← New search

2005 Toyota Prius

Owner reports · Recalls · Investigations

More warning signs than most Prius years

Owner complaints for the 2005 Toyota Prius are substantially higher than the model-year median of 164.

About this comparison →

When problems were reported

Mileage at the reported incident

871 reports with mileage · 180 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Exterior Lighting. Review the 346 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 178 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Service Brakes, Hydraulic. Review the 128 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

102 crash reports4 fire reports46 injury reports

What owners actually said

1,051 reports
137,507 miles · Mar 28, 2016
Exterior Lighting

DRIVER'S SIDE HEADLIGHT WENT OUT IN 2015 AND WAS REPLACED BY LOCAL MECHANIC. BEFORE IT WENT OUT IT HAD FLICKERED BUT CAME BACK ON. I WAS DRIVING AT NIGHT WHEN IT WENT OUT AND WAS PULLED OVER BY POLICE. FORTUNATELY I ONLY GOT A WARNING. MARCH 2016 THE HEADLIGHT WENT OUT AGAIN (I NOTICED IT IN MY DRIVEWAY) AND WAS REPLACED AT …

Read full complaint

DRIVER'S SIDE HEADLIGHT WENT OUT IN 2015 AND WAS REPLACED BY LOCAL MECHANIC. BEFORE IT WENT OUT IT HAD FLICKERED BUT CAME BACK ON. I WAS DRIVING AT NIGHT WHEN IT WENT OUT AND WAS PULLED OVER BY POLICE. FORTUNATELY I ONLY GOT A WARNING. MARCH 2016 THE HEADLIGHT WENT OUT AGAIN (I NOTICED IT IN MY DRIVEWAY) AND WAS REPLACED AT A TOYOTA DEALERSHIP ON 21 MARCH 2016. THAT VERY DAY, THE HEADLIGHT WENT OUT AGAIN (NOTICED IT IN MY DRIVEWAY). IT WOULD COME ON PERIODICALLY BUT KEPT GOING OUT. 25 MARCH 2016 THE TOYOTA DEALERSHIP REPLACED THE "COMPUTER SUB-ASSY, H" FOR $458.52. 28 MARCH 2016, THE HEADLIGHT IS OUT AGAIN (NOTICED IT AGAIN IN MY DRIVEWAY).

NHTSA ODI #10851885

Mileage unknown · Mar 25, 2016
Exterior Lighting

THE HEADLIGHTS (HID) STOP FUNCTIONING INTERMITTENTLY. ONE OR THE OTHER OR BOTH WILL RANDOMLY SHUT OFF. THE LIGHTS WILL COME BACK ON IF THEY ARE TURNED OFF THEN ON AGAIN. THE ISSUE HAS BEEN HAPPENING FOR SEVERAL MONTHS.

NHTSA ODI #10851551

230,000 miles · Mar 20, 2016
Exterior Lighting

WHILE DRIVING THE PASSENGER SIDE HEADLIGHT WENT OUT, I REPLACED THE BULB AND THE PROBLEM CONTINUED. IT TURNS OFF SHORTLY AFTER STARTING THE VEHICLE WETHER IT IS DRIVING OR SITTING, WHEN I TURN LIGHTS OFF AND ON AGAIN LIGHT WILL TURN BACK ON FOR A MOMENT AND TURN OFF AGAIN, THIS HAPPENS WHILE I AM DRIVING AND I AM AFRAID TO DRIV…

Read full complaint

WHILE DRIVING THE PASSENGER SIDE HEADLIGHT WENT OUT, I REPLACED THE BULB AND THE PROBLEM CONTINUED. IT TURNS OFF SHORTLY AFTER STARTING THE VEHICLE WETHER IT IS DRIVING OR SITTING, WHEN I TURN LIGHTS OFF AND ON AGAIN LIGHT WILL TURN BACK ON FOR A MOMENT AND TURN OFF AGAIN, THIS HAPPENS WHILE I AM DRIVING AND I AM AFRAID TO DRIVE IT AND BE PULLED OVER FOR NOT HAVING WORKING HEADLIGHTS.

