IllustrationTHE VEHICLE SUDDENLY LOST POWER ON THE HIGHWAY. THE CAR WAS STILL RUNNING, BUT THERE WAS NO POWER TO THE WHEELS. THE FRONT DIFFERENTIAL HAD FAILED DUE TO A LEAK IN THE FRONT OF THE TRANSFER CASE. THIS FAILURE CAUSED THE TRANSMISSION TO FAIL AS WELL. *TR
2009 Toyota Highlander
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2009 Toyota Highlander do not stand out strongly from the model-year median of 186.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Highlander years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
310–25K
1225–50K
1650–75K
1775–100K
19100–150K
10150K+
105 reports with mileage · 29 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine. Review the 23 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes. Review the 21 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 20 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
6 crash reports5 fire reports5 injury reports
What owners actually said
134 reportsTHE POWER ARM BROKE OFF OF THE REAR POWER LIFT GATE WHEN CLOSING. THE DRIVER SIDE HINGE ON THE REAR POWER LIFTGATE IS BOWED. *TR
I WAS TRAVELING 50 -60 MILES PER HOUR ON THE NEW JERSEY GARDEN STATE PARKWAY. WHILE DRIVING ALL OF A SUDDEN A HUGE VIBRATION OCCURRED THROUGH OUT THE VEHICLE. WHILE IT VIBRATED A LOUD NOISE OCCURRED. IT WAS SO LOUD MY DOG BEGAN TO BARK AND MY EARS COULD NOT TAKE THE NOISE OF THE VEHICLE. I TRIED TO BRAKE AND THE NOISE CONTIN…
Read full complaint
I WAS TRAVELING 50 -60 MILES PER HOUR ON THE NEW JERSEY GARDEN STATE PARKWAY. WHILE DRIVING ALL OF A SUDDEN A HUGE VIBRATION OCCURRED THROUGH OUT THE VEHICLE. WHILE IT VIBRATED A LOUD NOISE OCCURRED. IT WAS SO LOUD MY DOG BEGAN TO BARK AND MY EARS COULD NOT TAKE THE NOISE OF THE VEHICLE. I TRIED TO BRAKE AND THE NOISE CONTINUED AS WELL AS THE VIBRATION. I CONTINUED TO TRY AND GET IN THE RIGHT LANE HOWEVER THE NOISE AND VIBRATION CONTINUED. THE VIBRATION FELT LIKE WHEN YOU GO ACROSS SPEED BUMPS THAT GIVES A RUMBLE SOUND. THE ROAD WAS SMOOTH AND THERE WERE NO SPEED BUMPS HOWEVER IT FELT AS IF I WAS GOING OVER SPEED BUMPS. ON 10/25/12 I TOOK THE VEHICLE TO TOYOTA OF HACKENSACK NJ WHERE THE VEHICLE WAS PURCHASED ON. I INFORMED THE SERVICE GUY ABOUT THE SITUATION. THEY DID A MULTI-POINT INSPECTION AND NOTHING CAME UP. THEY TEST DROVE THE VEHICLE IN CITY LIMITS AND NOTHING CAME UP. I THEN INFORMED THEM THAT THE VIBRATION DOES NOT OCCUR UNTIL YOU ARE ON THE HIGHWAY. THE TECHNICIAN THEN TEST DROVE WITH ME IN THE VEHICLE. THE VIBRATION DID NOT OCCUR. THIS SPECIFIC VIBRATION AND NOISE HAS ONLY OCCURRED TWICE SINCE I PURCHASED THE VEHICLE. I PURCHASED THE VEHICLE OVER A MONTH AGO DUE TO A FAULTY 2005 KIA SORENTO CRANKSHAFT BOLT DESIGN. IF IT HAPPENS AGAIN I WILL FILE ANOTHER COMPLAINT. *TR
TL* THE CONTACT OWNS A 2009 TOYOTA HIGHLANDER. THE CONTACT WAS REVERSING FROM A PARKING SPACE AT 5 MPH WHEN THE ACCELERATOR PEDAL BECAME STUCK AND CAUSED THE VEHICLE TO ACCELERATE RAPIDLY. THE CONTACT MENTIONED THAT SHE WAS UNABLE TO STOP THE VEHICLE AND AS A RESULT, SHE CRASHED INTO A TREE. A POLICE REPORT WAS NOT FILED AND NO …
Read full complaint
TL* THE CONTACT OWNS A 2009 TOYOTA HIGHLANDER. THE CONTACT WAS REVERSING FROM A PARKING SPACE AT 5 MPH WHEN THE ACCELERATOR PEDAL BECAME STUCK AND CAUSED THE VEHICLE TO ACCELERATE RAPIDLY. THE CONTACT MENTIONED THAT SHE WAS UNABLE TO STOP THE VEHICLE AND AS A RESULT, SHE CRASHED INTO A TREE. A POLICE REPORT WAS NOT FILED AND NO INJURIES WERE REPORTED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 783 AND THE CURRENT MILEAGE WAS 22,000.
