Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
670–25K
3325–50K
3350–75K
1275–100K
11100–150K
3150K+
159 reports with mileage · 47 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Steering. Review the 46 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 31 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Vehicle Speed Control. Review the 31 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
26 crash reports0 fire reports12 injury reports
What owners actually said
206 reports
50,000 miles · Apr 26, 2018
EnginePower Train
I AM ASKING THAT THE NHTSA INVESTIGATE THE 2013 HIGHLANDER LIMITED FOR THE ABILITY TO TURN OFF THE CAR WHILE IN "DRIVE" AFTER PARKING. WE PURCHASED OUR CAR NEW FORM THE DEALER, AND EVER SINCE WE HAVE BEEN ABLE TO TURN THE CAR OFF THE VEHICLE AFTER PARKING BUT IN "DRIVE" WHICH HAS LED TO THE CAR UNINTENTIONALLY ROLLING DOWNHILL …
Read full complaint
I AM ASKING THAT THE NHTSA INVESTIGATE THE 2013 HIGHLANDER LIMITED FOR THE ABILITY TO TURN OFF THE CAR WHILE IN "DRIVE" AFTER PARKING. WE PURCHASED OUR CAR NEW FORM THE DEALER, AND EVER SINCE WE HAVE BEEN ABLE TO TURN THE CAR OFF THE VEHICLE AFTER PARKING BUT IN "DRIVE" WHICH HAS LED TO THE CAR UNINTENTIONALLY ROLLING DOWNHILL ON SEVERAL TIMES. ON TWO OCCASIONS IT HAS LED TO THE CAR NOT RESTARTING. WE HAVE ASKED OUR LOCAL DEALER AND SERVICE PEOPLE, AT TOYOTA OF SEATTLE, ABOUT THIS SEVERAL TIMES AND HAVE BEEN TOLD, ALBEIT WITH INCONSTANT REASONING, THAT THE CAR WAS DESIGNED TO HAVE THIS CAPABILITY. WE HAVE TWO SMALL CHILDREN AND TO US THIS SEEM EXTREMELY DANGEROUS, AS THE ONLY WAY TO BE ALERTED TO THE FACT THAT YOU'VE LEFT THE CAR IN "DRIVE", OTHER THAN THE VEHICLE ROLLING, IS A BEEP SOUND. HOWEVER, THIS BEEP IS THE EXACT SAME SOUND ALERT YOU GET WHEN YOUR LIGHTS ARE ON, OR A DOOR IS OPEN, OR YOU'RE RUNNING OUT OF GAS -- MAKING IT A COMMON SOUND THAT DOES NOT SIGNIFY A DANGEROUS SITUATION. ALSO, OFTEN THIS SOUND DOES NOT REGISTER IN THE BRAIN UNTIL YOU ARE OUT OF THE VEHICLE, BECAUSE THE SAME SOUND IS USED TO ALERT THAT A DOOR HAS BEEN OPENED BEFORE THE CAR WAS TURNED OFF. IN WHICH CASE, THE NOISE GOES AWAY AFTER YOU GET OUT AND CLOSE THE DOOR. WE HAVE HAD SEVERAL OCCASIONS WHERE OUR CHILDREN HAVE GOTTEN OUT OF THE PARKED VEHICLE WHILE WE'RE TRYING TO DETERMINE THE SOURCE OF THE BEEP AND THEN THE CAR WILL START ROLLING. I AM A CAREFUL PERSON, SO GIVEN MY INNUMERABLE CLOSE CALLS WITH THIS ISSUE I ENCOURAGE YOU TO INVESTIGATE THIS ISSUE BEFORE SOMEONE IS KILLED. THANK YOU OF YOUR TIME. SINCERELY, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #11090274
36,000 miles · Apr 6, 2018
Steering
WHILE TRAVELLING IN HIGH SPEED LANE ON I80 NEAR SACRAMENTO CA. I ATTEMPTED TO ADJUST TELESCOPIC STEERING WHEEL AND THE STEERING WHEEL CAME OFF IN MY HANDS AND BY GRACE OF GOD WAS ABLE TO SLOW AND GET OFF ROAD ON THE HAND HIGH SPEED BREAKDOWN LANE AND SOMEHOW REMOUNT THE STEERING WHEEL. VEHICLE CURRENTLY AT DEALERSHIP FOR REPAIR…
Read full complaint
WHILE TRAVELLING IN HIGH SPEED LANE ON I80 NEAR SACRAMENTO CA. I ATTEMPTED TO ADJUST TELESCOPIC STEERING WHEEL AND THE STEERING WHEEL CAME OFF IN MY HANDS AND BY GRACE OF GOD WAS ABLE TO SLOW AND GET OFF ROAD ON THE HAND HIGH SPEED BREAKDOWN LANE AND SOMEHOW REMOUNT THE STEERING WHEEL. VEHICLE CURRENTLY AT DEALERSHIP FOR REPAIR AND I WAS TOLD THAT THE STEERING AND MOUNT WOULD NEED TO BE REPLACED AND WILL COST IN EXCESS OF $2000.00. I HAVE CONTACTED TOYOTA, STARTED A CASE FILE WITH THEM AND WAITING ON THEIR REPLY.