NHTSA ODI #10850620

61,000 miles · Feb 27, 2016
Steering

TAKATA RECALL, DASH (SOUNDS LIKE SOMETHING IS LOSSE) WHEN DRIVING OVER BUMP OR AT HIGHER SPEEDS. THEN I TOKE IT TO THE DEALER THEY SAID THAT'S STEERING COLUMN PROBLEM.

NHTSA ODI #10838803

155,000 miles · Feb 20, 2016
Electrical System

DASH GOES COMPLETELY BLANK WHILE IN MOTION AND CAR WILL NOT TURN OFF

NHTSA ODI #10837300

135,000 miles · Jan 19, 2016
Exterior Lighting

I WAS DRIVING AT NIGHT ON THE FREEWAY 280 AND SUDDENLY BOTH HEADLIGHTS WENT OUT, IT WAS SO BLACK YOU COULDN'T SEE ANYTHING ON THE ROAD. TALK ABOUT SCARY, TRY DRIVING AT 65 MPH ON A ROAD THAT CURVES WHEN YOU ALL YO CAN SEE IS BLACK. I WAS ABLE TO JIGGLE THE SWITCH THE HEADLIGHT SWITCH OFF AND ON SEVERAL TIMES AND THE LIGHTS FINAL…

Read full complaint

I WAS DRIVING AT NIGHT ON THE FREEWAY 280 AND SUDDENLY BOTH HEADLIGHTS WENT OUT, IT WAS SO BLACK YOU COULDN'T SEE ANYTHING ON THE ROAD. TALK ABOUT SCARY, TRY DRIVING AT 65 MPH ON A ROAD THAT CURVES WHEN YOU ALL YO CAN SEE IS BLACK. I WAS ABLE TO JIGGLE THE SWITCH THE HEADLIGHT SWITCH OFF AND ON SEVERAL TIMES AND THE LIGHTS FINALLY CAME BACK ON. WITH MY HEART POUNDING I CONTINUED TO DRIVE HOME ONLY TO HAVE BOTH HEADLIGHTS AGAIN GO OUT TOGETHER. THIS HAPPENED 6-7MORE TIMES UNTIL I REACHED HOME. I WAS ACTUALLY SHAKING BY THE TIME I GOT OUT OF MY CAR. WHY WERE BOTH HEADLIGHTS MALFUNCTIONING AT THE EXACT SAME TIMES? I TOOK THE CAR TO THE DEALERS THE NEXT DAY AND AFTER INSPECTION THEY TOLD ME I SIMPLY NEEDED NEW HEADLIGHTS. I THOUGHT IT WAS AN ELECTRICAL MALFUNCTION, BUT THEY INSISTED THAT IT WAS JUST THE HEADLIGHTS GOING OUT AND THAT THIS HAPPENED ALL THE TIME. WHY WOULD THEY BE USING HEADLIGHTS THAT THEY KNOW BOTH GO OUT AT THE SAME TIME??THIS IS HIGHLY DANGEROUS. PEOPLE COULD HAVE A HEART ATTACK IF NOT AN ACCIDENT! I SPENT $500 TO REPLACE THE TWO HEADLIGHTS. HOWEVER, I JUST RECENTLY EXPERIENCE THE EXACT SAME PROBLEM OF BOTH HEAD LIGHTS GOING OUT. MY CAR IS AT THE DEALERS THIS VERY MOMENT FOR THE SAME PROBLEM. I HOPE MY 2005 PRIUS GETS RECALLED FOR THIS HEADLIGHT PROBLEM SO OTHER PEOPLE TO NOT HAVE TO EXPERIENCE THIS TRAMA AND DANGEROUS SITUATION. I WAS SURPRISED TO LEARN THAT THIS HEADLIGHT PROBLEM IS COMMON TO THE PRIUS. OUTSIDE OF THIS DANGEROUS HEADLIGHT PROBLEM I LOVE MY PRIUS.

