2008 Toyota Fj Cruiser

TL* THE CONTACT OWNS A 2008 TOYOTA FJ CRUISER. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 2 MPH, THE PASSENGER SIDE FRONT BALL JOINT FRACTURED. THE VEHICLE WAS TOWED TO AUTONATION TOYOTA SPOKANE VALLEY (8600 E SPRAGUE AVE, SPOKANE VALLEY, WA 99212, (509) 850-9359) TO BE REPAIRED. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 80,000.

DRIVER SIDE SEAT BELT RETRACTOR STOPPED WORKING. SEAT BELT IS FULLY EXTENDED AND WILL NOT RETRACT THE SEAT BELT. ONLINE RESEARCH SHOWS SEAT BELT RETRACTOR SPRINGS ARE RUSTING INTERNALLY, THUS PREVENTING THE RETRACTOR FROM RETURNING THE SEAT BELT TO NORMAL POSITION. DRIVING, PARKING, ETC. WILL NOT RESULT IN THE SEAT BELT RETRACTING AT ALL.

HELLO, TOYOTA CALIPERS AND CALIPER PISTONS HAVE A PROBLEM. THE PISTONS OR CALIPERS ARE CORRODING AND CAUSING DELAYED EMPLOYMENT OF BRAKING ON THAT CALIPER. UNDERSTAND THAT THE CALIPERS THAT ARE WORKING CORRECTLY WILL "PULL" TO THE SIDE THEY ARE ON AND THE CALIPER THAT HAS A PROBLEM WILL HAVE A DELAYED ENGAGEMENT. THIS IS EXTREMELY DANGEROUS. THE "GOOD" CALIPER CAUSES THE CAR TO PULL TO THAT SIDE, THEN THE "BAD" CALIPER ENGAGES PULLING THE CAR BACK THE OTHER WAY. WHEN THE BRAKES ARE RELEASED, THE "GOOD" CALIPER LETS GO AND THE "BAD" CALIPER RELEASES A FEW SECONDS LATER. UNDERSTAND THAT THIS CAN HAPPEN ON ANY OF THE FOUR CALIPERS FRONT OR REAR. THE COMBINATIONS OF GOOD AND BAD CALIPERS CAN CAUSE THE CAR TO ZIG ZAG LEFT OR RIGHT UNPREDICTABLY, PULLING LEFT OR RIGHT, AND IF THE DRIVER IS NOT READY FOR IT, CAN CAUSE A BIG PROBLEM CONTROLLING THE CAR. HARD TO EXPLAIN THE COMPLEXITY OF THE VARIOUS BRAKING RESPONSES YOU CAN GET WITH THIS PROBLEM, BUT CHECK THE COMMENTS ON THE INTERNET AND KNOW THAT THERE ARE THOUSANDS OF PEOPLE WITH ISSUES WITH FJ CRUISERS, FOUR RUNNERS ETC. I HAVE HAD THREE CALIPERS REPLACED UNDER WARRANTY, BUT THE PROBLEM IS RETURNING. TOYOTA KNOWS THEY HAVE A PROBLEM, BUT AS USUAL, NO PUBLIC ACKNOWLEDGEMENT. PLEASE DO SOMETHING ABOUT IT. YOU CAN CONTACT ME ANYTIME, [XXX]. THIS IS A PROBLEM AND PLEASE LOOK INTO IT. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