COMPLAINANT HAD TO REPLACE THE ORIGINAL BRIDGESTONE TIRES (245/55R19) ON A 2009 TOYOTA HIGHLANDER LTD AFTER 20,679 MILES. TREAD WEAR WAS BELOW 3/32'S. TOYOTA WOULD NOT WARRANT OR PARTICIPATE IN THE REPLACEMENT COSTS. BRIDGESTONE OFFERED TO SPLIT THE COST OF REPLACING THE FOUR TIRES WITH THEIR DUELER H/L (P245/55R19) WHICH I A…
Read full complaint
COMPLAINANT HAD TO REPLACE THE ORIGINAL BRIDGESTONE TIRES (245/55R19) ON A 2009 TOYOTA HIGHLANDER LTD AFTER 20,679 MILES. TREAD WEAR WAS BELOW 3/32'S. TOYOTA WOULD NOT WARRANT OR PARTICIPATE IN THE REPLACEMENT COSTS. BRIDGESTONE OFFERED TO SPLIT THE COST OF REPLACING THE FOUR TIRES WITH THEIR DUELER H/L (P245/55R19) WHICH I ACCEPTED ON APRIL 20, 2010. MY COST WAS $491.32. THE REPLACEMENT TIRES AFTER 9 MONTHS AND 17,011 MILES HAVE 5/32'S WEAR. HOWEVER, WITH THAT TIRE WEAR, THE HIGHLANDER IS UNSAFE TO DRIVE WHEN THERE IS FROST/SNOW/RAIN/ICE ON THE ROAD. THE VEHICLE LOOSES TRACTION AND IS UNCONTROLLABLE AS IT SLIDES THROUGH INTERSECTIONS. AGAIN, THE TOYOTA DEALERSHIP REFUSED TO WARRANT OR PARTICIPATE IN THE TIRE REPLACEMENT COSTS. BRIDGESTONE HAS OFFERED TO SPLIT THE COST TO REPLACE THE TIRES. THIS WOULD AMOUNT TO AN ADDITIONAL $500 (EST.) TO REPLACE TIRES THAT DO NOT WEAR PROPERLY. HOW CAN PAYMENTS OF APPROXIMATELY $1,000 FOR EIGHT TIRES THAT PROVIDE PREMATURE AND UNSAFE TIRE WEAR BE JUSTIFIED? THE VEHICLE IN ITS CURRENT CONDITION, IS A HAZARD ON THE ROAD AND UNSAFE TO DRIVE. TIRE WEAR IS PREMATURE. THE HIGHLANDER SHOULD BE RECALLED FOR A FREE FOUR WHEEL TIRE REPLACEMENT AND ALIGNMENT. UPDATED IVOQ 01/26/12 *TR
OUR CAR HAS 17,000. MILES AND TURNS OUT THE TIRES ARE BARE IN SPOTS AND THE CAR HYDROPLANED AND SKIDDED AND WOULD NOT HOLD THE ROAD IN A LIGHT SNOWSTORM. WE OFTEN SKIDDED RIGHT INTO ONCOMING TRAFFIC. WE HAVE DRIVEN MANY SUVS OVER THE YEARS -WE ARE 69- AND NEVER HAD A PROBLEM. TOYOTA EMAILED TO US THAT THE TOYO A20 P245/55R19 OPE…
Read full complaint
OUR CAR HAS 17,000. MILES AND TURNS OUT THE TIRES ARE BARE IN SPOTS AND THE CAR HYDROPLANED AND SKIDDED AND WOULD NOT HOLD THE ROAD IN A LIGHT SNOWSTORM. WE OFTEN SKIDDED RIGHT INTO ONCOMING TRAFFIC. WE HAVE DRIVEN MANY SUVS OVER THE YEARS -WE ARE 69- AND NEVER HAD A PROBLEM. TOYOTA EMAILED TO US THAT THE TOYO A20 P245/55R19 OPEN COUNTRY TIRES THE CAR CAME WITH ARE NOT MEANT FOR DRIVING IN SNOW. WE LIVE IN VT AND THE CAR WAS SOLD TO US AS AN ALL WHEEL DRIVE CAR FOR DRIVING IN SNOW. I HAVE LOOKED AT THE INTERNET AND OTHERS HAVE HAD THE SAME PROBLEM WITH THESE TIRES. I FEEL THERE SHOULD BE A RECALL ON THEM BEFORE SOMEONE IS KILLED. MY SON JUST PURCHASE A NEW HIGHLANDER AND I WORRY HIS TIRES ARE THE SAME. *TR