NHTSA ODI #10821024

211,000 miles · Jan 13, 2016
Electrical SystemExterior LightingService Brakes

DIGITAL DASHBOARD SOMETIMES IS COMPLETELY BLANK FOR EXTENDED PERIODS SO THAT I CAN'T SEE MY SPEED, FUEL LEVELS, ODOMETER, AND OTHER INFO. WHEN I START UP IT HAPPENS AND CONTINUES THE WHOLE TIME I AM DRIVING. IT IS CAUSING OTHER PROBLEMS RELATED TO THE HYDROLIC BRAKING SOMETIMES AS WELL WHEN THIS HAPPENS.

NHTSA ODI #10820021

83,706 miles · Jan 12, 2016
Service Brakes

THE VEHICLE BRAKES FAILED TO APPLY COMPLETELY DURING MORNING START UP AND BACK UP FROM PARKING SPACE. THE DASH WARNING LIGHTS ON INCLUDED BRAKE, TRIANGLE WITH EXCLAMATION, AND ABS. DURING DRIVE TO DEALER, PEDAL WENT TO THE FLOOR. TOYOTA DEALER FOUND BRAKE ACTUATOR ASSEMBLY FAILURE. PAID FOR REPAIR AND CONTACTED TOYOTA WITH CO…

Read full complaint

THE VEHICLE BRAKES FAILED TO APPLY COMPLETELY DURING MORNING START UP AND BACK UP FROM PARKING SPACE. THE DASH WARNING LIGHTS ON INCLUDED BRAKE, TRIANGLE WITH EXCLAMATION, AND ABS. DURING DRIVE TO DEALER, PEDAL WENT TO THE FLOOR. TOYOTA DEALER FOUND BRAKE ACTUATOR ASSEMBLY FAILURE. PAID FOR REPAIR AND CONTACTED TOYOTA WITH CONCERN. FOUND INTERNET INFORMATION ON SIMILAR FAILURE WITH LATER 2010 MODEL.

NHTSA ODI #10819749

Mileage unknown · Jan 11, 2016
Service Brakes

TL* THE CONTACT OWNS A 2005 TOYOTA PRIUS. WHILE DRIVING IN RAINY CONDITIONS, THE REAR BRAKES ENGAGED WITH A GRABBING FORCE. THE FAILURE WAS EXPERIENCED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE REAR BRAKE DRUMS WERE CLEANED; HOWEVER, THE FAILURE WAS NOT CORRECTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILUR…

Read full complaint

TL* THE CONTACT OWNS A 2005 TOYOTA PRIUS. WHILE DRIVING IN RAINY CONDITIONS, THE REAR BRAKES ENGAGED WITH A GRABBING FORCE. THE FAILURE WAS EXPERIENCED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE REAR BRAKE DRUMS WERE CLEANED; HOWEVER, THE FAILURE WAS NOT CORRECTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.

NHTSA ODI #10819430

186,000 miles · Dec 27, 2015
Service Brakes

EVEN MINOR TREPIDATION CAUSED BY ANY UNEVENNESS IN THE SURFACE OF THE ROAD WHILE SLOWING DOWN AND APPLYING THE BRAKES WILL DISENGAGE THE BRAKES MOMENTARILY CAUSING A DANGEROUS SITUATION AND RISK OF CRASH INTO VEHICLE IN FRONT. I OBSERVED THIS PROBLEM CONSISTENTLY IN SEVERAL PRIUS RANGING FROM 2005 TO 2010 SINCE I PURCHASED MINE…

Read full complaint

EVEN MINOR TREPIDATION CAUSED BY ANY UNEVENNESS IN THE SURFACE OF THE ROAD WHILE SLOWING DOWN AND APPLYING THE BRAKES WILL DISENGAGE THE BRAKES MOMENTARILY CAUSING A DANGEROUS SITUATION AND RISK OF CRASH INTO VEHICLE IN FRONT. I OBSERVED THIS PROBLEM CONSISTENTLY IN SEVERAL PRIUS RANGING FROM 2005 TO 2010 SINCE I PURCHASED MINE IN APRIL 2012. I HAVE COMPLAINED ABOUT THIS TO A COUPLE OF DEALERSHIPS BUT WAS TOLD "IT IS A DRIVER'S FAULT" ...!! ALL MY FRIENDS OWNERS OF PRIUS HAVE OBSERVED THE SAME PROBLEM IN THEIR CARS.