NHTSA ODI #11083623
60,000 miles · Apr 4, 2018
Electrical System
EACH OF THE FOUR DOOR LOCK ACTUATORS HAVE MALFUNCTIONED SUCH THAT THE DOOR CANNOT BE UNLOCKED/OPENED FROM EITHER THE INSIDE OR OUTSIDE OF THE CAR. THIS HAS OCCURRED DURING THE PAST 18 MONTHS. IT IS A SAFETY HAZARD IN CASE OF A WRECK/FIRE WHERE SOMEONE COULD NOT GET OUT OF THE CAR EMERGENTLY OR SECURITY THREAT IF THE DRIVER/PA…
Read full complaint
EACH OF THE FOUR DOOR LOCK ACTUATORS HAVE MALFUNCTIONED SUCH THAT THE DOOR CANNOT BE UNLOCKED/OPENED FROM EITHER THE INSIDE OR OUTSIDE OF THE CAR. THIS HAS OCCURRED DURING THE PAST 18 MONTHS. IT IS A SAFETY HAZARD IN CASE OF A WRECK/FIRE WHERE SOMEONE COULD NOT GET OUT OF THE CAR EMERGENTLY OR SECURITY THREAT IF THE DRIVER/PASSENGER EMERGENTLY NEEDED TO ENTER THE CAR TO AVOID HARM. I HAVE RECEIPTS FOR ALL REPAIRS AT THE LOCAL TOYOTA DEALERSHIP. I WAS TOLD BY A TOYOTA DEALER SHIP REPRESENTATIVE THIS IS A RECOGNIZED ISSUE WITH THE VEHICLE.
NHTSA ODI #11083206
63,000 miles · Mar 14, 2018
SeatsSteering
WHILE TURNING THE STEERING I FEEL A KLUNK THIS IS HAPPENS ALWAYS WHEN TURN THE WHEEL. FRUSTRATED REALLY NEED YOUR HELP. REGARDS..
NHTSA ODI #11079450
30,000 miles · Mar 14, 2018
Service Brakes
I HAVE A 2013 TOYOTA HIGHLANDER AND RECENTLY WHILE DRIVING TOWARD A STOP SIGN, I WENT TO SLOW MY VEHICLE TO STOP AND MY BRAKE PEDAL WAS STUCK. ALSO, THE BRAKE PEDAL SEEMED TO BE IN A HIGHER THAN NORMAL POSITION BECAUSE I REMEMBER HAVING TO RAISE MY LEG TO REACH THE HEIGHT OF THE PEDAL. NO MATTER HOW HARD I PRESSED I COULDN'T GET…
Read full complaint
I HAVE A 2013 TOYOTA HIGHLANDER AND RECENTLY WHILE DRIVING TOWARD A STOP SIGN, I WENT TO SLOW MY VEHICLE TO STOP AND MY BRAKE PEDAL WAS STUCK. ALSO, THE BRAKE PEDAL SEEMED TO BE IN A HIGHER THAN NORMAL POSITION BECAUSE I REMEMBER HAVING TO RAISE MY LEG TO REACH THE HEIGHT OF THE PEDAL. NO MATTER HOW HARD I PRESSED I COULDN'T GET THE BRAKE PEDAL TO THE FLOOR AND I WAS UNABLE TO STOP THE CAR. I WAS FORCED TO GO THROUGH THE STOP SIGN AND INTO WHAT IS OFTEN A VERY BUSY STREET IN MY CITY. THANK GOD NO CARS WERE COMING DURING THE TIME OF MY INCIDENT. AFTER THAT THE BRAKE PEDAL WENT BACK TO PERFORMING NORMALLY AND I GOT THE CAR BACK HOME. LATER I HAD MY VEHICLE FLATBED TO A VERY GOOD GARAGE. MECHANICS DISASSEMBLED THE ENTIRE BRAKE SYSTEM AND DROVE MY VEHICLE BUT, THEY DIDN'T FIND A PROBLEM. ROAD CONDITIONS THAT DAY WERE DRY OTHER THAN A SMALL ICE PATCH I HAD TO GO OVER PRIOR TO THE STOP SIGN. IT HAD SNOWED DAYS BEFORE SO THE ROADS WERE PLOWED AND VERY