IllustrationABS BRAKING SYSTEM ON MY 2005 TOYOTA PRIUS WILL LOCK THE DRIVE WHEELS LEAVING YOU STALLED IN THE MIDDLE OF THE ROAD/TURN. THE ACCELERATOR CAN BE ALL THE WAY TO THE FLOOR - ENGINE RACING - I HAVE HAD TO SIT FOR 30-45 SECONDS BEFORE SYSTEM RELEASED THE DRIVE WHEELS. *TR
2005 Toyota Prius
Owner reports · Recalls · Investigations
More warning signs than most Prius years
Owner complaints for the 2005 Toyota Prius are substantially higher than the model-year median of 164.
About this comparison →How this year compares
Owner complaints by model year
Compare all Prius years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1740–25K
10725–50K
13650–75K
12975–100K
185100–150K
140150K+
871 reports with mileage · 180 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Exterior Lighting. Review the 346 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 178 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 128 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
102 crash reports4 fire reports46 injury reports
What owners actually said
1,051 reportsWHILE BRAKING, MY 2005 TOYOTA PRIUS SOMETIMES SURGES FORWARD INSTEAD OF SLOWING. THIS USUALLY OCCURS ON ROUGH OR UNEVEN PAVEMENT. IT HAS HAPPENED BETWEEN 10 AND 20 TIMES SINCE I HAVE OWNED THE CAR. NO ACCIDENTS OR INJURIES HAVE OCCURRED, AND NOTHING HAS BEEN DONE SO FAR TO CORRECT PROBLEM. A MECHANIC FRIEND THINKS THIS SOUNDS LI…
Read full complaint
WHILE BRAKING, MY 2005 TOYOTA PRIUS SOMETIMES SURGES FORWARD INSTEAD OF SLOWING. THIS USUALLY OCCURS ON ROUGH OR UNEVEN PAVEMENT. IT HAS HAPPENED BETWEEN 10 AND 20 TIMES SINCE I HAVE OWNED THE CAR. NO ACCIDENTS OR INJURIES HAVE OCCURRED, AND NOTHING HAS BEEN DONE SO FAR TO CORRECT PROBLEM. A MECHANIC FRIEND THINKS THIS SOUNDS LIKE THE CURRENT RECALL SITUATION WITH THE 2010 PRIUS, AND SUGGESTED I REPORT IT. *TR
2005 TOYOTA PRIUS BRAKE FAILURE OVER BUMPY OR ICY ROADS REPORTED TO NHTSA IN 2005 WITH NO RESPONSE. TOYOTA DENIED FAILURE AND WE WERE TOLD TO SUE. *TR
I HAVE AN UNRESOLVED SAFETY ISSUE WITH MY 2005 TOYOTA PRIUS. THIS HAPPENED TO ME ON THE FIRST DAY THAT I DROVE MY THEN-BRAND NEW CAR. I STILL REMEMBER THIS DANGEROUS EVENT VERY CLEARLY. I CAN EASILY REPLICATE THE PROBLEM FOR YOU. I WAS ABOUT TO BACK MY PRIUS OUT OF ITS DIAGONAL PARKING SPACE ON A BUSY MAIN STREET IN DOWNTOWN …
Read full complaint
I HAVE AN UNRESOLVED SAFETY ISSUE WITH MY 2005 TOYOTA PRIUS. THIS HAPPENED TO ME ON THE FIRST DAY THAT I DROVE MY THEN-BRAND NEW CAR. I STILL REMEMBER THIS DANGEROUS EVENT VERY CLEARLY. I CAN EASILY REPLICATE THE PROBLEM FOR YOU. I WAS ABOUT TO BACK MY PRIUS OUT OF ITS DIAGONAL PARKING SPACE ON A BUSY MAIN STREET IN DOWNTOWN EL CAJON, CA. IT WAS DAYTIME. VEHICLES WERE PARKED ON EITHER SIDE OF ME, WHICH PREVENTED ME FROM SEEING WHETHER OR NOT THERE WAS TRAFFIC APPROACHING. I CAREFULLY BACKED OUT OF THE PARKING SPACE UNTIL I COULD SEE WHETHER OR NOT THERE WAS TRAFFIC APPROACHING. I SAW THAT THERE WAS AND IT WAS APPROACHING QUICKLY, SO WITH THE INTENTION OF STOPPING MY CAR'S BACKWARDS MOVEMENT AND, INSTEAD, GOING FORWARD INTO MY PARKING SPACE, I HIT THE BRAKES AND QUICKLY MOVED THE GEARSHIFT LEVER OVER TO THE LEFT AND FULLY DOWN INTO THE