TL*THE CONTACT OWNS A 2002 SUZUKI XL-7. WHILE DRIVING APPROXIMATELY 65 MPH, THE CONTACT HEARD A KNOCKING SOUND. THE AIR CONDITIONING SHUT OFF AND SHE EXITED OFF THE INTERSTATE. IN ADDITION, THE POWER STEERING WOULD NOT ALLOW HER TO TURN PROPERLY. SHE TURNED OFF THE VEHICLE AND ATTEMPTED TO RESTART IT, BUT THE FAILURES CONTIN…
Read full complaint
TL*THE CONTACT OWNS A 2002 SUZUKI XL-7. WHILE DRIVING APPROXIMATELY 65 MPH, THE CONTACT HEARD A KNOCKING SOUND. THE AIR CONDITIONING SHUT OFF AND SHE EXITED OFF THE INTERSTATE. IN ADDITION, THE POWER STEERING WOULD NOT ALLOW HER TO TURN PROPERLY. SHE TURNED OFF THE VEHICLE AND ATTEMPTED TO RESTART IT, BUT THE FAILURES CONTINUED. THE CONTACT MANAGED TO DRIVE TO A SERVICE STATION AND THE MECHANIC STATED THAT THE ISSUE MAY HAVE BEEN THE POWER STEERING. SHE PURCHASED FLUID, BUT ANOTHER MECHANIC STATED THAT THE BELT FAILED. THE CONTACT WENT TO AN AUTO PARTS STORE AND A MECHANIC REPLACED THE BELT. SHE THEN TOOK THE VEHICLE TO A DEALER WHO STATED THAT THE AIR CONDITIONING COMPRESSOR NEEDED TO BE REPLACED AND WOULD COST APPROXIMATELY $2,500. SHE WENT TO AN AUTO SERVICE SHOP AND THE MECHANIC DISABLED THE AIR CONDITIONING MECHANISM BECAUSE IT COULD POTENTIALLY BE A SAFETY HAZARD, IF ACTIVATED. THE COMPRESSOR HAS NOT YET BEEN REPLACED. A REPORT WAS FILED WITH THE MANUFACTURER AND THEY STATED THAT THEY COULD NOT ASSIST. THE CURRENT MILEAGE WAS APPROXIMATELY 62,000 AND FAILURE MILEAGE WAS APPROXIMATELY 59,000.
NHTSA ODI #10268646
38,000 miles · Nov 23, 2008
Engine And Engine CoolingEquipment
I HAVE A 2002 SUZUKI XL-7 AND IN JAN 2005 NEWBURGH SUZUKI HAD TO REPLACE THE A/C COMPRESSOR BECAUSE LOCKED UP. VEH ONLY HAD 13,247 MILES ON IT. NOW AGAIN NOV 2008 VEH ONLY HAS 38,000 MILES ON IT COMPRESSOR IS STARTING TO LOCK UP AGAIN. *TR
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 16-INCH WHEELS, THE FRONT BRAKE DISCS MAY BREAK UNDER SEVERE DRIVING CONDITIONS. THE BREAKAGE CAN OCCUR IN CONDITIONS WHERE THE VEHICLE IS DRIVEN ON A REGULAR BASIS ON EXTREMELY STEEP PAVED DOWN-SLOPES WHILE CONTINUOUSLY APPLYING THE BRAKES.
Consequence & remedy
Consequence: THE FRONT BRAKES MAY BECOME INOPERATIVE AND THE VEHICLE MAY PULL TO ONE SIDE. THIS COULD RESULT IN A CRASH WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE THE FRONT BRAKE DISCS ON THESE VEHICLES. THE RECALL BEGAN ON NOVEMBER 10, 2005. THESE VEHICLES ARE LOCATED ON ST. THOMAS ISLAND (VIRGIN ISLANDS). OWNERS MAY CONTACT SUZUKI DEL CARIBE AT 787-622-0600.
ON CERTAIN SPORT UTILITY VEHICLES, THE ACCELERATOR CABLE CASING CAP THAT IS ATTACHED TO THE VEHICLE FIREWALL CAN CRACK DUE TO EXTENDED EXPOSURE TO FORCES FROM THE ACCELERATOR CABLE AND INSUFFICIENT LONG-TERM DURABILITY OF THE PLASTIC CASING CAP. IF THE CASING CAP BECOMES CRACKED, MOVEMENT OF THE INNER ACCELERATOR CABLE THROUGH THE CAP CAN CAUSE THE INNER ACCELERATOR CABLE TO BECOME FRAYED.
Consequence & remedy
Consequence: IF THE INNER ACCELERATOR CABLE BECOMES FRAYED, IT CAN STICK DURING VEHICLE OPERATION. IN THE CASE WHERE AN ACCELERATOR CABLE STICKS, THE DRIVER COULD HAVE DIFFICULTY CONTROLLING VEHICLE SPEED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE ACCELERATOR CABLE, WHICH INCLUDES THE PLASTIC CASING CAP. OWNER NOTIFICATION BEGAN ON JANUARY 5, 2004. OWNERS SHOULD CONTACT SUZUKI AT 1-800-934-0934.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2002 Suzuki XL-7 Problems, Complaints & Recalls | Skip That Year
Illustration