NHTSA ODI #10816310

Official recalls

6

12V536000 · Engine And Engine Cooling; Hybrid Propulsion System: Inverter

Nov 14, 2012

Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.

Consequence & remedy

Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.

Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.

Additional source detail variants (2)

Hybrid Propulsion System: Inverter

Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.

Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.

Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.

Engine And Engine Cooling

Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.

Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.

Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.

12V537000 · Steering; Steering:gear Box:shaft Sector

Nov 14, 2012

Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.

Consequence & remedy

Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.

Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.

Additional source detail variants (2)

Steering:gear Box:shaft Sector

Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.

Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.

Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.

Steering

Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.

Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.

Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.

10V036000 · Equipment:other:labels

Feb 3, 2010

SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Consequence & remedy

Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.

Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.

09V388000 · Vehicle Speed Control:accelerator Pedal

Oct 5, 2009

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.

Consequence & remedy

Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.

Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.

06V188000 · Steering:electric Power Assist System

May 31, 2006

THE INTERMEDIATE SHAFT AND SLIDING YOKE IN THE ELECTRIC POWER STEERING SYSTEM CAN CRACK WHEN LARGE FORCES ARE APPLIED AND THE CONNECTION MAY SEPARATE OR THE SLEEVE MAY FRACTURE.

Consequence & remedy

Consequence: THIS COULD RESULT IN A LOSS OF STEERING CONTROL OF THE VEHICLE.

Remedy: TOYOTA WILL REPLACE THE STEERING INTERMEDIATE SHAFT AND INSPECT THE SLIDING YOKE AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON JUNE 9, 2006. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

06V096000 · Air Bags

Apr 3, 2006

ON CERTAIN VEHICLES, DUE TO IMPROPER ASSEMBLY OF THE AIR BAG INFLATOR, WHICH IS USED IN THE SIDE AIR BAG, THE CURTAIN SHIELD AIR BAG, AND THE KNEE AIR BAG ASSEMBLY, SOME INFLATORS WERE PRODUCED WITH AN INSUFFICIENT AMOUNT OF THE HEATING AGENTS NECESSARY FOR PROPER AIR BAG DEPLOYMENT. IN THIS CONDITION, THE EXPANSION FORCE OF THE GAS MAY BE INSUFFICIENT TO PROPERLY INFLATE THE AIR BAG WHEN THE SRS SYSTEM IS ACTIVATED DURING A CRASH.

Consequence & remedy

Consequence: THIS MAY INCREASE THE RISK OF INJURY TO THE OCCUPANT IN THE INVOLVED SEATING POSITION IN THE EVENT OF A CRASH.

Remedy: DEALERS WILL REPLACE THE SPECIFIC SRS AIR BAG. THE RECALL BEGAN ON APRIL 6, 2006. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371, SCION AT 1-866-548-1851, OR LEXUS AT 1-800-255-3987.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

3

DP22005 · Pedestrian Alert Sounds

Opened Jan 27, 2023 · Closed Aug 7, 2023

Status: closed (inferred from source dates) · Electrical System:propulsion System

NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.

DP13001 · Intermediate Steering Shaft Separation

Opened Feb 21, 2013 · Closed Apr 8, 2020

Status: closed (inferred from source dates) · Steering; Steering:column; Steering:linkages

The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606

Additional source detail variants (3)

Steering:column

The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606

Steering:linkages

The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606

Steering

The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606

PE05029 · Engine Stalling

Opened May 31, 2005 · Closed Oct 12, 2005

Status: closed (inferred from source dates) · Engine And Engine Cooling; Engine And Engine Cooling:engine; Unknown Or Other