DRIVE GATE TO THE STOP POSITION, BEFORE I RELEASED THE SPRING-LOADED SHIFT LEVER (WHICH SENDS IT BACK TO ITS 'HOME' POSITION). I THEN QUICKLY PRESSED THE GAS PEDAL, INTENDING FOR THE CAR TO MOVE FORWARD SO THAT I COULD DRIVE BACK INTO MY PARKING SPACE. TO MY SHOCK, MY CAR JUMPED FURTHER BACKWARDS INTO THE TRAFFIC LANE, INSTEAD OF FORWARDS INTO MY PARKING SPACE. HAVING GOOD REFLEXES, AND IN SOMEWHAT OF A PANIC NOW, I ONCE AGAIN SHOVED THE GEARSHIFT LEVER FULLY INTO THE DRIVE GATE AND FULLY DOWN UNTIL IT CONTACTED THE STOP, BEFORE LETTING GO OF IT. ONCE AGAIN I PUNCHED THE ACCELERATOR PEDAL AND ONCE AGAIN THE CAR JUMPED -- BACKWARDS! I FULLY APPLIED THE BRAKES AND HOPED THAT THE ONCOMING VEHICLES WOULD NOT HIT ME. FORTUNATELY, THEY DID NOT. THE PROBLEM IS THAT IF THE GEARSHIFT LEVER ON THE 2005 PRIUS IS MOVED TOO QUICKLY, THERE WILL BE NO GEAR CHANGE. THIS COULD BE CORRECTED IF THE GEAR SELECTOR REMAINED IN THE APPROPRIATE GEAR'S GATE, GIVING THE ELECTRONICS TIME TO MAKE THE SHIFT. THIS FLAW COULD CAUSE ACCIDENTS AND BE FALSELY ATTRIBUTED TO DRIVER ERROR. IN THE INTERESTS OF SAFETY, IT SHOULD BE FIXED. *TR
I OWN A 2005 PRIUS AND HAVE 3 UNINTENDED ACCELERATION INCIDENTS IN 5 YEARS, TWO SEPARATE DRIVERS. CITY DRIVING AT 35 MPH. PEDAL DID NOT STICK, IT WAS SUCKED TO THE FLOOR WE TURNED OF ENGINE BEFORE SPEED GOT TO 50MPH. NO ACCIDENT OR INJURY, NOTE THIS: EACH TIME I ASKED THE DEALER REPAIR SHOP ABOUT IT, THEY DISMISSED IT AS FLOOR M…
Read full complaint
I OWN A 2005 PRIUS AND HAVE 3 UNINTENDED ACCELERATION INCIDENTS IN 5 YEARS, TWO SEPARATE DRIVERS. CITY DRIVING AT 35 MPH. PEDAL DID NOT STICK, IT WAS SUCKED TO THE FLOOR WE TURNED OF ENGINE BEFORE SPEED GOT TO 50MPH. NO ACCIDENT OR INJURY, NOTE THIS: EACH TIME I ASKED THE DEALER REPAIR SHOP ABOUT IT, THEY DISMISSED IT AS FLOOR MATS AND "COULD NOT REPRODUCE IT ". INTERESTINGLY, THE REPAIR REQUEST DID NOT SHOW UP ON DEALERS ACTION LIST (2 DIFFERENT DEALERS) EVEN THOUGH EVERY TIME I ASKED ABOUT A SQUEAK OR RATTLE DID SHOW UP ON THE RECORDS.. DID TOYOTA GIVE INSTRUCTIONS TO DEALERS ON HOW TO DOWNPLAY IT AND NOT RECORD THE COMPLAINT? *TR
I WOULD LIKE TO FILE AN OFFICIAL REPORT OF MY ACCIDENT THAT INVOLVED MY 2005 TOYOTA PRIUS ON JANUARY 13 OF THIS YEAR. IT WAS IN THE MORNING AFTER I HAD DROPPED OFF MY CHILDREN TO THEIR SCHOOL. I WAS DRIVING DOWN THE HILL AND DRIVING THE NORMAL 25- 30MPH DOWN THE HILL TO GO HOME. UPON COMING TO THE STOPLIGHT, I NOTICED THE CAR…
Read full complaint
I WOULD LIKE TO FILE AN OFFICIAL REPORT OF MY ACCIDENT THAT INVOLVED MY 2005 TOYOTA PRIUS ON JANUARY 13 OF THIS YEAR. IT WAS IN THE MORNING AFTER I HAD DROPPED OFF MY CHILDREN TO THEIR SCHOOL. I WAS DRIVING DOWN THE HILL AND DRIVING THE NORMAL 25- 30MPH DOWN THE HILL TO GO HOME. UPON COMING TO THE STOPLIGHT, I NOTICED THE CARS IN FRONT OF ME STOPPED AT THE STOPLIGHT SO I WENT TO HIT MY BRAKES AND DID NOT FEEL ANY POWER FROM MY BRAKES SO I QUICKLY STOOD ON MY BRAKES WITH BOTH FEET AND REALIZED I HAD ABSOLUTELY NO BRAKE POWER. I SUBSEQUENTLY CRASHED QUITE HARD INTO THE CAR IN FRONT OF ME AND EXPERIENCED SEVERE PAIN TO THE RIGHT SIDE OF MY NECK. AFTER INITIAL SHOCK, I WAS ABLE TO MANEUVER MY CAR OUT OF TRAFFIC TO A