IllustrationChassis frame rotted
2008 Toyota Fj Cruiser
Owner reports · Recalls · Investigations
More warning signs than most Fj Cruiser years
Owner complaints for the 2008 Toyota Fj Cruiser are substantially higher than the model-year median of 26.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Fj Cruiser years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
390–25K
2325–50K
950–75K
1075–100K
6100–150K
10150K+
97 reports with mileage · 27 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Structure. Review the 42 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 17 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 14 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
5 crash reports1 fire reports2 injury reports
Suspension complaints
14 reportsthe brakes are constantly binding up due to rust and need replaced, recently ABS brake lines rusted off causing me to miss a stop sign, very dangerous, Upper rear control arm mount rusted and cracked completely off causing steering and braking problems and had to be replaced to even use this vehicle, , The front rack has been re…
Read full complaint
the brakes are constantly binding up due to rust and need replaced, recently ABS brake lines rusted off causing me to miss a stop sign, very dangerous, Upper rear control arm mount rusted and cracked completely off causing steering and braking problems and had to be replaced to even use this vehicle, , The front rack has been replaced due to excessive rust of lines and fittings, same with transmission cooler lines-rotted off...brake backing plates rotted off.. Even though I have had this undercoated and rust treated, the frame is rusting inside-out...frame braces, everything on the frame is rusted much more than one would expect, even in a salt state like Ohio....my safety was put at risk by faulty brakes, the frame is not safe under hard braking and may cause an accident, the dealer has seen this vehicle, a local independent says "get rid of it"...no warning lamps, just wild things happen with brakes, pulls left, pulls right, front, then back and this past time ...NONE!...only 111,000 miles.
After buying my vehicle I have began to notice a growing rust problem that is not due to salt water or other environmental conditions, but clearly a defect in manufacturing. After joining a few Facebook groups with other FJ owners I’ve found countless other people have had the same problem and that without massive trust removal …
Read full complaint
After buying my vehicle I have began to notice a growing rust problem that is not due to salt water or other environmental conditions, but clearly a defect in manufacturing. After joining a few Facebook groups with other FJ owners I’ve found countless other people have had the same problem and that without massive trust removal my vehicle is expected to have failures in the frame and suspension at some point.
FRAME, SUSPENSION, AND BRAKES HAVE EXTREME DAMAGE FROM RUST. REAR BRAKES ARE NON-FUNCTIONAL BECAUSE OF RUST.
THIS VEHICLE STARTED TO DEVELOPE RUST IMMEDIATELY AFTER PURCHASE. THE VEHICLE IS A 2008 AND IS SCARY RUSTY ON THE FRAME AND OTHER COMPONENTS. AN ABNORMAL AMOUNT OF RUST COMPARED TO OTHER 2008 ERA VEHICLES. EVENTUALLY ONE OF THESE FAULTY FRAMES ARE GOING TO BREAK IN A HIGH SPEED SCENARIO AND SERIOUS INJURY OR DEATH WILL OCCUR…
Read full complaint
THIS VEHICLE STARTED TO DEVELOPE RUST IMMEDIATELY AFTER PURCHASE. THE VEHICLE IS A 2008 AND IS SCARY RUSTY ON THE FRAME AND OTHER COMPONENTS. AN ABNORMAL AMOUNT OF RUST COMPARED TO OTHER 2008 ERA VEHICLES. EVENTUALLY ONE OF THESE FAULTY FRAMES ARE GOING TO BREAK IN A HIGH SPEED SCENARIO AND SERIOUS INJURY OR DEATH WILL OCCUR. MY OTHERWISE PERFECT FJ CRUISER ONLY HAS 35000 MILES ON IT AND SAT IN STORAGE FOR THE WINTER OF 2016 AND 2017.