CLEAN EXCEPT THIS SMALL ICE PATCH REMAINED. BUT, BECAUSE IT WAS ON THE ROAD MY SPEED WAS MUCH SLOWER THAN NORMAL. MONTHS PRIOR TO THIS INCIDENT I HAD A DIFFERENT A ISSUE WITH THESE BRAKES AND BOUGHT IT TO THE DEALER AND THEY DIDN'T FIND ANYTHING AND TOLD ME MY EXPERIENCE WAS NORMAL. UNCOMFORTABLE WITH THEIR ANSWER A MONTH LATER I HAD THE BRAKES CHECKED AT A DIFFERENT AUTO SHOP AND AGAIN THE MECHANIC FOUND NOTHING. HOWEVER, THIS LATEST INCIDENT WAS THE MOST SERIOUS ONE. I'M NOT CONVINCED IT'S NOTHING AND HAVE READ ABOUT OTHER HIGHLANDER OWNERS WHO HAD SIMILAR BRAKE ISSUES WITH THEIR VEHICLE. HOWEVER, I CAN'T SEEM TO FIND ANY FORMAL INVESTIGATIONS OR RECALLS RELATED TO ANY BRAKE ISSUES REGARDING TOYOTA HIGHLANDERS. EVEN SO I FELT I HAD TO SHARE MY STORY NOT JUST TO GET TO THE BOTTOM OF MY SITUATION BUT, TO ALSO ALERT OTHERS OF A SAFETY ISSUE THAT I AM EXPERIENCING WITH MY HIGHLANDER.
NHTSA ODI #11079188
70,000 miles · Mar 5, 2018
Steering
THIS VEHICLE HAS A KNOCKING OR CLUNKING SOUND WHEN TURNING THE STEERING WHEEL. THIS IS A COMMON COMPLAINT ON TOYOTA HIGHLANDERS BUT TOYOTA IS NOT OFFERING TO FIX THESE VEHICLES WHEN OUT OF WARRANTY. THIS IS A DEFECT IN THESE VEHICLES AND SHOULD BE FIXED BY TOYOTA FREE OF CHARGE.
NHTSA ODI #11076279
37,000 miles · Feb 26, 2018
Steering
THE VEHICLE HAS AROUND 37K MILES AND STARTED TO GET A BUMP OR THUD SOUND WHEN TURNING TO RIGHT AND TURNING OVER ALL BEGIN TO GET SLUGGISH. I TOOK IT TO THE DEALSHIP FRED HAAS IN HOUSTON AND IT WAS DIAGNOSED WITH A DRIVE SHAFT PROBLEM AND REQUIRED A EXPENSIVE REPAIR AND FRONT END ALIGNMENT. I QUESTIONED THE SERVICE REP AS IT SEE…
Read full complaint
THE VEHICLE HAS AROUND 37K MILES AND STARTED TO GET A BUMP OR THUD SOUND WHEN TURNING TO RIGHT AND TURNING OVER ALL BEGIN TO GET SLUGGISH. I TOOK IT TO THE DEALSHIP FRED HAAS IN HOUSTON AND IT WAS DIAGNOSED WITH A DRIVE SHAFT PROBLEM AND REQUIRED A EXPENSIVE REPAIR AND FRONT END ALIGNMENT. I QUESTIONED THE SERVICE REP AS IT SEEMED TO BE VERY LOW MILEAGE FOR A ISSUE WITH THE DRIVE SHAFT. HE ADVISED THAT IT WAS NOT COVERED AS MY 36K 3 YEAR STANDARD WARRANTY HAD RUN OUT. AFTER RESEARCHING IT SEEMS THAT THIS IS A HIGHLANDER DEFECT AND SHOULD BE COVERED BY A RECALL. IF THIS CAR HAD 80K OR MORE MILES I MIGHT BE OF A DIFFERENT OPINION BUT THIS CAR IS WAY TOO NEW TO HAVE AN ISSUE LIKE THIS ESPECIALLY ON SUCH AN IMPORTANT ELEMENT LIKE STEERING. THIS IS AN OBVIOUS ENGINEERING AND MANUFACTURING PROBLEM AND A REPLACEMENT PART THAT WILL ONLY HAVE A 1 YEAR WARRANTY IS NOT GOOD ENOUGH.