PARKING LOT AND NOTICED IT FUNNY THAT MY BRAKES WERE WORKING AT THAT POINT. AFTER EXCHANGING INFORMATION WITH THE MAN THAT I HIT, MY CAR WAS TOWED TO AN AUTOBODY SHOP. AFTER GOING TO KAISER TO LOOK INTO MY INJURY (WHICH WAS WHIPLASH) I WAS TOLD AT THE AUTOBODY SHOP THAT MY CAR WAS TOTALED AND COULD NOT BE FIXED. HE ALSO TOLD ME THAT MY AIRBAG DID NOT DEPLOY BECAUSE I HAD HIT A LARGER AMERICAN CAR WHICH WAS HIGHER THAN MY BUMPER. IT NEVER HIT THE AIRBAG SENSOR ON MY CAR THAT WAS LOWER THAN THE IMPACT POINT. AFTER THE ACCIDENT, I ASKED MY INSURANCE COMPANY, THE INTERINSURANCE EXCHANGE OF THE AUTOMOBILE , TO PLEASE LOOK INTO THE BRAKE SITUATION AND THEY STATED THAT THEY DID NOT FIND ANYTHING WRONG. I AM NOT SATISFIED WITH THIS ANSWER BECAUSE I HAVE READ THAT THE TOYOTA PROBLEMS ARE NOT EASY TO DIAGNOSE. I HAVE BEEN DRIVING FOR 27 YEARS AND HAVE NEVER BEEN IN AN AUTO CRASH THAT WAS MY FAULT. I ALSO HAVE NEVER EXPERIENCED SUCH A SCARY FEELING AS HAVING ABSOLUTELY NO CONTROL OVER MY CAR. *TR
I SENT AN E-MAIL TO NHTSA ON 2/8/10 DESCRIBING THIS COMPLAINT. MY HUSBAND AND I ARE THE OWNERS OF A 2005 PRIUS WHICH WE BOUGHT NEW. EVER SINCE WE'VE OWNED IT WE HAVE ALWAYS HAD THE FOLLOWING PROBLEM: WHEN WE GO OVER A BUMP, POTHOLE, OR UNEVEN SURFACE WE EXPERIENCE A MOMENTARY LOSS OF BRAKING ABILITY-WE HAVE ALWAYS FELT THIS WAS…
Read full complaint
I SENT AN E-MAIL TO NHTSA ON 2/8/10 DESCRIBING THIS COMPLAINT. MY HUSBAND AND I ARE THE OWNERS OF A 2005 PRIUS WHICH WE BOUGHT NEW. EVER SINCE WE'VE OWNED IT WE HAVE ALWAYS HAD THE FOLLOWING PROBLEM: WHEN WE GO OVER A BUMP, POTHOLE, OR UNEVEN SURFACE WE EXPERIENCE A MOMENTARY LOSS OF BRAKING ABILITY-WE HAVE ALWAYS FELT THIS WAS DUE TO THE NATURE OF THE ANTI-LOCK BRAKES AND NEVER CONSIDERED THAT IT MIGHT BE A DEFECT OR FLAW, UNTIL NOW. THIS SITUATION IS ONLY MOMENTARY, AND BECAUSE IT LASTS ONLY BRIEFLY WE NEVER FELT OUR SAFETY WAS COMPROMISED. THIS SITUATION IS ON-GOING. WE HAVE HAD OUR FLOOR MATS MODIFIED BY TOYOTA LAST MONTH. *TR
2005 TOYOTA PRIUS - SLIPPING BRAKES - MULTIPLE OCCURRENCES OVER THE YEARS, ONE TODAY WHILE APPROACHING A TRAFFIC LIGHT. AS CAR SLOWED, BRAKES SLIPPED DURING TRANSITION FROM REGENERATIVE TO MECHANICAL. CAR'S NOSE PASSED ABOUT 1 FOOT BEYOND WHITE LINE DEMARCATING INTERSECTION. NO CRASH OR DAMAGE TO VEHICLE OR OCCUPANTS - THIS TIME…
Read full complaint
2005 TOYOTA PRIUS - SLIPPING BRAKES - MULTIPLE OCCURRENCES OVER THE YEARS, ONE TODAY WHILE APPROACHING A TRAFFIC LIGHT. AS CAR SLOWED, BRAKES SLIPPED DURING TRANSITION FROM REGENERATIVE TO MECHANICAL. CAR'S NOSE PASSED ABOUT 1 FOOT BEYOND WHITE LINE DEMARCATING INTERSECTION. NO CRASH OR DAMAGE TO VEHICLE OR OCCUPANTS - THIS TIME. WHY IS TOYOTA PRIUS BRAKE RECALL LIMITED TO 2010 YEAR MODEL WHEN THESE EVENTS ARE OCCURRING IN EARLIER YEAR MODELS? I HAVE SUBMITTED TWO REQUESTS TO TOYOTA CUSTOMER SERVICE TO UNDERSTAND THE PROBLEM IN THE LAST TWO WEEKS WITH NO RESPONSE. *TR
I HAVE A TOYOTA PRIUS 2005. PURCHASED IN DECEMBER 2004. EVER SINCE I BOUGHT THIS CAR, I HAVE NOTICED THERE IS A ACCELERATION LAG WHILE MAKING TURN ON RIGHT OR LEFT. I HAVE NOTICED THAT THERE IS NOT CONTINUOUS ACCELERATION AND FEELS LIKE, CAR MAY STOP IN THE MIDDLE OF THE ROAD WHILE MAKING A SUDDEN TURN ON RIGHT OR LEFT. I HAVE…