2008 TOYOTA FJ CRUISER FRAME ROTTING FROM INSIDE AND OUT. ALL SUSPENSION COMPONENTS HAVE BEEN REPLACED DUE PARTS FAILING BECAUSE OF CORROSION THAT BLED OVER FROM THE FRAME TO INCLUDE BOTH FRONT STEERING KNUCKLES, TWO PARTS THAT ONLY EVER GET REPLACED IN THE EVENT OF AN ACCIDENT. SEVERAL FRAME SUPPORTS HAVE CORRODED FROM T…
Read full complaint
2008 TOYOTA FJ CRUISER FRAME ROTTING FROM INSIDE AND OUT. ALL SUSPENSION COMPONENTS HAVE BEEN REPLACED DUE PARTS FAILING BECAUSE OF CORROSION THAT BLED OVER FROM THE FRAME TO INCLUDE BOTH FRONT STEERING KNUCKLES, TWO PARTS THAT ONLY EVER GET REPLACED IN THE EVENT OF AN ACCIDENT. SEVERAL FRAME SUPPORTS HAVE CORRODED FROM THE INSIDE OUT AND ARE FLAKING OFF. BRAKE COMPONENTS THAT RUN ALONG THE FRAME HAVE CORRODED FROM THE FRAME TO THE BRACKET THAT HOLDS THEM TO THE LINES THEMSELVES. CAUSE A SLOW BRAKE LEAK OVER TIME THAT EVENTUALLY RESULTED IN A DANGEROUS NEAR ACCIDENT SITUATION THAT WAS CAUSED BY COMPLETE IMMEDIATE LACK OF BRAKE PRESSURE. EVASIVE DRIVING AND A SOUND MIND AVOIDED A LEGITIMATE ACCIDENT, HAD TO TOW THE TRUCK TO A SHOP. UNSAFE TO DRIVE. FRAME WILL NOT HOLD UP IN AN ACCIDENT. 12 YEAR OLD FRAME SHOULD NOT BE ANYWHERE NEAR THIS CONDITION. DUE TO OVERSIGHTS AT THE MANUFACTURER THIS FRAME IS NOW CORRODING FROM THE INSIDE OUT.
THE FRAME AND SUSPENSION PIECES ON MY FJ HAVE RUSTED DUE TO POOR COATINGS AND MATERIALS USED BY TOYOTA. *TR
VEHICLE WAS STATIONARY IN DRIVEWAY MY FRAME, SOME SUSPENSION COMPONENTS, AND MY ROCKER PANELS WERE FALLING APART IN MY HANDS
SEVER RUSTING OF FRAME, BREAK AND SUSPENSION COMPONENTS AND BRACKETS. THIS 2008 TOYOTA FJ CRUISER IS QUICKLY BECOMING A SAFETY HAZARD ON THE ROADS. I HAVE A 92 SABB AND A 93 VW THAT DON'T HAVE HAVE THE RUST ISSUES THIS TOYOTA HAS. TOYOTA SHOULD HAVE RECALLED THE FJ CRUISERS FOR FAULTY FRAMES AND UNDERCARRIAGE LONG AGO.
THE FRAME ON MY FJ CRUISER IT LITERATELY ROTTING TO NOTHING. AS ARE MOST PRODUCED FROM 2007 - 2012 I HAVE BEGGED TOYOTA FOR HELP AND A RESOLUTION LIKE WITH THE TUNDRA AND TACOMA FRAME ROTTING ISSUES. THIS IS A MAJOR SAFETY ISSUE AND SOMEONE IS GOING TO GET HURT OR KILLED. MY CONTROL ARE IN ROTTING AWAY FROM THE FRAME. AS YOU CAN…
Read full complaint
THE FRAME ON MY FJ CRUISER IT LITERATELY ROTTING TO NOTHING. AS ARE MOST PRODUCED FROM 2007 - 2012 I HAVE BEGGED TOYOTA FOR HELP AND A RESOLUTION LIKE WITH THE TUNDRA AND TACOMA FRAME ROTTING ISSUES. THIS IS A MAJOR SAFETY ISSUE AND SOMEONE IS GOING TO GET HURT OR KILLED. MY CONTROL ARE IN ROTTING AWAY FROM THE FRAME. AS YOU CAN SEE IN THE PICTURE THE THIS IS BAD BAD. FJ CRUISER WAS STATIONARY.
Official recalls
916V396000 · Seats:front Assembly:seat Heater/cooler
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
14V743000 · Seats:front Assembly:seat Heater/cooler
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
14V475000 · Equipment:other:labels
Aug 4, 2014
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2008-2014 FJ Cruiser and Tacoma vehicles equipped with accessory wheels and tires installed by Toyota or dealers prior to the vehicle's first sale. The affected vehicles may list incorrect spare tire size and/or cold tire inflation information on the tire placard. As such, these vehicles fail to comply with Federal Motor Vehicle Safety Standard No. 110, "Tire Selection and Rims for Passenger Cars."