WITHOUT PREJUDICE MY VEHICLE WAS REAR -ENDED BY ANOTHER VEHICLE AT SPEED OF APPROXIMATELY 75, AND GOT CRASHED ON TO THE CAR IN FRONT AT SPEED OF 40 TO 50. AIR BAGS FAILED TO DEPLOY AND DASH BOARD INDICATOR LIGHT CAME ON AND IT DOES NOT GO OFF. I STRONGLY BELIEVE THIS IS A MANUFACTURER DEFECT. THIS SUV CONSISTS WITH SIX AIR BA…
Read full complaint
WITHOUT PREJUDICE MY VEHICLE WAS REAR -ENDED BY ANOTHER VEHICLE AT SPEED OF APPROXIMATELY 75, AND GOT CRASHED ON TO THE CAR IN FRONT AT SPEED OF 40 TO 50. AIR BAGS FAILED TO DEPLOY AND DASH BOARD INDICATOR LIGHT CAME ON AND IT DOES NOT GO OFF. I STRONGLY BELIEVE THIS IS A MANUFACTURER DEFECT. THIS SUV CONSISTS WITH SIX AIR BAGS. NON OF THEM RESPONDED. I PURCHASE WITH CONFIDENCE THAT AIR BAGS ARE IN WORKING ORDER. MANUFACTURER RISK OUR LIFE FOR NEARLY TWO YEARS. I DESERVE COMPENSATION FOR RISKING 6 LIVES. *TR
2009 TOYOTA HIGHLANDER CLEARANCE BETWEEN BOTH REAR "SHOCK BASE PLATE" AND BOTH REAR TIRES ARE TOO CLOSE. EVERY TIME WHEN YOU HIT A "BUMP", BOTH REAR TIRES ARE HITTING THE "REAR SHOCK BASE PLATE". THIS WILL DAMAGE BOTH REAR TIRES AND CAUSE ACCIDENT !! DEFECTIVE ENGINEERING DESIGN !! TOYOTA SHOULD RECALL ALL HIGHLANDERS WITH…
Read full complaint
2009 TOYOTA HIGHLANDER CLEARANCE BETWEEN BOTH REAR "SHOCK BASE PLATE" AND BOTH REAR TIRES ARE TOO CLOSE. EVERY TIME WHEN YOU HIT A "BUMP", BOTH REAR TIRES ARE HITTING THE "REAR SHOCK BASE PLATE". THIS WILL DAMAGE BOTH REAR TIRES AND CAUSE ACCIDENT !! DEFECTIVE ENGINEERING DESIGN !! TOYOTA SHOULD RECALL ALL HIGHLANDERS WITH THIS DEFECTIVE DESIGN !!! YOU DON'T WANT TO WAIT FOR AN ACCIDENT TO HAPPEN THEN MAKE A MANDATORY RECALL. THANKS FOR READING MY MESSAGE AND CONCERN OF SAFETY FOR ALL HIGHLANDER OWNERS. *TR
TOYOTA HIGHLANDER 19" RIMS WITH TOYO OPEN COUNTRY A20 TIRES ARE VERY UNSAFE. THIS TIRE/WHEEL COMBINATION WAS STANDARD ON 2008/09 LIMITED AND SPORT HIGHLANDERS. MY 2009 HIGHLANDER WOULD SLIP ALL OVER THE PLACE IN WINTER DRIVING. BY FAR THE WORST WINTER VEHICLE I EVER OWNED AND I'VE OWNED PLENTY THAT WERE NOT ALL-WHEEL DRIVE. …
