IllustrationFLYWHEEL MAGNETS SHIFTED AND CRACKED. PIECES OF THE MAGNET ARE ALL OVER THE INSIDE OF THE ENGINE. STATOR IS SCRATCHED. FOUND OUT BECAUSE OF VIBRATION AT LOW RPM AND BIKE NOT HOLDING A CHARGE. *TR
2003 Suzuki SV1000
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Other model years Selected year
Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 9 of 9 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 6 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports0 fire reports1 injury reports
Engine complaints
3 reportsTHE CHARGING SYSTEM MAGNETS DETACHED FROM THE FLYWHEEL/ROTOR (INTERNAL TO THE MOTOR), CAUSING AN ISSUE WHERE THE CHARGING SYSTEM WAS NOT FUNCTIONING PROPERLY. THIS IS A SAFETY ISSUE BECAUSE THE MAGNETS COULD HAVE BECOME DISLODGED ENOUGH TO CAUSE A CATASTROPHIC AND IMMEDIATE ENGINE SEIZURE/FAILURE, RESULTING IN I A CRASH. THA…
Read full complaint
THE CHARGING SYSTEM MAGNETS DETACHED FROM THE FLYWHEEL/ROTOR (INTERNAL TO THE MOTOR), CAUSING AN ISSUE WHERE THE CHARGING SYSTEM WAS NOT FUNCTIONING PROPERLY. THIS IS A SAFETY ISSUE BECAUSE THE MAGNETS COULD HAVE BECOME DISLODGED ENOUGH TO CAUSE A CATASTROPHIC AND IMMEDIATE ENGINE SEIZURE/FAILURE, RESULTING IN I A CRASH. THANKFULLY, I CAUGHT THE ISSUE BEFORE IT BECAME SEVERE. AFTER A BIT OF ONLINE RESEARCH, I HAVE FOUND THIS TO BE A VERY COMMON ISSUE FOR SUZUKI BIKES EQUIPPED WITH THIS FAMILY OF ENGINES. NUMEROUS INSTANCES CAN BE FOUND ON THE SV650, SV1000, AND ALL MODELS OF THE V-STROM. I HAVE NOT YET CONTACTED SUZUKI REGARDING THIS MATTER, BUT PLAN TO DO SO TODAY. IT IS MY UNDERSTANDING THAT A CASE HAS BEEN OPENED TO LOOK INTO THIS MATTER. I BELIEVE THE CASE NUMBER IS [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
MY SV1000 HAS EXPERIENCED PROBLEMS WITH ITS CHARGING SYSTEM THAT AFFECTS THE ENTIRE ENGINE. I CAME TO FIND IT WAS A HEAVILY DOCUMENTED ON PUBLIC ONLINE FORUMS SUCH AS SV-PORTAL.COM AND HAS AFFECTED ALMOST ALL SV1000 OWNERS. THE MAGNETS, WHICH ARE GLUED TO THE INTERIOR OF THE STATOR ROTOR, BREAK FREE OF THEIR EPOXY BOND AND S…
Read full complaint
MY SV1000 HAS EXPERIENCED PROBLEMS WITH ITS CHARGING SYSTEM THAT AFFECTS THE ENTIRE ENGINE. I CAME TO FIND IT WAS A HEAVILY DOCUMENTED ON PUBLIC ONLINE FORUMS SUCH AS SV-PORTAL.COM AND HAS AFFECTED ALMOST ALL SV1000 OWNERS. THE MAGNETS, WHICH ARE GLUED TO THE INTERIOR OF THE STATOR ROTOR, BREAK FREE OF THEIR EPOXY BOND AND SHATTER INTO PIECES INSIDE THE ENGINE CASE. THIS IS A MAJOR SAFETY ISSUE AS DAMAGE TO THE STATOR/ALTERNATOR IS CERTAIN AND FRAGMENTED MAGNETS ENTER THE TRANSMISSION, OIL PAN, CLUTCH AND OTHER ENGINE SYSTEMS. WHEN ANY OF THESE SYSTEMS ARE CAUSED TO FAIL BY THE BROKEN MAGNET PIECES OR CHARGING SYSTEM FAILURE AT DRIVING SPEED THE RIDER AND ALL NEAR BY MOTORISTS ARE AT SERIOUS RISK. THIS PROBLEM IS WIDESPREAD AND AFFECTS ALL YEARS OF THE SV1000. THE SAFETY ISSUE OCCURS AT VARYING MILEAGE BUT IT IS CERTAIN THAT VEHICLES WITH MORE THAN 15,000 TO 18,000 MILES WILL HAVE THIS ISSUE. *TR
Official recalls
106V013000 · Fuel System, Gasoline:storage:tank Assembly
Jan 18, 2006
ON CERTAIN CALIFORNIA-SPECIFICATION MODEL MOTORCYCLES, REPEATED STRESS FROM VIBRATION CAN CAUSE A CRACK TO FORM IN THE AREA WHERE THE LIQUID/VAPOR SEPARATOR BRACKET IS WELDED INSIDE THE FUEL TANK. THIS CAN ALLOW FUEL LEAKAGE TO OCCUR.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL TANK FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 3, 2006. CUSTOMERS MAY CONTACT AMERICAN SUZUKI AT 714-572-1490.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE06018 · Motorcycle Stalling
Opened May 17, 2006 · Closed Oct 5, 2006
Status: closed (inferred from source dates) · Electrical System:wiring
THIS PE WAS OPENED ON THE BASIS OF 5 OWNER STALLING ALLEGATIONS COMMONLY INVOLVING A MAIN HARNESS CONNECTOR AT THE IGNITION SWITCH.CURRENTLY ODI IS AWARE OF 7 INCIDENTS (TWO IN 2004, FOUR IN 2005, AND ONE IN FEB 2006) WHERE THE MOTORCYCLE STALLED.THE SINGLE INJURY CRASH OCCURRED ON SEPTEMBER 13, 2004.AFTER GATHERING INFORMATION CONCERNING THIS ISSUE FROM SUBJECT VEHICLE OWNERS, SUZUKI DEALERS, AND AMERICAN SUZUKI MOTOR CORPORATION, WE FIND NO DEFECT TREND CURRENTLY EXISTS CONCERNING THIS SUBJECT.WE WILL CONTINUE TO MONITOR THIS MATTER CLOSELY.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTIO IF WARRANTED BY THE CIRCUMSTANCES.