ODI OPENED PE05-029 BASED ON 33 REPORTS OF ALLEGED GASOLINE ENGINE STALLING ON THE SUBJECT VEHICLES.THE SUBJECT VEHICLES ARE GASOLINE/ ELECTRIC HYBRID VEHICLES THAT CAN BE OPERATED IN GASOLINE OR ELECTRIC MODES, OR A COMBINATION OF BOTH DEPENDING ON THE POWER DEMAND.ALL REPORTS ALLEGE THAT THE GASOLINE ENGINE SHUT DOWN SUDDENLY WITHOUT WARNING.SOME OF THE COMPLAINANTS REPORTED THAT THE VEHICLE CONTINUED TO OPERATE USING THE ELECTRIC MODE FOR A PERIOD OF TIME AFTER THE GAS ENGINE STALLED AND SOME REPORTED THAT THE VEHICLE SHUT DOWN AT THE SAME TIME THAT THEY FELT THE GAS ENGINE STALLED.SOME CONSUMERS REPORTED THAT THEY WERE ABLE TO RESTART THE VEHICLE EITHER IMMEDIATELY OR AFTER ALLOWING THE VEHICLE SIT FOR A SHORT TIME, WHEREAS OTHERS REPORTED THAT THEY HAD THEIR VEHICLE TOWED.DURING PE05-029, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.THE COMPLAINT DATA REPRESENTS INCIDENTS WHERE ENGINE STALLING WAS ALLEGED OR WHERE THE VEHICLE WAS ALLEGED TO HAVE ONE OF THE VARIOUS CONDITIONS THAT CAUSES THE GAS ENGINE TO STALL.IN ITS AUGUST 26, 2005 RESPONSE TO ODI'S INFORMATION REQUEST, TOYOTA IDENTIFIED VARIOUS CONDITIONS THAT COULD CAUSE THE SUBJECT VEHICLES TO EXPERIENCE A GAS ENGINE STALL.IF THIS HAPPENS, THE DRIVER IS ALERTED BY AN AUDIBLE SOUND AND VARIOUS WARNING LIGHTS.THE VEHICLE WILL CONTINUE TO OPERATE IN THE ELECTRIC MODE AND THE ELECTRICALLY-POWERED BRAKE AND STEERING OPERATION WILL CONTINUE TO FUNCTION NORMALLY. ANALYSIS OF THE WARRANTY DATA INDICATED THAT OVER 97% OF VEHICLES EXPERIENCING A GAS ENGINE STALL RESULTED FROM AN ISSUE WITH THE PROGRAM LOGIC IN THE ELECTRONIC CONTROL MODULE (ECM) SYSTEM, WHICH MAY CAUSE THE ECM SYSTEM TO NOT START THE GAS ENGINE WHEN REQUIRED.AS A RESULT, THE VEHICLE WILL ENTER THE LIMITED OPERATION MODE DESCRIBED ABOVE.THE MAJORITY OF THE ODI COMPLAINTS ALSO INDICATED THAT THE DRIVER EXPERIENCED THIS CONDITION IN CONJUNCTION WITH THE ENGINE STALL. DURING OCTOBER 2005, TOYOTA INFORMED ODI THAT IT WOULD INITIATE A SPECIAL SERVICE CAMPAIGN (SSC) TO REPROGRAM THE ECM SOFTWARE ON APPROXIMATELY 75,000 MY 2004 AND EARLY 2005 SUBJECT VEHICLES TO ADDRESS THE GAS ENGINE STALLING CONDITION.DURING THIS SSC, DEALERS WILL ALSO APPLY SPECIAL DIELECTRIC GREASE TO A TRANSAXLE CONNECTOR TO PREVENT WATER INTRUSION WHICH MAY ALSO CAUSE SIMILAR LIMITED OPERATION CONDITIONS.BASED ON ODI'S ANALYSIS, THIS REMEDY SHOULD ADDRESS MOST OF THE INCIDENTS RESULTING IN A LIMITED OPERATION MODE.GIVEN THESE CIRCUMSTANCES, FURTHER USE OF THE AGENCY RESOURCES IN THIS MATTER DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.