Read full complaint
TOYOTA HIGHLANDER 19" RIMS WITH TOYO OPEN COUNTRY A20 TIRES ARE VERY UNSAFE. THIS TIRE/WHEEL COMBINATION WAS STANDARD ON 2008/09 LIMITED AND SPORT HIGHLANDERS. MY 2009 HIGHLANDER WOULD SLIP ALL OVER THE PLACE IN WINTER DRIVING. BY FAR THE WORST WINTER VEHICLE I EVER OWNED AND I'VE OWNED PLENTY THAT WERE NOT ALL-WHEEL DRIVE. LUCKILY THE TRACTION CONTROL SYSTEM IS GOOD AND SAVED ME FROM SEVERAL ACCIDENTS. TOYOTA USED VERY LARGE 19" RIMS AND PERFORMANCE TIRES ON THE VEHICLE. THE TIRES WERE WORN OUT AFTER 18 MONTHS AND 21,000 MILES. WHY TOYOTA THOUGHT BIG WHEELS AND PERFORMANCE TIRES WERE IMPORTANT TO AN SUV PURCHASER IS BEYOND ME. TOYOTA ALSO REFUSES TO STAND BEHIND THEIR SAFETY DEFECT (NOT TO MENTION THE TIRES ONLY LASTED 21,000 MILES). I PURCHASED 17" RIMS ON MY OWN AND TOYO PROVIDED CREDIT FOR 2 OF THE 4 NEW OPEN COUNTRY HT TIRES AND THE SUV IS NOW MUCH SAFER - IT NO LONGER FEELS LIKE I AM RIDING ON ROLLER SKATES! *TR
SUNSHINE KIDS RADIAN XTSL LATCH LOOSENS ITSELF. TWO TIMES I'VE GONE TO PUT MY 2 YEAR OLD INTO HER SEAT AND THE LATCH HAS HAD AT LEAST 2 INCHES OF SLACK!! PLEASE FIX THIS!! (RELATED VEHICLE INFORMATION: MODEL YEAR=2009, MAKE=TOYOTA, MODEL=HIGHLANDER). *TR
Official recalls
916V396000 · Seats:front Assembly:seat Heater/cooler
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
15V689000 · Visibility:power Window Devices And Controls
Oct 22, 2015
Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.
Consequence & remedy
Consequence: If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.
Remedy: Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.
14V743000 · Seats:front Assembly:seat Heater/cooler
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
14V168000 · Air Bags:frontal:driver Side:inflator Module
Apr 9, 2014
Toyota is recalling certain model year 2006-2008 RAV4, 2006-2010 Yaris, 2008-2010 Highlander, and 2009-2010 Tacoma, Corolla, Corolla Matrix and General Motors Pontiac Vibe vehicles. In the affected vehicles, the steering column assembly contains electrical connections to the driver's airbag module housed in a spiral cable assembly, which includes a Flexible Flat Cable (FFC). Due to the shape and location of the FFC's retainer, the FFC could become damaged when the steering wheel is turned.