Read full complaint
I HAVE A TOYOTA PRIUS 2005. PURCHASED IN DECEMBER 2004. EVER SINCE I BOUGHT THIS CAR, I HAVE NOTICED THERE IS A ACCELERATION LAG WHILE MAKING TURN ON RIGHT OR LEFT. I HAVE NOTICED THAT THERE IS NOT CONTINUOUS ACCELERATION AND FEELS LIKE, CAR MAY STOP IN THE MIDDLE OF THE ROAD WHILE MAKING A SUDDEN TURN ON RIGHT OR LEFT. I HAVE BROUGHT THIS PROBLEMS TO DEALERS ATTENTION BUT THEY NEVER TOOK MUCH INTEREST. I STILL HAVE THIS ISSUE WITH THIS VEHICLE. RECENTLY IN JANUARY OF 2010, STEERING TIE ROD CAME OFF WHILE REMOVING A CAR FROM THE SHOPPING MALL. NO BREAK,IT COMPLETELY CAME OFF WITHOUT HAVING ANY DAMAGE TO TIE ROD THREADS. WE WERE FORTUNATE THAT IT DID NOT HAPPEN ON THE FREEWAY, IT WOULD HAVE BEEN A BIG DISASTER. I STILL HAVE A TIE ROD WITH ME. *TR
ABS SERVICE LIGHT AND BRAKE LIGHT CAME ON. WHEN BRAKING VEHICLE BUCKS - DRIVER HESITATED TO DRIVE CAR FEW MILES TO DEALERSHIP. "ABS CODE C1247 STROLESENSOR MALFUNCTION PERFORMED LINEAR INT AND CALIBRATE. IF CONDITION RECURS ABS ECU MAY BE FAULTY" - (9/7/06) "ABS LIGHT COMES ON. CODE #C1247...INTERNAL OPEN CIRCUIT IN SKID CON…
Read full complaint
ABS SERVICE LIGHT AND BRAKE LIGHT CAME ON. WHEN BRAKING VEHICLE BUCKS - DRIVER HESITATED TO DRIVE CAR FEW MILES TO DEALERSHIP. "ABS CODE C1247 STROLESENSOR MALFUNCTION PERFORMED LINEAR INT AND CALIBRATE. IF CONDITION RECURS ABS ECU MAY BE FAULTY" - (9/7/06) "ABS LIGHT COMES ON. CODE #C1247...INTERNAL OPEN CIRCUIT IN SKID CONTROL COMPUTER, REPLACED COMPUTER. - (3/20/07) ABS LIGHT ON. DIAGNOSED BRAKE PEDAL STROKE SENSOR INTERNALLY SHORTED CODE #C1247. REPLACED SENSOR. (4/23/07) . THE PRECEDING WAS TAKEN FROM THE DEALERSHIP SERVICE DEPARTMENT'S NOTES ON THEIR SERVICE SHEETS. AFTER THE THREE TRIPS TO THE DEALER THE PROBLEM APPEARS TO HAVE BEEN SOLVED -- OBVIOUSLY AN ELECTRONIC PART THAT MIGHT HAVE HAD SERIOUS CONSEQUENCES DEPENDING ON THE CIRCUMSTANCES. *TR
Official recalls
612V536000 · Engine And Engine Cooling; Hybrid Propulsion System: Inverter
Nov 14, 2012
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence & remedy
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Additional source detail variants (2)
Hybrid Propulsion System: Inverter
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Engine And Engine Cooling
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
12V537000 · Steering; Steering:gear Box:shaft Sector
Nov 14, 2012
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence & remedy
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Additional source detail variants (2)
Steering:gear Box:shaft Sector
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Steering
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
10V036000 · Equipment:other:labels
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
09V388000 · Vehicle Speed Control:accelerator Pedal
Oct 5, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
06V188000 · Steering:electric Power Assist System
May 31, 2006
THE INTERMEDIATE SHAFT AND SLIDING YOKE IN THE ELECTRIC POWER STEERING SYSTEM CAN CRACK WHEN LARGE FORCES ARE APPLIED AND THE CONNECTION MAY SEPARATE OR THE SLEEVE MAY FRACTURE.
