005 SUBJECT VEHICLES TO ADDRESS THE GAS ENGINE STALLING CONDITION.DURING THIS SSC, DEALERS WILL ALSO APPLY SPECIAL DIELECTRIC GREASE TO A TRANSAXLE CONNECTOR TO PREVENT WATER INTRUSION WHICH MAY ALSO CAUSE SIMILAR LIMITED OPERATION CONDITIONS.BASED ON ODI'S ANALYSIS, THIS REMEDY SHOULD ADDRESS MOST OF THE INCIDENTS RESULTING IN A LIMITED OPERATION MODE.GIVEN THESE CIRCUMSTANCES, FURTHER USE OF THE AGENCY RESOURCES IN THIS MATTER DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.

Engine And Engine Cooling

ODI OPENED PE05-029 BASED ON 33 REPORTS OF ALLEGED GASOLINE ENGINE STALLING ON THE SUBJECT VEHICLES.THE SUBJECT VEHICLES ARE GASOLINE/ ELECTRIC HYBRID VEHICLES THAT CAN BE OPERATED IN GASOLINE OR ELECTRIC MODES, OR A COMBINATION OF BOTH DEPENDING ON THE POWER DEMAND.ALL REPORTS ALLEGE THAT THE GASOLINE ENGINE SHUT DOWN SUDDENLY WITHOUT WARNING.SOME OF THE COMPLAINANTS REPORTED THAT THE VEHICLE CONTINUED TO OPERATE USING THE ELECTRIC MODE FOR A PERIOD OF TIME AFTER THE GAS ENGINE STALLED AND SOME REPORTED THAT THE VEHICLE SHUT DOWN AT THE SAME TIME THAT THEY FELT THE GAS ENGINE STALLED.SOME CONSUMERS REPORTED THAT THEY WERE ABLE TO RESTART THE VEHICLE EITHER IMMEDIATELY OR AFTER ALLOWING THE VEHICLE SIT FOR A SHORT TIME, WHEREAS OTHERS REPORTED THAT THEY HAD THEIR VEHICLE TOWED.DURING PE05-029, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.THE COMPLAINT DATA REPRESENTS INCIDENTS WHERE ENGINE STALLING WAS ALLEGED OR WHERE THE VEHICLE WAS ALLEGED TO HAVE ONE OF THE VARIOUS CONDITIONS THAT CAUSES THE GAS ENGINE TO STALL.IN ITS AUGUST 26, 2005 RESPONSE TO ODI'S INFORMATION REQUEST, TOYOTA IDENTIFIED VARIOUS CONDITIONS THAT COULD CAUSE THE SUBJECT VEHICLES TO EXPERIENCE A GAS ENGINE STALL.IF THIS HAPPENS, THE DRIVER IS ALERTED BY AN AUDIBLE SOUND AND VARIOUS WARNING LIGHTS.THE VEHICLE WILL CONTINUE TO OPERATE IN THE ELECTRIC MODE AND THE ELECTRICALLY-POWERED BRAKE AND STEERING OPERATION WILL CONTINUE TO FUNCTION NORMALLY. ANALYSIS OF THE WARRANTY DATA INDICATED THAT OVER 97% OF VEHICLES EXPERIENCING A GAS ENGINE STALL RESULTED FROM AN ISSUE WITH THE PROGRAM LOGIC IN THE ELECTRONIC CONTROL MODULE (ECM) SYSTEM, WHICH MAY CAUSE THE ECM SYSTEM TO NOT START THE GAS ENGINE WHEN REQUIRED.AS A RESULT, THE VEHICLE WILL ENTER THE LIMITED OPERATION MODE DESCRIBED ABOVE.THE MAJORITY OF THE ODI COMPLAINTS ALSO INDICATED THAT THE DRIVER EXPERIENCED THIS CONDITION IN CONJUNCTION WITH THE ENGINE STALL. DURING OCTOBER 2005, TOYOTA INFORMED ODI THAT IT WOULD INITIATE A SPECIAL SERVICE CAMPAIGN (SSC) TO REPROGRAM THE ECM SOFTWARE ON APPROXIMATELY 75,000 MY 2004 AND EARLY 2005 SUBJECT VEHICLES TO ADDRESS THE GAS ENGINE STALLING CONDITION.DURING THIS SSC, DEALERS WILL ALSO APPLY SPECIAL DIELECTRIC GREASE TO A TRANSAXLE CONNECTOR TO PREVENT WATER INTRUSION WHICH MAY ALSO CAUSE SIMILAR LIMITED OPERATION CONDITIONS.BASED ON ODI'S ANALYSIS, THIS REMEDY SHOULD ADDRESS MOST OF THE INCIDENTS RESULTING IN A LIMITED OPERATION MODE.GIVEN THESE CIRCUMSTANCES, FURTHER USE OF THE AGENCY RESOURCES IN THIS MATTER DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.