Consequence & remedy
Consequence: If the FFC is damaged, connectivity to the driver's air bag module could be lost and the air bag deactivated. The failure of the driver's air bag to deploy in the event of a crash that typically necessitates deployment increases the risk of injury to the driver.
Remedy: Toyota will notify the Toyota vehicle owners, and General Motors will notify the Pontiac Vibe owners. Toyota sent owners an interim notification letter in May 2014 to advise owners of the recall. Toyota will mail owners a second letter when remedy parts are available. General Motors sent Pontiac Vibe owners an Interim letter on June 20, 2014 notifying them that parts are currently unavailable. General Motors sent notices to the Pontiac Vibe owners on September 15, 2014, that a remedy is available. The recall began on October 27, 2014. Owners may contact Toyota at 1-800-331-4331. Owners may contact General Motors at 1-800-762-2737.
13V014000 · Air Bags:frontal:sensor/control MODULE-INACTIVE ; Seats
Jan 16, 2013
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence & remedy
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Additional source detail variants (2)
Seats
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
10V035000 · Equipment:other:labels
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
10V036000 · Equipment:other:labels
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
10V023000 · Vehicle Speed Control:accelerator Pedal
Jan 27, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008-2010 HIGHLANDER, MODEL YEAR 2009-2010 COROLLA, VENZA AND MATRIX PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT. THIS RECALL IS AN EXPANSION OF A CAMPAIGN OF 3.8 MILLION OTHER TOYOTA VEHICLES ANNOUNCED IN 2009 FOR THE SAME ISSUE (SEE 09V-388).
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA WILL MODIFY OR REPLACE THE ACCELERATOR PEDALS ON THE SUBJECT VEHICLES. FLOOR SURFACE MODIFICATIONS ARE ALSO BEING CONSIDERED AND WILL BE INCLUDED FOR ANY MODEL FOR WHICH IT IS DEEMED APPROPRIATE. INITIALLY, DEALERS WILL BE INSTRUCTED ON HOW TO RESHAPE THE ACCELERATOR PEDAL FOR THE REPAIR. AS REPLACEMENT PARTS WITH THE SAME SHAPE AS THE MODIFIED PEDAL BECOME AVAILABLE, THEY WILL BE MADE AVAILABLE TO THE DEALERS FOR THE REPAIR. CUSTOMERS WHO HAVE HAD THE PEDAL RESHAPE REMEDY COMPLETED WILL HAVE THE OPPORTUNITY TO RECEIVE A NEW PEDAL IF THEY DESIRE, AFTER REPLACEMENT PEDALS BECOME AVAILABLE. IN ADDITION, TOYOTA WILL REPLACE ANY TOYOTA ALL-WEATHER FLOOR MAT IN A SUBJECT VEHICLE WITH A NEWLY DESIGNED MAT, FREE OF CHARGE. FOR THOSE CUSTOMERS WHO HAVE THE PREVIOUS DESIGN ALL-WEATHER FLOOR MAT BUT DO NOT NEED OR WANT THE NEWLY DESIGNED ALL-WEATHER FLOOR MAT, TOYOTA WILL RECOVER THE PREVIOUS DESIGN ALL-WEATHER FLOOR MAT AND REIMBURSE ITS PRICE. THE SAFETY RECALL BEGAN MARCH 30, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
09V223000 · Equipment:other:labels
Jun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Consequence & remedy
Consequence: INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA18006 · Steering Column Separation
Opened Nov 16, 2018 · Closed Apr 2, 2024
Status: closed (inferred from source dates) · Steering; Steering:column
On November 16, 2018, the Office of Defects Investigation (ODI) opened an Engineering Analysis (EA18-006) as an upgrade to a Preliminary Evaluation (PE18-005). The investigation focused on allegations of steering wheel separation from the lower steering column after using the tilt and/or telescoping mechanism. Given the separation occurring when operating the tilt and/or telescoping function and failure of both shear capsules to maintain the lower steering column mounting position, potential for shear capsule damage in the known failures due to collisions, the overall low rate of occurrence, and the updated manufacturer documentation, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists. The agency reserves right to take further action if warranted by the circumstances. A detailed summary of the investigation is attached to this closing resume. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Steering:column