Additional source detail variants (3)

Engine And Engine Cooling:engine

ODI OPENED PE05-029 BASED ON 33 REPORTS OF ALLEGED GASOLINE ENGINE STALLING ON THE SUBJECT VEHICLES.THE SUBJECT VEHICLES ARE GASOLINE/ ELECTRIC HYBRID VEHICLES THAT CAN BE OPERATED IN GASOLINE OR ELECTRIC MODES, OR A COMBINATION OF BOTH DEPENDING ON THE POWER DEMAND.ALL REPORTS ALLEGE THAT THE GASOLINE ENGINE SHUT DOWN SUDDENLY WITHOUT WARNING.SOME OF THE COMPLAINANTS REPORTED THAT THE VEHICLE CONTINUED TO OPERATE USING THE ELECTRIC MODE FOR A PERIOD OF TIME AFTER THE GAS ENGINE STALLED AND SOME REPORTED THAT THE VEHICLE SHUT DOWN AT THE SAME TIME THAT THEY FELT THE GAS ENGINE STALLED.SOME CONSUMERS REPORTED THAT THEY WERE ABLE TO RESTART THE VEHICLE EITHER IMMEDIATELY OR AFTER ALLOWING THE VEHICLE SIT FOR A SHORT TIME, WHEREAS OTHERS REPORTED THAT THEY HAD THEIR VEHICLE TOWED.DURING PE05-029, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.THE COMPLAINT DATA REPRESENTS INCIDENTS WHERE ENGINE STALLING WAS ALLEGED OR WHERE THE VEHICLE WAS ALLEGED TO HAVE ONE OF THE VARIOUS CONDITIONS THAT CAUSES THE GAS ENGINE TO STALL.IN ITS AUGUST 26, 2005 RESPONSE TO ODI'S INFORMATION REQUEST, TOYOTA IDENTIFIED VARIOUS CONDITIONS THAT COULD CAUSE THE SUBJECT VEHICLES TO EXPERIENCE A GAS ENGINE STALL.IF THIS HAPPENS, THE DRIVER IS ALERTED BY AN AUDIBLE SOUND AND VARIOUS WARNING LIGHTS.THE VEHICLE WILL CONTINUE TO OPERATE IN THE ELECTRIC MODE AND THE ELECTRICALLY-POWERED BRAKE AND STEERING OPERATION WILL CONTINUE TO FUNCTION NORMALLY. ANALYSIS OF THE WARRANTY DATA INDICATED THAT OVER 97% OF VEHICLES EXPERIENCING A GAS ENGINE STALL RESULTED FROM AN ISSUE WITH THE PROGRAM LOGIC IN THE ELECTRONIC CONTROL MODULE (ECM) SYSTEM, WHICH MAY CAUSE THE ECM SYSTEM TO NOT START THE GAS ENGINE WHEN REQUIRED.AS A RESULT, THE VEHICLE WILL ENTER THE LIMITED OPERATION MODE DESCRIBED ABOVE.THE MAJORITY OF THE ODI COMPLAINTS ALSO INDICATED THAT THE DRIVER EXPERIENCED THIS CONDITION IN CONJUNCTION WITH THE ENGINE STALL. DURING OCTOBER 2005, TOYOTA INFORMED ODI THAT IT WOULD INITIATE A SPECIAL SERVICE CAMPAIGN (SSC) TO REPROGRAM THE ECM SOFTWARE ON APPROXIMATELY 75,000 MY 2004 AND EARLY 2005 SUBJECT VEHICLES TO ADDRESS THE GAS ENGINE STALLING CONDITION.DURING THIS SSC, DEALERS WILL ALSO APPLY SPECIAL DIELECTRIC GREASE TO A TRANSAXLE CONNECTOR TO PREVENT WATER INTRUSION WHICH MAY ALSO CAUSE SIMILAR LIMITED OPERATION CONDITIONS.BASED ON ODI'S ANALYSIS, THIS REMEDY SHOULD ADDRESS MOST OF THE INCIDENTS RESULTING IN A LIMITED OPERATION MODE.GIVEN THESE CIRCUMSTANCES, FURTHER USE OF THE AGENCY RESOURCES IN THIS MATTER DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.

