2008 Toyota Fj Cruiser

While operating my vehicle at normal legal speeds on a public road, the aftermarket Rough Country lifted steering knuckle suffered a sudden, catastrophic structural breakage at the tie-rod mounting point after hitting a standard pothole. The complete fracturing of the steering knuckle resulted in an immediate, unpreventable loss of steering control on the driver's side wheel. This sudden structural failure forced the front wheel assembly out of alignment, completely disabling the vehicle's steering mechanics and bending the lower drop crossmember brackets. This is a severe life-safety hazard. Had this casting failure occurred at highway speeds or in heavy traffic, it easily could have resulted in a rollover, a head-on collision, or a fatal accident. Heavy-duty cast suspension components should never experience catastrophic metal breakage from everyday public road imperfections. The manufacturer, Rough Country, is refusing to recognize this as a structural defect and is denying liability. This failure needs to be investigated immediately to see if there is an underlying casting, metallurgical, or design defect in Rough Country's lifted steering knuckles before it causes a fatal crash on public roads.

I have 47k miles on my car. I took it in for an oil change (Fox Toyota, Rochester Hills, MI) and was told that it was dangerous to drive. I needed a new rear axle and much more. No details were provided. I could not open the email link they sent to my phone. I left the car at the service dept. 10/21/25 -prior to this visit I brought my car in to Fox for an oil change august 2024 and was told I would probably need new struts soon. I had appx 44,000 miles on my car at that time. - I park in my garage every night and have had an undercarriage wash each month at a car wash. - I live on a dirt road but my husband's 2017 Chevy Silverado has 180,000+ miles. -People online have asked me if I parked in the ocean -I contact Toyota Brand Engagement immediately. They paid a small amount ($3900) toward fixing the $17,000 bill. My car was in limbo at service for 30 days. I had not care. So I had to accept.

The contact owns a 2008 Toyota FJ Cruiser. The contact stated while driving at an undisclosed speed, the contact became aware that the electronic power steering was not functioning properly, requiring increased steering wheel rotation before the vehicle started to maneuver in either direction. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was 197,000.

The frame of the vehicle is rotted out. Holes in it. Front to back , side to side ROTTED. TOYOTA DEALER looked at it at my request when it was in for service and said it was very bad. I’m [XXX] on Social Security, I cannot afford a frame or a new car. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

the brakes are constantly binding up due to rust and need replaced, recently ABS brake lines rusted off causing me to miss a stop sign, very dangerous, Upper rear control arm mount rusted and cracked completely off causing steering and braking problems and had to be replaced to even use this vehicle, , The front rack has been replaced due to excessive rust of lines and fittings, same with transmission cooler lines-rotted off...brake backing plates rotted off.. Even though I have had this undercoated and rust treated, the frame is rusting inside-out...frame braces, everything on the frame is rusted much more than one would expect, even in a salt state like Ohio....my safety was put at risk by faulty brakes, the frame is not safe under hard braking and may cause an accident, the dealer has seen this vehicle, a local independent says "get rid of it"...no warning lamps, just wild things happen with brakes, pulls left, pulls right, front, then back and this past time ...NONE!...only 111,000 miles.

On the home my wife went to apply the brakes and she had no brake pressure. The pedal went all the way to the floor. Then several lights and a buzzer sound started, and she could not stop the car. She was able to pull up on the e-brake just before she drove completely into the intersection, where several cars were driving in both directions. The front end of car ended partially in the north bound lane of US MD-5. There was also a home at the end of the road that she could have also driven into. I researched on several forums where other owners have had the same issue and the dealership has been unable to diagnose the issue. No TSB or recall has been made, but the number of people that have had this issue, something should have been done. My 4-year-old daughter was in the car, and I could have lost both of them. People need to aware of this. I had no idea that a total brake failure was possible with these vehicles.

I was given this car seat as a gift 12/18/2021. The metal buckle is inserted backwards on the left side. This results in a twist of the seat belt that can’t be corrected. I cannot remove the metal piece to fix this because the strap is sewn together. I thought it was just twisting because that’s what car seats sometimes do. But when I remove the padding to clean it today I realized it was a manufacturer error.