On November 16, 2018, the Office of Defects Investigation (ODI) opened an Engineering Analysis (EA18-006) as an upgrade to a Preliminary Evaluation (PE18-005). The investigation focused on allegations of steering wheel separation from the lower steering column after using the tilt and/or telescoping mechanism. Given the separation occurring when operating the tilt and/or telescoping function and failure of both shear capsules to maintain the lower steering column mounting position, potential for shear capsule damage in the known failures due to collisions, the overall low rate of occurrence, and the updated manufacturer documentation, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists. The agency reserves right to take further action if warranted by the circumstances. A detailed summary of the investigation is attached to this closing resume. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Steering
On November 16, 2018, the Office of Defects Investigation (ODI) opened an Engineering Analysis (EA18-006) as an upgrade to a Preliminary Evaluation (PE18-005). The investigation focused on allegations of steering wheel separation from the lower steering column after using the tilt and/or telescoping mechanism. Given the separation occurring when operating the tilt and/or telescoping function and failure of both shear capsules to maintain the lower steering column mounting position, potential for shear capsule damage in the known failures due to collisions, the overall low rate of occurrence, and the updated manufacturer documentation, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists. The agency reserves right to take further action if warranted by the circumstances. A detailed summary of the investigation is attached to this closing resume. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
PE18005 · Upper Steering Column Separation
Opened May 4, 2018 · Closed Nov 20, 2018
Status: closed (inferred from source dates) · Steering; Steering:column
On May 4, 2018, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE18-005 to investigate three allegations of steering column separation for Model Year (MY) 2008 through 2013 Toyota Highlander vehicles. Two (2) of the 3 complaints were received by ODI in April 2018 and occurred while the vehicle was in motion. Since opening PE18-005, one (1) additional VOQ involving steering column separation has been received. This incident occurred while the vehicle was stationary.As part of PE18-005, ODI examined the field data, warranty data, and relevant technical information submitted by Toyota in response to the PE18-005 information request letter. Ten (10) additional incidents of steering column separation were identified. Four (4) of these instances occurred while driving. During PE18-005, ODI confirmed that the steering columns in the subject vehicles are equipped with breakaway capsules that are designed to collapse/shear during certain types of vehicle collisions. This design feature aims to reduce driver injury severity from impact with the steering wheel in frontal vehicle collisions. There is no direct method for detecting when the capsules in the subject vehicles have sheared. If the driver operates the tilt/telescoping feature after the breakaway capsules have separated, the steering column may drop out of position and could subsequently detach entirely from the rest of the steering assembly. Loss of steering while driving may cause a loss of vehicle control, which could lead to a vehicle crash.To date, ODI has identified 14 incidents involving complete steering column separation, 6 of which occurred while driving. One of these incidents involved a minor crash. Additionally, there have been 16 events where the steering column dropped from the dashboard mounting brackets, but column separation did not occur. Four of these incidents happened while driving. Of these 30 total separation/drop incidents, 5 of the vehicles have evidence of minor collision repairs months or years prior to the steering column failure.This investigation has been upgraded an to Engineering Analysis (EA18-006) in order to 1) conduct a more detailed analysis of the conditions that may cause the steering column breakaway capsules to separate and 2) assess factors that may contribute to the problem of failing to detect and repair breakaway capsules after they have separated. Toyota has recently revised their repair manual and issued a Collision Repair Information Bulletin to help address the second concern.The VOQs associated with this investigation can be viewed at www.NHTSA.gov under the following ODI complaint numbers: 11141761, 11083623, 11083280, 10888043.