Engine And Engine Cooling

ODI OPENED PE05-029 BASED ON 33 REPORTS OF ALLEGED GASOLINE ENGINE STALLING ON THE SUBJECT VEHICLES.THE SUBJECT VEHICLES ARE GASOLINE/ ELECTRIC HYBRID VEHICLES THAT CAN BE OPERATED IN GASOLINE OR ELECTRIC MODES, OR A COMBINATION OF BOTH DEPENDING ON THE POWER DEMAND.ALL REPORTS ALLEGE THAT THE GASOLINE ENGINE SHUT DOWN SUDDENLY WITHOUT WARNING.SOME OF THE COMPLAINANTS REPORTED THAT THE VEHICLE CONTINUED TO OPERATE USING THE ELECTRIC MODE FOR A PERIOD OF TIME AFTER THE GAS ENGINE STALLED AND SOME REPORTED THAT THE VEHICLE SHUT DOWN AT THE SAME TIME THAT THEY FELT THE GAS ENGINE STALLED.SOME CONSUMERS REPORTED THAT THEY WERE ABLE TO RESTART THE VEHICLE EITHER IMMEDIATELY OR AFTER ALLOWING THE VEHICLE SIT FOR A SHORT TIME, WHEREAS OTHERS REPORTED THAT THEY HAD THEIR VEHICLE TOWED.DURING PE05-029, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.THE COMPLAINT DATA REPRESENTS INCIDENTS WHERE ENGINE STALLING WAS ALLEGED OR WHERE THE VEHICLE WAS ALLEGED TO HAVE ONE OF THE VARIOUS CONDITIONS THAT CAUSES THE GAS ENGINE TO STALL.IN ITS AUGUST 26, 2005 RESPONSE TO ODI'S INFORMATION REQUEST, TOYOTA IDENTIFIED VARIOUS CONDITIONS THAT COULD CAUSE THE SUBJECT VEHICLES TO EXPERIENCE A GAS ENGINE STALL.IF THIS HAPPENS, THE DRIVER IS ALERTED BY AN AUDIBLE SOUND AND VARIOUS WARNING LIGHTS.THE VEHICLE WILL CONTINUE TO OPERATE IN THE ELECTRIC MODE AND THE ELECTRICALLY-POWERED BRAKE AND STEERING OPERATION WILL CONTINUE TO FUNCTION NORMALLY. ANALYSIS OF THE WARRANTY DATA INDICATED THAT OVER 97% OF VEHICLES EXPERIENCING A GAS ENGINE STALL RESULTED FROM AN ISSUE WITH THE PROGRAM LOGIC IN THE ELECTRONIC CONTROL MODULE (ECM) SYSTEM, WHICH MAY CAUSE THE ECM SYSTEM TO NOT START THE GAS ENGINE WHEN REQUIRED.AS A RESULT, THE VEHICLE WILL ENTER THE LIMITED OPERATION MODE DESCRIBED ABOVE.THE MAJORITY OF THE ODI COMPLAINTS ALSO INDICATED THAT THE DRIVER EXPERIENCED THIS CONDITION IN CONJUNCTION WITH THE ENGINE STALL. DURING OCTOBER 2005, TOYOTA INFORMED ODI THAT IT WOULD INITIATE A SPECIAL SERVICE CAMPAIGN (SSC) TO REPROGRAM THE ECM SOFTWARE ON APPROXIMATELY 75,000 MY 2004 AND EARLY 2005 SUBJECT VEHICLES TO ADDRESS THE GAS ENGINE STALLING CONDITION.DURING THIS SSC, DEALERS WILL ALSO APPLY SPECIAL DIELECTRIC GREASE TO A TRANSAXLE CONNECTOR TO PREVENT WATER INTRUSION WHICH MAY ALSO CAUSE SIMILAR LIMITED OPERATION CONDITIONS.BASED ON ODI'S ANALYSIS, THIS REMEDY SHOULD ADDRESS MOST OF THE INCIDENTS RESULTING IN A LIMITED OPERATION MODE.GIVEN THESE CIRCUMSTANCES, FURTHER USE OF THE AGENCY RESOURCES IN THIS MATTER DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.