Consequence & remedy
Consequence: If the spare tire is inflated to the incorrect pressure provided on the placard, tire failure may occur while it is being driven on, increasing the risk of a crash.
Remedy: For the involved vehicles, overlay stickers to correct the tire placard will either be mailed to owners or provided to dealers for placement over the incorrect information on the placard. The recall is expected to begin in September 2014. Owners may contact Toyota customer service at 1-800-331-4331.
13V163000 · Exterior Lighting
Apr 25, 2013
Toyota Motor Corporation (Toyota) is recalling certain model year 2007-2013 FJ Cruiser vehicles manufactured January 25, 2006 through February 23, 2013 and equipped with a Toyota Auxiliary Driving Lamp Kits mounted to the front bumper. These lamp assemblies include 55 watt bulbs and due to this wattage and mounting angle, the combination of the upper beam headlamps plus the auxiliary lamps are too bright and exceed the maximum light output allowed for an upper beam headlamp. Therefore, these vehicles fail to conform to Federal Motor Vehicle Safety Standard No. 108, "Lamps, reflective devices, and associated equipment."
Consequence & remedy
Consequence: Light intensities above the maximum allowable limit could cause increased glare for oncoming traffic and increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the 55 watt bulbs with 35 watt bulbs, free of charge. The recall began on June 6, 2013. Owners may contact Toyota at 1-800-331-4331.
13V098000 · Seat Belts:front:anchorage
Mar 15, 2013
Toyota is recalling certain model year 2007 through 2013 FJ Cruiser passenger vehicles. The retractors for the front driver and passenger seat belts are mounted in the access door (rear door) panels of the vehicle. Due to insufficient strength of the access door panel, cracks may develop in the panel if the access door is repeatedly and forcefully closed over an extended period of time.
Consequence & remedy
Consequence: If cracks occur in the panel around the lower retractor anchor, the seat belt retractor could become detached, which could increase the risk of injury to an occupant in the event of a crash.
Remedy: The safety recall began on June 6, 2013. Toyota will mail an interim letter to owners late in April 2013. Remedy notifications to the owners for the repair will begin in late May 2013. Owners may contact Toyota at 1-800-331-4331.
11V148000 · Tires:pressure Monitoring And Regulating Systems
Mar 4, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 FJ CRUISER, LAND CRUISER, TACOMA, SEQUOIA AND TUNDRA VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 138, "TIRE PRESSURE MONITORING SYSTEM (TPMS)." WHEN FACTORY-INSTALLED WHEELS AND TIRES WERE REPLACED WITH TOYOTA AUTHORIZED ACCESSORY WHEELS AND LT TIRES PRIOR TO FIRST SALE, THE TIRE PRESSURE MONITORING SYSTEMS WERE NOT RE-CALIBRATED CORRECTLY AND THEREFORE DO NOT START ILLUMINATING THE LOW TIRE PRESSURE WARNING TELLTALE AT THE REQUIRED MINIMUM ACTIVATION PRESSURE.
Consequence & remedy
Consequence: FAILURE TO WARN OF TIRE DEFLATIONS IS A NON-COMPLIANCE WITH FMVSS 138 AND COULD LEAD TO TIRE FAILURE INCREASING THE RISK OF A CRASH.
Remedy: FOR THE LAND CRUISER, SEQUOIA, TACOMA AND TUNDRA VEHICLES, THE DEALER WILL RE-CALIBRATE THE TIRE PRESSURE MONITORING SYSTEM ON AFFECTED VEHICLES AND INSTALL AN UPDATED TIRE AND LOADING INFORMATION LABEL AT NO CHARGE. FOR THE FJ CRUISER VEHICLES, THE TPMS CANNOT BE RESET SO THE ELECTRONIC CONTROL UNIT (ECU) FOR THE TPMS WILL BE REPLACED. TOYOTA IS CURRENTLY DEVELOPING THE REMEDY ECU. IF AN OWNER IS NOT CERTAIN WHETHER HIS OR HER VEHICLE IS EQUIPPED WITH THESE ACCESSORIES, PLEASE CONTACT ANY TOYOTA DEALER FOR AN INSPECTION AT NO CHARGE. THE SAFETY RECALL BEGAN ON MARCH 31, 2011. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
10V035000 · Equipment:other:labels
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
10V036000 · Equipment:other:labels
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
09V223000 · Equipment:other:labels
Jun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Consequence & remedy
Consequence: INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.