NHTSA ODI #11075061
Mileage unknown · Feb 12, 2018
Steering
THERE IS A CLUNKING NOISE WHEN TURNING AT LOW SPEEDS. MY MECHANIC SAYS THERE IS A DEFECT IN THE DESIGN OF THE STEERING SHAFT. HE SAID THIS COMMONLY OCCURS WITH THIS MODEL HIGHLANDER, SOMETHING SUPPORTED BY NUMEROUS COMPLAINTS ABOUT THE SAME ISSUE. TOYOTA DENIES RESPONSIBILITY AND WON'T ISSUE A RECALL, THOUGH IT IS A SAFETY RISK.
NHTSA ODI #11072265
44,700 miles · Jan 7, 2018
Electrical System
POWER TRAIN FAILED WHILE DRIVING ALONG A CITY STREET AT 30MPH- CAR HAD NO POWER- CHECK HYBRID COMPONENTS AND CHECK BRAKE SYSTEM LIGHTS APPEARED ON THE CENTER CONSOLE- I BELIEVE IT FAILED DUE TO THE HYBRID ELECTRICAL SYSTEM AND IS IDENTICAL TO DESCRIPTIONS OF EARLIER HYBRID INVERTER FAILURES IN 2006-2010 MODELS OF HIGHLANDER AND …
Read full complaint
POWER TRAIN FAILED WHILE DRIVING ALONG A CITY STREET AT 30MPH- CAR HAD NO POWER- CHECK HYBRID COMPONENTS AND CHECK BRAKE SYSTEM LIGHTS APPEARED ON THE CENTER CONSOLE- I BELIEVE IT FAILED DUE TO THE HYBRID ELECTRICAL SYSTEM AND IS IDENTICAL TO DESCRIPTIONS OF EARLIER HYBRID INVERTER FAILURES IN 2006-2010 MODELS OF HIGHLANDER AND LEXUS THAT WERE RECALLED BY TOYOTA-
Toyota is recalling certain model year 2013 Highlander vehicles manufactured March 13, 2013, through August 6, 2013. In the affected vehicles, the second row left hand seat may not lock in place when positioned in the forward front or second adjusting position. As such, the vehicles do not conform to Federal Motor Vehicle Safety Standard (FMVSS) number 207, "Seating Systems."
Consequence & remedy
Consequence: If the seat does not lock into the seat track, there may be an increased risk of injury to an occupant in the event of a crash.
Remedy: Toyota will notify owners, and dealers will modify the second row left hand seat so that it will lock into the seat track, free of charge. The recall began on May 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Southeast Toyota is recalling certain model year 2008 and 2010-2013 Toyota Tundra, 2010-2012 Rav4, 2012 Toyota Sequoia, 2010-2011 Toyota Corolla, 2010-2011 Toyota Camry and Camry Hybrid, 2010-2013 Toyota Highlander and Highlander Hybrid, 2010-2013 Toyota FJ Cruiser, 2011 Toyota Land Cruiser, 2010-2013 Toyota Venza, 2010-2011 Toyota 4Runner, 2010-2013 Toyota Tacoma, 2011-2012 Toyota Sienna, 2012 Toyota Prius, 2013 Scion FR-S, 2011 Scion XD, 2011 Scion XB, and 2012 Scion TC vehicles. These vehicles were sold with labels that were outside the allowable one percent of accuracy of actual weight added. Thus, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) Number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: An inaccurate label could lead to owners overloading their vehicles and tires. An overloaded vehicle can result in a tire failure which may result in a vehicle crash, personal injury, or property damage.