Additional source detail variants (2)
Steering:column
On May 4, 2018, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE18-005 to investigate three allegations of steering column separation for Model Year (MY) 2008 through 2013 Toyota Highlander vehicles. Two (2) of the 3 complaints were received by ODI in April 2018 and occurred while the vehicle was in motion. Since opening PE18-005, one (1) additional VOQ involving steering column separation has been received. This incident occurred while the vehicle was stationary.As part of PE18-005, ODI examined the field data, warranty data, and relevant technical information submitted by Toyota in response to the PE18-005 information request letter. Ten (10) additional incidents of steering column separation were identified. Four (4) of these instances occurred while driving. During PE18-005, ODI confirmed that the steering columns in the subject vehicles are equipped with breakaway capsules that are designed to collapse/shear during certain types of vehicle collisions. This design feature aims to reduce driver injury severity from impact with the steering wheel in frontal vehicle collisions. There is no direct method for detecting when the capsules in the subject vehicles have sheared. If the driver operates the tilt/telescoping feature after the breakaway capsules have separated, the steering column may drop out of position and could subsequently detach entirely from the rest of the steering assembly. Loss of steering while driving may cause a loss of vehicle control, which could lead to a vehicle crash.To date, ODI has identified 14 incidents involving complete steering column separation, 6 of which occurred while driving. One of these incidents involved a minor crash. Additionally, there have been 16 events where the steering column dropped from the dashboard mounting brackets, but column separation did not occur. Four of these incidents happened while driving. Of these 30 total separation/drop incidents, 5 of the vehicles have evidence of minor collision repairs months or years prior to the steering column failure.This investigation has been upgraded an to Engineering Analysis (EA18-006) in order to 1) conduct a more detailed analysis of the conditions that may cause the steering column breakaway capsules to separate and 2) assess factors that may contribute to the problem of failing to detect and repair breakaway capsules after they have separated. Toyota has recently revised their repair manual and issued a Collision Repair Information Bulletin to help address the second concern.The VOQs associated with this investigation can be viewed at www.NHTSA.gov under the following ODI complaint numbers: 11141761, 11083623, 11083280, 10888043.
Steering
On May 4, 2018, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE18-005 to investigate three allegations of steering column separation for Model Year (MY) 2008 through 2013 Toyota Highlander vehicles. Two (2) of the 3 complaints were received by ODI in April 2018 and occurred while the vehicle was in motion. Since opening PE18-005, one (1) additional VOQ involving steering column separation has been received. This incident occurred while the vehicle was stationary.As part of PE18-005, ODI examined the field data, warranty data, and relevant technical information submitted by Toyota in response to the PE18-005 information request letter. Ten (10) additional incidents of steering column separation were identified. Four (4) of these instances occurred while driving. During PE18-005, ODI confirmed that the steering columns in the subject vehicles are equipped with breakaway capsules that are designed to collapse/shear during certain types of vehicle collisions. This design feature aims to reduce driver injury severity from impact with the steering wheel in frontal vehicle collisions. There is no direct method for detecting when the capsules in the subject vehicles have sheared. If the driver operates the tilt/telescoping feature after the breakaway capsules have separated, the steering column may drop out of position and could subsequently detach entirely from the rest of the steering assembly. Loss of steering while driving may cause a loss of vehicle control, which could lead to a vehicle crash.To date, ODI has identified 14 incidents involving complete steering column separation, 6 of which occurred while driving. One of these incidents involved a minor crash. Additionally, there have been 16 events where the steering column dropped from the dashboard mounting brackets, but column separation did not occur. Four of these incidents happened while driving. Of these 30 total separation/drop incidents, 5 of the vehicles have evidence of minor collision repairs months or years prior to the steering column failure.This investigation has been upgraded an to Engineering Analysis (EA18-006) in order to 1) conduct a more detailed analysis of the conditions that may cause the steering column breakaway capsules to separate and 2) assess factors that may contribute to the problem of failing to detect and repair breakaway capsules after they have separated. Toyota has recently revised their repair manual and issued a Collision Repair Information Bulletin to help address the second concern.The VOQs associated with this investigation can be viewed at www.NHTSA.gov under the following ODI complaint numbers: 11141761, 11083623, 11083280, 10888043.