Consequence & remedy
Consequence: THIS COULD RESULT IN A LOSS OF STEERING CONTROL OF THE VEHICLE.
Remedy: TOYOTA WILL REPLACE THE STEERING INTERMEDIATE SHAFT AND INSPECT THE SLIDING YOKE AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON JUNE 9, 2006. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
06V096000 · Air Bags
Apr 3, 2006
ON CERTAIN VEHICLES, DUE TO IMPROPER ASSEMBLY OF THE AIR BAG INFLATOR, WHICH IS USED IN THE SIDE AIR BAG, THE CURTAIN SHIELD AIR BAG, AND THE KNEE AIR BAG ASSEMBLY, SOME INFLATORS WERE PRODUCED WITH AN INSUFFICIENT AMOUNT OF THE HEATING AGENTS NECESSARY FOR PROPER AIR BAG DEPLOYMENT. IN THIS CONDITION, THE EXPANSION FORCE OF THE GAS MAY BE INSUFFICIENT TO PROPERLY INFLATE THE AIR BAG WHEN THE SRS SYSTEM IS ACTIVATED DURING A CRASH.
Consequence & remedy
Consequence: THIS MAY INCREASE THE RISK OF INJURY TO THE OCCUPANT IN THE INVOLVED SEATING POSITION IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SPECIFIC SRS AIR BAG. THE RECALL BEGAN ON APRIL 6, 2006. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371, SCION AT 1-866-548-1851, OR LEXUS AT 1-800-255-3987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP13001 · Intermediate Steering Shaft Separation
Opened Feb 21, 2013 · Closed Apr 8, 2020
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:linkages
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Additional source detail variants (3)
Steering:column
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Steering:linkages
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Steering
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
PE05029 · Engine Stalling
Opened May 31, 2005 · Closed Oct 12, 2005
Status: closed (inferred from source dates) · Engine And Engine Cooling; Engine And Engine Cooling:engine; Unknown Or Other
ODI OPENED PE05-029 BASED ON 33 REPORTS OF ALLEGED GASOLINE ENGINE STALLING ON THE SUBJECT VEHICLES.THE SUBJECT VEHICLES ARE GASOLINE/ ELECTRIC HYBRID VEHICLES THAT CAN BE OPERATED IN GASOLINE OR ELECTRIC MODES, OR A COMBINATION OF BOTH DEPENDING ON THE POWER DEMAND.ALL REPORTS ALLEGE THAT THE GASOLINE ENGINE SHUT DOWN SUDDENLY WITHOUT WARNING.SOME OF THE COMPLAINANTS REPORTED THAT THE VEHICLE CONTINUED TO OPERATE USING THE ELECTRIC MODE FOR A PERIOD OF TIME AFTER THE GAS ENGINE STALLED AND SOME REPORTED THAT THE VEHICLE SHUT DOWN AT THE SAME TIME THAT THEY FELT THE GAS ENGINE STALLED.SOME CONSUMERS REPORTED THAT THEY WERE ABLE TO RESTART THE VEHICLE EITHER IMMEDIATELY OR AFTER ALLOWING THE VEHICLE SIT FOR A SHORT TIME, WHEREAS OTHERS REPORTED THAT THEY HAD THEIR VEHICLE TOWED.DURING PE05-029, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.THE COMPLAINT DATA REPRESENTS INCIDENTS WHERE ENGINE STALLING WAS ALLEGED OR WHERE THE VEHICLE WAS ALLEGED TO HAVE ONE OF THE VARIOUS CONDITIONS THAT CAUSES THE GAS ENGINE TO STALL.IN ITS AUGUST 26, 2005 RESPONSE TO ODI'S INFORMATION REQUEST, TOYOTA IDENTIFIED VARIOUS CONDITIONS THAT COULD CAUSE THE SUBJECT VEHICLES TO EXPERIENCE A GAS ENGINE STALL.IF THIS HAPPENS, THE DRIVER IS ALERTED