Unknown Or Other

ODI OPENED PE05-029 BASED ON 33 REPORTS OF ALLEGED GASOLINE ENGINE STALLING ON THE SUBJECT VEHICLES.THE SUBJECT VEHICLES ARE GASOLINE/ ELECTRIC HYBRID VEHICLES THAT CAN BE OPERATED IN GASOLINE OR ELECTRIC MODES, OR A COMBINATION OF BOTH DEPENDING ON THE POWER DEMAND.ALL REPORTS ALLEGE THAT THE GASOLINE ENGINE SHUT DOWN SUDDENLY WITHOUT WARNING.SOME OF THE COMPLAINANTS REPORTED THAT THE VEHICLE CONTINUED TO OPERATE USING THE ELECTRIC MODE FOR A PERIOD OF TIME AFTER THE GAS ENGINE STALLED AND SOME REPORTED THAT THE VEHICLE SHUT DOWN AT THE SAME TIME THAT THEY FELT THE GAS ENGINE STALLED.SOME CONSUMERS REPORTED THAT THEY WERE ABLE TO RESTART THE VEHICLE EITHER IMMEDIATELY OR AFTER ALLOWING THE VEHICLE SIT FOR A SHORT TIME, WHEREAS OTHERS REPORTED THAT THEY HAD THEIR VEHICLE TOWED.DURING PE05-029, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.THE COMPLAINT DATA REPRESENTS INCIDENTS WHERE ENGINE STALLING WAS ALLEGED OR WHERE THE VEHICLE WAS ALLEGED TO HAVE ONE OF THE VARIOUS CONDITIONS THAT CAUSES THE GAS ENGINE TO STALL.IN ITS AUGUST 26, 2005 RESPONSE TO ODI'S INFORMATION REQUEST, TOYOTA IDENTIFIED VARIOUS CONDITIONS THAT COULD CAUSE THE SUBJECT VEHICLES TO EXPERIENCE A GAS ENGINE STALL.IF THIS HAPPENS, THE DRIVER IS ALERTED BY AN AUDIBLE SOUND AND VARIOUS WARNING LIGHTS.THE VEHICLE WILL CONTINUE TO OPERATE IN THE ELECTRIC MODE AND THE ELECTRICALLY-POWERED BRAKE AND STEERING OPERATION WILL CONTINUE TO FUNCTION NORMALLY. ANALYSIS OF THE WARRANTY DATA INDICATED THAT OVER 97% OF VEHICLES EXPERIENCING A GAS ENGINE STALL RESULTED FROM AN ISSUE WITH THE PROGRAM LOGIC IN THE ELECTRONIC CONTROL MODULE (ECM) SYSTEM, WHICH MAY CAUSE THE ECM SYSTEM TO NOT START THE GAS ENGINE WHEN REQUIRED.AS A RESULT, THE VEHICLE WILL ENTER THE LIMITED OPERATION MODE DESCRIBED ABOVE.THE MAJORITY OF THE ODI COMPLAINTS ALSO INDICATED THAT THE DRIVER EXPERIENCED THIS CONDITION IN CONJUNCTION WITH THE ENGINE STALL. DURING OCTOBER 2005, TOYOTA INFORMED ODI THAT IT WOULD INITIATE A SPECIAL SERVICE CAMPAIGN (SSC) TO REPROGRAM THE ECM SOFTWARE ON APPROXIMATELY 75,000 MY 2004 AND EARLY 2005 SUBJECT VEHICLES TO ADDRESS THE GAS ENGINE STALLING CONDITION.DURING THIS SSC, DEALERS WILL ALSO APPLY SPECIAL DIELECTRIC GREASE TO A TRANSAXLE CONNECTOR TO PREVENT WATER INTRUSION WHICH MAY ALSO CAUSE SIMILAR LIMITED OPERATION CONDITIONS.BASED ON ODI'S ANALYSIS, THIS REMEDY SHOULD ADDRESS MOST OF THE INCIDENTS RESULTING IN A LIMITED OPERATION MODE.GIVEN THESE CIRCUMSTANCES, FURTHER USE OF THE AGENCY RESOURCES IN THIS MATTER DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.