BRAKE CALIPER AND BRAKE CALIPER PISTONS BIND IN CALIPER BORE CAUSING THE VEHICLE TO PULL TO ONE SIDE OR THE OTHER DEPENDING ON WHICH SIDE THE PROBLEM IS. WHEN THE BRAKES ARE APPLIED, THE "GOOD" CALIPERS DO THEIR JOB, BUT THE BAD CALIPER PISTONS ARE MOMENTARILY STUCK AND THIS CAUSES THE CAR TO PULL TO THE GOOD SIDE AS THE BRAKES ARE APPLIED, THEN A MOMENT LATER THE "BAD" BRAKE PISTONS LET LOOSE AND THE CAR PULLS BACK THE OTHER WAY. ALSO THEN AS THE PISTONS ARE BOUND, WHEN THE BRAKES ARE RELEASED, THE GOOD SIDE PISTONS RETRACT, BUT THE BAD SIDE BIND ON RETURN, SO PULLING TO THE BAD SIDE. THIS IS MOST NOTICED ON THE FRONT BRAKES BUT ALSO OCCUR ON THE BACK. NOTE THAT THE "BAD" SIDE ON THE BACK MAY NOT BE THE SAME SIDE AS "BAD" ON THE FRONT, CAUSING A ZIG-ZAG TYPE PULLING , FRONT ONE WAY, BACK THE OTHER AND CAN BE VERY UNPTEDICTABLE, PARTICULARLY WHEN SUDDEN OR "PANIC" BRAKING OCCURS. I PURCHASED AN EXTENDED WARRANTY WITH THE CAR AND TOYOTA AUTHORIZED AND THE DEALER DID REPLACE THREE COMPLETE CALIPERS NO CHARGE UNDER MY EXTENDED TOYOTA WARRANTY. HOWEVER SUBSEQUENT COMPLAINTS BROUGHT THE REGIONAL SERVICE REP TO A MEETING AT MY REQUEST WHERE WE WENT TO AN EMPTY PARKING LOT AND CONDUCTED "PANIC" STOPS SEVERAL TIMES AT 35 MPH AND ONE AT 40 MPH WITH NOT DUPLICATION OF MY COMPLAINTS. I AM SUSPICIOUS THAT THE PANIC STOPPING IS A WAY TO GET WHAT WOULD BE CALLED A "PROPORTIONING CONTROL VALVE" TO UN-STICK. THIS VALVE AS I CALL IT IS A DEVICE THAT BALANCES BRAKE FLUID PRESSURE TO ALL FOUR CALIPERS IN AN EQUAL CRISS-CROSS PRESSURE SO ALL CALIPERS ARE GETTING THE SAME PRESSURE UNLIKE OLD FASSIONED SINGLE OR DOUBLE SYSTEMS FROM BACK IN THE DAY. I CAN'T VERIFY THIS IS A "SECRET" SERVICE FIX FOR UNBALANCED BRAKING, BUT NOW SOME MONTHS AFTER MY CALIPER REPLACEMENTS, THE CALIPERS ARE BEGINNING TO EXHIBIT THE SAME PROBLEM AND I'M OUT OF WARRANTY. OBVIOUSLY THERE IS A PROBLEM WITH THE DESIGN

DRIVER SEAT BELT WONT RETRACT. DEFECT ON RECALL AND REPORTEDLY REPAIRED ON 08-15-13 AT CARSON CITY SCION, NEVADA. THE DEFECT REMAINS AS SEAT BELT WILL NOT RETRACT. I PURCHASED VEHICLE USED IN JULY, 2016; SEAT BELT RETRACTED THEN BUT WAS VERY LOOSE REQUIRING ADJUSTMENT CONSTANTLY. I CONTACTED TOYOTA OF SALINAS ON 2/28/17 AND SPOKE WITH SERVICE MANAGER DON CORRELL. CORRELL INFORMED ME HIS COMPANY WOULD NOT REPAIR THE DEFECT AS TOYOTA IN CARSON CITY ALREADY DID. I THEN SHOWED HIM, AND SERVICE ASSISTANT IVAN GONZALES OF THE DEFECT AND ADVISED THEM THE SAFETY DEFECT WAS NOT PROPERLY REPAIRED AND REMAINS DEFECTIVE AND UNSAFE DUE TO REPAIR DEFICIENCY AS IT WAS SELF EVIDENT THE ALLEGED REPAIR WAS NOT DONE PROPERLY. CORRELL'S RESPONSE WAS: : WE ARE NOT GOING TO FIX YOUR CAR".