BY AN AUDIBLE SOUND AND VARIOUS WARNING LIGHTS.THE VEHICLE WILL CONTINUE TO OPERATE IN THE ELECTRIC MODE AND THE ELECTRICALLY-POWERED BRAKE AND STEERING OPERATION WILL CONTINUE TO FUNCTION NORMALLY. ANALYSIS OF THE WARRANTY DATA INDICATED THAT OVER 97% OF VEHICLES EXPERIENCING A GAS ENGINE STALL RESULTED FROM AN ISSUE WITH THE PROGRAM LOGIC IN THE ELECTRONIC CONTROL MODULE (ECM) SYSTEM, WHICH MAY CAUSE THE ECM SYSTEM TO NOT START THE GAS ENGINE WHEN REQUIRED.AS A RESULT, THE VEHICLE WILL ENTER THE LIMITED OPERATION MODE DESCRIBED ABOVE.THE MAJORITY OF THE ODI COMPLAINTS ALSO INDICATED THAT THE DRIVER EXPERIENCED THIS CONDITION IN CONJUNCTION WITH THE ENGINE STALL. DURING OCTOBER 2005, TOYOTA INFORMED ODI THAT IT WOULD INITIATE A SPECIAL SERVICE CAMPAIGN (SSC) TO REPROGRAM THE ECM SOFTWARE ON APPROXIMATELY 75,000 MY 2004 AND EARLY 2005 SUBJECT VEHICLES TO ADDRESS THE GAS ENGINE STALLING CONDITION.DURING THIS SSC, DEALERS WILL ALSO APPLY SPECIAL DIELECTRIC GREASE TO A TRANSAXLE CONNECTOR TO PREVENT WATER INTRUSION WHICH MAY ALSO CAUSE SIMILAR LIMITED OPERATION CONDITIONS.BASED ON ODI'S ANALYSIS, THIS REMEDY SHOULD ADDRESS MOST OF THE INCIDENTS RESULTING IN A LIMITED OPERATION MODE.GIVEN THESE CIRCUMSTANCES, FURTHER USE OF THE AGENCY RESOURCES IN THIS MATTER DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Additional source detail variants (3)
Engine And Engine Cooling:engine
ODI OPENED PE05-029 BASED ON 33 REPORTS OF ALLEGED GASOLINE ENGINE STALLING ON THE SUBJECT VEHICLES.THE SUBJECT VEHICLES ARE GASOLINE/ ELECTRIC HYBRID VEHICLES THAT CAN BE OPERATED IN GASOLINE OR ELECTRIC MODES, OR A COMBINATION OF BOTH DEPENDING ON THE POWER DEMAND.ALL REPORTS ALLEGE THAT THE GASOLINE ENGINE SHUT DOWN SUDDENLY WITHOUT WARNING.SOME OF THE COMPLAINANTS REPORTED THAT THE VEHICLE CONTINUED TO OPERATE USING THE ELECTRIC MODE FOR A PERIOD OF TIME AFTER THE GAS ENGINE STALLED AND SOME REPORTED THAT THE VEHICLE SHUT DOWN AT THE SAME TIME THAT THEY FELT THE GAS ENGINE STALLED.SOME CONSUMERS REPORTED THAT THEY WERE ABLE TO RESTART THE VEHICLE EITHER IMMEDIATELY OR AFTER ALLOWING THE VEHICLE SIT FOR A SHORT TIME, WHEREAS OTHERS REPORTED THAT THEY HAD THEIR VEHICLE TOWED.DURING PE05-029, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.THE COMPLAINT DATA REPRESENTS INCIDENTS WHERE ENGINE STALLING WAS ALLEGED OR WHERE THE VEHICLE WAS ALLEGED TO HAVE ONE OF THE VARIOUS CONDITIONS THAT CAUSES THE GAS ENGINE TO STALL.IN ITS AUGUST 26, 2005 RESPONSE TO ODI'S INFORMATION REQUEST, TOYOTA IDENTIFIED VARIOUS CONDITIONS THAT COULD CAUSE THE SUBJECT VEHICLES TO EXPERIENCE A GAS ENGINE STALL.IF THIS HAPPENS, THE DRIVER IS ALERTED BY AN AUDIBLE SOUND AND VARIOUS WARNING LIGHTS.THE VEHICLE WILL CONTINUE TO OPERATE IN THE ELECTRIC MODE AND THE ELECTRICALLY-POWERED BRAKE AND STEERING OPERATION WILL CONTINUE TO FUNCTION NORMALLY. ANALYSIS OF THE WARRANTY DATA INDICATED THAT OVER 97% OF VEHICLES EXPERIENCING A GAS ENGINE STALL RESULTED FROM AN ISSUE WITH THE PROGRAM LOGIC IN THE ELECTRONIC CONTROL MODULE (ECM) SYSTEM, WHICH MAY CAUSE THE