Remedy: Southeast Toyota will notify owners and provide a corrected label with instructions concerning its installation. A small group of the affected vehicles will need additonal remedies which are still being developed. The recall began on May 28, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence & remedy
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Additional source detail variants (2)
Seats
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
EA18006 · Steering Column Separation
Opened Nov 16, 2018 · Closed Apr 2, 2024
Status: closed (inferred from source dates) · Steering; Steering:column
On November 16, 2018, the Office of Defects Investigation (ODI) opened an Engineering Analysis (EA18-006) as an upgrade to a Preliminary Evaluation (PE18-005). The investigation focused on allegations of steering wheel separation from the lower steering column after using the tilt and/or telescoping mechanism. Given the separation occurring when operating the tilt and/or telescoping function and failure of both shear capsules to maintain the lower steering column mounting position, potential for shear capsule damage in the known failures due to collisions, the overall low rate of occurrence, and the updated manufacturer documentation, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists. The agency reserves right to take further action if warranted by the circumstances. A detailed summary of the investigation is attached to this closing resume. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Steering:column
On November 16, 2018, the Office of Defects Investigation (ODI) opened an Engineering Analysis (EA18-006) as an upgrade to a Preliminary Evaluation (PE18-005). The investigation focused on allegations of steering wheel separation from the lower steering column after using the tilt and/or telescoping mechanism. Given the separation occurring when operating the tilt and/or telescoping function and failure of both shear capsules to maintain the lower steering column mounting position, potential for shear capsule damage in the known failures due to collisions, the overall low rate of occurrence, and the updated manufacturer documentation, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists. The agency reserves right to take further action if warranted by the circumstances. A detailed summary of the investigation is attached to this closing resume. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Steering
On November 16, 2018, the Office of Defects Investigation (ODI) opened an Engineering Analysis (EA18-006) as an upgrade to a Preliminary Evaluation (PE18-005). The investigation focused on allegations of steering wheel separation from the lower steering column after using the tilt and/or telescoping mechanism. Given the separation occurring when operating the tilt and/or telescoping function and failure of both shear capsules to maintain the lower steering column mounting position, potential for shear capsule damage in the known failures due to collisions, the overall low rate of occurrence, and the updated manufacturer documentation, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists. The agency reserves right to take further action if warranted by the circumstances. A detailed summary of the investigation is attached to this closing resume. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
PE18005 · Upper Steering Column Separation
Opened May 4, 2018 · Closed Nov 20, 2018
Status: closed (inferred from source dates) · Steering; Steering:column
On May 4, 2018, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE18-005 to investigate three allegations of steering column separation for Model Year (MY) 2008 through 2013 Toyota Highlander vehicles. Two (2) of the 3 complaints were received by ODI in April 2018 and occurred while the vehicle was in motion. Since opening PE18-005, one (1) additional VOQ involving steering column separation has been received. This incident occurred while the vehicle was stationary.As part of PE18-005, ODI examined the field data, warranty data, and relevant technical information submitted by Toyota in response to the PE18-005 information request letter. Ten (10) additional incidents of steering column separation were identified. Four (4) of these instances occurred while driving. During PE18-005, ODI confirmed that the steering columns in the subject vehicles are equipped with breakaway capsules that are designed to collapse/shear during certain types of vehicle collisions. This design feature aims to reduce driver injury severity from impact with the steering wheel in frontal vehicle collisions. There is no direct method for detecting when the capsules in the subject vehicles have sheared. If the driver operates the tilt/telescoping feature after the breakaway capsules have separated, the steering column may drop out of position and could subsequently detach entirely from the rest of the steering assembly. Loss of steering while driving may cause a loss of vehicle control, which could lead to a vehicle crash.To date, ODI has identified 14 incidents involving complete steering column separation, 6 of which occurred while driving. One of these incidents involved a minor crash. Additionally, there have been 16 events where the steering column dropped from the dashboard mounting brackets, but column separation did not occur. Four of these incidents happened while driving. Of these 30 total separation/drop incidents, 5 of the vehicles have evidence of minor collision repairs months or years prior to the steering column failure.This investigation has been upgraded an to Engineering Analysis (EA18-006) in order to 1) conduct a more detailed analysis of the conditions that may cause the steering column breakaway capsules to separate and 2) assess factors that may contribute to the problem of failing to detect and repair breakaway capsules after they have separated. Toyota has recently revised their repair manual and issued a Collision Repair Information Bulletin to help address the second concern.The VOQs associated with this investigation can be viewed at www.NHTSA.gov under the following ODI complaint numbers: 11141761, 11083623, 11083280, 10888043.