Unknown Or Other

ODI OPENED PE05-029 BASED ON 33 REPORTS OF ALLEGED GASOLINE ENGINE STALLING ON THE SUBJECT VEHICLES.THE SUBJECT VEHICLES ARE GASOLINE/ ELECTRIC HYBRID VEHICLES THAT CAN BE OPERATED IN GASOLINE OR ELECTRIC MODES, OR A COMBINATION OF BOTH DEPENDING ON THE POWER DEMAND.ALL REPORTS ALLEGE THAT THE GASOLINE ENGINE SHUT DOWN SUDDENLY WITHOUT WARNING.SOME OF THE COMPLAINANTS REPORTED THAT THE VEHICLE CONTINUED TO OPERATE USING THE ELECTRIC MODE FOR A PERIOD OF TIME AFTER THE GAS ENGINE STALLED AND SOME REPORTED THAT THE VEHICLE SHUT DOWN AT THE SAME TIME THAT THEY FELT THE GAS ENGINE STALLED.SOME CONSUMERS REPORTED THAT THEY WERE ABLE TO RESTART THE VEHICLE EITHER IMMEDIATELY OR AFTER ALLOWING THE VEHICLE SIT FOR A SHORT TIME, WHEREAS OTHERS REPORTED THAT THEY HAD THEIR VEHICLE TOWED.DURING PE05-029, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.THE COMPLAINT DATA REPRESENTS INCIDENTS WHERE ENGINE STALLING WAS ALLEGED OR WHERE THE VEHICLE WAS ALLEGED TO HAVE ONE OF THE VARIOUS CONDITIONS THAT CAUSES THE GAS ENGINE TO STALL.IN ITS AUGUST 26, 2005 RESPONSE TO ODI'S INFORMATION REQUEST, TOYOTA IDENTIFIED VARIOUS CONDITIONS THAT COULD CAUSE THE SUBJECT VEHICLES TO EXPERIENCE A GAS ENGINE STALL.IF THIS HAPPENS, THE DRIVER IS ALERTED BY AN AUDIBLE SOUND AND VARIOUS WARNING LIGHTS.THE VEHICLE WILL CONTINUE TO OPERATE IN THE ELECTRIC MODE AND THE ELECTRICALLY-POWERED BRAKE AND STEERING OPERATION WILL CONTINUE TO FUNCTION NORMALLY. ANALYSIS OF THE WARRANTY DATA INDICATED THAT OVER 97% OF VEHICLES EXPERIENCING A GAS ENGINE STALL RESULTED FROM AN ISSUE WITH THE PROGRAM LOGIC IN THE ELECTRONIC CONTROL MODULE (ECM) SYSTEM, WHICH MAY CAUSE THE ECM SYSTEM TO NOT START THE GAS ENGINE WHEN REQUIRED.AS A RESULT, THE VEHICLE WILL ENTER THE LIMITED OPERATION MODE DESCRIBED ABOVE.THE MAJORITY OF THE ODI COMPLAINTS ALSO INDICATED THAT THE DRIVER EXPERIENCED THIS CONDITION IN CONJUNCTION WITH THE ENGINE STALL. DURING OCTOBER 2005, TOYOTA INFORMED ODI THAT IT WOULD INITIATE A SPECIAL SERVICE CAMPAIGN (SSC) TO REPROGRAM THE ECM SOFTWARE ON APPROXIMATELY 75,000 MY 2004 AND EARLY 2005 SUBJECT VEHICLES TO ADDRESS THE GAS ENGINE STALLING CONDITION.DURING THIS SSC, DEALERS WILL ALSO APPLY SPECIAL DIELECTRIC GREASE TO A TRANSAXLE CONNECTOR TO PREVENT WATER INTRUSION WHICH MAY ALSO CAUSE SIMILAR LIMITED OPERATION CONDITIONS.BASED ON ODI'S ANALYSIS, THIS REMEDY SHOULD ADDRESS MOST OF THE INCIDENTS RESULTING IN A LIMITED OPERATION MODE.GIVEN THESE CIRCUMSTANCES, FURTHER USE OF THE AGENCY RESOURCES IN THIS MATTER DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.