ECM SYSTEM TO NOT START THE GAS ENGINE WHEN REQUIRED.AS A RESULT, THE VEHICLE WILL ENTER THE LIMITED OPERATION MODE DESCRIBED ABOVE.THE MAJORITY OF THE ODI COMPLAINTS ALSO INDICATED THAT THE DRIVER EXPERIENCED THIS CONDITION IN CONJUNCTION WITH THE ENGINE STALL. DURING OCTOBER 2005, TOYOTA INFORMED ODI THAT IT WOULD INITIATE A SPECIAL SERVICE CAMPAIGN (SSC) TO REPROGRAM THE ECM SOFTWARE ON APPROXIMATELY 75,000 MY 2004 AND EARLY 2005 SUBJECT VEHICLES TO ADDRESS THE GAS ENGINE STALLING CONDITION.DURING THIS SSC, DEALERS WILL ALSO APPLY SPECIAL DIELECTRIC GREASE TO A TRANSAXLE CONNECTOR TO PREVENT WATER INTRUSION WHICH MAY ALSO CAUSE SIMILAR LIMITED OPERATION CONDITIONS.BASED ON ODI'S ANALYSIS, THIS REMEDY SHOULD ADDRESS MOST OF THE INCIDENTS RESULTING IN A LIMITED OPERATION MODE.GIVEN THESE CIRCUMSTANCES, FURTHER USE OF THE AGENCY RESOURCES IN THIS MATTER DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Engine And Engine Cooling
ODI OPENED PE05-029 BASED ON 33 REPORTS OF ALLEGED GASOLINE ENGINE STALLING ON THE SUBJECT VEHICLES.THE SUBJECT VEHICLES ARE GASOLINE/ ELECTRIC HYBRID VEHICLES THAT CAN BE OPERATED IN GASOLINE OR ELECTRIC MODES, OR A COMBINATION OF BOTH DEPENDING ON THE POWER DEMAND.ALL REPORTS ALLEGE THAT THE GASOLINE ENGINE SHUT DOWN SUDDENLY WITHOUT WARNING.SOME OF THE COMPLAINANTS REPORTED THAT THE VEHICLE CONTINUED TO OPERATE USING THE ELECTRIC MODE FOR A PERIOD OF TIME AFTER THE GAS ENGINE STALLED AND SOME REPORTED THAT THE VEHICLE SHUT DOWN AT THE SAME TIME THAT THEY FELT THE GAS ENGINE STALLED.SOME CONSUMERS REPORTED THAT THEY WERE ABLE TO RESTART THE VEHICLE EITHER IMMEDIATELY OR AFTER ALLOWING THE VEHICLE SIT FOR A SHORT TIME, WHEREAS OTHERS REPORTED THAT THEY HAD THEIR VEHICLE TOWED.DURING PE05-029, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.THE COMPLAINT DATA REPRESENTS INCIDENTS WHERE ENGINE STALLING WAS ALLEGED OR WHERE THE VEHICLE WAS ALLEGED TO HAVE ONE OF THE VARIOUS CONDITIONS THAT CAUSES THE GAS ENGINE TO STALL.IN ITS AUGUST 26, 2005 RESPONSE TO ODI'S INFORMATION REQUEST, TOYOTA IDENTIFIED VARIOUS CONDITIONS THAT COULD CAUSE THE SUBJECT VEHICLES TO EXPERIENCE A GAS ENGINE STALL.IF THIS HAPPENS, THE DRIVER IS ALERTED BY AN AUDIBLE SOUND AND VARIOUS WARNING LIGHTS.THE VEHICLE WILL CONTINUE TO OPERATE IN THE ELECTRIC MODE AND THE ELECTRICALLY-POWERED BRAKE AND STEERING OPERATION WILL CONTINUE TO FUNCTION NORMALLY. ANALYSIS OF THE WARRANTY DATA INDICATED THAT OVER 97% OF VEHICLES EXPERIENCING A GAS ENGINE STALL RESULTED FROM AN ISSUE WITH THE PROGRAM LOGIC IN THE ELECTRONIC CONTROL MODULE (ECM) SYSTEM, WHICH MAY CAUSE THE ECM SYSTEM TO NOT START THE GAS ENGINE WHEN REQUIRED.AS A RESULT, THE VEHICLE WILL ENTER THE LIMITED OPERATION MODE DESCRIBED ABOVE.THE MAJORITY OF THE ODI COMPLAINTS ALSO INDICATED THAT THE DRIVER EXPERIENCED THIS CONDITION IN CONJUNCTION WITH THE ENGINE STALL. DURING OCTOBER 2005, TOYOTA INFORMED ODI THAT IT WOULD INITIATE A SPECIAL SERVICE CAMPAIGN (SSC) TO REPROGRAM THE ECM SOFTWARE ON APPROXIMATELY 75,000 MY 2004 AND EARLY 2005 SUBJECT VEHICLES TO