Additional source detail variants (2)
Steering:column
On May 4, 2018, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE18-005 to investigate three allegations of steering column separation for Model Year (MY) 2008 through 2013 Toyota Highlander vehicles. Two (2) of the 3 complaints were received by ODI in April 2018 and occurred while the vehicle was in motion. Since opening PE18-005, one (1) additional VOQ involving steering column separation has been received. This incident occurred while the vehicle was stationary.As part of PE18-005, ODI examined the field data, warranty data, and relevant technical information submitted by Toyota in response to the PE18-005 information request letter. Ten (10) additional incidents of steering column separation were identified. Four (4) of these instances occurred while driving. During PE18-005, ODI confirmed that the steering columns in the subject vehicles are equipped with breakaway capsules that are designed to collapse/shear during certain types of vehicle collisions. This design feature aims to reduce driver injury severity from impact with the steering wheel in frontal vehicle collisions. There is no direct method for detecting when the capsules in the subject vehicles have sheared. If the driver operates the tilt/telescoping feature after the breakaway capsules have separated, the steering column may drop out of position and could subsequently detach entirely from the rest of the steering assembly. Loss of steering while driving may cause a loss of vehicle control, which could lead to a vehicle crash.To date, ODI has identified 14 incidents involving complete steering column separation, 6 of which occurred while driving. One of these incidents involved a minor crash. Additionally, there have been 16 events where the steering column dropped from the dashboard mounting brackets, but column separation did not occur. Four of these incidents happened while driving. Of these 30 total separation/drop incidents, 5 of the vehicles have evidence of minor collision repairs months or years prior to the steering column failure.This investigation has been upgraded an to Engineering Analysis (EA18-006) in order to 1) conduct a more detailed analysis of the conditions that may cause the steering column breakaway capsules to separate and 2) assess factors that may contribute to the problem of failing to detect and repair breakaway capsules after they have separated. Toyota has recently revised their repair manual and issued a Collision Repair Information Bulletin to help address the second concern.The VOQs associated with this investigation can be viewed at www.NHTSA.gov under the following ODI complaint numbers: 11141761, 11083623, 11083280, 10888043.
Steering
On May 4, 2018, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE18-005 to investigate three allegations of steering column separation for Model Year (MY) 2008 through 2013 Toyota Highlander vehicles. Two (2) of the 3 complaints were received by ODI in April 2018 and occurred while the vehicle was in motion. Since opening PE18-005, one (1) additional VOQ involving steering column separation has been received. This incident occurred while the vehicle was stationary.As part of PE18-005, ODI examined the field data, warranty data, and relevant technical information submitted by Toyota in response to the PE18-005 information request letter. Ten (10) additional incidents of steering column separation were identified. Four (4) of these instances occurred while driving. During PE18-005, ODI confirmed that the steering columns in the subject vehicles are equipped with breakaway capsules that are designed to collapse/shear during certain types of vehicle collisions. This design feature aims to reduce driver injury severity from impact with the steering wheel in frontal vehicle collisions. There is no direct method for detecting when the capsules in the subject vehicles have sheared. If the driver operates the tilt/telescoping feature after the breakaway capsules have separated, the steering column may drop out of position and could subsequently detach entirely from the rest of the steering assembly. Loss of steering while driving may cause a loss of vehicle control, which could lead to a vehicle crash.To date, ODI has identified 14 incidents involving complete steering column separation, 6 of which occurred while driving. One of these incidents involved a minor crash. Additionally, there have been 16 events where the steering column dropped from the dashboard mounting brackets, but column separation did not occur. Four of these incidents happened while driving. Of these 30 total separation/drop incidents, 5 of the vehicles have evidence of minor collision repairs months or years prior to the steering column failure.This investigation has been upgraded an to Engineering Analysis (EA18-006) in order to 1) conduct a more detailed analysis of the conditions that may cause the steering column breakaway capsules to separate and 2) assess factors that may contribute to the problem of failing to detect and repair breakaway capsules after they have separated. Toyota has recently revised their repair manual and issued a Collision Repair Information Bulletin to help address the second concern.The VOQs associated with this investigation can be viewed at www.NHTSA.gov under the following ODI complaint numbers: 11141761, 11083623, 11083280, 10888043.
2013 Toyota Highlander Problems, Complaints & Recalls | Skip That Year
Illustration