ADDRESS THE GAS ENGINE STALLING CONDITION.DURING THIS SSC, DEALERS WILL ALSO APPLY SPECIAL DIELECTRIC GREASE TO A TRANSAXLE CONNECTOR TO PREVENT WATER INTRUSION WHICH MAY ALSO CAUSE SIMILAR LIMITED OPERATION CONDITIONS.BASED ON ODI'S ANALYSIS, THIS REMEDY SHOULD ADDRESS MOST OF THE INCIDENTS RESULTING IN A LIMITED OPERATION MODE.GIVEN THESE CIRCUMSTANCES, FURTHER USE OF THE AGENCY RESOURCES IN THIS MATTER DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Unknown Or Other
ODI OPENED PE05-029 BASED ON 33 REPORTS OF ALLEGED GASOLINE ENGINE STALLING ON THE SUBJECT VEHICLES.THE SUBJECT VEHICLES ARE GASOLINE/ ELECTRIC HYBRID VEHICLES THAT CAN BE OPERATED IN GASOLINE OR ELECTRIC MODES, OR A COMBINATION OF BOTH DEPENDING ON THE POWER DEMAND.ALL REPORTS ALLEGE THAT THE GASOLINE ENGINE SHUT DOWN SUDDENLY WITHOUT WARNING.SOME OF THE COMPLAINANTS REPORTED THAT THE VEHICLE CONTINUED TO OPERATE USING THE ELECTRIC MODE FOR A PERIOD OF TIME AFTER THE GAS ENGINE STALLED AND SOME REPORTED THAT THE VEHICLE SHUT DOWN AT THE SAME TIME THAT THEY FELT THE GAS ENGINE STALLED.SOME CONSUMERS REPORTED THAT THEY WERE ABLE TO RESTART THE VEHICLE EITHER IMMEDIATELY OR AFTER ALLOWING THE VEHICLE SIT FOR A SHORT TIME, WHEREAS OTHERS REPORTED THAT THEY HAD THEIR VEHICLE TOWED.DURING PE05-029, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.THE COMPLAINT DATA REPRESENTS INCIDENTS WHERE ENGINE STALLING WAS ALLEGED OR WHERE THE VEHICLE WAS ALLEGED TO HAVE ONE OF THE VARIOUS CONDITIONS THAT CAUSES THE GAS ENGINE TO STALL.IN ITS AUGUST 26, 2005 RESPONSE TO ODI'S INFORMATION REQUEST, TOYOTA IDENTIFIED VARIOUS CONDITIONS THAT COULD CAUSE THE SUBJECT VEHICLES TO EXPERIENCE A GAS ENGINE STALL.IF THIS HAPPENS, THE DRIVER IS ALERTED BY AN AUDIBLE SOUND AND VARIOUS WARNING LIGHTS.THE VEHICLE WILL CONTINUE TO OPERATE IN THE ELECTRIC MODE AND THE ELECTRICALLY-POWERED BRAKE AND STEERING OPERATION WILL CONTINUE TO FUNCTION NORMALLY. ANALYSIS OF THE WARRANTY DATA INDICATED THAT OVER 97% OF VEHICLES EXPERIENCING A GAS ENGINE STALL RESULTED FROM AN ISSUE WITH THE PROGRAM LOGIC IN THE ELECTRONIC CONTROL MODULE (ECM) SYSTEM, WHICH MAY CAUSE THE ECM SYSTEM TO NOT START THE GAS ENGINE WHEN REQUIRED.AS A RESULT, THE VEHICLE WILL ENTER THE LIMITED OPERATION MODE DESCRIBED ABOVE.THE MAJORITY OF THE ODI COMPLAINTS ALSO INDICATED THAT THE DRIVER EXPERIENCED THIS CONDITION IN CONJUNCTION WITH THE ENGINE STALL. DURING OCTOBER 2005, TOYOTA INFORMED ODI THAT IT WOULD INITIATE A SPECIAL SERVICE CAMPAIGN (SSC) TO REPROGRAM THE ECM SOFTWARE ON APPROXIMATELY 75,000 MY 2004 AND EARLY 2005 SUBJECT VEHICLES TO ADDRESS THE GAS ENGINE STALLING CONDITION.DURING THIS SSC, DEALERS WILL ALSO APPLY SPECIAL DIELECTRIC GREASE TO A TRANSAXLE CONNECTOR TO PREVENT WATER INTRUSION WHICH MAY ALSO CAUSE SIMILAR LIMITED OPERATION CONDITIONS.BASED ON ODI'S ANALYSIS, THIS REMEDY SHOULD ADDRESS MOST OF THE INCIDENTS RESULTING IN A LIMITED OPERATION MODE.GIVEN THESE CIRCUMSTANCES, FURTHER USE OF THE AGENCY RESOURCES IN THIS MATTER DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.